What 891 owners told NHTSA about the 2021 Jeep Wrangler 4-door 4xe

A recall repair was completed in 2023 related to an overheating warning. Recently, the same issue has returned. The engine cooling fan runs at a very high speed for several minutes and then shuts off, even when the vehicle is cold or operating under normal conditions. An overheating warning message appeared briefly while driving, but the temperature gauge remained within the normal range. This suggests the engine may not actually be overheating and that the issue may be related to a faulty sensor, electrical system, or control module. The problem has not yet been fully diagnosed by a dealer due to diagnostic costs, but the symptoms are consistent with the original issue that led to the recall repair. This condition could pose a safety risk because the driver may receive inaccurate overheating warnings or may not be alerted if a real overheating condition occurs. The issue is intermittent and has occurred both while driving and when the vehicle is stationary. Attempts were made to contact the manufacturer to report this as a repeat issue after a recall repair, but no resolution was provided and a formal case was not successfully established.

NHTSA ODI 11727281

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was taken to a local dealer, where an engine oil replacement was performed, and the High-Voltage Battery was replaced. Upon further inspection, the local dealer diagnosed the High-Voltage Battery replacement as a failure. In addition, the contact stated that the vehicle remained at the local dealer for several months; however, the parts were not available for the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.

NHTSA ODI 11726411

Glendale Dodge (CA) is actively using Federal Fire Risk Recall 68C to fraudulently conceal a separate, critical High-Voltage hardware failure on my 2021 Jeep Wrangler 4xe. Upon intake, my vehicle’s internal VIP diagnostic scan showed an active P0E15 code (Electric Coolant Heater Failure). Per Stellantis Technical Service Bulletins, this code indicates a severe failure requiring a physical hardware replacement to ensure the high-voltage system operates safely. To avoid performing this costly warranty repair, the dealership deliberately falsified the diagnosis on Final Invoice #31349. Under Line C (Customer States Check Engine Light is On), the dealership officially recorded the cause and correction as: 'DUE TO RECALL MODULE UPDATES AND BAD BATTERY.' This is an affirmatively false written diagnosis. A dead 12V battery and a recall software update do not cause, nor do they resolve, a P0E15 High-Voltage Electric Coolant Heater failure. The dealership lied on the legal invoice to scrub the hardware defect from the record. They then applied the 68C software patch as a smokescreen, falsified the 'Date Out' to 12/26/2025 to prematurely close the federal recall ticket, and attempted to return a vehicle that remains mechanically compromised and unsafe. This is intentional warranty fraud masking a high-voltage system failure. Stellantis and its authorized repair facility are refusing to properly remedy the vehicle. The vehicle is currently held at the dealership pending an active fraud investigation by the California Bureau of Automotive Repair (Case #6596-WS4PV6).

NHTSA ODI 11723871

My vehicle is experiencing EV system failures, stalling, and system shutdown warnings that make the vehicle unsafe to operate. These symptoms began after a recall repair that was performed by the dealership. The dealership initially stated the recall was repaired, but the same symptoms have continued and have now worsened. The vehicle will display EV system warnings and will stall or shut down systems while driving. The air conditioning and other systems also shut down as the vehicle attempts to protect the electrical system. I have brought the vehicle back to the dealership multiple times regarding this issue. Despite the vehicle showing the same symptoms associated with the recall, I am now being told I may have to pay for additional teardown work unrelated to the EV system. This vehicle has become unsafe to drive, and I have requested assistance and escalation from dealership management but have not received a resolution. I am filing this complaint due to the safety risk posed by the vehicle stalling and shutting down systems while in operation.

NHTSA ODI 11723946

This is a plug in hybrid vehicle. The (ECH) electric coolant heater is prone to failure. This failure can lead to loss of power and might cause the hybrid battery pack to not regulate its temperature leading to a fire. This is a high failure rate with some saying it has failed more than once. Jeep 4xe Fans on Facebook has been doing some tracking of numbers and shows a 50% failure rate with some failing after being replaced. This failure is not being addressed by Jeep.

NHTSA ODI 11720824

Car partially charged and when driving feels like it’s going to stall out. Seems like whatever update Stellantis did to hide the 4xe issues is impacting my ability to safely get around

NHTSA ODI 11720834

My vehicle is subject to an open safety recall (NHTSA Recall 25V-741) involving high-voltage battery separator damage that may cause a vehicle fire when parked or charging. The recall has been active on this vehicle for over four months. The manufacturer and dealers have confirmed the recall applies but have not provided a remedy timeline or parts availability. The vehicle is considered unsafe to park near structures or other vehicles and I have been advised to avoid recharging. No repair has been performed. The condition places occupants and others at risk of fire and prevents safe use of the vehicle. I am reporting this because the manufacturer has failed to remedy this safety recall in a timely manner.

NHTSA ODI 11718397

Jeep continues to apply bandaids to the high voltage battery system. The latest recall, 68c, is another software fix that doesnt address the root cause, high voltage battery. after the recall, the car drives horrible when in electric mode - engine kicks on all the time, loss of power until you stomp on the accelerator (which then kicks on engine). NHTSA needs to hold Jeep Stellantis accountable for selling an inferior product and take care of the customers who have supported them for the past 5 years until they stopped selling them! there are 320,000 jeeps impacted, lets fix this!!! I will be scheduling service soon, but you cant expect customers to stop our lives to live at the service center. Jeep really needs to start offering a large scale buyback OR fix the issue which would be to replace the battery with new improved updated one that doesnt become a fire risk every year! Thats where the NHTSA should come in to play - which is "dedicated to saving lives, preventing injuries, and reducing economic costs associated with motor vehicle crashes. It achieves this by setting safety standards, investigating defects, issuing recalls"

NHTSA ODI 11718436

After 68C recall has been performed and "passed" the car will lose acceleration and power when trying to go up a hill. Will not accelerate when in electric mode.

NHTSA ODI 11717746

The uconnect radio is not functioning correctly at 55000 miles it refreshes and restarts intermittently and the rear camera is not operating properly after switching to drive from reverse. The image remains in the screen for an extended period of time causing a view of the rear of the vehicle as it is driving forward. This gives a skewed perception of what is going on around the vehicle. It’s is distracting and confusing until the rear view camera returns to the “drive” condition of the vehicles transmission and removes the view of the rear of the vehicle from the radio.

NHTSA ODI 11717108

See attached letter

NHTSA ODI 11714248

There has been an electrical issue with this car since it was purchased in May 2021. The start stop system has always said service it and each time the dealership has said the temperature in the car has to be prime. It still doesn’t work. The key fobs continue to disconnect even with new batteries. The screen at times delays and needs an upgrade. The battery or both batteries even in the summer dies if the car isn’t driven for more than 3 days. We spend more time jumping the vehicle than driving it. It’s a 2021 and only has 35000 miles on it. Why pay for a vehicle that spends more time in the shop than in the driveway?

NHTSA ODI 11713446

My engine light came on shortly after my first warranty oil change August 23,2025 at the Tonkin Hillsboro dealership. During my 2nd warranty oil change January 9,2026 at Tonkin Hillsboro dealership I let them know my engine light came on after their last service and they wanted to charge me the diagnosis fee. After continued discussion learned they already checked the code indicator and mentioned possible gas cap seal and it was not fixed. Today I received an Updated Carfax of my recent service and saw a recall for my vehicle dated on October 30, 2025 re: Urgent Fire Risk When Parked. NHTSA Recall Number 25V741000 Manufacturer Recall Number68C NHTSA Recall Number25V-741 Recall StatusRecall Incomplete This safety was not checked, fixed or completed within the consumer regulatory requirement of recalls while my vehicle was in service and in their observation. If the recall notice is dated October 30, 2025, there should be no reason for an oversight in providing clear communication and corrective action immediately while the vehicle was in service on January 9,2025 and communication/information before I picked up the vehicle and drove it off the lot. This is a certified vehicle that so far has not given me any confidence of proper dealership quality and car for vehicle safety and consumer co concern.

NHTSA ODI 11710540

The manufacturer refuses to process the 68c recall. The car was purchased from a dealer in Canada in 2021. I purchased it in 2025 and imported it to Poland. Currently, the car is registered and used in Poland. The dealership refused to process it. He suggested I take the car to North America and have the recall performed there. It's possible to have the software related to the 68c recall installed at an independent repair shop in Poland, but if the battery needs to be replaced, Jeep won't do it. I tried contacting Jeep in the US to ask how to resolve this, but there's no email address or online form available. Given zip code is incorrect since this form do not allow to use forein zipcode. Please contact me via email address. Regards [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11709568

On Tuesday January 6 2026, I was driving my 2021 Jeep Wrangler 4xe. I noticed smoke coming out the engine. I pulled over to the side of the road to determine the problem. Upon exiting the vehicle, I saw flames coming from the undercarriage of the engine. The fire soon engulfed the vehicle. 911 was called. Police and Fire responded. The vehicle was destroyed in the fire. I have photos and videos of the fire and aftermath, taken once I exited the vehicle. I assume the fire is the result of the recent recall on the battery components of the Jeep Wrangler 4xe. The vehicle is currently in an impound lot and would be available for inspection upon request. I have notified Jeep and my insurance of the incident, but the jeep has not as of yet, been inspected by either entity. The fire was of great risk to myself. If I hadn't pulled over when I did who knows what might have occurred. In addition I had a full tank of gas so the vehicle could have exploded endangering other people, vehicles, and property. No warning lamps, messages, or other symptoms of the problem appeared prior to the failure. The vehicle had been operating as intended prior to smoke/fire. I have documentation of a service of the vehicle on Wednesday Dec 3, 2025 with Raidon's of Kirkland in which the performed recall services.

NHTSA ODI 11709432

I own a 2021 Jeep Wrangler 4xe – VIN: [XXX] . I previously brought the vehicle in for a recall related to the high-voltage battery. Months later, I received another safety notice instructing me not to charge the vehicle and to park it outdoors away from structures due to fire risk. This indicates the original recall service did not resolve the defect. My vehicle is currently unable to perform its intended function (EV charging/commuting functionality) and may pose a safety hazard when parked. I am requesting NHTSA oversight to ensure FCA/JEEP provides an available remedy and that owners are informed and supported. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11707926

Multiple failed recalls to stop vehicle High Voltage battery fires. I've already had the battery pack replaced once and now another recall of a software flash (68c) to test the battery cells separators for damage. So again the issue is still there and this is just another band-aid to catch it before it catches fire. This has been a ongoing issue for over a year and the issue is still not properly corrected. Multiple months of no charging, no parking in garage or near other vehicles/structures just to have another band-aid of a software flash, to stop the fire before it starts doesn't make me feel safe enough to put my family in this vehicle or to still want to charge or park anywhere near other vehicles or structures. This is the same process that "fixed" this issue the last time that obviously isn't a fix at all. The new battery they installed in 07/22/25 is just more of the same junk batteries without a proper fix.

NHTSA ODI 11705318

Open recall with no fix that’s a safety issue do to the potential of the vehicle catching fire. I have filed a claim with mopar and they just keep saying that there’s no fix available. I’m looking to get a buy back because this vehicle is not safe.

NHTSA ODI 11704315

Fire risk. Recalls for software update. I’ve done the software update once already after my jeep wouldn’t start and had to be towed to the dealership. My engine light came on again along with a stabilizer bar warning light. The dealership said they need to do another software update again, but that there’s still no real fix for the issue. I’m dropping it off again tonight. The fact that I have to do this and to be told there’s still no real fix is ridiculous. I’d really like to get rid of my jeep at this point, but I feel stuck because who’s going to buy it with all these unresolved issues?

NHTSA ODI 11703744

I purchased (traded into) a 2021 Jeep Wrangler on October 31, 2024. The vehicle already had an open safety recall (68C) at the time of purchase. Shortly after, the vehicle began experiencing severe and dangerous safety failures. While driving, the Jeep suddenly goes into “turtle mode,” loses power without warning, and drops to 7–12 mph in traffic. The engine light comes on and the vehicle becomes almost undrivable. This creates an extremely hazardous situation where I could be rear-ended or left stranded on the road. This is a serious safety risk to me and to other drivers. I contacted Jeep/Stellantis Recall Customer Care to report the issue. Only after calling did I receive an email telling me I must pay out of pocket for a rental vehicle, even though the vehicle is unsafe and the recall remedy is not available. I immediately responded saying I cannot pay upfront. Since November 25, Jeep/Stellantis has ignored my messages completely. The vehicle remains unsafe, undrivable, and under a recall with no available parts. Jeep has refused to provide a direct-billed rental or any safe alternative transportation. I have been left without a usable vehicle while the manufacturer fails to communicate or offer assistance. This is a major safety defect, and the lack of manufacturer response puts me in danger. If this vehicle loses power in traffic again, it could cause an accident. I am requesting NHTSA intervention because Jeep/Stellantis is not addressing this safety issue, not providing a remedy, and not honoring their recall responsibilities. Symptoms: •Sudden power loss •Turtle mode activation •Speed dropping to 7–12 mph unexpectedly •Engine warning light on •Vehicle unsafe to operate Manufacturer Failure: •Recall 68C remedy unavailable •Denied direct-billed rental •Required me to pay upfront for rental •No response to my communication since Nov 25 •Left me without transportation

NHTSA ODI 11703521

In June 2025, I brought my vehicle to the dealership (Hendricks Chrysler Dodge Birmingham, AL) for a full diagnostic inspection, and at that time I was told everything was fine. There were no warnings, no notes about electrical issues, airbags, coolant leaks, engine leaks, or any of the major concerns now being reported. On my most recent visit (October 2025), the dealership suddenly reported multiple “Immediate Attention” failures, including: • Airbag system issues • Electrical system failure • Coolant system leak • Water pump leak • Engine oil separator leak These items were never mentioned during my previous full diagnostic despite being safety-related components that typically show symptoms or codes. Because these new issues involve critical components like the airbags, engine, and electrical system, my safety was put at risk. I have been driving the vehicle daily under the belief that it had passed a full diagnostic months earlier. If these problems really existed at that time, then I was unknowingly operating an unsafe vehicle. If they did NOT exist, then the sudden appearance of multiple major failures raises concerns about incorrect diagnostics or improper prior inspection. I have not received any warning lights except the airbag light. The dealership has not provided a clear explanation as to how these issues appeared only months after a full inspection. This has caused significant concern regarding vehicle safety, diagnostic reliability, and whether the previous inspection was performed correctly. I am requesting NHTSA review because the dealership failed to identify or disclose major safety-related failures, which has potentially placed me in danger without any warning.

NHTSA ODI 11702988

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11702991

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 25V741000 (Electrical System). The contact stated that a recall repair for the battery was previously completed in 2023. The contact called a dealer and the manufacturer and was advised that the remedy was not yet available and to follow the instructions not to park the vehicle near any structures or other vehicles, and not to charge the battery due to the risk of a fire. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ODI 11702460

On April 15th 2025 my Instrument Panal Clusters IPC which is main computer system of Jeeps 2018-2024. It has service lights for check engine, tire pressure, def system recalibrations/cleanings, tells me how fast I'm going, oil levels, all other fluid levels, when I need a oil change, how many miles is on jeep, gas gage, along with all other issues or maintenance on a vehicle including if something is wrong or overheating of vehicle. After doing some research I did see there was a Ipc recall on Jeeps/Gladiators 2018-2024. After going on the website to check if my vin qualified it was sadly not included. I ended up taking my vehicle into the dealership and paid out of my pocket 150.00 to have my vehicle diagnosed. The dealership said it was indeed the Ipc but also said my vin number was not included which was a shock to them also since is a severe issue not being able to see anything on dash for my and other driver's on the road . They tried to submit a goodwill to Jeep Corporate office which was sadly declined also. They advised me to park my vehicle and suggest that it was not safe to drive as I do not know when it needs gas an oil change or any other important issues that may be needed. After waiting 8 months patiently making payments not only for a vehicle I cannot use is ridiculous not till mention insurance on top of that something needs to be done weather it's fixing problems, giving me a rental, or just trading the vehicle in for a usable one. Thank you for your time in advance. I tried to upload photos of the diagnostics for the Ipc also the denial of the goodwill. Oh and I forgot I was on the phone for 4 hours with FCA 18003349200 customer care spoke to recall center spoke to Shawn on 6/27/2025 @ 215pm after getting the run around and being transferred 6 different times to Ann Riley and Josh wasting my time to get told I'm not able to speak to a supervisor and there was nothing they could do to help!!!!

NHTSA ODI 11701552

I was driving on the freeway, 65mph, in Los Angeles and the '21 Jeep Wrangler 4xe started showing a bunch of error messages telling me to safely pull over, loss of propulsion, etc. I lost power and was unable to drive past 38mph. Upon getting to the end of the off-ramp and before coming to a full stop, the vehicle threw itself into parking gear. I shifted to Park, and it wouldn’t shift out of Park, while I was blocking traffic on the off-ramp, which could have been a dangerous incident. I required a tow truck. There was a Check Engine Light and a 12V battery light while I was bricked. The tow truck was unable to jump start it. The dealer provided a pre-scan report showing stored codes P0607 (ECU Internal Performance) and P1B13 (Park-By-Wire Unintended Out of Park). Refusal to Repair: The dealer just replaced the 12V battery and "cleared the codes" (per their invoice). There is a known TSB 08-054-22 (NHTSA ID 10248015) specifically relating to code P0607 software logic, but they refused to look into it further. I didn’t have confidence in their diagnosis, and when requesting them to do a safety test drive with me, they refused. When I pressed for safety verification, the Service Director told me to “leave the dealership and never come back.” I was genuinely concerned about the safety of this vehicle and their lack of investigative diagnosis, specifically their refusal to verify if the TSB was performed to ensure the Hybrid Control modules have up-to-date software. They refused to offer any help and just told me to “take the vehicle and leave.” I don’t believe it’s normal for a car to lose propulsion from a weak 12V battery while driving. There seems to be a more complicated communication issue (P0607) that is happening, and it very much concerns me as losing propulsion on the highway is very dangerous.

NHTSA ODI 11701592