What 73 owners told NHTSA about the 2020 GMC Sierra 2500 Hd

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11645276

While towing my dump trailer early in the morning for about 20 minutes I noticed sudden hard up shifting and down shifting in some gears on flat surface roads. I then proceeded to approach an incline hill about a 5% grade and then, what I've recently learned, my transmission locked up and released for a split second. The roads were slick so it didn't seem too harsh, I continued with no incident for another 40 miles and then it happened again while pulling up a 7% grade in a left hand sharp turn at 40 mph. The truck fish tailed and jack knifed my trailer on the left rear side of my truck and the front left side of the trailer. I was on a one lane road and had to continue until I reached my detitanation, I slowed and maintained a speed of 45 in order to prevent it from happening again but it did it 5 more times before reaching my destination. I'm currently scheduled to have the transmission checked on 02/27/2025 at Peterson's Chevrolet Nampa Idaho. In the meantime, I have no means of using any of my trailers.

NHTSA ODI 11644738

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacture was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11642616

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train). After reading the context of the recall, the contact stated that the proposed remedy of a software update was not an adequate repair for the rear wheel lock-up failure. The contact stated that the safety of the vehicle could not be trusted and believed that the vehicle was unsafe to operate. The local dealer was made aware of the issue and confirmed the recall remedy. The contact was referred to the manufacturer for further assistance. The manufacturer was made aware of the issue and the contact proposed a buyback offer for the vehicle which the manufacturer denied. The contact was provided a case number. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11641401

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving 63 MPH, and towing a 15,000 lb. 5th Wheel RV, the contact heard the rear wheels make an abnormal squealing or chirping sound. The contact stated that the front end of the vehicle was pulling to the right. The contact adjusted the steering wheel to the left to compensate. The contact stated that the vehicle was losing motive power. The contact stated that the drive(D) symbol was flashing on the instrument cluster. The contact depressed the accelerator pedal; however, the vehicle failed to respond as intended. The contact exited the highway and stopped the vehicle. The contact had the vehicle towed to an independent mechanic. The mechanic scanned the vehicle but did not retrieve any fault codes. The mechanic researched online and informed the contact that the VIN was included in NHTSA Campaign Number: 24V797000 (Power Train) for a defective transmission control valve. The contact was referred to a dealer by the mechanic. The vehicle was not repaired. The contact had the vehicle towed to a local dealer who diagnosed the vehicle and determined that the transmission needed to be replaced. The contact was informed that the transmission was not covered for repairs if damaged while performing the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 112,000.

NHTSA ODI 11640707

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the transmission jerked. The contact stated that the transmission was skipping gear while shifting. The check engine warning light turned on and off. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 114,000. VIN tool confirms parts not available.

NHTSA ODI 11635928

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11634303

The contact owns a 2020 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11631611

Tires locking up while driving. NOT SAFE TO DRIVE

NHTSA ODI 11628860

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The contact stated that he had not depressed the brake pedal. The contact was towing a 20-foot flatbed trailer with a load of lumber of approximately 4,000 lbs. in weight. The contact stated there was no warning light illuminated. The contact pulled over with the vehicle still running and attempted to shift into drive(D) and reverse(R); however, the vehicle failed to respond. The contact stated that after shifting into drive(D), several unknown warning lights were illuminated. The contact had the vehicle towed to a local dealer; however, the vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 24V797000 (Power Train). The manufacturer was informed of the failure. The failure mileage was approximately 100,000.

NHTSA ODI 11626451

I HAVE A 5TH WHEEL WITH SOLAR AND MY BRAKE CONTROLER STOPS WORKING PERIODICALLY. I HAVE A CASE# WITH GM 9-13676268071. I ALSO HJAVE AN EXTENDED WARRANTY WITH GM AND IT'S NOT COVERED DUE TO MY VIN# NOT BEING ON A BULLENTIN# 23-NA-149. GM ALSO HAS A CUSTOMER SATISFACTION PROGREAM # N232414840 AND STILL WON'T COVER IT. THIS IS A MAJOR SAFETY ITEM AND CONCERN FOR ME.

NHTSA ODI 11615574

The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving 65 MPH, the message "Check Service Brakes Now" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed with electric parking brake malfunction. The mechanic informed the contact that the electric parking brake had been engaged unintendedly, causing the rear driver's side brake calipers to seize. The vehicle was repaired; however, the failure recurred on the rear passenger's side while driving. The vehicle was taken to the dealer, where it was diagnosed with electric parking brake circuitry failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.

NHTSA ODI 11607029

Well, we ended up having a problem with our transmission in our 2020 truck. I am the wife and I was driving down the highway and all of a sudden the truck started bucking and went down to 35 mph. I was in a middle lane on the highway when this happened which Was very scary! Then I was stranded along side the highway until I could get help. Here we found that our transmission went out already only after four years, which is crazy. Very crazy! We bought this truck because we were told with the weight of this truck and all that it would pull out 42 foot fifth wheel we have. So of course we did use this truck to pull our trailer and now four years later we have been without a truck because we cannot even find a transmission with our transmission code of OMEF. Now today we found a possibility which is going to cost $7000 which is Love Ludacris! We buy a $65,000 truck just for years ago and now had to put $7000 out for a transmission. Is there anything we can do to rectify this situation??

NHTSA ODI 11603243

The contact owns a 2020 GMC Sierra 2500. The contact stated that when the vehicle was parked, the contact's husband noticed that rainwater had entered the rear interior of the vehicle. The contact stated that the rainwater had entered through the rear sliding window. In addition, the contact stated that the aluminum casing around the rear window had fractured. The contact stated that due to the failure, the interior of the vehicle had a moldy odor. The vehicle was taken to the dealer where it was diagnosed with a fractured window frame. The contact was informed that the rear window and frame needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed that the repair would not be covered under warranty. The failure mileage was approximately 69,000.

NHTSA ODI 11595742

The contact owns a 2020 GMC Sierra 2500. The contact stated while driving 60 MPH, the vehicle independently slowed and dramatically decelerated. The vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that when the failure occurred, the gear shifter position indicator light flashed, and once the vehicle returned to normal functionality, the light remained solid. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the Forward Collision Avoidance warning sensor. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was 102,000.

NHTSA ODI 11594842

My vehicle inadvertently locks the rear tires at highway speeds and then releases and drives. In some instances it may brake several times causing the tires to burn rubber for a short distance causing rear traffic to either swerve to avoid rear ending me and in a couple instances causes the rear following traffic to abruptly change lanes to avoid rear ending me

NHTSA ODI 11580026

Tailgate fell down when I had a trailer hooked up. I was parked, then backed up the trailer. Tailgate came down on the jack and scratched the tailgate. There is a recall on some trucks but mine says no recall. Sounds like same issue.

NHTSA ODI 11574977

I was travelling south bound on the highway at 70 mph when out of no where the left rear tire failed. The tread peeled back like an alligator skin and tore apart the side of my truck and caused me to fishtail all over the highway. I was able to avoid colliding with other vehicles on the road and miraculously made it to the shoulder of the highway. The tire is a Goodyear Wrangler TrailRunner AT in a size LT275/65/R20. I still have the remaining parts of the tire. My vehicle is still under manufacturer warranty, but the GMC dealer turned me away and told me I had to deal with Goodyear directly. I reached out to Goodyear to file a claim for the tire failure and damages related to it. They have been ignoring me for over a week, so I have filed a claim with my insurance company to handle the damages. I'm currently waiting to get my truck into the shop for repairs. There were no indications of any issues with the tire. I had them rotated as recommended by the manufacturer and kept the tire pressure at the recommended levels through the dealer when my vehicle was serviced. The TPMS light came on as soon as the tire failed and lost pressure showing the vehicle tire pressure monitoring system was working properly when the tire failed.

NHTSA ODI 11560290

The rear window of my 2020 GMC Sierra developed major water leaks across the entire window in 2021. GM has documented this issue with a service bulletin and the dealership has documented their resolution to the first repair under warranty. GM knows of this manufacturing issue and continued to install a faulty back window. Not only did the back window leak large amounts of water into the cab causing a potential dangerous mold issue, the security and integrity of the back window breaking or falling onto rear passengers is a major safety hazard. The integrity of the back window falling out into traffic is another safety hazard to consider. GM issued a service bulletin for leaking back windows for their Sierra trucks due to the known problems. GM has documented their problem and remedied a quick inexpensive solution. Many other GM Sierra truck owners have documented their issues and frustration with GM, and the BBB. GM has invested this issue and found the rear window plastic frame was installed or will develop stress cracked in the frame. GM’s remedy is to use a silicon window caulk and apply the silicon between the outside top section of the glass to the cab. This did not address the safety aspect of the situation. It only delayed the issue temporarily until vehicle owners were out of warranty. GM’s solution usually only last for one or two years before the issue develops again. After GM and the dearship siliconed the rear window per the service bulletin in 2021, my vehicle once again developed the same leak as before. The dealer ship once again inspected the rear window, but this time told me the issue and replaced the entire rear window because of the “stress cracks”. It’s amazing that GM wants to replace the rear window at the customer’s expense since I am out of warranty. It preposterous that GM knew of this safety issue and created a temporary correction that would last a short time until vehicle owners are out of warranty and stick them with a bill.

NHTSA ODI 11556481

Rear sliding window leak and has saturated seat and carpet causing an unhealthy environment. Spoke with dealer and was told it is a design flaw and repairs are not covered under extended warranty. I was also told it is only a temporary fix and “ leak will reoccur”. I only realized of the problem when soap residue was seen on the inside of the widow. Dealer gave estimate of repair.

NHTSA ODI 11547265

Low coolant light keeps coming on and dealership checks and confirms coolant is not low. The end result is the sensor In the resivor is bad and requires the entire tank to be replaced rather than just the sensor

NHTSA ODI 11541548

When towing a trailer a notice to service trailer brakes comes on and the trailer brakes are disabled

NHTSA ODI 11529539

Check engine came on Sunday morning the code that through was P0 526 u062F. After calling the dealer and setting maintenance to be done one day later, the truck broke down while driving on the side of the road. The dealer is saying that the belt came off and the tensioner locked up doing damage to the fan clutch and connector. The case, because the code that ran is saying that the belt wasn’t going the speed that it was supposed to because the tensioner failed. The vehicle only has 55,000 miles on it.

NHTSA ODI 11511745

There is an issue that is causing the batteries to die. This in return causes the Vehicle to go into Limp home mode with no warning. The "issue" was supposed to be resolved by the Dealer in March 2022. The resolution was that one battery was bad. The vehicle is equipped with two batteries. Each of which is sufficient to run the vehicle. A single battery failure should not have caused the truck to have a power limitation. Furthermore the issue was not resolved and General Motors and the Local dealership refuse to continue to work on the issue. This is even after filling complaints with BBB. As of November 2022 the issue has cause both batteries to go bad. The dealer has refused to work on the vehicle and it has been out of service for more than 30 days. Secondary issue. The dealer has refused to work on the vehicle but computer is locked by GM so that only GM equipment can see full scope of codes. This means I can not have third parties work on the vehicle. This is can get the vehicle stuck in areas where there is not GM facilities and GM will not provide any assistance as it is not under warranty. This has also prevented me from finding the actual resolution to the problem.

NHTSA ODI 11499881

1. The Engine Block heater sparked and created a small flash underneath the truck. It can be inspected whenever you would like. 2. Electric spark/fire 3. The problem has not been reproduced nor inspected by the dealer. I would not dare to plug it back in. 4. There were not any warning messages. It happened the first time the engine block heater was plugged in. February of 2022.

NHTSA ODI 11498646