What 591 owners told NHTSA about the 2020 Subaru Forester

Windshield cracked with minor strikes. There are two cracks, one small crack, one large crack in windshield and some chips. The windshield seems to be prone to cracking and when I discussed this with the Subaru dealer on 08/05/2022 about the 2020 Forester, he stated that the windshields are thinner to reduce weight for improved fuel efficiency and are not as durable as older windshields. The representative said it would cost $1415.80 plus tax to replace with original windshield. Why would I want an original windshield if it not durable and prone to breaking? This is a defective product and I would think it would be replaced by the dealer at no charge with a more durable product.

NHTSA ODI 11477866

The windshield on the 2020 Subaru Forester, as reported by many other owners, is extremely brittle and prone to frequent chips/rapidly spreading cracks. Since purchasing new, I have had two chips that resulted in small cracks and one that resulted in a larger spiderweb crack. None of these were caused by stone/pebble impacts I would have expected to cause windshield damage. (I have lived in the same area with a Ford Ranger, Jeep Wrangler, Ford Escape, VW Sportwagen, and 2016 Forester, and never experienced any windshield chips needing repair with any of the others.) While getting my third crack repaired today, the technician stated that a disproportionate amount of his work in the last two years has been on late-model Subarus. The technician who completed the second chip repair around four months ago stayed the same — a high number of late-model Subarus with chips and cracks. My experience seems reflective of a high number of other Subaru owners, and is reflected in an ongoing class action case involving the increased fragility of recent Subaru’s windshields.

NHTSA ODI 11476554

Battery drained, towed to dealership twice within a month battery replaced then failed within 2 weeks everything checked out ok but battery still drained very frustrating

NHTSA ODI 11476599

I believe the SUBARU FORESTER 2020 WINDSHIELD is dangerous and is a system failure. In April, 2022 a piece of gravel hit the windshield--smaller than the size of a quarter. Within hours, the windshield had fractured so much that there was no way that I could continue to drive safely as the windshield flowered and split the driver's eye view. I reported the claim to insurance (USAA) and took the car on May 12, 2022 to Safelight to be repaired. After working on it for three hours, they couldn't get the EYESIGHT to calibrate. I drove for two weeks without those safety features until I could get to Safelight again. After 3 more hrs I was finally told to take it to the dealership to finalize repairs and again the EYESIGHT was not calibrated. Those safety features were not available until on June 6, 2022 the delearship calibrated EYESIGHT. Driving on July 20, 2022 a small piece of gravel hit the passenger corner and within 2 hrs, split the windshield again. I have NEVER had a windshield perform like this--it is very dangerous and I believe in a crash, the windshield would INJURE me rather than prevent impact. I am worried about my safety. I cannot afford to repair the windshield when it may happen again. In 44 years of driving, I have NEVER had a windshield that was so weak.

NHTSA ODI 11475570

I was driving down the highway & noticed a crack was growing insanely large due to the heat & while I had other cracks on my windshield that were little dings it looked like a grain of sand/very small pebble hit the side of my windshield and nearly cracked in down the middle. I have heard of other people with Subaru foresters complaining about this issue & it makes the safety of the driver at risk when just about anything can crack your windhshield making it unsafe to drive/hard to see.

NHTSA ODI 11475601

DTC P26A3 thermo control valve ? All my safety features are disabled until the part becomes available- it is apparently on back order and/ or not part of an active recall or both ? Having difficulty getting information from my dealer/service dept

NHTSA ODI 11474804

My windshield cracked overnight, in my driveway, with no possibility of a person or animal being the cause. The nearest neighbor is 2 miles away. Subaru warranty denied my claim and said they saw a rock chip in the pics. The glass repair shop that submitted the claim said their was no sign of force (rock) to the windshield being the cause of the crack.

NHTSA ODI 11474519

UNKNOWN - the windshield seems to have spontaneously cracked. It was parked overnight in an uncovered driveway, and now there is a large crack down the middle. There is no particular pattern to suggest impact (and regardless the driveway is not underneath any nearby trees or other structures).

NHTSA ODI 11474535

The contact owns a 2020 Subaru Forester. The contact stated that the battery was continually being drained and needed to be recharged frequently. There were no warning lights illuminated. The vehicle was taken to the local dealer however, a cause for the failure was not determined. The dealer recharged the battery. The vehicle was not repaired. The contact related the failure with electrical system defects which consistently drained the battery. The contact recharged the battery after each time the vehicle was driven. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.

NHTSA ODI 11473973

The vehicle has 27000 miles and the windshield shows multiple small chips and voids. The windshield is really thin and can’t take any wear and tear.

NHTSA ODI 11473459

The contact owns a 2020 Subaru Forester. The contact stated that there was a crack the size of a quarter at the lower center bottom of the windshield The contact had the windshield repaired by a glass specialist. The failure recurred close to the location of the repair. The windshield was repaired a second time. The failure recurred a third time however, on the top passenger’s side of the windshield. The dealer was notified of the failure by voicemail however, the contact had not received a call back. The manufacturer was not made aware of the failure. The approximate failure mileage was 500.

NHTSA ODI 11471602

While driving one day on the road I heard a pop noise and noticed a huge thin line crack in my windshield. This was directly in front of my line of vision while driving. It made it extremely difficult and dangerous to see while driving and light would reflect off the crack causing a glare. Yes, the problem has been confirmed by an independent service center and has been inspected by an independent party. There was no warning prior to this incident.

NHTSA ODI 11470527

FRONT WINDSHIELD CRACKED STARTING AT PASSENGER SIDE TO MIDDLE OF WINDSHIELD. CAR WAS SITTING IN A PARKING LOT WHEN THIS HAPPENED. SUBARU SAID THEY WONT PAY FOR IT EVEN THOUGH THE ORIGINAL WARRANTY IS STILL CURRENT. HAD TO REPLACE WINDSHIELD, $1750.00.

NHTSA ODI 11470186

Windshield Glass Cracked.

NHTSA ODI 11469681

While driving, a small pebble was believed to strike the front windshield (lower passenger side) because we heard a loud pop then noticed the windshield cracked immediately spanning the lower center of the windshield at least 18 inches from end to end. This crack negatively impacts driver visibility, distorting the view during both day and night driving. Insurance has not yet inspected the windshield.

NHTSA ODI 11469691

The Windshield broke for no apparent reason. It’s a big crack that affects visibility. I know there is an ongoing problem with other similar suburu vehicles and is currently under a lawsuit process.

NHTSA ODI 11468107

Front windshield seems very susceptible to chips and cracks. Since I purchased the vehicle new on 4/16/2020, the following repaired have happened: 3/15/21- chip repaired $19 8/30/21- two chips repaired $19 9/8/21- front window replaced after the formation of a large crack $410.28 5/30/22- crack spread from a chip that occurred yesterday (not repaired yet)

NHTSA ODI 11466669

Windshield has cracked in 2 different spots, one on the driver side and the other on the passenger side. The passenger side is a crack from the edge to the center of the windshield. I didn't see the item, it was so small it may have been a pebble, and barely heard the noise. I don't feel safe to drive it because I am worried the crack will go across the entire windshield making it unsafe to drive. I haven't filed a claim with my insurance company yet, but understand it is expensive to replace and get calibrated for the EyeSight camera.

NHTSA ODI 11466608

2 small cracks on windshield, unknown cause, possible small pebble. Now extended to a large crack on my winshield effecting eyesite. Through research appears this year and model has been shown to have a defective windshield and previous lawsuits filed. Would like to know if this lawsuit can be used in my case or if I can file. Cost to replace is ~ $3,000 out of pocket. This is ridiculous.

NHTSA ODI 11466377

Windshield cracked for no reason. Has continued to worsen. Has to be repaired for and paid for by customer. This seems to be a known Subaru problem.

NHTSA ODI 11466200

Battery constantly dying. Significant safety concern. Never no when the car is going to not start. Unreliable

NHTSA ODI 11465828

The windshield cracked without any known trauma. The car was parked in a lot and when I came out the windshield had a large crack in it. The dealer where the car is serviced refused to see it stating they do not replace windshields.

NHTSA ODI 11465368

Drove the car to my place of work. There were no rocks , chips or other hitting the windshield. Came out to the car in the parking lot at lunch and the was a crack that stretched from the lower passenger side to the middle of the windshield. The local Subaru dealer played "dumb" and acted like they had never seen this problem and then blamed it on a rock chip after learning we knew of the thousands of Subaru's with similar problems.

NHTSA ODI 11465186

There have been three cracks in the front windshield in 18 months with little to no provocation. These have required replacement of the front windshield and re-calibration of eyesight. With each crack, there was little to no cause. On one occasion, there was a tiny piece of gravel that resulted in a crack that extended across 50% of the front windshield. My concern is for my personal safety should the windshield crack and cause harm to me as the driver or impair my visibility while driving which increases my risk for an accident. There’s also the concern about cost and time spent with repeated replacements. The date of incident below is the date of the third crack

NHTSA ODI 11464768

On highway speeds, the hood, which is shut, rattles. I have not had the hood inspected nor I have brought it to the manufacturer.

NHTSA ODI 11464500