What 377 owners told NHTSA about the 2021 Toyota RAV4 Hv

Driving about 35 mph, I pressed break pedal approximately 50% in order to stop at the light ahead. When the car reached somewhere around 10-20 mph, the degree of deceleration sudden decreased (the car was still slowing, but the rate of slowing suddenly decreased) without any change in a degree of depression of the break pedal. The road had a couple of bumps on it, and I have noticed that this seems only reproducible when the car is going over bumps during the deceleration. I was able to find a forum that describes similar behavior related to other Toyota Hybrid vehicles https://forums.edmunds.com/discussion/5357/toyota/highlander-hybrid/highlander-hybrid-brake-problems

NHTSA ODI 11454814

LED headlights do not emit heat and allow ice to cover entire headlight group, blocking illumination. Problem is exacerbated with road grime in the ice. LED headlights, also, do not provide enough light spectrum to identify objects in the dark—nearly all other lights provide better/friendlier illumination to the human eye at night. LED headlights are a safety issue in the dark… made worse in icy conditions.

NHTSA ODI 11453677

Lane keeping assistance over corrected and caused an accident that resulted in total loss of my vehicle. My tire crossed white line , I was trying to gradually adjust to keep from over correcting. The lane keeping assistance caused the steering to pull in the opposite direction and would not allow me to correct. The more I tried to get back in the lane the harder the lane assistance pulled in the oppposite direction. It ultimatley jerked the steeing wheel in the opposite direction a caused me to hit a tree head on.

NHTSA ODI 11452204

Toyota RAV4 2021 fuel tank capacity should be 14.5 Gallons as per manufacturer but never managed to pump close to 12 Gallons. Called Dealer but refuse to acknowledge the defect

NHTSA ODI 11449666

Vehicle's hood has adhesive separation. The defect is located at the bottom of the hood closest to the windshield. Air infiltration is causing the inside of the hood to flex at speeds higher than 40mph. This flexing will cause adhesive in other parts of the hood to separate and fail as well, which will in turn will increase the air infiltration and drag on the hood itself which will more than likely affect the hood latching system. This is a major safety concern that the company tells me is a "characteristic" of the vehicle.

NHTSA ODI 11448976

I had 2 sudden acceleration incidents. The first occurred 10/6/21.My car lurched forward & hit a pole. I was with my mom who saw me press the brake, which did not engage. My car has an auto-braking system which did not function as designed. I took it to Toyota.They determined there were no issues w/the vehicle. I insisted there was something wrong & warned this will happen again & could be much worse. I felt defeated but hoped it was an isolated glitch & hoped for the best. Fast forward 2 months to 12/13/21 I was in a drive-thru using the hold button, which is a feature that holds the brake in place, so my foot was not on any pedal. All of a sudden, my car began to accelerate & the brakes would not engage. An error message on the dash said “BRAKE MALFUNCTION”. I could not stop the car. I put in park, but it did not stop the car. The car jumped the curb & drove into oncoming traffic & hit two cars. They were traveling north, I was traveling west. It’s a miracle another car did not hit & kill me. The most frightening experience of my life. I had the car towed to Toyota as the front wheel blew out & could not be driven. Another inspection was done & once again Toyota came back with “they could not find anything wrong with the vehicle.” And added that the brakes were never engaged, which is an outright lie & utterly insane. I spoke to an attorney & what he told me was quite eye opening. He has been practicing product liability law for 30 years. He told me the letter received from Toyota was a standard letter that all car companies respond with. They never admit a problem unless forced to, usually by the govt, to do a recall after enough people file a complaint. I really believed Toyota would tell the truth. I never imagined they would lie & participate in a cover-up. They would rather fight you in court. As mentioned earlier, my car has an auto braking system, so why didn't it work? Clearly it malfunctioned. My hope is that this deceit by car manufacturers ends.

NHTSA ODI 11448547

Purchase vehicle 2 weeks ago and the tire pressure light has come on 2 times, along with the truck sliding at turns, it also is very bumpy and unstable on expressway, very scary. Would like to get another vehicle.

NHTSA ODI 11448018

Toyota of Portland sold me a used 2021 RAV4 hybrid XSE with a defective gas tank. The gas tank does not carry the 14.5 gallons as advertised, the gas gauge cluster is inaccurate, and the mileage remaining on the dash cluster is inaccurate. These defects were not disclosed to me prior to the sale. Immediately after seeing the problem, I brought the vehicle in for service at Vancouver (WA) Toyota. They botched the repair job and the vehicle is emitting gas vapors non stop. Over the weekend, my house was inundated with gas vapors and my household and I experienced dizziness, irritability, poor eyesight, and nausea.

NHTSA ODI 11445937

During inclement weather (snow) this morning, I went to brake and it felt like my car sped up instead of slowing down. I tried pressing my brakes again and it did the same thing again.

NHTSA ODI 11446024

I was driving down an open road when I suddenly heard a loud rattling noise and a huge explosion. Luckily, there wasn’t any cars around us and we weren’t going very fast. As you can imagine this was very shocking and distracting and I was eventually able to pull over to the side of the road to investigate what had happened. I had my 9 month pregnant sister as well as my 4 month infant in the car. What we found was the sunroof of my car had exploding upwards and there were shards of glass everywhere. We had been experiencing extreme weather conditions the past few days and had to assume this to be the cause. There was no one around us nor anything above us and my car is kept under a carport. An external force would not cause the sunroof glass to explode upwards, it would be the exact opposite and smashed downwards.

NHTSA ODI 11444257

To whom this may concern, I have had many problems with the Toyota Rav-4. I had so many problems with my 2017 Rav 4, that I under pressure upgraded to the 2021 LE version. I have had many problems with the breaks. I have brought it in (3) times to be serviced since I purchased it in March of 2021. The breaks are still squeaking. I have also had problems with the electrical system. The dash panel comes on, and abruptly shuts down when it feels like it. My wipers also come on intermittently. Every time I try and talk to Toyota about this they tell me there is nothing wrong. This same thing happens with the 2017, until my breaking mechanism stopped. I am looking for someone to look into this matter because these are dangerous conditions and unacceptable especially for new cars.

NHTSA ODI 11444083

I found the moonroof of my 15-day old 2021 Toyota RAV4 spontaneously exploded while sitting parked in my driveway. As the shade that covers the moonroof was open, I incurred minor abrasions from not realizing that the "s**t on my console" was not dust or fuzz, but tiny shards of broken glass that I had already swiped with my hand. There is a large, jagged hole near center on the rear section of glass and the entire moonroof is shattered. Strangely, the glass around the hole is bowed outward as if something was shot through from the inside of the vehicle. Thankfully I was not driving & did not have my kids in the car with me when it happened because there would have been definite safety issues for me, my passengers, and any others out on the road with me. The car was last used about 6:30pm on Saturday, 12/11/21 and not used again until about 11:15am on Monday, 12/13/21. It spent the time not being used parked towards the rear of my driveway, shaded by my house. There are no trees or other possible falling hazards near my driveway and nothing found in or around my car to suggest a projectile/object was involved.

NHTSA ODI 11443668

Water is leaking into the cabin from around the roof rails, this could lead to water getting into the side airbag system and causing a failure in the airbag system.

NHTSA ODI 11443157

My 2021 Toytoa rav4 Hybrid limited has memory seat buttons. However they don't light up at night or even if the headlights are turned on. There are two memory seat buttons. In a scenario where there are two drivers and one is a larger driver with more girth, and the second is a much slimmer driver, there will be significant distances between the positions. At nightime(or whenverer it is dark, when the larger driver sits in the vehilce and accidentally presses the power seat memory button for the slimmer driver(this can happen since Toyota decided not to illuminate the button in any way(at least they should have did it while the vehicle is in the parked position), the larger drive can get squished, hurt, possibly even die as the seat moves forward toward the steering wheel. Now in the toyota manual, it does say that if any power button is pressed again, the seat should stop. What actually happens is that the driver becomes panicked and pressed the button over and over again and the seat continues closer to the steering wheel. I was able to stop this the first time by pure accident by reaching between the door and the seat to my seat position controls. This is an accident waiting to happen! Toyota needs to illuminate the power seat buttons (at least in the parked position). The seat memory buttons cannot to be used in any other driving position so we are thankful for that. There may be other trims and years of the rav4 that have this issue. The best way to understand this issue is to experience this for yourself. Get a car with memory seat positions. Have two positons set, one positon will be very close to the steering wheel. Have a larger driver with more girth sit in and then press the button for the slimmer driver's postion. Do this at nightime.

NHTSA ODI 11442674

I have a 2021 Toyota RAV4. There is a noise in the B pillar. The sound is faint, dealership has replaced the entire seatbelt. The noise is still there. Today was the 4th time to the dealership, the technician drove and service advisor both was in the vehicle today and all of a sudden they can't hear anything. The driver side mirror also shakes when driving and by just shutting the door. My safety concerns are both the B pillar and mirror shaking. I'm concerned the B pillar may not have been properly welded and may fail in a collision The rattle started at 22 miles and now has approximately 1800 miles.

NHTSA ODI 11441710

We bought our new 2021 Toyota RAV4 Hybrid on Sept. 1, 2021, but didn't drive it on a highway until Oct. 4, 2021. On that day, I was driving on Interstate Hwy 70. I entered that highway near Copper Mountain, CO and was driving east to return to Denver. It is a big highway with wide, well marked lanes. I set my cruise control speed to 63 mph. Almost immediately, I noticed that the Lane Centering steering adjustment system seemed to be taking the car from close to the left lane line to close to the right lane line, and back and forth. A couple of times, it even drifted to or over the lane line and triggered the Land Departure Alert alarm. At first, I tried to overcome the automated Lane Centering adjustment by manually steering against it, but the swaying back and forth across the lane became increasingly wide and violent. I was unable to control it. It was terrifying. For a moment, I was sure that I would crash. I don’t know if I hit the brake pedal, but I did quickly press the CANCEL button on the cruise control, and that ended the swaying back and forth. The whole experience lasted probably less than one minute, and at no time did I notice any alarms or warning signals. I took the car to my dealership and asked them to check the functioning and settings of the cruise control and lane tracing assist functions. They told me that my settings were normal and that everything was working properly. I informed Toyota customer service about the problem and told them of my near crash. They consulted with my dealership's service department and repeated that everything was working properly. Neither the dealer nor Toyota customer service offered any explanation of reasons for my near crash. I have continued to drive the car, but I have tried to disable all the "safety" features that allow the car to take control of my steering. I am afraid to try to reproduce the problem myself, and I am quite sure that my dealer did not attempt to do that either.

NHTSA ODI 11440411

P225 / 60 R18. Passenger rear tire blew out driving at highway speeds (75-80 mph). The car swerved back and forth across lanes almost into the median and then to the shoulder a couple of times and almost flipped before I was able to pull to the shoulder and stop. Another driver stopped to make sure I was ok and said he also thought I was going to flip more than once. I did not notice any warning lights prior to the incident. There were a couple of times prior to the failure that it felt like the car was swerving slightly - I thought possibly due to wind or different texture of the road surface, then the tire blew. The entire inside wall of the tire is separated from the tread. The dealer has not inspected the tire yet. I am ordering a set of new tires - I don't trust these and never want to go through that again.

NHTSA ODI 11439821

Moon roof exploded and shattered while driving down the road in normal conditions, no other issues. Vehicle is less than 3 months old with 7,000 miles. It sounded like a gun shot and only because I reacted without panic did it not cause me to have an accident because of the major distraction. Pulled over and no other damage. Had to drive 45 miles per hour to my destination or glass would have sprayed on anyone behind me. Currently, had to tarp and duct tape damage because dealership will not fixed under warranty unless I can prove it was a defective glass/part. My dealer did text me and I have it that there are problems but it’s so hard to prove it will be my expense out of pocket. I would appreciate any help on other Toyotas having a similar problem and wanted to officially report to help out the next person if I can’t obtain proof of a defective part.

NHTSA ODI 11437229

The knee airbag deployed during a collision and caused devastating shin injuries. The muscle and skin was ripped off the driver's legs revealing bone.

NHTSA ODI 11435967

Defective windshield, visible distortion, Is available for inspection. (Brand new vehicle) Safety hazard to drive as I can't see properly through it, everything is blurry. Eyes can't focus - like looking through someone else's glasses! Makes me physically ill as well due to the continued eye fatigue/strain. I"m not sure it's even possible to drive it more than half an hour, I wouldn't risk it. Problem is confirmed by the dealer, both technicians that inspected said distortion is visible. Dealer said won't fix because "Every Rav currently on the lot has a defective windshield, most worse than yours"! Was told this was not their first complaint about the bad windshields. and if they did fix it I could end up worse off, because all the windshields are coming out defective currently, some with even worse "visible waves" in the glass. I had ordered the vehicle & put a deposit on it to hold, I didn't get to drive it till the paperwork was done and I was driving off the lot. Within 20 minutes problem was apparent.

NHTSA ODI 11429448

While using Cruse control. It did not slow the vehicle. I could not turn it off. The brakes would not work. I ran thru an intersection against the light. Bounced over the median. I turned off the ignition, still coasted about 1/2 mile. Finally I jammed the gear shift lever into Park. Toyota has the vehicle for inspection and reading of the black box. THE CONSUMER STATED THE VEHICLE DID NOT HAVE ANY WARNING SIGNS OF THE FAILURE. WARNING MESSAGES DID DISPLAY DURING THE FAILURE, WHICH WERE "CRUISE CONTROL INOPERATIVE", "BRAKE FAILURE", AND "LANE DEPARTURE".

NHTSA ODI 11428721

Since buying this 2021 Toyota RAV4 Hybrid vehicle in 12/2020 gas tank only takes about 10-11 gallons of fuel when refueling , whereas tank capacity is 14+gallons. This leads to trickle filling to get a full tank which Toyota advises against as unsafe. Toyota has agreed to pay for fixing this manufacturing defect for 2020 model RAV 4's with the same manufacturing defect, but so far Toyota holding back issuing authorization to fix the 2021 RAV4 Hybrids . Car available for inspection upon request. Toyota dealer wants me to pay for diagnosis, manufacturer unwilling to pay for inspection of this safety risk despite paying for it in 2020 RAV4's with same defect.

NHTSA ODI 11428217

Me ([XXX]) and my 3 children went on a trip from July 25- July 30 to Sequoia National Park & Yosemite National Park . On Wednesday , July 28 around 1:30 pm we were at Yosemite Park and I pulled over to take some photos of the beautiful park(nature) . I made sure my children , the car and myself were in a correct parking spot , I put my RAV4 LE in Park position (P) and the car automatically put on the hand break and it makes a loud noise, letting me know it's safe . The RAV4 does not have a hand break like other cars , it only has a small pull button. Anyways the car was in Park position with the automatic break , I stepped out the vehicle and walked toward the front of the car and my RAV4 just stared to roll down and hit a tree . I ran inside the car to stop it but it was too late . The RAV4 had crashed into the tree with my 3 children, they were all asleep when it happen and lucky no one was hurt. The car has a alot of damages in the front area and on the drivers side . The dash was all lit up with messages saying system fail(Pre collision system) INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11427394

June 25, 2012 driving to work at about 7:35 in the morning going about 45 mph my moon roof exploded. No others cars were around me and nothing hit my car or moon roof for this to happen. I called the police for a report if I needed it, but I did not. I drove it to the dealership after this happened and spoke with the sales manager that I had bought the car from in January. My car was only 5 months old. They replaced my moonroof and gave me a rental car and said it would be covered under warranty.

NHTSA ODI 11425434

Rear windshield shattered on a parked car. We closed the passenger doors after getting in and the rear windshield started falling off in pieces

NHTSA ODI 11425320