What 627 owners told NHTSA about the 2020 Toyota RAV4 Hv

2020 RAV4 with 47,589 miles. The engine maintenance light came on. It turns off once I shut off the vehicle and start it up again. It only comes back on when I put the air conditioner or heater on. I was told it's the heater control valve/coolant bypass valve and would cost around $900+ to repair. I did some research and see that this problem is occurring alot.

NHTSA ODI 11560982

Coolant bypass valve failed vehicle warning lights came on for this 2020 Toyota Rav4 at 31,641 miles. This is absolutely available for inspection on request. Safety as this can potentially cause overheating, coolant leaking, a cracked cylinder. The manufacturer (Local Toyota dealership - "Ed Morse Delray Toyota" inspected and suggested replacement of the coolant bypass valve for this 2020 toyota rav4 for a price around 800$. the technician say they see a load of these newer model Rav4's needing new coolant bypass valves. I opted not to immediately replace the valve due to it being a vehicle model-wide issue that should likely be a recall. These appeared the day before I brought it in to the dealer so withing 5-10 miles of the 31,641 miles for this 2020 Toyota Rav4. Warning just says "error please take in to dealership for service".

NHTSA ODI 11558972

Engine bypass valve sensor is faulty. Many users have reported this past 40k miles on RAV4 2019-2021

NHTSA ODI 11558462

2020 RAV4 hybrid. Vehicle doesn't start; requires a jump, which is inconvenient or unsafe, depending on where it happens. Intermittent occurrence, ~ 3 times/year. Toyota checked 12V battery, pronounced OK, of course the car was driven to the shop for the check, so was operating at the time. I've checked the battery when the car wouldn't start and found it to be a little low (11.5V) but by no means fully discharged. Not associated with leaving components on (we are careful to turn everything off) or weather; the vehicle is garaged in the winter. I turned off the "Bluetooth" system which we never used and haven't had this issue over the past year. Suspect that the "Bluetooth" system was operating even when the vehicle was off?

NHTSA ODI 11558087

Coolant bypass valve less than 40k miles and there is hundreds of them going bad this needs to be a recall issue

NHTSA ODI 11557699

My coolant bypass valve in the engine malfunctioned and shorted at a mere 27,300 miles on the vehicle and I had to bring it into the dealership to be replaced. A coolant bypass valve failing or malfunctioning can cause the engine to overheat, catch fire, or cause complete seizure. Can also cause the vehicle to stall and possibly cause a crash or wreck. Toyota has acknowledged the problem in the RAV4’s but no recalls have been issued. Dealer knew exactly what the problem was when I mentioned that the ‘engine maintenance required’ light came up on my dashboard BEFORE mechanic diagnosed it and confirmed which tells me they are aware of the issue in these cars.

NHTSA ODI 11556456

In September 12,2023 I took my 2020 Toyota Rava 4 vehicle in to Cobb Toyota for a coolant by pass valve to be replaced after my check engine light kept coming on. I only had 25 790 miles on my vehicle at the time. Anthony Sullivan was my service rep. at the time And he stated that this something has been common with this type of vehicle. But could not explain why. I just wanted to report this to Toyota. They need to know about this. And I need to be reimbursed for $99.30 for what I paid for this repair under warranty. Thank you,

NHTSA ODI 11556191

Engine maintenance required signed popped on and wouldn’t go away. Took it to the dealership. They say it’s a common coolant bypass valve. Was charged a hefty amount of nearly $700

NHTSA ODI 11554983

engine coolant bypass valve short to battery

NHTSA ODI 11554989

At 68,000 miles my Toyota Rav4 needs to have coolant bypass valve replaced. My understanding is this is getting to be a common problem and would like to see it placed on a RECALL. Thank You.

NHTSA ODI 11553584

My 2020 Toyota RAV4, "Engine Maintenance Required: See Dealer" message came on my dashboard and would not go away when I cleared it. I took it into the dealership, and they stated that they had 1000s of RAV4's come in with this same message. They said it was the engine's coolant bypass valve. After diagnosing the problem, the dealership confirmed it was the coolant bypass valve. This was very expensive to fix, $926.67, to be exact. For a car that is just over 3 years old, less than 40,000 miles, Toyota knew of these defective parts and still put them in to get the car out of their factory and onto a dealer’s lot. They do not care if it kills anybody, just get the car sold. Toyota needs to have this bypass valve as a ‘recall’ and issue refunds to THEIR loyal customers, so they call us, loyal customers, not sure how much longer I will be a 'loyal' Toyota customer. I addressed this matter with Toyota Motor Sales U.S.A. Inc. and the dealership I purchased my 2020 RAV4, Milton Martin Toyota of Gainesville, GA. They just blew it off. So, I went to another Toyota dealership to have the repair done.

NHTSA ODI 11553501

Coolant Bypass valve has stopped working, which can cause engine issues and forces a message on LED display saying Engine Maintenance Required. Local Toyota technician admitted that they've had 100's of these issues with the Rav4 recently and it costs over $500 to fix.

NHTSA ODI 11553268

Engine maintenance light came on and dealership indicates it’s the coolant bypass valve. This seems to be a common safety issue being ignored by both Toyota and the transportation safety board…

NHTSA ODI 11552224

Coolant bypass valve shorts out and doesn't open or close to allow coolant through it. "Engine Maintenance Required" message pops up for this. Toyota dealer inspected it and it replacing the part. NOT covered under my warranty.

NHTSA ODI 11551588

2020 Toyota Rav4 - Cooling valve failure reported and is not covered under warranty or recalled. Car only has 35k miles. This is apparently a common issue as the dealer knew the problem before even doing any diagnosis. Once I told them the "Engine Maintenance Required" message was on, they said "Oh, thats usually the coolant bypass valve". If it is that common an issue it should be recalled. Toyota should take ownership of this issue and fix / reimburse people for the problem. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11551642

Engine coolant bypass valve needs to be replaced. Seems to be a very common issue in 2019-2023 RAV4s but Toyota has not issued a recall and is making customers pay $600-900 to fix. I ask that Toyota take responsibility and issue the recall now so this can be fixed!

NHTSA ODI 11551648

I have a 2020 Toyota RAV4, two weeks ago the following display appear "Engine Maintenance Require, Visit Your Dealer". I attempted to clear it but it cannot be done. I check online for similar issues. I found that the 2019 Toyota RAV4, Camry, Avalon, and Lexus ES300H vehicles have similar issue with the 'coolant bypass valve'. Mine is also a 2.5L 4-Cylinder Engine. I purchase my Rav4 on Feb 24, 2020. My car only has 15,429 miles and a possible fire issue makes me nervous. I also notice than some preselected 2020 RAV4 were added to the recall, but not my RAV. Should I wait till my engine cracks or the cooling system fail?

NHTSA ODI 11551325

Unknown engine maintenance light alert check light Recommend engine coolant bypass valve with gallon of coolant

NHTSA ODI 11551118

Part # 16260-f0010 - engine coolant bypass valve failed due to open or internal short and caused a Engine maintenance required warning which blocked other safety items on the display. This is a wide spread and known issue for Toyota which can result in engine overheating due to leaking coolant and result in engine failure (severely damage the engine) leading to engine stall and/or fire risk, causing potentially unsafe situations to occur for the driver and others in the vehicle. The error code is "P268115" for "Engine Coolant Bypass Valve Circuit Short to Battery or Open". Yes. the problem has been reported with NHTSA by others and from some dealers. When I took the vehicle into the dealership, and they stated that they had many RAV4's come in with this same message. They immediately said it is some engine component failure. There is a related NHTSA Campaign Number: 20V064000 (Engine and Engine Cooling) and also a recall related to it (but not for my vehicle's VIN): [XXX] Yes, the component has been inspected by the dealer. No, there was no warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear Engine maintenance required warning sign did not go off which is good to have warning but blocking other safety items on the display dash board is a safety hazard. This could only be removed if we spend $185 for diagnostics (which is charged knowingly that this has been a reported/unreported problem around the 2.5-4yr/30-60k miles for the vehicles with this part) and fixing the part at the dealer and resetting the code. The cost of the part is affordable but the labor charge of $700 is exorbitant. The part replacement isn't covered under manufacturer's warranty. This part warrants recall as this is accidental poor manufacturing issue that is outside the scope of normal wear and tear and especially when the owner is not at fault. I'm expecting more repairs in future. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11550514

There was a warning message pop up all the time and I went to Toyota service. They said I need to pay for a coolant bypass valve replacement and it costs approx 600-800 dollars. Also, they did not fill up for the engine oil even it’s in very low to dry position.

NHTSA ODI 11550293

Engine maintenance required light came on. Scan code came up engine coolant bypass valve stuck open. Had to replace it. Cost me $120 for the part with hoses attached.

NHTSA ODI 11550007

-Inspection found coolant bypass valve seized recommendation, was to replace coolant hose with bypass valve. YES, the car is available for inspection upon any request -Safety risk unknown if not fixed -Michaels Toyota of Bellevue Washington confirmed on September 23rd 2023. I brought the car in originally on September 9th 2023 for a 10,000 mileage service and oil change. when I called to ask why the engine maintenance notice wouldn't turn off. I was scheduled to bring the car back on September 23, 2023 the needed part was not in stock nor covered by the factory or powertrain warranty with 31,2002 miles on it. The warning light came on at the same time the service and oil change was due. I was stopped a month prior by a random mechanic who noticed the car was leaking abnormal amounts of what he said could be coolant on the passengers front undercarriage. This leaking has been happening for approximately a year and I was not notified the previous 3 times the car had been in for inspections.

NHTSA ODI 11549804

RAV4 53,000 miles on and engine maintenance required prompt came on. No other warning lights on dash. Took it to dealership and it was a coolant bypass valve. Read up on it and it’s been happening to many more people. Was originally charged $900 but got a discount ended up being $825

NHTSA ODI 11549835

Engine maintenance required “Visit dealer” Light is on and won’t turn off even when resetting the scheduled maintenance data. Needs a 3 point valve according to dealership. $650 cost for that part to make light go away. This is something that needs fixed and recalled as he says it’s a common issue with the RAV4.

NHTSA ODI 11549595

I have 2020 Toyota rav4 XLE and all of sudden I got "Engine Maintenance Required" When I turn off the AC, this message goes away but comes in when I turn on the AC. I believe, it is coolant bypass valve which needs to be replaced. I read my forums in [XXX] and [XXX] and many others have complaint about the same. Toyota has to have a recall on this poorly manufactured bypass value. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11549387