What 120 owners told NHTSA about the 2022 Kia K5

Driving anywhere in general and which ever speed my gas would leak and smell would over take the car and I have a [XXX] and [XXX] babies. This is not the first but the third recall and this is a fire hazard I can’t imagine my car going in flames while we’re already suffering with a leaking gas smell every time we drive the car I can loose my whole family I will soon being filing a lawsuit against this I want a new vehicle completely I do not feel safe in this car with my kids at all there’s always an issue and my dealership is over 40min away to be going so often throughout the years of having this car this is completely unsafe dangerous and just out right unexpectedable and will be filing soon for a new car and compensation INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11748609

The contact owns a 2022 Kia K5. The contact stated that while attempting to reverse her vehicle and then shifting the gear shift into drive, the contact noticed her check engine warning illuminated, and she heard an abnormal noise coming from the front of the vehicle. The contact then parked the vehicle, went into the dealer, and let them know about the failure, but they offered no assistance. The vehicle was initially taken to the dealer, where NHTSA Campaign Number: 25V794000 (FUEL SYSTEM, GASOLINE) was completed. It was after the recall was completed that it was discovered that the check engine light illuminated, and the vehicle was not driving properly. The dealer took the vehicle back and provided a loaner. The contact mentioned that the engine was replaced, and then a catalytic converter was replaced. Most recently, the fuel oxygen sensor was discovered to be melted. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure and informed that the recall was complete with no other assistance offered. The failure mileage was 91,000.

NHTSA ODI 11747936

The contact owns a 2022 Kia K5. The contact stated that while driving approximately 45-50 MPH, the automatic front collision avoidance system abruptly engaged while there was a vehicle was parked on the passenger-side of the roadway. The contact stated the parked vehicle did not present a safety hazard to the vehicle. The dealer was notified of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 9,000.

NHTSA ODI 11743707

In XXX 2026, I brought my 2022 Kia K5 GT-Line (VIN: [XXX] ) to Jim Click Kia in Tucson, AZ for routine maintenance. Fuel system testing revealed my vehicle failed inspection due to an active federal recall affecting the fuel tank/fuel valve system. Kia America confirmed the recall defect caused cascading damage to additional components, rendering the vehicle completely unrepairable and unsafe to drive. My safety was put at risk because the vehicle cannot be operated and Kia has confirmed no repair is possible. I have been without my vehicle for over two months. Kia America has proposed a buyback at $10,550 (KBB value), which does not reimburse me for the approximately $35,000+ I paid into this vehicle. I have formally requested full reimbursement under 49 U.S.C. § 30120 and the Magnuson-Moss Warranty Act, which Kia has declined. I am currently in a rental vehicle paid by Kia, which they have threatened to terminate on June 9, 2026 if I do not accept their offer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11740880

The Integrated Thermal Management System (ITMS) in my Kia K5 GT (2.5T engine) has experienced a recurring internal electronic and mechanical fault. This is the third failure of this component. The failure causes the cooling system to malfunction, either by over-cooling or failing to cycle coolant once at operating temperature. ​Under acceleration—specifically when merging onto expressways—the vehicle suffers a sudden loss of power and enters 'limp mode' with a dashboard alert stating the engine is overheating. This creates an immediate safety hazard in high-speed traffic. When the fault occurs, the radiator fans lock at 100% duty cycle. This is a documented systemic issue with the Kia 2.5T powertrain (referenced by major automotive publications and multiple Technical Service Bulletins). ​Despite a prior Lemon Law settlement and an active 100,000-mile powertrain warranty, the manufacturer refuses to acknowledge this as a powertrain or emissions defect, attempting to charge out-of-pocket for a component that prevents the vehicle from passing state emissions and safety inspections."This was also cited in a 2023 issue of car and driver magazine long-term test with The Kia Sorento that shares the same engine and transmission combination This is a third time that part has failed for me with others had to replace that part over seven times The first time it happened it was at 8,000 mi it did not get fixed until 30,000 mi The second time it happened was at 51,000 mi The third time 75,000 mi

NHTSA ODI 11737476

I was driving on the highway and my check engine light came on. I pulled over and it told it was from engine control system. I had a computer connected to it and it came back the idle control system rpm higher than expected.

NHTSA ODI 11736237

A fuel system-related safety recall (SC356) remains incomplete on the vehicle. The vehicle was taken to an authorized Kia dealership in Jersey City, NJ, where I was informed that the recall repair had been completed. I paid for towing to the dealership for this repair. However, after picking up the vehicle, it immediately began exhibiting worsening symptoms, including engine shaking, rough operation while driving and idling, and prior stalling incidents. A check engine light also appeared after the visit. Upon further verification, the recall still shows as incomplete. This indicates that the recall repair was either not performed or not completed correctly. The issue appears to involve the fuel system, as the symptoms worsened after refueling and include unstable engine performance consistent with improper fuel delivery or air entering the system. This condition creates a safety risk due to potential engine stalling while driving, as well as the known recall risk involving fuel tank deformation and possible fire hazard. The problem has not been properly resolved by the dealership, and the vehicle is currently unsafe for normal use. The failed recall repair is available for inspection.

NHTSA ODI 11732899

The vehicle experienced an overheating condition involving the fuel system, which aligns with an active recall stating that a damaged check valve can allow air into the fuel tank, causing it to expand and come into contact with hot exhaust components, potentially melting the fuel tank. While operating the vehicle, this created a serious safety concern due to the risk of fuel tank damage, fuel leakage, and potential fire. This was not a minor issue, as it directly involved a component that could lead to a fire hazard. The vehicle was later evaluated and deemed unrepairable due to the severity of the issue. Because of this, the vehicle is not currently being used due to safety concerns. Despite the known safety risk and recall-related defect, the situation has not been properly resolved. The handling of this issue raises concerns given the potential for fuel system failure and fire risk associated with this defect. This complaint is being submitted due to the safety risk involving the fuel system and the potential for fire while operating the vehicle.

NHTSA ODI 11732143

I bought a 2022 KIA K5 gt-line new and the horn stopped working less than a year later at 64,000 miles Gary Rome KIA assessed the repair and said KIA would not cover. I paid $169.00. In January 2026 my horn stopped working again. Ron Bouchard KIA assessed and said KIA would not cover repairs, I paid $819.98 myself. I have contacted KIA myself and with the assistance of the Ma Atty Gen'l office. I and the Atty Gen'l advocate have not received a reply from KIA. my out of pocket cost so far is $877.38 not including down time and inconvenience. KIA reportedly quietly acknowledged the horn issue in the K5 and extended warranty to cover repairs but did not or will not reimburse me my cost. I have uploaded bills and KIA horn defect acknowledgment article

NHTSA ODI 11730356

My 2022 Kia K5 GT-Line has had a recurring check engine light fault (P0471 — exhaust pressure sensor circuit) since approximately 9,874 miles in September 2022. The vehicle has been brought to the servicing Kia dealer a minimum of five times for this same fault across nearly 65,000 miles. It has never been permanently resolved. Most critically: dealer repair records from May 2025 (56,501 miles) confirm a technician identified fault code P047100, noted it as a history code, cleared it, test drove the vehicle, and returned it without performing any repair and without informing me. Ten months later, the same dealer presented this identical fault as a $1,121.07 customer-pay repair on a vehicle under active 10-year/100,000-mile powertrain warranty. The repair was only approved after I contacted Kia Consumer Affairs directly — the dealer had not contacted them despite claiming otherwise. The February 2026 repair failed within 15 minutes of pickup. I made five documented phone calls to the dealer over 33 days reporting the failure. No action was taken. The April 2026 repair — sensor and hose replacement — failed within one hour of pickup on April 1, 2026. Of additional concern: Recall SC288/SC288A (Fuel Tank Inspection and ECM Re-Update) was performed on this vehicle twice — July 2024 and August 2025. The ECM governs the exhaust pressure sensor circuit. The P0471 fault first appeared in dealer records between these two recall dates and has persisted through both completions. CARFAX confirms the April 2026 repair involved the engine/powertrain computer module. I am requesting NHTSA investigate whether SC288/SC288A is connected to recurring P0471 faults in 2022 Kia K5 vehicles. Kia Consumer Affairs Case escalated April 2, 2026.

NHTSA ODI 11728917

STATEMENT OF FACTS: I presented my Kia K5 for two safety recalls (SC356 and SC263) with an active Check Engine Light for code P047100 (Exhaust Pressure Sensor). I informed the service advisor, Aliyah, that this code is a symptomatic secondary fault of the pressure irregularities addressed in Recall SC356, which explicitly lists an "Illuminated Check Engine Light" (MIL) as a primary warning sign. The dealership dismissed my technical assessment—which was backed by advanced AI data analysis. After the software update was performed, the advisor claimed the code remained "active," thereby "proving" it was unrelated to the recall. Based on this, I was charged a $248 diagnostic fee and told I needed a $534.02 out-of-pocket hardware repair for a "physically failing" differential pressure sensor that was allegedly reading 2 HPA against a spec of 23.09 HPA. EVIDENCE OF ERROR: Upon taking delivery of the vehicle, the Check Engine Light was completely extinguished. If the light were truly "still active" after the update, as I was told to justify the fee, the fault would have been present at pickup. Since then, I have driven over 120 miles (including multiple cold-start drive cycles between [XXX] and my place of work) with a 100% clear dashboard. My XXX App confirms the XXX fault is resolved, while the recalls remain "Open" administratively. REGULATORY VIOLATION: Under 49 U.S.C. Chapter 301, a manufacturer must remedy a safety defect without charge. A software "Logic Update" cannot physically repair a broken pressure sensor. The fact that the fault disappeared immediately following the update proves the sensor was functional and the fault was caused by the recall defect. By misdiagnosing a recall symptom as a non-covered hardware failure, the dealer effectively charged me for a federal safety repair. I request an investigation into these "diagnostic gatekeeping" practices and a full refund of the $248.00 fee. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11728595

The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline); however, while taking the vehicle to the dealer, it was determined by the dealer that the vehicle could not be repaired. The contact was not given any reason why the vehicle could not be repaired and was offered a buy-back option instead. The contact stated that the rear passenger seats were extremely hot. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 90,000.

NHTSA ODI 11728275

The infotainment system in my 2022 Kia K5 began failing on or around early December, 2025, at approximately 44,000 miles and has continued to worsen. The vehicle is currently at approximately 47,000 miles. The screen displays the Kia startup screen repeatedly and does not fully load, flashing, becoming unresponsive, and ultimately causing distraction while driving. Audio may still function, but key features such as Bluetooth, Apple CarPlay, and auxiliary input do not work. The backup camera will either not function at all or will flash intermittently while reversing. This failure affects safe operation of the vehicle because it limits access to vehicle controls and creates distraction while driving due to the malfunctioning display. It also impacts visibility and usability of integrated systems that are expected to function reliably. The problem has been reproduced consistently and was evaluated by a Kia dealership. The dealership was unable to determine a clear cause for the failure but recommended full replacement of the infotainment system at a cost of approximately $6,700. There were no clear warning messages prior to failure. The issue has persisted despite attempts to reset the system and power cycle the vehicle. This appears to be a premature failure of a critical electronic system that should not occur at this mileage.

NHTSA ODI 11727119

EPB light with multiple other dash lights come on. It affects my breaking, shifting and acceleration. I was attempting to get on the freeway the first time it happened and my car would not accelerate. I had to drive off to the side to prevent getting hit. It happens intermittently at no given time. I just got it back from the dealership and am still having the issue.

NHTSA ODI 11722377

The car was in an accident with the previous owner I bout the car and the carfax showed rear end collision I told the car worked perfectly. After purchase the car brakes have built up 2 times in 5 months the car stalled it has rpm issues lagging and hesitation as well as the safety front end collision has malfunctioned and it locked my brakes up I did all the steps to try to fix it and I ended up having to disconnect the battery. I sent it to the dealer and they said it was fine I now see the carfax as showing front end collision was reported and has been in the shop multiple times for the hesitation and stalling issue which now that my blue certificated warranty is out they found the issue (pcv valve etc) I’ve asked for a remedy with the dealer and they won’t budge this car is a safety liability.

NHTSA ODI 11714570

My 2022 Kia k5 has gone into limp mode multiple times now while I am driving in addition to when it starts up. Check engine light, AUTOHOLD, EPB, traction control, etc. all aluminate on my dashboard. Car drives very rough and doesn’t want to accelerate or shift. Huge safety issue. Dealership said it was the throttle body assembly. Paid to have it replaced and the issues still persists. I have read multiple other comments with the same issue and dealerships have no idea what the issue is or how to correctly diagnose. Error codes were P00BD00, C136081, and C174181.

NHTSA ODI 11711976

The driver's seat heater automatically deactivates after 30 seconds. The heating element remains active for only 20 seconds, and unfortunately, the console with the wireless phone charging station is not functioning.

NHTSA ODI 11710833

I am submitting this complaint regarding a confirmed safety recall on my 2022 Kia K5 LX that has not been repaired and currently has no available remedy, despite being acknowledged by Kia. This unresolved recall places me, my passengers, and other motorists at ongoing risk. I rely on this vehicle for daily transportation, and continuing to operate it under these conditions creates a constant safety concern that is beyond my control. I have been informed that the recall exists, yet there has been no corrective action, repair timeline, or interim safety solution provided. Leaving consumers in possession of a known defective vehicle without a remedy is unacceptable, especially when the issue involves safety-related components. I am requesting that the NHTSA: •Review Kia’s handling of this recall •Require timely corrective action or an interim safety solution •Ensure accountability so affected drivers are not left operating unsafe vehicles indefinitely I am deeply concerned about the lack of urgency and transparency surrounding this issue. A confirmed safety recall without a remedy is not a minor inconvenience; it is a serious hazard. Thank you for your attention to this matter. I am available to provide additional documentation if needed.

NHTSA ODI 11710200

The ac and or heat goes out and I have to press the fuse under the hood and it comes back on other Kia k5 owners have had the same problem was told to report here for recall so fuse box doesn’t get burned out.

NHTSA ODI 11710146

The drive train car would not go then my accelerator will rev up and down and not go over 10 miles a hour then all these service lights come on and car go in like limp mode and not drive in middle of intersection no one inspected the car i tuned it off and let it sit for 24 hours and started it and it was normally except the acceleration goes up and down when it wants to there were a lot of warning lights

NHTSA ODI 11708605

UNKNOWN. Engine misfires. Piston rings

NHTSA ODI 11707649

My son owned the 2022 Kia s-K5 and lost his life in the same car ...him and my nephew died in this car last [XXX] one month after his [XXX] birthday...he was driving the car hit maybe black ice or the car lock up and went sideways on the payment for .3 of a mile and couldn't pick straits or gain control of the car and then hit a ditch n tree and satellites 2 total with the front of the car rolled the car over into a canal with water in drown and died ..the front air bags never deployed the side ones did but it took a lot of damage on the front were it showed them air bags was defaults and did not perform as a safe device as they are designed for ...then the seat belts were locked and that's cause them to not be able to get out of the car they was trapped in the car so this Kia safety equipment didn't do or perform the job it was intended for so them factors could of very well contribute to them 2 boys deaths so I'm putting an the Kia manufacturer as the responsible ones for building or producing such a bad none safe vehicle that has killed my son and my nephew....I feel that the Kia manufacturer should pay for there negligence and be punished for selling them to the public...it's not fair I'll never see my son again INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11706904

My vehicle is subject to an unrepaired safety recall involving the fuel system. According to the manufacturer’s recall notice, a damaged check valve may allow air to enter the fuel tank, causing the tank to expand and contact hot exhaust components. This can melt the fuel tank, cause fuel leakage, and increase the risk of a vehicle fire. This vehicle has experienced multiple fuel-system-related recalls, and this recall is currently listed as incomplete with no remedy available. The manufacturer has not provided a repair timeline, and owner notification and repair availability are delayed. I am concerned for my safety and the safety of my passengers because I am required to continue driving a vehicle that the manufacturer acknowledges poses a fire risk and cannot currently be repaired.

NHTSA ODI 11705994

The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact experienced the failure, causing the check engine warning light to remain illuminated, and the vehicle hesitated while accelerating. The vehicle was taken to the local mechanic, who diagnosed the vehicle and determined that the check valve was faulty and needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that while the AC was activated, one vent was blowing hot air while the other vent was blowing cold air. No further information was available. The failure mileage was 103,000.

NHTSA ODI 11705504

When engine is Idling the cabin immediately starts to smell completely like gasoline. This happens whether the A/C system is on or not. It’s so strong sometimes that I have to put my window down to release the fumes.

NHTSA ODI 11702623