What 377 owners told NHTSA about the 2021 Toyota RAV4 Hv

New 2021Toyota Rave4 vehicle would take over steering and turn left or right from the center of the lane. This issue would consistently steer you to a road shoulder or into another lane. A less experienced driver would have crashed. The steering pull is so significant that one is unable to take a drink or turn on the radio without the possibility of an accident. The last incident steered me into the path of a Cement Truck nearly causing an accident. Had I not been extra cautious, an accident would have occurred. The "vehicle is operating as designed" and "some customers are overly sensitive to the safety features" was the conclusion of Vancouver WA Toyota Service and advised to return the vehicle when an incident reoccurs. I insisted the next incident could kill someone. Service spoke to someone and apologized that in fact a Past Tech Bulletin (2019-2021) was released by Toyota addressing this issue. Service obtained a video from the vehicle and confirmed my complaint that the steering had indeed hijacked the vehicle and steered into the path of a Cement Truck. My concern of serious bodily injury or death is substantiated and documented by Vancouver WA Toyota and Toyota Corporation. Respectfully [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11423630

I PURCHASED A BRAND NEW TOYOTA RAV 4 IN MAY 2021 AND DURING THE TEST DRIVE CAR DID NOT SEE ANY ISSUES AT ALL. THIS IS RELATED TO THE BACKUP CAMERA DURING THE TEST DRIVE WE DID NOT PLACE INSTALLED ON THE CAR. RECENTLY I TAKE A CAR TO KOONS TOYOTA IN TYSON CORNER AND THE SERVICE MANAGER SAID HE IS AWARE OF THIS AND THERE IS NOTHING THEY CAN DO ABOUT IT. NOW WE HAVE THE REAR LICENSE PLATE INSTALLED AND CAN ONLY SEE 3/4 OF THE SCREEN THE OTHER 1/4 OF THE SCREEN SHOWS THE REAR PLATE, VIEW NOR CLEAR %100.

NHTSA ODI 11421663

Windshield Crack sitting in parking lot, nothing hit it( i.e. no rocks, no chips, no nothing). It broke randomly, radiating out from the bottom edge near wiper toward center of windshield. Yes, available for inspection upon request Could have happened when driving. It has not yet been confirmed by dealer (pending), insurance, or other third party The new vehicle was only 5 weeks old.

NHTSA ODI 11419505

MY 2021 TOYOTA RAV4 HAVE DESIGN PROBLEMS WITH SUSPENSION SYSTEM. WHERE IF THE FREEDOM OVER 55MPH THE CAR WILL BE UNSTABLE, BUMPY AND SHAKY. I AM REALLY SCARED TO DRIVE MY CAR ON THE HWY. I HEARD MIST 2021 RAV4 HAVE THE SAME PROBLEM. TOYOTA NEEDS TO HAVE A RECALL TO FIX OR CHANGE SUSPENSION SYSTEM WITH A FIRM ONE ASAP. THANK YOU.

NHTSA ODI 11416567

THE CONTACT OWNS A 2021 TOYOTA RAV4. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THERE WAS AN ABNORMALLY LOUD GRINDING SOUND COMING FROM THE ENGINE. THE CONTACT STATED THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO CABE TOYOTA (2849 LONG BEACH BLVD, LONG BEACH, CA 90806, (562) 595-7411) WHERE IT WAS DIAGNOSED WITH NOTHING NEEDING TO BE REPLACED. THE CONTACT STATED THAT THE DEALER REPLACED THE BATTERY HOWEVER, THE FAILURE PERSISTED. THE CONTACT RELATED THE FAILURE TO AN UNKNOWN RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000.

NHTSA ODI 11416598

JUST BOUGHT THIS VEHICLE ON JANUARY AND WITH JUST OVER 4K MILES THIS WARNING CAME UP.. PARKING BRAKE MALFUNCTION.. TURNED OFF THEN ON THE CAR AND SAME WARNING...CALLED THE DEALER FOR INSPECTION ASAP..

NHTSA ODI 11415942

NO AUDIO WARNING. BLIND SPOT MONITORING (BSM) FLASHING IS NOT VISIBLE WHEN SUNLIGHT DIRECTLY REFLECTS INTO MIRROR. AUDIO ALERT IS AVAILABLE, BUT LIMITED TO CROSS TRAFFIC ALERT WHICH USES SAME SENSORS.

NHTSA ODI 11415768

IN A 4 CAR PILE UP. HIT IN REAR X2 BY A LARGE VAN WHILE SITTING IN TRAFFIC ON NJ PARKWAY FOOT ON BREAK AND PUSHED INTO CAR IN FRONT OF ME X2. AIRBAGS DID NOT DEPLOY.

NHTSA ODI 11414593

TL* THE CONTACT OWNS A 2021 TOYOTA RAV 4. THE CONTACT STATED WHILE DRIVING AT 45 MPH, THE VEHICLE INDEPENDENTLY VEERED OFF TO THE RIGHT AND THE CONTACT LOST CONTROL OF THE STEERING OF THE VEHICLE. AS A RESULT, THE VEHICLE VEERED OFF TO THE RIGHT FLIPPING OVER A CINDERBLOCK CAUSING THE VEHICLE TO FALL DOWN A MOUNTAIN TOP. THE AIR BAGS DID DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A BROKEN RIGHT ANKLE AND A FRACTURED DISK IN HER BACK THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DRIVABLE AND WAS TOWED TO A JUNKYARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE BLACK BOX READ THAT THE ACCIDENT WAS SELF INFLICTING. THE FAILURE MILEAGE WAS 620.

NHTSA ODI 11414647

TL* THE CONTACT OWNS A 2021 TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE GEAR SHIFTER DISENGAGED, PREVENTING THE CONTACT FROM SHIFTING GEARS. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO TOYOTA OF DEERFIELD BEACH (1441 S FEDERAL HWY, DEERFIELD BEACH, FL 33441) WHERE IT WAS DIAGNOSED HOWEVER, NOTHING WAS REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 2,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 11404841

TL* THE CONTACT RECEIVED A 2021 TOYOTA RAV4 AS A LOANER VEHICLE FROM SERRA TOYOTA (1300 CENTER POINT PKWY, BIRMINGHAM, AL 35215) AS HIS PERSONAL VEHICLE WAS AWAITING REMEDY REPAIRS FOR NHTSA CAMPAIGN NUMBER: 20V682000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT WHILE DRIVING THE LOANER VEHICLE AT AN UNDISCLOSED SPEED, THE VEHICLE STARTED JERKING WHILE ACCELERATING. THE DEALER WAS MADE AWARE OF THE ISSUE HOWEVER, THE CONTACT WAS INFORMED THAT THERE WAS NO OTHER LOANER VEHICLE AVAILABLE. THE CONTACT INFORMED THE MANUFACTURER AND A CASE FILED. THE FAILURE MILEAGE WAS 2,935. THE VIN WAS UNAVAILABLE.

NHTSA ODI 11403677

THERE IS A RATTLING SOUND COMING FROM THE DRIVER'S DOOR WHEN THE CAR IS STATIONARY AND THE DOOR IS SWUNG CLOSED. THE REARVIEW MIRROR OF THE DOOR HAS SIGNIFICANT SHAKING WHILE THE CAR IS IN MOTION, SO THIS IS A SAFETY HAZARD. THE SPEAKER IN THE DRIVER'S DOOR MAKES A STATIC OR CRACKLING SOUND WHEN MUSIC IS OFF.

NHTSA ODI 11403428

CAR HAD A LOW FUEL INDICATOR ON (APPROX. 15MILES DISTANCE TO EMPTY LEFT ON A DASHBOARD). UPON REFUELING, THE CAR ONLY TOOK ABOUT 11.38 GALLON OF FUEL TO REFILL THE EMPTY TANK. THIS IS VERY ANNOYING AS I JUST BOUGHT THIS CAR NEW THINKING IT HAS 14.5 GALLON FUEL TANK CAPACITY BUT IN REALITY IT HAS A DEFECTIVE FUEL TANK AND IT ONLY TAKES ABOUT 11 GALLON OF FUEL.

NHTSA ODI 11399965

THE GAS TANK OF 2021 RAV4 HYBRID DOES NOT FILL IN AS ADVERTISED. TOYOTA ADVERTISES THAT IT CAN TAKE 14.5 GALLONS OF FUEL, HOWEVER WHEN THE FUEL LOW WARNING LIGHT IS ON AND YOU TRY TO FILL THE FULL TANK, IT NEVER TAKES MORE THAN 10 GALLONS, THUS THERE'S DISCREPANCY OF 4 GALLONS. THIS REDUCES THE CAR'S ADVERTISED RANGE FROM 550 MILES TO LESS THAN 400 MILES. TOYOTA CLAIMS THIS IS A DESIGN MISTAKE AND DOESN'T OFFER ANY FIX.

NHTSA ODI 11399666

VEHICLE BATTERY COMPLETELY DEAD AFTER ONLY 3 DAYS OF NOT BEING DRIVEN. VEHICLE WOULD NOT START AND COULD NOT BE JUMP STARTED. VEHICLE IS ONLY 2 MONTHS OLD. WIRELESS CHARGING DOES NOT CHARGE CONSISTENTLY. INTERMITTENT CONNECTION ONLY AND GETS VERY HOT. USB PHONE CONNECTION RANDOMLY DISCONNECTS AND RECONNECTS. OCCASIONALLY THE VOICE COMMAND PROMPT ON CENTER CONTROL IS ACTIVATED AND STAYS CONNECTED WHEN CONNECTING A PHONE THROUGH USB AND CANNOT EXIT TO SEE INFORMATION DISPLAY. REMOTE START FROM FOB WILL NOT WORK. LANE DEPARTURE SYSTEM TOO SENSITIVE AND TAKES OVER STEERING OF CAR CAUSING COUNTERSTEERING FROM DRIVER CONTROL.

NHTSA ODI 11399292

THIS VEHICLE HAS INTERMITTENT OPERATION OF ITS LANE KEEP ASSISTANCE. ONE ACTIVATED, IT REGULARLY WILL DO THE OPPOSITE OF KEEPING YOUR LANE. IT HAS RUN ME OFF THE ROAD AND ALSO INTO THE LANE OF ONCOMING TRAFFIC. I HAVE REPORTED TO THE DEALER BUT THEY COULDN'T REPLICATE IT. I HAVE ESCALATED TO THE DEALER AS THIS HAPPENS VERY FREQUENTLY AND IS IN SAFE. UPON ACTIVATION OF THE LTA, IT TURNS THE STEERING WHEEL APPROX 15- 20 DEGREES AND IMMEDIATELY TAKES YOU OUT OF THE LANE. THE LANE DEPARTURE SYSTEM KICKS IN AND THEN TRIES TO BRING YOU BACK AND THIS GOES ON AND ON WITH CLEARLY MARKED LANES. IF I DIDN'T APPLY QUITE A BIT OF FORCE TO PREVENT THE DEPARTURE I COULD HAVE WELL BEEN AN INCIDENT. THE VEHICLE WAS IN MOTION, GOING DOWN A WELL MARKED INTERSTATE HIGHWAY, NIGHT AND DAY TIME, NO RAIN OR SNOW/ICE. THE VEHICLE RECOGNIZED THE LANE DEPARTURE (BEEPS) BUT IT WAS THE VEHICLES SYSTEM THAT DROVE THE CAR OUT OF THE LANE (WITH MY HANDS ON THE WHEEL OF COURSE). A VIDEO CAN BE SHARED UPON REQUEST.

NHTSA ODI 11398108

I RECENTLY PURCHASED A 2021 TOYOTA RAV4. THE FIRST WEEK I OWNED IT I EXPERIENCED A FLAT TIRE. WHEN I ATTEMPTED TO AIR IT UP THE VALVE STEM BROKE AND THE TIRE WENT COMPLETELY FLAT. THE VALVE STEM IS ONE UNIT AND CONNECTED TO THE TIRE PRESSURE MONITORING SYSTEM. I LEARNED THAT THE STEMS ARE MADE OF ALUMINUM AND SUBJECT TO BREAKING DUE TO THE SOFT METAL. TOYOTA REFUSED TO COVER THE EXPENSE SAYING IT WAS DRIVER ERROR. THE TECHNICIAN AT THE SHOP WHERE THE TIRE WAS PLUGGED TOLD ME THIS HAPPENS QUITE A BIT. I WAS SHOCKED THAT TOYOTA WOULD INSTALL SUCH CHEAP METAL ON THEIR CARS. THIS IS A ROAD HAZARD AND CAN EASILY LEAVE ONE STRANDED. MY COST WAS NEARLY $300. THE BREAKAGE WAS NOT MY FAULT. IT WAS A PROBLEM OF SOFT ALUMINUM. I BELIEVE THESE STEMS SHOULD BE RECALLED AND REPLACED WITH HIGH QUALITY STEEL. THANK YOU.

NHTSA ODI 11397144

PASSENGER HEATED SIDE MIRROR CRACKED FROM COLD WEATHER. NOT IMPACTED BY ACCIDENT OR NEGLIGENCE FROM I OR SOMEONE. WHEN HEATED MIRROR WAS ON I NOTICED A CRACK APPEARING.

NHTSA ODI 11395824

CANNOT FILL FUEL TANK COMPLETELY FULL. HAD SOME TESTS RUN BY TOYOTA AND THEY FOUND THAT THERE WERE ONLY 12.5 GALLONS IN THE 14.5 GALLON TANK WHEN THE PUMP SHUTS OFF. I WAS TOLD THIS WAS "WITHIN THE SPEC" AND OFFERED NO FURTHER HELP.

NHTSA ODI 11394555

HAVE A 2019 AMS 2021 RAV4 HYBRID XSE THAT WILL NOT FILL TO ITS 14.5 GAL CAPACITY. TOYOTA NEEDS TO MAKE A FORMAL ANNOUNCEMENT HERE TO ACKNOWLEDGE THE ISSUE AND A TIMELINE ON A FIX. WITH NOTING, THE DEALERSHIP SAID IT TOOK 14 GAL ON INITIAL FILL WHEN PURCHASED, SO NOT SURE WHAT TO THINK HERE - CAN PROVIDE PHOTOS AS WELL

NHTSA ODI 11389684

WHEN THE LOW FUEL LIGHT COMES ON IT ONLY TAKES 10 GALLONS TO REFILL. THIS GIVES ME A RANGE OF 400 MILES ON A TANK OF FUEL. I WAS EXPECTING A RESERVE AMOUNT OF FUEL AFTER THE LOW FUEL LIGHT COMES ON TO DRIVE TO A FUEL STATION BUT ONLY USING 10 GALLONS OUT OF A 14 GALLON TANK SEEMS WRONG.

NHTSA ODI 11387955

THIS ISSUE HAPPENED ON 12/31/2020. I WAS DRIVING TO WORK THIS EVENING. I CAME ONTO AN ONRAMP DURING MY DRIVE AND I BEGAN INCREASING MY SPEED TO 70MPH. AS I'M ACCELERATING I STARTED TO NOTICE A WHISTLING SOUND COMING FROM THE SUNROOF . I INSTANTLY ASSUMED THAT MY HUSBAND HAD ACCIDENTALLY OPENED THE SUNROOF AND HAD NOT CLOSED IT BACK UP ALL THE WAY. (WE HAVE NOT HAD THIS CAR VERY LONG AT ALL SO WE ARE STILL LEARNING WHICH BUTTONS DO WHAT.) AS I PULL BACK THE COVER I NOTICE THAT THERE ARE SHARDS OF GLASS FALLING ONTO MY LAP FROM THE SUNROOF. I WAS IN COMPLETE SHOCK AND PULLED OVER TO MAKE SURE I WAS NOT MISTAKEN. SURE ENOUGH THE SUNROOF HAD SHATTERED AND THERE WAS GLASS EVERYWHERE. I HAVE NO WAY OF EXPLAINING HOW THIS HAPPENED AND I AM VERY FRUSTRATED THAT I HAVE TO MAKE A CLAIM ON A CAR I HAVE HAD FOR MAYBE A MONTH AND A HALF AND EVEN MORE UPSET THAT I CANNOT EXPLAIN HOW THIS ACTUALLY HAPPENED. I WAS ALSO SURPRISED THAT THERE WERE PEOPLE HAVING SIMILAR ISSUES WITH THE SUNROOF!

NHTSA ODI 11386212

MY SPOUSE WAS DRIVING THE CAR AND SHE COMPLAINED TO ME THAT OUR NEW 2021 RAV4 SUDDENLY LURCHES WHEN SLIGHTLY ACCELERATING FROM A ROLLING STOP. I THEN DROVE WITH HER AND WITNESSED THE SAME ISSUE ALTHOUGH I COULD NOT REPLICATE IT MYSELF. I TOOK THE CAR TO THE TUSTIN TOYOTA DEALERSHIP (FROM WHERE I PURCHASED THE CAR) BUT THEY WERE NOT ABLE TO FIND ANY ISSUES OR REPLICATE THE PROBLEM. THAT BEING SAID THE CARS ARE SO NEW THAT IT MAY JUST BE THAT THERE AREN'T ENOUGH NEW OWNERS YET TO REPORT THE PROBLEM.

NHTSA ODI 11382724

DRIVING NEW 2021 TOYOTA RAV4 AND THE SUNROOF BLEW OUT FOR NO APPARENT REASON.

NHTSA ODI 11365940

TL* THE CONTACT OWNS A 2021 TOYOTA RAV4. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING APPROXIMATELY 75 MPH, THE GLASS SUNROOF SUDDENLY EXPLODED. DURING THE FAILURE, THE SUNROOF WAS CLOSED. THE LOCAL DEALER VALLEY HIGH TOYOTA LOCATED AT 14612 VALLEY CENTER DR, VICTORVILLE, CA 92395 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,500.

NHTSA ODI 11364557