What 557 owners told NHTSA about the 2022 Ford F-150 Supercab

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11703935

The contact owns a 2022 Ford F-150. While the contact's son was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The Mobile App indicated a failure related to the power train and to reduce power. The contact's son drove the vehicle to the shoulder of the road and turned off the vehicle. While the contact's son was attempting to start the vehicle, the vehicle started. The vehicle was driven to the intended destination, which was approximately 30 minutes away. The following day, the failure reoccurred. The contact stated that the failure had occurred several times. The contact stated that several days later, the 4WD Low warning light illuminated. The dealer was made aware of the failure and a diagnostic test was scheduled for the following week. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was informed that the VIN was included in Customer Satisfaction Program: 23S65/NHTSA Campaign Number: 23V896000 (Power Train). In addition, the contact had not received notification of the Customer Satisfaction Program or recall. The failure mileage was approximately 65,000.

NHTSA ODI 11703715

Hv harness failed (confirmed by dealer/manufacturer) without known reason and without warning, leaving stranded, unable to move vehicle.

NHTSA ODI 11703831

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train), and the vehicle was taken to the dealer, where an inspection was performed. The contact was then informed that the recall repair needed to be performed; however, the part to do the recall repair was not yet available. The dealer ordered the part. The contact stated that while the vehicle was parked in the garage, the contact noticed that oil had leaked onto the ground underneath the vehicle. The vehicle was driven to the dealer, where it was diagnosed that the rear axle bolts and rear main seal had failed; however, the part to do the recall repair was not yet available. The vehicle was not repaired and had been at the dealer for two weeks. The manufacturer was notified of the failure. The failure mileage was approximately 27,000.

NHTSA ODI 11702969

The contact owns a 2022 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 23V896000 (Power Train) and 25V455000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The contact stated that upon starting the vehicle and shifting to drive(D), the vehicle jumped and attempted to accelerate unintendedly. Additionally, the contact stated that upon shifting to reverse(R), the 4WD engaged unintendedly, and the vehicle made an abnormal sound and became difficult to steer. The dealer was contacted, and an appointment was scheduled for the recall repairs; however, upon taking the vehicle to the dealer, the contact was informed that the parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was notified of the failure and contacted the dealer on the contact's behalf. The dealer then called the contact and advised that the recall parts were not yet available. The failure mileage was approximately 14,000.

NHTSA ODI 11702725

The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, there was a loud rattling sound coming from the vehicle. There was no warning light illuminated. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 23V896000 (Power Train); however, parts for the recall repairs were not yet available. The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer informed the contact that the vehicle could not be serviced because parts were still unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,400.

NHTSA ODI 11702768

The electric motors in the hybrid system intermittently fault and fail completely. I get an error saying there's a powertrain/4wd system failure. There's no clear cause. I've had this in for service numerous times. I've paid for a repair that did not resolve it. They had me pay for a repair for a new alternator-generator unit ($1500). When I get this fault, the truck operates only on gas power and does not use any electric motor power. I go from ~21 mpg highway (which is lower than when new) to ~18 mph highway.

NHTSA ODI 11702204

The contact owns a 2022 Ford F-150. The contact stated while the vehicle was at the independent mechanic receiving a tire replacement, the contact was informed that the rear passenger's side axle bolt was fractured and had detached. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was taken to the dealer; however, the contact was informed that the part was not available to repair the vehicle. In addition, the dealer kept the bolt. The contact was advised to contact the manufacturer for assistance. The contact stated that the vehicle was taken to the dealer twice for inspection prior to the failure, however the contact was informed that the parts were not available. The contact was unsure of when the failure had occurred between 10/16/2025 and 10/24/2025. The contact stated that because of the failure and the parts not being available, the vehicle was not repaired. In addition, the contact no longer had a vehicle to drive. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part was not available for the recall repair. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the parts were being manufactured. The failure mileage was approximately 40,500.

NHTSA ODI 11701670

Since I've purchased the truck in 2023 I've been receiving in the mail notices about a recall for the rear-axel shaft for my 2022 f150. I am a major proponent of safety and maintenance. Year over year I've attempted to get it fixed at authorized ford dealerships but I've been told a handful of times that the parts are not available and I'm not getting the appropriate urgency required for an issue of this stature. I am embarking on a big trip and I'm concerned about my safety and the safety of others on the road.

NHTSA ODI 11700862

Loss of engine coolant resulted in overheating and need to pull off to side of highway. Issue is described in the SSM - 51485 described below 2021-2023 F-150 - 3.5L PowerBoost - Loss Of Engine Coolant Due To External Coolant Leak At The Heat Exchanger Coolant Spigots Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine may experience a loss of engine coolant with possible engine overheat and/or illuminated malfunction indicator (MIL). This may be due to a crack in the exhaust heat exchanger coolant spigots on the top of the exhaust heat exchanger. The exhaust heat exchanger coolant spigots are now released and should be serviced in pairs. It is no longer necessary to replace the muffler inlet pipe assembly for this type of concern. Workshop Manual, Section 309-00D has been updated to include a new service procedure. For claiming, use causal part 18663 and applicable labor operations in Section 05 of the Service Labor Time Standards (SLTS) Manual. Heat exchanger coolant spigots - NL3Z-18663-A (2 req).

NHTSA ODI 11700890

On Acceleration from a stop at approx. 35 miles per hour the rear wheels locked up causing the vehicle to come to an abrupt screeching stop. Almost rear ended by other vehicles causing great concern for safety. According to Ford the codes that kicked off are transmission shift solenoids. This is the second time this happened, fist time was backing out of a driveway, no codes and could not detect. I have fear this could happen at higher speeds and cause great harm.

NHTSA ODI 11697209

Transmission malfunctioned leaving me with stuck in an intersection with no power, has down shifted unexpectedly on the highway causing the truck to slow down out of nowhere, also very rough shifts at low speed. No warning lights on the dash, problem appeared intermittently but was confirmed by AutoNation Ford St Petersburg location by Ford tech. Took it to an independent transmission specialist and they also confirmed the failure and found large metal chunks in the transmission oil pan. I am out of warranty and even though it was still drive able and not giving a check engine light, I opted to replace the transmission out of pocket due to safety concerns.

NHTSA ODI 11692485

I have a 2022 f150 2.7l with 46000 miles. I have had issues with the truck ever since I bought it. The safety issue is a few things. One when I put it in reverse my truck shudders and acts like I pressed on the break really fast several times. I also havr an issue with a cold start when I start it up the truck it acts like it wants to die or looses rpms. I here a paddling coming from the intake valves possibly. Im not sure what part is broke but it makes a rattling sound. Iv brought it to the dealership that I bought the truck from and they say we domt notice anything and its been a struggle to get them to actually thoroughly look into it. Im concerned it will lead to an engine failure because it also loses power and wants to die at times. Iv taken excellent care of the truck and always change oil and any parts on time. It also when I put it in drive makes a loud clunk sound and has a very hard time shifting gears between 3 and 4. Very rough shifting and very concerning.

NHTSA ODI 11692176

I bought the truck and two months later as I was driving the vehicle the rear defrental went out and caused the wheels to improperly balance the speed of all tires as I turned and cause my truck to turn roughly and I almost got in a wreck. I brought it to ford and they seen it needed to be replaced. Mind you its only been a few months. About a year later it has issues again as im driving and I also noticed it was leaking def oil really bad. I brought it in and they said they fixed it. About 7 months later I had issues with it again and they had to repair again. Its very concerning and is a big issue and safety concern.

NHTSA ODI 11692177

9/17 driving home. Light rain. Put the truck in slippery mode prior to starting my drive. Truck was actually slipping and seemed to be shutting off and on. Prior to me being able to pull off to the side of the road, the truck stalled and spinned out across five lanes slamming into the barrier.

NHTSA ODI 11689324

Rear axle bolt has broken, creating issues in the rear end which Ford that said they do not have the parts to fix. The Ford dealership has told me it is perfectly safe to drive although the recall states could result in a crash. The Ford mechanic opened the hubcap and took the broken bolt out still saying it was safe to drive. That was six months ago. I have contacted Ford several times to get my vehicle in And they tell me they still do not have the parts. This is a huge safety issue with Ford not willing to fix the problem. They said they did not have loaner vehicles available either.

NHTSA ODI 11687829

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while receiving a tire rotation during a routine oil change, the dealer informed the contact that the passenger’s and driver’s side rear axles were fractured, and the recall repair needed to be performed. The dealer informed the contact that parts had not yet been sent by the manufacturer for the recall repair. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 27,000.

NHTSA ODI 11682368

Issue #1 Transmission while going up steep incline and gears go from gear 10th to 9th gear there is a hard thump, dealership says they will not do anything if it passes their clutch pack test. Issue #2 rear driver shock absorber was replaced at 38,000 miles due to leakage. 4k miles(1month) later the new shocks paint is wore off and has the same markings the old one has, this will cause premature failure and premature rusting. The sock absorber on the other side has no markings and paint is fine (42k Miles old) This may be due to a defective bolt Bolt (w720200 S440 nut I had to have replaced as it was missing..Then few months later the shock absorber went out and was charged ($358 for repair) now I have a premature wearing part installed again seems to be an overall issue with back end suspension

NHTSA ODI 11680504

Have contacted 2 different Ford dealers starting from November 2024, when I bought the truck, to get this recall repaired. Dealers tell me they'll order the parts and get back to me, but never call me back. When I call them they tell me there's nothing they can do. This recall was issued in August of 2023. I've recieved 4 different recall letters since November of 2024 for different probmems related to my truck. It's been 2 years that have gone by with no remedy to repair this recall of the axle bolts breaking...I guess they're waiting until I'm in an accident and sue them before they'll do anything....This is BS...!

NHTSA ODI 11678368

While proceeding through a four-way stop, my vehicle unexpectedly lost driveline engagement. The engine began free-spinning while still in "Drive," and the truck stopped accelerating, leaving me stranded in the middle of the intersection. I had to shift repeatedly between Park and Drive before the vehicle would respond and move again. This is not an isolated incident. The same failure occurred previously in early 2024. The vehicle has also exhibited persistent transmission issues, including gear hunting and harsh downshifts, particularly a hard clunk during the 4–3 shift on deceleration. The dealer has dismissed these symptoms in the past, stating it was due to the transmission being "cold." However, the intermittent loss of driveline engagement presents a serious safety risk to myself and others, especially when it occurs in active traffic situations. This is the second time the vehicle has left me stranded without warning. I’m extremely concerned that Ford has not addressed this recurring safety issue. The condition is unpredictable and dangerous. Immediate investigation and corrective action are needed.

NHTSA ODI 11678384

This is regarding ford's known issue with their evaporator cited in TSB 22-2089. The evaporator caused a compressor to fail, which caused a power train failure notification in sync and on the phone app. The compressor is under warranty, but the evaporator is not, which causes a $3600 repair (parts and labor). According to the bulletin, the evaporator known issue is NOT considered a threat to life, even though it certainly is a threat to life to not have air conditioning in hotter states. The part is currently being replaced at our local dealership.

NHTSA ODI 11676934

While driving multiple issues presented themselves. First was a drivers screen warning light. It said Drivetrain Malfunction-Power Reduced. I was on a 1000-mile road trip and wisas well into the trip. I kept driving without any operating issues with the exception of having steering wheel button controls malfunctions also. They included cruise control cancel button not working. The slow down button actually speeding up. This issue was actually repaired previously and now it is presenting itself again. Very unsafe when buttons work in reverse or don't work as intended. The Drivetrain Malfunction disappeared for the next few days but came back. There have been other wiring splicing repairs made at the dealer and these could be related. The wires were spliced because a wiring harness could not be obtained as it was backordered. Vehicle is just out of warranty and only has 23K miles. Critical wiring has corroded already.

NHTSA ODI 11672754

The contact owns a 2022 Ford F-150. The contact stated that while attempting to accelerate, the transmission unexpectedly downshifted while the accelerator pedal was depressed. In addition, while releasing the accelerator pedal to decelerate, the transmission unexpectedly upshifted. No warning light was illuminated. The vehicle was taken to a local independent mechanic and was diagnosed with transmission failure. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.

NHTSA ODI 11672815

I was driving through rain on [XXX] and my truck was having trouble shifting in 4x4 mode. An error message appeared stating "4x4 Service Needed". I clicked OK and the message went away. Due to driving, I was unable to take a photo of the error message. When I called Maguires Ford where I purchased the vehicle, they told me this message meant the system could malfunction and that I needed to bring the vehicle in ASAP. At first they told me there was no history of the error message and since they could not pull a code, there was nothing they could do. After reviewing a second time, they verified the error message did appear but they could still not pull a code so there wasn't anything they could do. They said most likely the rain got into the module and caused the system to malfunction. I asked how rain would get into the module and they didn't answer the question. No further investigation was completed and they told me to take the vehicle home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11671721

Jan 2025 bought a 2022 Ford F150 Lariat 3.5 eco boost with 10 speed transmission with 32,000 miles on the transmission started going out around 35,000 miles as it was shaking, shuttering, and hesitating. Took it to one dealership they had it for a couple of weeks and couldn’t figure it out and said it was normal. I told them it’s not safe to drive with as bad as the hesitation was. Decided to go to another dealership they figured out the problem fixed and got it fixed. Drove it for a week starting have issues with it shaking between gears 7-10 with the smell of burning transmission fluid in the cabin. Took it back to the dealer they had it for 3 weeks drove the truck and felt the issue I explained but told me they couldn’t fix the problem and there is nothing they can do right now. During the time of going between dealerships got in contact with Ford they made a case against the truck but have not got involved with fixing the problem. All of this does not include the 2020 F150 Lariat 3.5 eco boost I bought at the end of 23’ with 38,000 miles and at 45000 miles had Transmission issues and had to be rebuilt but never got fixed correctly so ended up having to trade it in with all of the other issues with that truck. Ford denied the buyback I applied for and refuses to fix the problem. This is a very big problem as this has been going on for a while with Fords 10 speed transmission.

NHTSA ODI 11669428