What 67 owners told NHTSA about the 2021 Audi Q7

My independent repair shop has just diagnosed a coolant leak weeping from the vacuum line connection at the water pump; they referred to this problem as “coolant migration”. As documented extensively by Audi in Technical Service Bulletin 19-23-45 (2070349/2), this indicates an internal seal failure of the water pump, causing pressurized engine coolant to migrate directly into the vehicle’s vacuum system. While I understand that my vehicle is technically past its 4-year factory warranty timeline, a mechanical failure of this nature at just 43,000 miles is highly premature and points to a known manufacturer design defect rather than standard wear and tear. More importantly, this defect poses an immediate, severe safety risk. Because the vacuum system directly services the power brake booster, the migration of coolant into these lines risks catastrophic contamination of the braking system. This results in a stiff brake pedal and compromised vehicle stopping ability. I am deeply concerned about operating this vehicle with an active, manufacturer-acknowledged safety hazard affecting my brakes. At this time, I have not had this problem confirmed by the dealer, but plan to in the next week. The vehicle it available for inspection upon request.

NHTSA ODI 11746888

My rear backup sensors have fallen out of my vehicle and the dealership wants to charge me $200.00 to diagnose the problem. All they need to do is reattach the sensors which were originally put on the vehicle with double sided adhesive tape which is a poor design. I cannot afford this $200.00. This is a big safety concern because I rely on those sensors when backing up. Can you help me?

NHTSA ODI 11744149

We were in my vehicle. An audi q7 2021 driving in the highway ([XXX]) Headed to Ohio from Florida and during a traffic jam all the sudden my car stopped and will not react and was “stucked in park” and transmission malfunction, parking brake malfunction, start/stop system malfunction codes popped up all at once. So scary and cars started to move and we couldn’t. Luckily we were able to get to safety and check battery but this shouldn’t happen to anyone as could cause irreversible damage to human life. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11739641

The contact owns a 2021 Audi Q7. The contact stated that while driving approximately 50 - 55 MPH, the Check Engine light had illuminated. The vehicle was taken to the dealer, who diagnosed code PO299, which referred to coolant migration into the vacuum system. The contact was unable to provide the exact parts that were needed for repairs. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer opened a case regarding the issue. The failure mileage was approximately 60,000.

NHTSA ODI 11738957

Early fuel pump failure at 55k miles. Coolant is now leaking and the fuel pump and vac system need replacement.

NHTSA ODI 11738191

I am submitting this complaint regarding a safety-related recall on my Audi Q7 involving the alternator. The wording of the recall is significantly underplayed, written off as an emissions issues. When in reality this is a life threatening flaw in the alternator. It is highly concerning that Audi isn’t being transparent with people who are driving these cars and risking their lives while doing so. This is not simply emissions, in reality, the car can totally malfunction while in operation. The entire electrical system fails and the car completely stops responding to the driver, fully stops and dies no matter where you are driving or at what speed. While driving on the highway, my vehicle experienced a catastrophic electrical failure caused by the recalled alternator, which caused the car to completely stop and it would not restart in any way. This created a life-threatening situation for my family and me. As a result of this electrical failure, the vehicle’s battery was damaged, and Audi has acknowledged coverage of 90% for the battery repair. However, the voltage converter, which is part of the same charging system, was also damaged during the same event. Audi is refusing coverage for the $1,600 repair of the voltage converter, despite the damage being caused directly by the alternator failure. I believe this represents a significant safety risk, as the vehicle’s sudden loss of power could lead to serious injury or death. Additionally, the recall itself caused secondary damage that is being denied coverage, which is unfair and unsafe. I am requesting that NHTSA review this matter as a safety defect/recall-related failure, and ensure the manufacturer addresses all consequences of this recall-related defect, including coverage of secondary damage like the voltage converter.

NHTSA ODI 11723294

The contact owns a 2021 Audi Q7. The contact stated that the rear-view mirrors on the driver's side failed to indicate when another vehicle, person, or object was nearby the vehicle. The passenger's side rear-view mirror's audible alarm occasionally erroneously alerted the driver that there was a vehicle, a person, or an object nearby the vehicle. The infotainment screen occasionally blacked out, and the following day, the screen activated but failed to finish uploading all the systems and functions. The back-over prevention camera alarm made abnormal sounds compared to the normal sound. The infotainment center intermittently failed to display the icon indicating that the key was in the ignition after the vehicle had been started. The vehicle was not taken to the dealer to be diagnosed or repaired. The contact was unaware that the vehicle was included in NHTSA Campaign Number: 25V900000 (Back Over Prevention). The manufacturer was not informed of the failure. The failure mileage was approximately 44,000.

NHTSA ODI 11717221

I was driving on the freeway and got off on an exit ramp at high speeds and began to slow down and break. As I was breaking the car became clunky and slowed down and suddenly shut off. The warning lights “transmission failure and “ESC failure” came on and I was unable to drive or put the car into gear. The car flashed “stop. Pull over” and “not safe to drive” and see “Audi dealer”. The car would not turn back on. We were stuck in the middle Of the freeway off-ramp with cars flying by us with no sidewalks or safe ways to exit the vehicle. I had my wife, dog and 2 and 4 year old kids with me. I then had to be towed to my local Audi dealer. At the Audi dealer, I told them what happened and asked for a full diagnostic. They then called me the next day and said they ran codes and nothing popped up. I said can they run a full diagnostic further and see what happened. They called me the next day and said they did a “deeper dive” and I needed to replace my transmission intake body valve and gave me a repaid quote of $8,000. My car had been serviced 2 months prior on 10/16/25 with the transmission being checked and said great.

NHTSA ODI 11709089

The vehicle was parked on a sloped driveway. After the driver exited the car, the automatic parking brake/Auto-P fail-safe failed to engage. The vehicle rolled backward unexpectedly, causing the driver-side door to strike a fire hydrant and rebound into the driver's body. There is significant property damage ($6000) and personal injury. Complete home security video footage of the incident is available [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11707425

- Engine water pump failure and coolant intrusion into the vacuum system. Parts were replaced on 5 Nov 2025 and possible still at the dealer's location. - The defect poses the following safety risks: It resulted in contamination of vacuum lines; potential for sudden engine stalling or loss of power while driving; potential for catastrophic damage to engine-management systems dependent on vacuum integrity; potential for damage to emissions and combustion-control systems; potential for reduced braking system performance if vacuum supply is compromised, expensive and unexpected component failures, and possible recurrence since the cause appears related to design rather than normal wear. Any failure can create cascading hazards affecting safety-critical functions. - The problem was confirmed by an authorized Audi dealer. Dealer name and contact info can be provided upon request. - I do not know if the dealer delivered the involved parts to the manufacturer or insurance representative for inspection. Police or others did not inspect it. - There were no warning lights, messages, or other symptoms of the problem prior to the failure. It was identified by the Audi technician on 5 November 2025 while the vehicle was in the dealer for other services. The failure occurred at 47,855 miles which is far below the average lifespan of a water pump or vacuum system.

NHTSA ODI 11705219

An alert popped up on the dashboard. Stating driver system malfunction. This happened on the freeway and then the car shut down immediately. I've gotten this notification over 8 times and it has yet to be fixed. I'm extremely anxious and terrified when driving this vehicle, because my 3 children are in this vehicle while im driving. All services has been all done at audi oakland, they have all the records/documents. This car has been serviced over 120 days in total

NHTSA ODI 11703709

The contact owns a 2021 Audi Q7. The contact received notification of NHTSA Campaign Number: 25V201000 (Electrical System). The interface turned off, and the touchscreen was inoperable. The CP message was displayed on the instrument cluster. The vehicle was taken to the local dealer, who confirmed that the USB port was not working and was not covered under warranty. The vehicle was not repaired. The contact reached out to another local dealer, Audi Riverside (3210 Adams St, Riverside, CA 92504), but no additional assistance was provided. The manufacturer was contacted and offered a discount on the repair, but no additional assistance was provided. The failure mileage was approximately 98,000.

NHTSA ODI 11702729

I am filing this complaint regarding a serious safety and mechanical issue involving my 2021 Audi Q7. The alternator on my vehicle was replaced by Audi in November 2024 as part of an official Audi recall. On October 22, 2025, less than one year later, the alternator failed while I was driving, causing the following safety hazards and damages: Sudden loss of battery power Complete battery drain Damage to the electrical stabilizer Vehicle shut down while driving Required towing Left me stranded on the road Another independent auto shop confirmed that the alternator failure directly caused the battery to fail. My vehicle is only four years old, and the battery should not fail under normal operation unless another component (such as the alternator) is defective. Audi of America refuses to cover the resulting damages, even though the alternator was replaced under their recall and failed prematurely. They have denied reimbursement for repairs, towing, and related expenses, despite clear evidence that the alternator caused the battery and electrical damage. This is a serious safety concern because the alternator failed without warning, and the vehicle lost electrical power while driving. I am requesting NHTSA to review this issue, as the failure of the recall-installed alternator may impact other Audi Q7 owners and may indicate a broader defect or improper recall repair. Thank you for your attention to this matter

NHTSA ODI 11699936

My water pump went out on my 2021Q7. The car had 57271 miles on it. I looked up the Vin and it is not covered in the class action lawsuit however, my model and my year comes up but not my Vin. I feel a water pump should last until 100,000 miles.

NHTSA ODI 11699105

During a routine service on my 2021 Audi Q7, the shop found the coolant level low and traced it to a leak. The Audi dealer later diagnosed failure of the water pump, thermostat, valves, and related parts, with a repair estimate of nearly $5,000. I discovered that prior model years (up to 2020) were included in a class action lawsuit for the same type of cooling system failures, though my VIN is not covered. This appears to be the same issue, happening just a few months outside of warranty, and raises concerns about premature failure and safety risk from overheating.

NHTSA ODI 11689690

I continue to smell a foul, moldy odor almost every time I turn on the air conditioner or heater. It has been a problem since I purchased the vehicle in August of 2024. I took the car back to the dealer from which I purchased it FOUR times. They finally “fixed” the issue by clearing out some tube. However, the issue has presented itself again. I had the cabin filter replaced last week to no avail. It still smells awful. I definitely cannot use the heater. This potentially presents a health issue and needs to be fixed.

NHTSA ODI 11688173

El carro fue comprado en febrero 2024 en greenway ford inclui un paquete de cambio de aceite,rotacion de llantas y cambio de los limpiabrisas.esto ha sido un dolor de cabeza. cada vez que se le realiza el servicio sale con la luz del ingenier prendido, en la computadora de auto zone aparece TURBOCHARGER INTERCOOLER(P0299). Ademas El asiento del pasajero esta siempre muy caliente el carro gasta demasiada gasolina y esta perdiendo velocidad,en verdad no se si el carro esta gastando aceite, ya que recién cambiado el sistema me mostro falta de aceite .o el consecionario no cambio el aceite correctamente..

NHTSA ODI 11684120

On [XXX], I experienced multiple failures of core safety systems in my 2021 Audi Q7 that put my 17-month-old child at serious risk and exposed critical flaws in how the vehicle’s systems operate and record events. On [XXX], the pre sense automatic braking system suddenly engaged while I was driving approximately 35 mph on a clear, empty suburban road. There were no visible obstructions, no warning lights, and nothing recorded in the vehicle’s logs. This occurred less than 48 hours after the vehicle had received recall-related software updates and routine service at an Audi dealership. Prior to that service, the vehicle had no history of mechanical or safety issues. The following day, the keyless entry and anti-lockout system failed. I placed my toddler in his rear-facing car seat behind the front passenger seat and set our baby bag—with the key fob inside—on the rear seat. After closing the door and walking to the driver’s side, the car unexpectedly locked. The fob and my child were both inside. The outdoor temperature was over 90°F. I attempted to open the vehicle and then to break the window with tools, without success. After approximately seven minutes, I broke the driver’s side window with a sledgehammer and removed my child from the car. The car alarm eventually activated, but no lock-in event, key fob error, or warning was recorded. The vehicle was inspected by the dealership twice and Audi Corporate engineers once. Audi confirmed faults in the emergency call module, comfort system, rear lid sensor, and parking sensors. However, they could not reproduce or explain the braking event or lock-in failure. Audi confirmed that the vehicle should not be able to lock with the key inside, and they do not know why it did and are unable to guarantee the safety feature will work in the future. The vehicle has not been driven since. The failure of both safety function and system visibility placed my child in danger. I am requesting a safety investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11683470

The recall involves the virtual cockpit instrument cluster. Audi requires the use of the vehicle’s USB port to complete the update. However, my USB system is not functioning properly. •The Issue: Audi has refused to perform the recall because of the inoperable USB. They have stated that without the USB, they cannot install the update. They are not offering any alternative method or solution to ensure that this recall is completed. •Why This is a Concern: A recall is issued because of a safety-related defect. The manufacturer is obligated under federal law to remedy the defect at no cost to the owner. By refusing to provide a solution beyond requiring a functioning USB, Audi is failing its duty to correct a known safety defect. This leaves me driving a vehicle with an unresolved recall. •My Position: It is unreasonable and negligent for Audi to deny responsibility simply because the recall requires a USB port that is not functioning. The recall repair should be performed regardless, whether through replacement of the port, use of alternate diagnostic tools, or another approved method. By refusing to act, Audi is leaving my vehicle unrepaired, unsafe, and in violation of recall compliance obligations. Requested Action: I respectfully request that the NHTSA investigate Audi’s handling of this recall and require them to provide an effective remedy at no cost to me, in accordance with federal safety recall requirements.

NHTSA ODI 11681319

I am reporting a severe defect in my 2020 Audi Q7 involving “coolant migration” due to a faulty water pump, a known issue in Audi models (Q7, S4, A6, 2013–2022). This poses critical safety risks due to sudden failure with minimal warning. My out-of-warranty Q7 showed minor coolant fouling near a solenoid, with normal coolant levels and no fluid added. The dealer quoted ~$6,000 to replace the water pump and vacuum system. This defect is highly dangerous due to: Sudden Power Loss: Coolant in the vacuum system impairs solenoids and lines, disrupting engine/turbo function. This can cause abrupt power loss, risking loss of control in traffic or at high speeds, potentially leading to collisions. Catastrophic Overheating: A failing water pump may halt coolant circulation, causing rapid engine overheating without warning, risking sudden engine shutdown and stranding drivers in hazardous conditions like highways. Brake Assist Failure: The vacuum system powers the brake booster. Contamination can reduce braking effectiveness, increasing pedal effort and stopping distances, heightening collision risks in emergencies. Emissions Control Issues: Coolant fouling affects PCV and EVAP systems, causing misfires, stalling, or increased emissions, potentially triggering check engine lights and compromising engine stability. Undetectable Progression: The defect often shows no clear symptoms or warnings until severe damage occurs. My vehicle had only minor fouling that could only be detected by visual inspection, yet extensive repairs were needed, indicating the issue’s stealthy nature, which prevents timely driver intervention. Systemic Issue: Forums and a class-action lawsuit confirm this defect across Audi models, yet owners face high repair costs post-warranty. This defect endangers drivers and others by risking vehicle failure, impaired braking, and unstable performance. I urge NHTSA to investigate and mandate a recall or extended warranty.

NHTSA ODI 11663107

The instrument cluster failed as was reported in a previous recall. This failure was caused by a hardware problem which was fixed via a software update. Unfortunately, the hardware (instrument cluster) has already been compromised and warning lights are all lit up and some warnings aren't working and the instrument panel still goes blank when driving.

NHTSA ODI 11661780

The contact owns a 2021 Audi Q7. The contact stated the vehicle was repaired under NHTSA Campaign Number: 25V201000 (Electrical System); however, the repair failed to prevent a failure from occurring. The contact stated that two days after the recall repair, several unknown warning lights illuminated. In addition, the contact stated that after refueling the vehicle, the fuel gauge failed to provide an accurate reading for the fuel. The contact stated that the check coolant and temperature warning lights were intermittently illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 105,000.

NHTSA ODI 11657159

There is a recall for my issue from Audi 90VC. The “remedy” is a software update that a previous dealer and Audi field techs say willl not fix my issue. It’s a hardware issue. The remedy provided for the recall is a facade and doesn’t fix the root cause of the issue. I’m one that actually have the symptoms of the cockpit failed (completely blank screen) but yet Audi is telling me I have to pay to have this safety recall/issue fixed.

NHTSA ODI 11656509

The contact owns a 2021 Audi Q7. The contact stated that while operating the vehicle, the instrument cluster display was inoperable and could not be viewed by the driver. During the failure, the driver was unable to view the speedometer and turn signals. The vehicle was taken to the local dealer, who diagnosed that the instrument cluster was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact was informed that the VIN was included in NHTSA Campaign Number: 25V201000 (ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 52,000.

NHTSA ODI 11655166

Both of the screens went blank while I was driving and the top one showed this: ENGINEERING +Update + Activation keys +Version information +Reboot to normal mode

NHTSA ODI 11654382