What 245 owners told NHTSA about the 2022 Ford Explorer Gas

Im being told my car is not covered under the recalls from the Chicago Ford plan when I have the exact same DTC codes currently showing on my car as listed in the recall and SSM. The check engine light is on with DTCs P018C and P04F0. Please have the technician specifically reference Ford Special Service Message (SSM) 51247 and inspect connector C1198 on the driver's side frame rail for water intrusion, damaged terminals, or poor pin fit before replacing any parts. Also, please check my VIN for open Recall 22C02 (Fuel Filler Tube End Form) and perform the recall if applicable. If the P04F0 is related to the recall, please diagnose and repair accordingly. combination of P018C + P04F0 is still the reason to have connector C1198 inspected.

NHTSA ODI 11749225

On [XXX], at approximately [XXX] PM, my 2022 Ford Explorer suddenly lost power while driving in the left lane of [XXX] in Emporia, VA, at 70 MPH (the posted speed limit), with my [XXX] daughter. My vehicle shuddered and started to decrease in speed. I was able to maneuver safely to the shoulder, and my Explorer became inoperable requiring roadside assistance. My daughter and I remained on [XXX] for several hours due to delayed tow service availability. My Explorer has been at Battlefield Ford in Culpeper, VA since June 19, 2026, and is available for inspection upon request. Battlefield has confirmed the low-pressure fuel pump failure, confirmed this is subject to Safety Recall 25S75 (NHTSA Recall 25V455), and there is no remedy available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11747291

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11747129

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part required for the recall repair was unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted, and it was confirmed that the recall remedy was not available. The contact inquired about a loaner while waiting for the remedy but did not receive assistance. The manufacturer was made aware of the issue, and it was confirmed that the remedy was not available, and a loaner would not be provided. The contact had not experienced a failure.

NHTSA ODI 11743432

The contact owns a 2022 Ford Explorer. The contact stated while driving at 55 MPH, the vehicle was driving unusually rough and the vehicle stalled. In addition, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was driven to the shoulder of the road. The contact stated while attempting to start the vehicle, the vehicle failed to stall as intended. The vehicle was towed to the independent mechanic where it was diagnosed with a failed low pressure fuel pump. The contact was informed that the low pressure fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced a recall, NHTSA Campaign Number: 25V455000 (Fuel System,Gasoline) however the contact's VIN was not associated. The failure mileage was approximately 64,598.

NHTSA ODI 11740416

The contact owns a 2022 FORD EXPLORER. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE) however, the part to do the recall repair was not yet available. Local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact state that while his daughter was at a stop sign and depressing the accelerator pedal to drive, the vehicle stalled. The contact was concerned that control of the vehicle was lost and could result in a accident. In addition, the contact stated that when depressing the brake pedal there was an abnormal sound coming from the vehicle. The failure would occur on numerous occasions. The vehicle was taken to a dealer where it was diagnosed but the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure milage was 30,000.

NHTSA ODI 11740100

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The vehicle was restarted. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,000.

NHTSA ODI 11736284

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The vehicle was restarted and taken to the dealer, who was unable to duplicate the failure. There were no diagnostic trouble codes retrieved. The dealer confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

NHTSA ODI 11732715

There are three active recall on my car, all of which say there are not remedy available and NHTSA Recall Number 25V455 can cause engine failure that leads to a crash, was reported in July 2025, and STILL has no remedy. The other 2 recalls are NHTSA Recall Number 26V123 and NHTSA Recall Number 26V117.

NHTSA ODI 11730431

This recall has been open for 8 months, all the while posing a huge safety risk. A new car can be built in less time. Why is this urgent recall effort taking so long to complete? Jul 08,2025 Manufacturer Recall Number25S75 NHTSA Recall Number25V455 Recall Status Recall Incomplete, remedy not yet available

NHTSA ODI 11724942

Component/System: Low-pressure fuel pump/fuel delivery system related to Recall 25S75. Vehicle is a 2022 Ford Explorer Hybrid. Description: My vehicle is subject to Recall 25S75 involving the low-pressure fuel pump that can cause loss of fuel pressure and engine stalling. The vehicle has stalled six times between about 15,000 and 35,000 miles. The issue is intermittent but ongoing. The vehicle is available for inspection. What failed or malfunctioned: The fuel delivery system appears to lose pressure consistent with Recall 25S75, leading to engine stalling and temporary inability to restart. Safety risk: One stall occurred while driving on a highway on 9/30/23 at about 15,000 miles. The engine lost power without warning and I had to coast to a gas station. Sudden loss of propulsion in traffic creates a serious crash risk. Other stalls happened in driveways or parking lots after the vehicle had been running. In several cases the vehicle would not restart for 20–60 minutes, which could be dangerous if it occurred in traffic or an unsafe location. Reproduction or dealer confirmation: Two incidents required towing to Ford dealerships. The vehicle has been taken to Ford dealers multiple times. Earlier incidents were not linked to a recall at the time. Now that Recall 25S75 has been issued, the symptoms match. Ford has not repaired it because the remedy is still under development and parts are unavailable. Inspections: The vehicle has been inspected by Ford dealerships and towed twice by AAA for diagnosis. No permanent fix has been made because the recall remedy is not yet available. Warnings or symptoms: Stalls often occurred after the vehicle had been running. The vehicle then would not restart for 20–60 minutes. In one event there were dashboard errors. There was not always a clear warning before a stall. Reason for complaint: The recall has been open since July 2025 with no remedy available. The vehicle continues to stall. I do not feel it is safe to operate.

NHTSA ODI 11718125

The contact’s employer owns a 2022 Ford Explorer. The owner received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was purchased as a driver's education vehicle, and due to the recall, the vehicle could not be used for the driving courses. The dealer was contacted and confirmed that the remedy was not yet available. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11715548

The contact owns a 2022 Ford Explorer. The contact stated that while driving approximately 35 MPH, the vehicle stalled. There was no warning light illuminated; however, before the vehicle stalled, the engine was sputtering. The vehicle was towed to a local dealer where it was diagnosed, and determined that the fuel pump had failed; however, the part to repair the vehicle was not available. The vehicle was not repaired. The contact had received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 52,000.

NHTSA ODI 11714280

The fuel level indication on my 2022 Ford Explorer behaves erratically and inaccurately. The issue occurs regardless of whether the vehicle is parked uphill, or downhill, just any time I’m on an incline, and it happens even when the fuel tank is full. The fuel gauge and/or “miles to empty” reading changes unexpectedly and does not reliably reflect the actual amount of fuel in the tank. This behavior is not limited to low fuel conditions. The problem appears consistently raising concerns about inaccurate fuel level reporting and potential fuel system malfunction. The vehicle has not displayed warning lights, and the issue is resolved by refueling, but changing parking orientation does not reset or cause the fuel gauge to show accurate reading. I have had one instance of needing to call roadside assistance as it falsely read I was out of fuel.

NHTSA ODI 11710580

I own a 2022 Ford Explorer purchased in April 2025. Since purchasing the vehicle, I have experienced multiple defects affecting safety and normal use. The instrument cluster becomes foggy, making it difficult to clearly see my speed while driving. The infotainment screen intermittently malfunctions and affects the backup camera display, reducing rear visibility. I also experienced fuel contamination that was confirmed and repaired by the dealership. In addition, the rear HVAC air vents close and do not provide airflow to the back seats. The vehicle has been taken to the dealership four separate times for different issues. Despite these repair attempts, the problems have continued or new issues have appeared. Due to the ongoing defects and safety concerns, I do not feel safe or confident operating this vehicle.

NHTSA ODI 11708973

The exhaust/ downpipe broke while driving down the road.

NHTSA ODI 11700020

I can’t get my gas tank below 1/4. It always starts lagging and has a late reaction time. I also have to use better gas and get treatments to help. With no solution in sight

NHTSA ODI 11699304

Ford Explorer Recall – Ongoing Safety Hazard In July 2025, Ford issued a recall notice for my vehicle. Shortly after, the check engine light came on. Starting October 15, 2025, my vehicle began failing to start after refueling—making noise and taking multiple attempts to start. The same issue occurred repeatedly on October 23 and October 30, worsening each time. On November 3, we brought the car to a Ford dealership. They confirmed there is no available fix for the recall and said there’s “nothing they can do.” I explained this was a safety issue since I drive my son with a disability to therapy daily. They told me I would have to pay out of pocket for repairs even though the problem is linked to the recall. On November 8, while driving in Arizona, my vehicle again failed to start after refueling. Later that day, it lost power on the road, the speed dropped suddenly, and it would not accelerate. The same stalling and jerking occurred again on November 10 while my husband was driving. We contacted Ford Corporate and NHTSA, but both said nothing could be done because the recall label says the car is “still drivable.” This is inaccurate and dangerous. The car stalls and loses acceleration randomly, creating a serious risk of an accident. On November 21, the car again failed to start after refueling. This has happened multiple times each week, and Ford continues to delay a fix. My vehicle is unsafe to drive, and this unresolved recall poses an ongoing safety hazard to my family and others on the road.

NHTSA ODI 11698789

The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle was able to restart. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The VIN was included, but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 99,000.

NHTSA ODI 11698551

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11690778

When i accelerate, the car jerks back and forth and stalls. ford has said the car was throwing codes but the TECH didnt feel the issue so they sent me on my way.... well fast forward to today, i am informed my car has thrown codes 4 times in the past few days and this morning i was scared to drive my car it was bad... and i have a [XXX] daughter. Our safety is my top priority and it doesnt seem to matter to anyone else INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11677769

The contact owns a 2022 Ford Explorer. The contact stated while driving 50 MPH, the "Service Engine Soon" message was displayed. The dealer was contacted. The vehicle was taken to a dealer where it was diagnosed that the fuel pump sensor needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 40,677.

NHTSA ODI 11677886

Charcoal canister and vapor purge valve failure. Broke down twice after putting gas in my car right at the pump. One time in not the greatest neighborhood that I have to drive through to get to work. Putting myself at risk by sitting at a gas pump with a car that sounds like it wants to start but keeps just choking. After fueling a few times prior I noticed the idle of the car getting very low and reported it to the dealer. They replaced both cats. Problem didn’t go away. Got an emissions warning when I tried to start the car at the gas station after fueling. Car has 70,000 miles on it.

NHTSA ODI 11656664

My wife was driving the car all of a sudden the check engine light came on, and it started to flash on and off. The car started sputtering. She pulled over turned the car off and called me. I informed her to wait a little bit and restart the car. She did – and then the check engine light came on, but was no longer flashing, and a car started running as if no problem. I had the code checked out it is P0300 – which is an error code of random misfire detected in the engine. Fortunately, she was not evolved in an accident, even though she was traveling on the highway. I am taking it to the dealer as his recommended. This happened when the mileage on the odometer read 40,144.

NHTSA ODI 11635503

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked on an incline, and with a quarter tank of fuel in the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 20,000.

NHTSA ODI 11577936