Home · 2021 Ford F-550 · Complaints

What 11 owners told NHTSA about the 2021 Ford F-550

These are the actual owner complaints behind this car’s reliability verdict, filed with the federal government, unedited. They’re unverified reports, not confirmed defects: read them as leads for your pre-purchase inspection, not a diagnosis.

All (11)Crash / fire / injury (2)Fuel System, Diesel (7)Engine (2)Engine & cooling (1)Fuel system (1)Fuel System, Other (1)Steering (1)Transmission & drivetrain (1)

2 of 11 complaints match · Engine · clear filters

Jun 17, 2025Fuel System, OtherEngineFire

Operator was driving a 2021 Ford F550 equipped with an Altec AT48M aerial upfit. As he was driving the operator noted that the check engine light came on and almost immediately followed by the message center displayed "Low Fuel Pressure" warning. As he was preparing to stop, he could see smoke coming out from under the hood of the truck. As he exited the cab, he could see smoke and flames coming out of the truck.

NHTSA ODI 11667475

Sep 16, 2021Engine & coolingEngineFuel systemFire

While driving down the road at approximately 45 mph, under normal conditions, with no warning indicators the low fuel pressure light came on. When the driver stopped the vehicle he lost all power and observed smoke emanating from the underside and hood of the vehicle. Prior to him exiting the vehicle he observed flames shooting out from under the console towards his feet. Upon exiting the vehicle I saw flames under the hood of the vehicle and utilized his supplied fire extinguisher to attempt to put the fire out. This was futile and to our benefit he had a pressure washer and 119 gallons of water that he was able to put into action to subdue the fire. Noting that the drivers side front fender melted off and a hole melted in the drivers side hood from the fire. The entire engine compartment was burned as well as melted components and plastic in the passenger compartment of the vehicle from the fire.

NHTSA ODI 11433239

Working with the data? Download all 11 complaints as CSV · fetched from NHTSA July 19, 2026

How to use these: a complaint is one owner’s report, filed voluntarily and published unverified. Patterns matter more than any single story. If several owners describe the same failure at similar mileage, put that system at the top of your pre-purchase inspection list. Back to the full 2021 Ford F-550 verdict →