What 191 owners told NHTSA about the 2022 Chrysler Pacifica Awd

I am reporting an ongoing, catastrophic safety defect and corporate suppression regarding Chrysler Recall 03A (NHTSA Campaign 23V010) on my 2022 Chrysler Pacifica Hybrid. The official recall remedy has repeatedly failed to prevent total electrical system depletion and unexpected motive power shutdown in the field, leaving my family in extreme danger. On March 3, 2023, at 6,000 miles, the vehicle suffered a complete, un-warned motive power shutdown while I was driving my two young children on a rural highway. The vehicle stalled dead on an incline in the middle of a lane. The brakes failed to engage automatically, so I couldn’t evacuate my children because I had to keep my foot on the brake. Cars had to swerve around our vehicle at 55 MPH, as it was on a blind corner. My children were deeply traumatized; my autistic child was completely inconsolable and now suffers from an ongoing, severe psychological fear surrounding this vehicle stopping unexpectedly. We were only saved from a crash because a passerby stopped to help after about 15 minutes. The dealership subsequently applied the Recall 03A software update and replaced the 12V battery. This recall remedy has utterly failed. The replacement 12V battery died again in May 2025 and died a third time in June 2026, proving a chronic electrical defect exists. The dealership refused to perform parasitic draw testing, refused diagnostics, and simply charged the battery, stating 'it's fine.' Chrysler corporate support subjected me to a cycle of unresponsive case managers. One manager promised a buyback review within 3 days, but instead, a subsequent manager closed my file. Corporate explicitly refused to escalate the vehicle to their STAR technical team and flatly refused to provide copies of my warranty and service records. I explained to both corporate and the dealership that I don’t feel safe driving this car without further diagnostics but corporate refused to authorize, stating they stood by the dealer.

NHTSA ODI 11748250

Upon attempting to charge the vehicle with factory supplied Level 1 charger, a dashboard message appeared stating "Service Charging System" and the vehicle would not charge. Took the vehicle to a service station and scanned the vehicle. Listed error code is p0d27-00. The code could not be cleared and the vehicle was unable to be charged. Vehicle had to be taken to a Chrysler dealer for the code to be cleared in order to charging capability to be restored. This was considered a "software" issue and not covered under the vehicles warranty - despite it directly affecting the fuel/hybrid propulsion system. This defect and inability to clear the code means the vehicle cannot be charged, reducing its range and fuel economy, and increasing emissions. This is a critical issue and should not incur customer expense to have the code cleared.

NHTSA ODI 11746134

1. Most emergency lights come on while the vehicle's brake engages automatically. The brake then pumps up and down on its own if any pressure is applied. Shortly after, the vehicle goes into "limp mode". The vehicle is currently at a Chrysler Dealership service department and available for inspection. 2. This has occurred 8 times since the vehicle was purchased in October 2024. All but one time, it has happened while driving. Once it happened while on a major highway. I had to quickly veer into a turn lane so our vehicle was not rearended by another car. Another time, I was driving my children to school and it happened about 10 seconds before crossing the worst intersection in our city. That could have resulted in a major crash based on the history of that intersection. A third time, I was traveling at about 40 miles an hour when warnings came on and the brake started to engage. Luckily, I had just gotten off a major highway and I was able to get to the side of the road. 3. The problem has been confirmed by a dealer, since it happened while I was in their service parking lot. However, they have been unable to recreate, find the source of, or fix the issue after 7 times of servicing it. 4. I am unsure whether the manufacturer has sent anyone outside of the dealer's service department to inspect the vehicle. We have been in contact with the manufacturer directly since December 26, 2025 in relation to this issue. Our extended warranty company may have had an inspector out on the first visit to the dealership for the issue, but no one since that I am aware of. 5. Emergency messages have included: Service Electronic Stability Control, Service Charging System, Service Hybrid Electronic Vehicle System, Auto Emergency Braking Unavailable Service Required. Multiple emergency lights come on including: Check Engine, Electronic Throttle Control, Electronic Stability Control Active, Service Forward Collision Warning. The first incident was January 22, 2025.

NHTSA ODI 11740092

My 2022 Chrysler Pacifica PHEV has experienced three separate complete losses of motive power at highway speed, each preceded only by a brief dashboard warning to pull over safely. First occurrence: April 18, 2026. Second: May 7, 2026 — vehicle towed to Spitzer Motor City (Cleveland, OH), an authorized Stellantis dealer. Dealer replaced the Power Inverter Module hardware under warranty (R.O. 42463CY). Third occurrence: May 17, 2026 — just five days after the repair. Notably, the battery was at 40% on the third occurrence, meaning the engine had not cycled on, distinguishing this failure from the prior two. The root cause is the internal transmission wiring harness connector short identified in NHTSA Recall 03A (23V-010). Per NHTSA's own ODI investigation (RQ24-004), the software recall remedy does not prevent loss of motive power. TSB 21-008-23 / Warranty Extension XE1 identifies full transmission replacement as the correct fix. The dealer did not perform a transmission replacement. The safety risk is severe — complete, sudden loss of drive power at interstate speeds with minimal warning creates immediate rear-end collision risk. The defect has been confirmed by the authorized dealer. The transmission assembly is available for inspection. No police or insurance involvement. This VIN currently shows zero open recalls, suggesting the incomplete repair was logged as satisfying Recall 03A.

NHTSA ODI 11738423

I was traveling on the freeway at approximately 65 miles per hour. I slowed to approximately 50 miles per hour to pass a disabled vehicle and began accelerating again when the dash displayed a message that said "Stop Safely- Vehicle will Shut off soon" the check engine light, a red turtle light also lit up. I had to make a quick maneuver to the far right lane putting myself and other vehicles at risk to avoid the car shutting down in the middle of the freeway. I wanted to get closer to an exit so I continued driving slowly on the shoulder. The wouldn’t accelerate, so whatever speed I let it get down to was the fastest it would go. At the exit I was concerned I wouldn’t have enough power to make it up the hill so I shut off the car. I let it sit for a couple of minutes and then turned it back on. It turned on with the check engine light still on . I then drove it straight to the dealership using surface streets and keeping my speed around 40-45 miles per hour. This was the second time this vehicle has experience this kind of loss of power. The first time happened in July 2024 and resulted in a full transmission replacement. This incident constitutes a dangerous loss of motive power at highway speeds. The failure mode appears identical to the issues described in NHTSA Safety Recall 23V-010 (Chrysler Recall 03A), yet this vehicle has already had a full transmission replacement for this exact issue in the past.

NHTSA ODI 11732606

While driving 75MPH, the vehicle shut down with a message to pull over. All acceleration was lost. We had to navigate, without warning, across 3 lanes of traffic to pull over on the right side of the highway. This was EXTREMELY unsafe as we were slowing down and essentially cutting off other vehicles who were honking at us as this was a traffic hazard. All 6 members of my family were in the vehicle. We had this happen another 3 times before arriving home. I took it to my local dealer, who could not replicate it. They performed a software update, which I have since learned would NEVER fix this problem. We had it happen to us 5 more times, so I took it to another dealership, who initially could not replicate it. In all cases, we had the following check engine light codes be triggered. I have screen shots of them from my personal OBDII reader: P0A43 "Drive Motor 'A' Position Sensor Circuit Intermittent", C2225 "Status: MIL - PCM Disabled EDU: No Sub Type Information". After doing my own reading, it seemed many others have experienced the exact same symptoms and it has required a transmission repair/replace. I also learned most people had a battery charge on the high voltage battery (as this is a plug-in hybrid) when the vehicle shuts down. I charged my van, took it for a ride at 75MPH and it occurred within the first mile. I took it back to the dealership, and at this point, I refuse to drive it until the hardware fix happens. It seems like this should be a recall for all vehicles that can have this problem. It is EXTREMELY unsafe as it occurs at 70MPH+ speeds.

NHTSA ODI 11710194

Fuel line leak near engine. It sounds very similiar to the 2023 Chrysler Pacifica Recall. The vehicle reaked of gasoline fumes coming in through the vents. Our mechanic replaced the fuel line, said it had a hole. We felt very unsafe even starting the car when it reaked of gas due to risk of fire. No warnings lights or anything, just the smell to tip us off. No one else has inspected the car since we didn't have anything catastrophic happen.

NHTSA ODI 11701709

6/21/25 , a Saturday, I stopped at a traffic light when gas saver function kicked in and shut car off. The car went into park mode by itself and parking brake engaged. The car would not start and had to be towed. It sat until Monday when I was able to start it and drive it to my mechanic's business a mile from my location and shut it off. Immediately after shutting it off it would not start again. My mechanic was able to start it a few days later and when he drove it about 5 miles it just shut off and wouldn't start again. Today he is replacing the starter and believes the gas saver function may have contributed to the increased wear on the starter leading to failure, as well as the heat from the catalytic converter located near the starter. I am very nervous about driving this car again and worry it may happen again when I am in traffic. This is a major safety problem if not resolved.

NHTSA ODI 11670249

While at freeway speed (~75mph) "Vehicle Will Shut Off Shortly" warning appeared and lost propulsion. I pulled over and was able to get to a rest stop at reduced speed (~35mph) with the remaining battery power but it was not ideal as shoulder was limited due to road construction and could not leave vehicle on side of the road. Prior software update 03A / 23V-010 was performed as it looks to be a known condition. The software update does not repair the root cause of the failure.

NHTSA ODI 11665757

When driving on hybrid mode with battery charged up suddenly warning message showing “Transmission Failure” and message saying “Stop Safely Vehicle is going to shut off soon”. Breaks don’t work as normal when this happens and vehicle wouldn’t stop immediately. Feels unsafe to drive. Engine warning lights turn on and stay for a day after this happens. Checked with dealership and they mentioned recall is still being worked upon and not yet available. Tried reaching MOPAR directly but no response yet.

NHTSA ODI 11654634

I was driving down the highway. The check engine light comes on. Then a warning comes on that say prepare to stop the car will shut down. This is a hybrid. The electricity is depleted but the gas tank is half full. After turning the car off i can run it for a little while and then the same warning comes back.

NHTSA ODI 11643528

When driving on the interstate highway with about 70 mph a warning message “Service hybrid electric vehicle system” appeared. The high voltage battery charging level was less than 1%. About 30 minutes later, after exiting the highway, another warning message was displayed: “Stop Safely Vehicle will shut off soon”. After about 30s later the motive power was stopped and the car continued rolling. There was no propulsion power anymore, and I was only able to roll into the entrance of a parking lot. Luckily it was a relatively safe location where the vehicle came to a stop. I was alone in the car and was not in direct danger. The vehicle could not be restarted. I called a towing service, and the car was transported to a Chrysler dealership. The fault codes were read out. Chrysler Star recommended to replace a 350 A fuse. The dealership service team drove the car for more than 70 miles without being able to reproduce the fault after this repair. One day after collecting the car from the dealership I drove about 300 miles on the highway. After about 250 miles the warning message “Service hybrid electric vehicle system“ appeared. The high voltage battery charging level was less than 1%. When driving on the highway with about 55 mph, about 150 miles after the warning message appeared, the motive power stopped inadvertently without any warning. I felt a short impulse on the gas pedal, then while rolling at below 50 mph the message “Switch P to start engine“ was displayed. I managed to roll out from the 3rd lane from the right to the emergency stopping lane. It was a dangerous maneuver and I feared for the safety of my five family members traveling with me in the car as the oncoming traffic behind my car didn’t slow down even after switching on the hazard lights. The vehicle could not be restarted and I had to call a towing service to transport the vehicle to the nearest Chrysler dealership. Now I am waiting for the service team to start reading out the failure codes.

NHTSA ODI 11612905

while driving all warning lights came on on the dashboard. said pull over, car will stop. car would not move . after a while it would start again and warning cleared. had scan done . multiple communication failure codes for multiple modules. had codes cleared. waiting for next time. chat forums indicate this is common and usually leads to the can buss star connector defective where the multiple modules plug in.

NHTSA ODI 11604860

Shortly into my trip home from work, I entered onto the interstate and accelerated up to speed. Within a minute the vehicle seemed to slow down and I had no power using the accelerator Pedal. The vehicle continued to slow and the gas engine failed to turn on.(this is a PHEV hybrid model). Eventually the vehicle lost all power and I was able to park it along the side of the interstate. The vehicle was still on, AC and electoral systems worked. After about 5 minutes, gas engine spontaneously started back up. I was able to gain speed start bad down the road. Approximately 3 min later, gas engine shuts down and same process occurred. This cycle took place about 6 times before vehicle would not start up anymore and ultimately had to be towed. After a week, dealership is not sure what’s wrong as the transmission has been replaced which did not fix the problem. Dealership is now planning to replace the PIM module although there is an over 45day wait and they are unsure if that will fix the problem.

NHTSA ODI 11596503

Loss of drive power while at high speed on the highway. Warning popped up saying car will lose power soon, with a turtle icon. Had to pull over 3 lanes to shoulder. Could have been dangerous, Chrysler known issue - they had recall 03A to make sure the warning turns up, but didn't fix it.

NHTSA ODI 11573301

My car had less than 500 miles on it. While driving down the interstate, it suddenly stopped accelerating and a warning to “pull to a safe place the vehicle will soon shut off” appeared. The vehicle shut off. It was towed to the dealership. After almost a week with the van, the dealer said nothing was wrong and they sent me back on my way. 5 miles down the road and on a busy road, same thing happened. Van stalled and was again towed to the dealership. This time they said it needed a new PIM system. It was at this time that I became aware of NHTSA Campaign Number: 23V-010. I was sold this car on June 14 after Chrysler was aware of the issue.

NHTSA ODI 11533119

The air conditioner stopped working and a warning message was displayed on the dash stating service hybrid system, immediately after the Vehicle shut off while driving above 70MPH. Fits symptoms of 03A recall. Vehicle at dealership for service. 80 miles driven by Customer total since purchase

NHTSA ODI 11532581

I was driving around 15 mph and the van suddenly lost all electrical and engine power. I could not drive and none of the instruments were working. I could not turn on the emergency blinkers / hazard lights. I could not restart the van. No buttons were working. The van came to a stop with some bad sounds from the engine. I was on a hill and I had to keep my foot on the brake otherwise the van would start rolling backwards. I could not place the vehicle into park and the parking break did not work either. This means I was effectively trapped in the vehicle, in the middle of the road, unable to engage any hazard lights. I called my spouse and he drove to meet me. He opened the hood and after a minute the power returned and the vehicle displayed a "service electrical system" message. I was then able to drive the vehicle home about half a mile. Later that evening the vehicle again "died" and was unresponsive. Hours later it is still not turning on and will have it towed to the dealership. This complete loss of power has happened a few times before, but always when the vehicle was parked overnight and I discovered it was not working in the morning. But it would always turn itself back on after a few minutes.

NHTSA ODI 11514339

The fuel line into the fuel tank and tank itself were leaking gas. It was not a large leak but it was enough to soak the felt lining underneath the gas tank. It made our garage completely smell of gas fumes and the fumes began to migrate into the home. The dealer originally took a look at it on 3/13/23 and determined that the fill line was just loose into the tank. However when we filled the tank with gas again on 3/20/23 the problem began again. It went back into the dealer on 3/21/23 and they are replacing the fuel tank and the fuel fill line. No warning lights or messages ever came on.

NHTSA ODI 11513197

On 3/6/2023 while driving on a freeway, my vehicle experienced a complete loss of motive power and the accelerator was unresponsive. The dash gave me a warning that the vehicle was off. On 3/7/2023, the same incident occurred twice while on the same freeway. on 3/7/23, I dropped it off at Moss Bros Chrysler Dealer in Riverside, CA for the loss of motive power recall I was just notified of. The software update from the recall was performed, and the service adviser informed me that it was successful and the issue had been resolved. On 3/9/2023, I drove it on the freeway, and again, the same loss of motive power occurred. This time, the dash warned me that vehicle shutdown was imminent, and a turtle icon displayed on the dash. However, the moment the dash displayed this information, all motive power was lost and the experience was identical to before the software update. This is a significant safety issue as the freeways in my area usually do not have any shoulders or areas that are safe to pull over on. This is a serious defect that poses a safety risk to anyone in the vehicle. It has not been fixed by the recall.

NHTSA ODI 11511113

This is a Plug in Hybrid vehicle (Rental from Avis). I was driving on freeway today January 13, 2023 and vehicle lost all propulsion (did no respond to accelerator being depressed) with warning message on screen "Press Brake and Push Button to Start" and "Shift to P to Start" while at 64mph. Vehicle was slowing down and would not accelerate when pushing on the accelerator pedal. Happened twice during 20 min drive into work. I was able to have my phone ready and took pictures of the warning screen the second time. Pulled off to the side of the road to be able to switch the car to "P", turned off the the car with the push button and then restart. Notes: 40 degrees F 10 minutes into drive Heated Seats ON Rained the night before, damp in the morning This issue occurred on January 10th as well and had to pull off and restart as well.

NHTSA ODI 11501573

Was driving home and accelerating when there was a mechanical "thump" noise and the vehicle MIL indicator came on with a "red turtle" indicator on. Vehicle speed/performance was immediately reduced and I was not able to maintain a safe speed or have enough power to travel at appropriate speeds when hills were involved. This is the second time this has happened in this vehicle. The dealer has already looked at the vehicle prior and claimed they found the issue and resolved it. Since it occurred again the issue has clearly not been resolved or properly identified.

NHTSA ODI 11481671

Was driving down I-270 with family when the vehicle immediately registered a fault that the hood was open and unable to charge/condition battery. All engine power and speed control was lost at highway speeds and was barely able to get out of the way of traffic. I was able to coast to the shoulder without injury or accident with a few near misses. Opened / closed the hood at the side of the road and the fault didn't clear. 5-10 minutes later vehicle cleared the error and I was able to drive to a local dealership who told me "there is nothing they can do for me". The best option I had after talking with the Chrysler dealership was to to drive home praying my family didn't get stuck again.

NHTSA ODI 11463780

The car stalled while driving. I was driving down a city street and the engine cut off and a message on the dash read "Put Vehicle in P to start." I pulled over and it took several minutes to get the car to restart. This happened several times on the way back to the dealership (we had only just bought the car the day before). Our safety and that of others on the road was put at risk because we were stopped in the middle of traffic and were unable to move. Pulling over across traffic once the car had stalled was also dangerous because I could not propel the car forward. I did manage to steer the car to the side of the road. After this happened several times in the course of a few blocks, I called for roadside assistance to tow the car back to the dealership. After the incident happened, the "check engine" light came on. The car is currently at the dealership awaiting repair.

NHTSA ODI 11450601