What 328 owners told NHTSA about the 2022 Ford Bronco Sport

I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until it caught fire and electrical smoke was rolling i had to call the fire department i was parked at a dayhab for special needs had to run and have them to remove all of the special needs people in wheelchairs and or with other adaptive equipment had to run into another office building and tell them to remove their vehicles i had a serious worry that this could have hurt or even killed people they at the ford dealer that has had my car 21 days said it's the starter no way the starter just went nuts for no reason we had to call the fire department and everything they replaced the battery which my understanding has recall 24s24 which says causes glitches either someone is blaming a starter for something other than that

NHTSA ODI 11690883

The contact owned a 2022 Ford Bronco Sport. The contact stated that while the son was driving at approximately 60 MPH, smoke was seen coming from under the hood. After driving over to the shoulder and exiting the vehicle, the vehicle was quickly engulfed in flames. The fire department was called to the scene and extinguished the fire. No injuries were reported. During the incident, the vehicle was destroyed and later towed to a nearby towing yard. The cause of the fire was not determined. The manufacturer and dealer were notified of the failure but no assistance was offered. The contact indicated that the vehicle was previously serviced for the NHTSA Campaign Number: 22V859000(Fuel System, Gasoline). The contact indicated that the vehicle had experienced that same failure listed in the recall. No police report was taken. The failure mileage was 6,000.

NHTSA ODI 11584401

On [XXX] I began my drive from Miami, FL to SF, CA for my next travel nurse assignment. Three hours into my drive, I stop for gas and return to the highway. I remember accelerating to catch up to traffic and moving into the left lane. Then I remember abruptly seeing brake lights ahead, braking hard, and the collision warning system going off. I was braking for several seconds and it became clear to me that I was going to crash into the vehicle in front of me. Immediately upon impact, my Bronco Sport caught fire. I felt the heat. I smelled the fire and fumes. I saw people running towards me, yelling for me to get out of my burning car. The airbag went off and I sustained minor injury to my right hand. At that point, my priority was to locate my cat inside my perfectly packed vehicle with all of my most important possessions. I grabbed my cat, my phone, and my purse and escaped as flames overtook my SUV. The Nissan Rouge in front of me sustained some rear bumper damage but overall relatively minor exterior damages. I am in awe that what should have been a minor collision turned into escaping a burning car with my cat and watching my everything burn away. I struggle with PTSD from the accident. The Bronco was well-maintained. I had the recall repaired, along with oil change and tire rotation in November, prior to driving from Southern California to my home in Miami in early December. The vehicle was deemed a total loss by the insurance company. The insurance company did not choose to pursue any investigation on why this happened. I’ve tried to find answers and have not been successful. The Ford dealership where I purchased the Bronco has been less than helpful and even normalized that this happens sometimes. Four months later and I’m still waiting to get refunded for all the extra extended warranties that I bought for a vehicle that I planned on having for a long time. No one seems concerned that my car caught fire instantly. This should not have happened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11582599

The contact's daughter owned a 2022 Ford Bronco Sport. The contact stated that an intermittent fuel odor would emit from the vehicle without warning. The contact had inspected the vehicle and did not detect any leaks or defects. The contact stated that while his daughter was stopped in a parking lot, an "engine compartment hot" warning message appeared on the instrument panel as an unknown color smoke began to emit from the vehicle. The vehicle quickly caught fire soon after the smoke began. The fire department arrived at the scene and extinguished the fire. A fire report was filed. The contact's daughter sustained mental anguish as a result of the fire. Due to the failure, the vehicle was towed to an independent tow yard where it remained in their possession for an investigation. The manufacturer was notified of the failure but offered no assistance. The vehicle was destroyed. The failure mileage was approximately 2,700.

NHTSA ODI 11522646

vehicle with 900 miles on it began smoking and caught fire under the hood for no apparent reason. Vehicle was in new condition. Vehicle likely a total loss (see photos). Driver was lucky to escape

NHTSA ODI 11492022

The driver was on M53 near Armada around 5pm today, July 25, 2022. The owner was driving down the road another vehicle pulled up next to her and told her the vehicle was on fire. The driver was able to exit the vehicle and took the photo (unable to upload photo). Owner called 911 and fire department was able to extinguish the fire.

NHTSA ODI 11475881