What 144 owners told NHTSA about the 2022 Ford Maverick Later Release

Door check spot welds broke. Door has unsafe operation. Will not hold open, and swings wildly. No inspection yet. Ford Dealer aware of problem. 2 month out of warranty.

NHTSA ODI 11663661

Water intrusion on front passenger side of vehicle causing mold. Vehicle still has original windshield and all original carpet and interior. Ford Service department unable to do “leak detection at facility” but referenced several online sources believing it is a defective cowl or a/c part that is not sealed. Service department dried vehicle out for 3-4 days and water intrusion is still happening and mold came back.

NHTSA ODI 11661588

At 70,000 (stock truck) truck began shaking under load/ acceleration. Both front CV axles have failed.

NHTSA ODI 11657819

2022 Ford Maverick had water build up under the front passenger seat floor. I'm at 3.5 years of ownership and the dealer is telling me it will cost $1100 to fix because of an improperly installed windshield and cowl issue which ruined the internal filter and air circulation motor. Now i have to pay out of pocket because of a crappy manufacturer defect. I have seen in Maverick forums that this is a common issue and yet we are the ones having to fork out the cash.

NHTSA ODI 11654046

The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 25V019000 (Electrical System); and Parts distribution disconnect for NHTSA Campaign Number: 24V684000 (Back Over Prevention).

NHTSA ODI 11651287

At 61,000 miles on the odometer and the Cv shafts have to be replaced. Ford has no supply on hand and is on a global back order until the end of April. Part adviser said that this is a consistent issue with mavericks.

NHTSA ODI 11651414

The contact owns a 2022 Ford Maverick. The contact stated while her husband was driving at approximately 35 MPH approaching a light with the Auto STOP/START feature engaged, the vehicle shut off. There were no warning lights illuminated. The contact replaced the battery. The contact received notification of NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was taken to the local dealer; where it was determined that the battery was not acknowledging the software. The vehicle was repaired, but the failure recurred. The dealer indicated that there was a loosened bearing and missing screws. The contact stated that the vehicle failed to start 60 percent of the time. While the contact was driving at 35 MPH, the vehicle stalled approaching a stop. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 36,000. VIN tool confirms parts not available.

NHTSA ODI 11647811

My truck's CV axles broke around 20,000 miles. Replacement parts weren't available. This was a safety issue because I expected a new truck with low mileage to be reliable. If I wasn't technically inclined, I might not have understood the danger. The dealership replaced them under warranty, but they didn't inspect the broken parts. The truck shook badly when accelerating, which was the warning sign.

NHTSA ODI 11647390

CV axles failed at around 28k. Replacement parts not available nationwide. Ford has recognized an engineering flaw in the axles, but have not issued a recall. I was informed it was dafe to drive while waiting for new cv axles.

NHTSA ODI 11647410

Vehicle CV Axels going bad repeatedly. Replaced them 3 times. Luckily we've discovered the CV axel failures in low speeds. If it fails at the wrong time like during a turn on the highway, it could cause a serious accident. Plus the cost and inconvenience of repeated repairs continue to be an issue on such a new truck. Most owners report the same issue happening on Maverick forums. It seems lie this program is too common to be ignored. When we contact Ford dealerships parts are never available (back ordered) and it takes weeks to get this replaced adding more complexity to this situation. Formally requesting this issue to be reviewed at the NHTSA level.

NHTSA ODI 11646975

At a intersection turning lane as I got a green arrow, ( as I pushed down on accelerator)a loud pop sounded and all vehicle operations stopped immediately. The battery had popped in the top front side, with battery liquid all over battery. No hazard lights, no putting into gear, only driver door operational at a very busy intersection. Flagging traffic and trying to call for new battery, very tough. Plant city Florida police arrived 20 minutes later. They waited with me until 40 minutes a battery arrived. I cleaned up acid with towel I had in front and tech changed battery. [THIS INCIDENT [XXX]- intersection [XXX] ] I can't express th [XXX] ot changing every battery thats compromised is beyond crazy. I paid $385 for the battery and spent $10 thousand of my life in that intersection. Fords are a lifetime of Dad's/my Family vehicle purchase history and I wish I had some of Ford Brass in the intersection with me. If they think they have a problem, I can guarantee it. Bartow Ford can't do anything because ( its Ford problem/remedy. I was discouraged they didn't say bring it in, but my buying any future product may be my remedy. Their were no warning lights, no smells from engine, no signs of any whisps of smoke coming up from hood. All I can finish with is when it happens, your out of business completely, where ever your at. The tech took the battery and I didn't take a picture because getting out of traffic was No.1. You can't sit inside and read your manual, with no emergency hazards at a busy intersection. You won't get this adrenaline rush/anxiety on a Universal thrill ride. You have a good chance of being hit by one or more vehicles on the inside or outside. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11646748

Cv axles bad went out at 29000 miles could break and your truck could roll

NHTSA ODI 11646408

The contact owned a 2022 Ford Maverick. The contact stated that while her grandson was driving at various speeds, the steering wheel locked and the vehicle lost power steering and functionality. The vehicle flipped over several times. An unknown warning light illuminated. It was unknown if the air bags were deployed. A police report was filed. The contact’s grandson was taken to the hospital via ambulance due to sustaining injuries to the back and neck. The vehicle was towed to a local towing yard. The insurance company was contacted and deemed the vehicle a total loss. The insurance company towed the vehicle to an unknown location. The manufacturer was not notified of the failure. The failure mileage was approximately 27,000. 

NHTSA ODI 11644855

The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (BACK OVER PREVENTION) and 25V019000 (ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11644164

The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11642453

while i was driving the truck lost power and i could not turn on my 4 way flashers when i was on the side of the road. when i called ford and asked if i would replace the battery if i would get compensation they told me no even though there is a recall

NHTSA ODI 11642103

The contact’s father owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that the electrical components in the vehicle were on; however, the engine was off. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that no cause for the failure was found. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 24,104.

NHTSA ODI 11642369

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 25V019000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11642039

The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to accelerate as designed. The powertrain message was displayed. Additionally, the WRENCH symbol was displayed. The vehicle was taken to the local dealer, but the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The Ford Pass App alerted the contact of the failure. The vehicle was taken to another local dealer, Loudon Motors Ford LLC (3476 Union Ave SE, Minerva, OH 44657); where it was diagnosed that the throttle assembly had caused the failure. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was approximately 20,000.

NHTSA ODI 11641628

The contact owns a 2022 Ford Maverick. The contact stated that while attempting to park the vehicle, the rearview camera became inoperable. The contact stated that the image displayed on the screen was frozen. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 52, 000. VIN tool confirms parts not available.

NHTSA ODI 11641645

This is possibly more information regarding the known back-up camera recall NHTSA 24V684. After backing out of a parking space 1/26/2025, the camera froze (not the first time) and this time a message appeared in the upper left corner that read: "Indexing Nexus". I have also had on other occasions times where the Infotainment system itself would freeze with no warning and when the back up camera was not in use. I suspect the recall addressing the camera issue is only part of this and that the system itself has issues not related to the camera. Pressing and holding the POWER and Fast Forward buttons forcing a system restart restored usability.

NHTSA ODI 11639627

The radio head unit often is unresponsive. Needs to be reset multiple times a week. Volume will either not work or no sound at all. Screen freezes and pops. Music cuts out. Skip button from steering wheel does not work sometimes. All operations on the touch screen are slow and laggy. Has had this problem since owning the vehicle.

NHTSA ODI 11638573

The vehicle constantly goes into deep sleep mode and will not start. Battery was tested good at the dealer but would die after 2 hours of sitting. Battery was replaced with an AGM and still has the same issues. Dealer cant find an issue. Happened again today and left me stranded.

NHTSA ODI 11636944

The contact owns a 2022 Ford Maverick. The contact stated that while driving on the highway at 70 MPH, the transmission unexpectedly shifted out of drive. The contact pulled over; however, the transmission failed to shift to park(P). The contact activated the parking brake and disconnected the battery to park the vehicle. The vehicle was restarted; however, the transmission failed to shift into park. The contact stated that while driving at an undisclosed speed, the transmission jumped out of gear, and the contact pulled over and had the vehicle towed to a local dealer to be diagnosed. The contact was informed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure milage was 126,000.

NHTSA ODI 11636047

The contact owns a 2022 Ford Maverick. The contact stated upon opening the front driver's side door, the door made an abnormal cracking and popping sound. The vehicle was taken to the dealer, where it was determined that the door hinge or the entire door might need to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 57,000.

NHTSA ODI 11635931