What 31 owners told NHTSA about the 2020 Mazda Cx-30

My 2020 Mazda CX-30 has an intermittent no-start condition caused by a complete electrical failure. This occurs randomly, often overnight and after long or short trips. When it happens: The car does not respond to the key fob or ignition Dashboard warning lights are off Vehicle cannot be started, creating a safety risk if it occurs during travel or in an emergency The defect began during car's full warranty period and has persisted despite multiple service visits and battery replacement. The dealer has been unable to diagnose or correct the issue, and Mazda Corporate is aware of the defect under case Case Number 00398310. After about two years of these intermittement failures, and parasitic draws ruled out, I paid to have the Battery replaced, independently of Mazda and the battery failed yet again. Routine diagnostics have not resolved the defect Issue is intermittent and unpredictable This is a Safety Risk as the Car has failed to start when needed on numerous occasions, and has left me stranded. ALL of these Failures have occured without warning Mazda Corporate is aware and has requested dealership diagnostics. Dealership has not reproduced the problem. Issue remains unresolved as of 1/10/2026 Video documentation exists showing dealer inspection and inability to find failure source. I am submitting this complaint to NHTSA because the defect: Impairs the vehicle’s safe operation Has not been reliably repaired Represents a potential safety risk to the driver and public I request that this complaint be recorded for investigation and included in any potential recall or safety evaluation. Service records available on request Emails with Mazda Corporate als available Video of dealer inspection showing intermittent failure avaialble

NHTSA ODI 11710048

The front camera didn't operate properly The brakes have an elongated stopping distance

NHTSA ODI 11702067

There is a module that should connect to the hatch door to open. That module in no longer available. Without the hatch door opening, in case of side impact and being pushed into something else, there is no way to get out of the car. This poses a serious safety hazard. I have contacted the Mazda dealership and I am told that the part is "retired" and there is no replacement part at this time.

NHTSA ODI 11700042

I OWN 2020 MAZDA CX 30 WITH 66000 MILES. THE TRANSMISSION WAS SHIFTING WITH JERKY MOTIONS. ON JULY 14, 2025 I BROUGHT THE CAR TO PALISADES MAZDA IN ROCKLAND COUNTY NEW YORK TO HAVE TRANSMISSION LOOKED AT AND TO CHANGE TRANSMISSION FLUID CHANGED. AFTER I DROPPED THE CAR OFF LATER THAT DAY I GOT A CALL THAT THE TRANSMISSION WAS CONDEMNED. I LOOKED ON THE INTERNET WITH SAME YEAR MAKE AND MODEL AND SEE THERE IS A BIG PROBLEM WITH THE TRANSMISSIONS ON THESE CARS AND MAZDA IS AWARE OF THE PROBLEM. TSB 05-002/20 IS A BULLETIN ABOUT TRANSMISSION FAILURES IN THIS VEHICLE. MAZDA IS WELL AWARE OF THE TRANSISSION PROBLEMS

NHTSA ODI 11674592

The initial sensor alarm indication was low oil pressure and within less then an hour engine malfunction was detected and the vehicle stopped functioning. This incident occurred on [XXX] in SanAntonio and thereafter it was towed to the Mazda Dealership for inspection upon request. I was driving from Dallas to SanAntonio with my [XXX] and [XXX] children when the vehicle started making strange noise and It the notification on dashboard stated I need to immediately stop the vehicle for safety. Middle of nowhere I had to find a nearest safe place for my children. This vehicle put me and my kids in an unsafe environment due to the faulty engine that was installed by the Mazda company. I was afraid thinking the car will start on fire because it was an engine alert. Yes the vehicle has been inspected by the North Park Mazda dealership on 5/12/25 with an initial quote of engine repair for $7905.88. The first time I noted which was few weeks back prior to this incident when the vehicle stalled at me while I arrived and stopped the vehicle at UT Southwestern Medical Center were I work as a nurse to badge into my parking lot. I got worried for a moment thinking could it be battery issue? I turned off the vehicle and turned it back on and the vehicle starting working. I parked the car and completed a 12 hr shift and thereafter did few weeks of work without any alerts or issue on the vehicle until the day off [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11665901

I am reporting a repeated and potentially dangerous transmission failure in my 2020 Mazda CX30. At 6 months old, the original transmission failed. Mazda confirmed it was defective and replaced it with a refurbished unit with 10,000 miles on it. That replacement is now also failing—within 4 years of the first failure. This means the car has experienced two transmission failures before reaching 5 years of service. This raises concerns about: •The reliability of Mazda’s factory parts •The quality and safety of refurbished transmissions Mazda uses in warranty repairs •A potential pattern of premature transmission failures on this model Repeated transmission failure can cause loss of power and control, posing serious safety risks to drivers and passengers. Mazda has all service records confirming both incidents. I am submitting this to alert NHTSA to a possible defect pattern that may warrant investigation.

NHTSA ODI 11661587

The contact owns a 2020 Mazda CX-30. The contact stated that after starting the vehicle, the instrument panel made an abnormal sound. The contact then noticed that the odometer had inadvertently rolled back to 9,999 miles. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000.

NHTSA ODI 11631587

Low Engine Oil Light keeps appearing at seemingly random intervals. I will heat up my vehicle, begin driving, and sometimes after 10 minutes, sometimes after 20 minutes it will come on. I drove 2.5 hours and it did not come on at all. It first started Friday 11/29 and was driven to and from a few places and came on 50% of the time. The 2.5 hour drive occurred on Saturday 11/30 and the light did not come on at all.

NHTSA ODI 11628495

Rear coil spring broke at ~33,000 miles under normal driving conditions. No warnings given in vehicle safety system and not included in recommended maintenence. Seen when inspected by independent service center. Cannot safely drive vehicle until replaced.

NHTSA ODI 11625683

I am experiencing sharp edge on the Driver Side window up button. The Nicle plating is wearing off and causing safety concern. I have images of the concern. Will send upon request. Mazda is suggesting that I take the vehicle in for diagnostics and service. Their diagnostic cost is extremely high, and I am trying to avoid paying the diagnostic fee. Copy of the contents of my email sent to Mazda. I am experiencing sharp edge on the Driver Side window up button. I am wondering if this can be repaired under warranty or, should I report the abnormally to NHTSA to pursue a possible recall to have this switch replaced. I recall NHTSA had a recall on Hyundai vehicles a few years ago for the same issue. Can you please advise.

NHTSA ODI 11623146

Defective windshield. There is visible warping in the windshield and Mazda won't cover the cost of the replacement. This is a known issue.

NHTSA ODI 11615251

Front and rear brakes premature wear, would have failed safety inspection under 30,000 miles but brakes were inspected just outside of warranty with metal on metal. RIGHT rear coil spring snapped lower middle of coil while driving on flat even ground. Just outside of warranty.

NHTSA ODI 11596869

My sunroof spontaneously shattered/exploded during a standstill at a stoplight while waiting to enter a freeway. The glass sunroof panel appeared slightly curved upwards (caused by built up interior pressure?) and the shattered hole is right below my roof crossbar. There is no damage to metal roof surface or crossbar. My interior roof slider was closed when my sunroof shattered as it could have compromised my family's safety. After the incident, I drove my vehicle to the nearest dealership (Capistrano Mazda) but they didn't lift a finger besides taking a couple pics and suggested I call their 800 customer experience center number. Since it was a Saturday, I reached out through Mazda's customer experience email. I didn't hear back from Mazda until 4 days later on [XXX] requesting additional information (address, VIN # & mileage). After providing requested information, I didn't hear back from Mazda until [XXX] suggesting I bring my vehicle back to Capistrano Mazda dealership for a diagnosis. Almost 10 days had passed with no action from Mazda while I still had to commute to/from work dealing with loud incessant cabin noise from shattered sunroof open cavity. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11585002

The car was running in parking garage without ignition being turned on. When I entered the car, the motor wouldn't catch at all, and message popped up saying the there was a brake malfunction. All the lights were on, so it did not seem to be a battery problem, but the drive function was dead. Several months ago the car started racing while i was driving and i couldnt get it to stop. I finally, while still driving, turned off the ignition and rolled off the road. After a few minutes, i restarted the engine. it had stopped racing and i drove it to the Mazda dealership. They didnt find anything wrong. So this latest incident, Jan. 3rd, involved an uninitiated running vehicle that was parked, and the brake malfunction console notice that said "brake malfunction". Again, the prior incident involved the same vehicle racing on a roadway and necessitated the turning off the ignition while on a major road and rolling the car onto the shoulder. There is something wrong with this car involving the engine and brakes. Triple A came to tow it to the dealership and utilized an alternator to start it, which enabled them to drive it to the tow truck.

NHTSA ODI 11563320

The contact owns a 2020 Mazda CX-30. The contact stated while driving out of the driveway, the steering wheel became firm. The contact stated that the power steering warning light was illuminated. The vehicle was towed to the dealer. The dealer diagnosed the vehicle and determined that the power steering unit needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 66,000.

NHTSA ODI 11528975

Every 1000 miles the low oil light comes on. I have 24000 miles on the car and this only started about 4000 miles ago. I have to add a quart of oil every 1-2000 miles.

NHTSA ODI 11513156

I bought Mazda CX30 in 2020 and the battery already starts to fail. The engine light and the battery light are on suddenly when I was driving. Then, after a while, when I restart the engine and it starts to work again. However, it happens for two times within a week. I have sent the car to the Auto Zone and the nearby car auto repair company to check the car. However, they said they cannot detect anything as the engine light and the battery light are on again this time. It is so dangerous when the car suddenly stop in the middle of the road when I was driving. I am so lucky that this accident happened during rush hour and there were heavy traffic.

NHTSA ODI 11506136

Driver door cannot be opened from inside with either engine ON or OFF. After I came home from work , I parked the car inside the garage and I could not get out of the car.It took me approximately 2-4 minutes.After that the car just opened. This is the second time in 4 months.

NHTSA ODI 11499099

Check Engine light is on Mazda knows this model car has a manufacture defect based on a 3 page safety report I obtained. Requesting Mazda to repair my vehicle at no charge to me.

NHTSA ODI 11489142

While driving across Speer Blvd in Denver, CO (6 lanes) the emergency assist brake engaged and brought my car to a complete stop. There were no cars or objects ahead of me and fortunately the cars behind me were able to stop.

NHTSA ODI 11468192

MY KEY FOB HAS FAILED 5 TIMES AND AS A RESUKLT IT DRAINS THE BATTERY THUS NEEDING TO GRET A JUMP START. THIS IS ALL IN A TWO YEAR PERIOD. I BELIEVE THERE IS AN ISSUE WITH MAZDA KEY FOBS

NHTSA ODI 11448132

The Automatic Emergency Braking system is activated even if there is nothing in front of the car. The car stops on its own. This has happened 11 times. Yes, my car is available for inspection. I do not know when it's going to happen. My car has malfunctioned like this 11 times. I can get hit from behind since the car is suddenly and unexpectedly braking. The dealership has not been able to reproduce the problem. The local dealership told me that Mazda is aware of the problem, but does not know what is causing it or how to fix it. The first time I brought my car into the dealership for this issue, I was told that Mazda Headquarters instructed the dealership to NOT release my car until I completed their "Unintended Braking form". My car has only been taken to the same dealership that I purchased it from. No others have examined my car. The dashboard displays BRAKE and it sounds like someone is blowing a whistle. This happens at the same time as the car stops.

NHTSA ODI 11438761

ON SUNDAY MAY 2ND, THE BOSE SOUND SYSTEM SPEAKERS STARTED EMITTING AN EXTREMELY LOUD STATIC/WHISTLING THAT I WAS UNABLE TO TURN OFF. MY CAR WAS PARKED IN THE DRIVEWAY AT MY SHORE HOUSE WHEN THIS OCCURRED. I COULD NOT TURN IT OFF!!! IT WAS EXTREMELY DAMAGING TO MY EARS!! HAD I BEEN DRIVING WHEN THIS OCCURRED I DON'T KNOW WHAT WOULD HAVE HAPPENED! I CAN'T EVEN THINK WHAT WOULD HAVE HAPPENED IF MY DOG WAS IN THE CAR!! NO ONE SHOULD BE SUBJECTED TO THAT HIGH PITCH NOISE. LUCKILY, SOMEONE HEARD AND SAW WHAT WAS GOING ON AND HAD TO POP THE HOOD AND REMOVE A CHIP OR FUSE THAT CONTROLS THE SYSTEM. MAZDA JUST SENT ME A RECALL LETTER STATING THAT A LOUD HISSING MAY OCCUR AND THE CAR NEEDS TO BE BROUGH TO THE DEALER. THEY ARE COMPLETELY DOWNPLAYING THE ISSUE WHEN IN FACT IT COULD HAVE BEEN A VERY DANGEROUS SITUATION. MAZDA NEEDS TO STOP DOWNPLAYING THE ISSUE AND SEND A LETTER THAT REFLECTS THAT. I'VE ATTACHED THE MAZDA RECALL LETTER.

NHTSA ODI 11414958

DRIVER'S SIDE SEAT BELT IS TOO SENSITIVE. WITHOUT EVEN STOPPING ABRUPTLY, THE SEAT BELT BECOMES LOCKED MAKING IT DIFFICULT IF TRYING TO LEAN FORWARD TO SEE IF TRAFFIC IS COMING AS SEAT BELT DOESN'T UNLOCK EASILY. I TYPICALLY HAVE TO UNCLIP THE SEAT BELT TO LET IT RETRACT THEN PUT IT BACK ON. THIS HAPPENS ALMOST DAILY. CAR DOESN'T HAVE TO BE IN MOTION EITHER, I CAN BE STOPPED AND NOT ALL BUT MOST TIMES IF LEANING FORWARD THE BELT BECOMES LOCKED. I'VE HAD MANY CARS, NONE WITH THIS ISSUE. HAPPENS WHEN SLOWING DOWN OR STOPPED AND LEANING.

NHTSA ODI 11363884

NEW MODEL YEAR AND ALREADY 1.SAFETY AND EMISSION RECALL 4520F POTENTIAL FUEL LEAK 2.SAFETY RECALL 4420F FRONT BRAKE BOLTS MAY FALL OFF 3.DRIVE OFF LOT 1/20 AND HUGE AIR GAP WITH HEAT SYSTEM - DEFECTIVE WORKMANSHIP, 4.AC IN SUMMER NO GOOD - DEFECTIVE WORKMANSHIP THESE ISSUES BEGAN IN JAN 2020, DATE BELOW MAY NIGHT BE EXACT AND MORE TROUBLE HAS CONTINUED WITH A/C AND NOW FUEL TANK RECALL AND BRAKE RECALL. THIS IS NOT A SAFE VEHICLE ANYMORE. SENT LETTER TO MAZDA HEADQUARTERS WITH CC TO DEALERSHIP ON 8/21/20. TO DATE NO RESPONSE FROM MANUFACTURER. I WANT A LIFETIME BUMPER TO BUMPER WARRANTY ON THIS VEHICLE OR FULL REIMBURSEMENT TOWARD A 2021 MODEL. SEE IMAGE OF LETTER SENT. I SHOULD NOT HAVE TO WORRY ABOUT THE SAFETY OF MY VEHICLE WITH A NEW MODEL. IT IS MAZDA EXPERIMENT, NOT MINE.

NHTSA ODI 11361499