What 594 owners told NHTSA about the 2020 Jeep Wrangler 4-door 4xe

An internal defect in the 2014-2020 Jeep Wranglers with the 3.6L Pentastar V6 engine affects its rocker arms, lifters, and related valvetrain components, including the engine control module (ECM) software that controls the precise timing and function of the lifters. Specifically, the rollers of a Pentastar engine’s rocker arms prematurely wear down, become loose, and then drop, which shifts the rocker arm out of alignment. The rocker arms then come into contact with the cam, scraping both components and creating metal debris. This Pentastar V6 engine defect creates an audible ticking sound that stems from metal particles and debris from the failed rocker arms and other components, contaminating the engine oil and circulating throughout the engine. This defect also causes engine misfires, resulting in bucking and surging, decreased engine performance, hesitation, loss of power, premature wear on internal components, and eventually catastrophic engine failure. The check engine light came on in my 2020 Jeep Wrangler with 69,000 miles. After having it read by a dealer, it showed the P219A code, Bank 1 air/fuel imbalance. The dealership told me that if the Jeep was running fine, I did not have to worry about it, as it was likely an O2 sensor. The code was cleared, and the P219A code returned the following day. It was driven approximately 500 miles before noticing that it began idling roughly and had an engine tick, which the dealership confirmed to be a valvetrain issue. The rocker arms, lifters, valves, and camshaft components of the Pentastar V6 engine in my 2020 Jeep Wrangler with 70,000 miles have failed. Three Jeep dealerships in my area and MANY online forums stated that this is a common occurrence with this engine, which has escalated my concern about this problem.

NHTSA ODI 11572425

Vehicle started to get extreme smell of gas fumes, interior and exterior, to the point it would make you nauseous. My vehicle was taken to a dealer where the tech noticed that a fuel pump was leaking and a fuel line behind the engine had a small hole in it and was leaking on the top and was unlikely debris hit it, to get at the line the whole motor has to get dropped. After reading the description of the fuel line/pump issues with the 2020 2.0 L, this seems that it would be related and part of the effected parts.

NHTSA ODI 11544501

The contact's partner owns a 2020 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11538405

The contact owns a 2020 Jeep Wrangler. The contact stated while his son was driving approximately 35 MPH, he turned on the air conditioning and the blower filled the cabin with a gasoline odor. The contact stated no warning light was illuminated. The contact stated was made aware of the issue by his son. The contact checked underneath the vehicle and became aware that there was a fuel leak running down the length of the fuel supply line and was dripping on the driveway. The contact had not taken the vehicle to a local dealer; however, the contact called the dealer and was informed there were no available appointments for two months. The vehicle had not been repaired and had not been driven. The contact researched online and related the failure to NHTSA Campaign Number: 21V665000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 32,500.

NHTSA ODI 11527451

The contact owns a 2020 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11523721

I just purchased my 4th Wrangler last month from a dealership - a 2020 Certified Pre-Owned Unlimited Sport Willys 2.0L with Automatic transmission. Within the first days, I noticed odor of fuel or exhaust that would be more obvious some times than others, and not constantly strong or apparent. At first I thought maybe it was from being in garage at dealer and something on a mat, but then it continued and was more apparent if I had the windows closed and the heat on. Called the dealer two weeks ago and got an appointment to have it checked this past Friday. First I was told I’m probably not used to it if it’s my first “turbo” (which made no sense), then they came back to tell me it’s probably dirty air filters (which they should’ve checked/changed when they inspected it before selling it because it was at 31,200mi). Then they decided to take it for a ride and, lo and behold, they smelled what I have been smelling. They put it back on the lift to look again. Diagnosis: Fuel leak from the connector to the high pressure fuel line. I see there were some JLs with 2.0L manufactured the same year recalled for this, but they insisted mine wasn’t. Search online confirms it’s not included in the recall. I had no luck getting anywhere when I called Jeep customer service either. The dealer wants to charge me my extended warranty deductible when I haven’t even made my first payment on it yet. (According to vehicle records, 3 years for manufacturer warranty was up Nov 2022, and it has less than 32,500mi.) They insisted they keep it while waiting for the part for repair because it’s unsafe to drive, and put me in a rental (which they told me they didn’t have available when I asked for the appointment). I think this is clearly a safety issue consistent with other recalls for this model and should be repaired at no cost to me. Perhaps the initial recall didn’t include all the vehicles it should have.

NHTSA ODI 11520793

I am having a stalling issue when driving down the road. its not a constant issue but will occasionally stall/stop accelerating. you will have to let off the pedal and push down again. it will gain power back right after and be fine. believe it possibly a fuel pump issue or tps problem.

NHTSA ODI 11515109

I was driving my vehicle on the expressway and a dash light with an “A” and a circle came on. My car began to slow down on its own and would not allow me to accelerate. I managed to coast off the expressway to an exit. I immediately smelled gas and my eyes began to burn. I tried to restart my car but it was sputtering. I checked under the hood and the car smelled like strong gas. After this my eyes were burning as if someone sprayed pepper spray in them. I had get assistance to get a tow. I went to a nearby urgent care to get my eyes checked out because after all of this they were blood shot red….I see that some 2020 2.0L Jeeps have a fuel line recall but my recall isn’t showing up. This vehicle should definitely have a recall. I also have issues with my radio saying “overheating” then the volume goes out and the radio shuts off.

NHTSA ODI 11513792

The contact owns a 2020 Jeep Wrangler. The contact stated that there was a strong fuel odor inside and outside of the vehicle. There was no warning light illuminated. The contact stated that the fuel odor had become stronger over time. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel supply line connector was fractured and leaking fuel. The mechanic related the failure to NHTSA Campaign Number: 21V665000 (Fuel System, Gasoline). The dealer and the manufacturer were notified of the failure and informed the contact the vehicle could not be repaired under the recall as the VIN was not included. The vehicle was not repaired. The failure mileage was approximately 84,000.

NHTSA ODI 11513447

Fuel line ruptured above fuel tank causing diesel fuel to pour out while driving. Driver was unaware of the issue. Rear of vehicle and spare tire were covered In diesel fuel. No impact caused this issue and could have caused a fire.

NHTSA ODI 11462012

Our jeep has smelled of gas since our first week. We were told is was normal, when the tank is just filled or nearly empty, However It happpens all the time and I see that 14,000 2020 jeep wranglers were recalled. Not mine as I guess I have the larger engine. We do not smell it when the windows are up, but in good weather with windows down or top off, is it extremely disconcerting at stop lights. And we cannot park in a garage to be safe,

NHTSA ODI 11458216

The contact owns a 2020 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 21V665000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11446457

There is fuel smell inside and outside of vehicle as fuel is leaking. it's getting worse day by day putting myself & passengers at risk and vehicle catching fire. I've shown it to the dealer but they have not done anything about it as yet for the past 2 months.

NHTSA ODI 11439104

We began to notice a strong smell of gas in and around the vehicle, which was not normal or present for the first year of ownership. Knowing that this was not 'normal' we scheduled a service appointment with the dealership. Upon inspection, it was found that the gas line was leaking due to rubbing on a component. The resolution was the dealer replacing the line, rerouting, and verifying the repair. It should be noted that: 1. The vehicle is stock & has not been modified 2. Despite the strong smell of gas, there were not any warning messages/check engine lights, performance issues, etc. that would otherwise signal an issue

NHTSA ODI 11421157

8 SPD TRANSMISSION CONTINUOUSLY UP AN DOWN SHIFTING AT HIGHWAY 5TH6TH7ENTH GEAR MAYBE 8TH AND CITY DRIVING VERY DANGEROUS IN ROUNDABOUTS . NO DECELERATION DOWNSHIFT UNTIL 2ND GEAR SLAM YOU INTO THE DASHBOARD .STAYS IN GEAR AT STOP HAVE PUT IN NEUTRAL . POORR FUEL MILEAGE 13-14MPG HIGHWAY 12-14MPG CITY. STEERING LOTS LANE WONDERING CONTINUOUSLY STEERING EASY-TO-CROSS LANES ON CURVES IF TIRE HITS GROVE IN ROAD MAY SHOOT IN OTHER LANE. DEALERSHIP SAID THAT'S NORMAL

NHTSA ODI 11384860