What 162 owners told NHTSA about the 2020 Chrysler Pacifica

Intermittent power steering loss, when I turn van off and back on and go in reverse it stops sometimes.

NHTSA ODI 11748384

Head gasket is cracked causing cylinder 5 to misfire and burned up coolant in the engine causing the engine to overheat while driving and put safety of driver and passengers in danger while vehicle was traveling at high speeds.

NHTSA ODI 11744283

Driving down a road, Power Steering warning light came on, and the power steering went completely out. My wife was driving, and is not strong enough to steer manually. She was able to partially get off the road to stop. Needed other drivers to help get it off the road. We had it towed to a repair shop, and they said the electronic components replaced and only the dealerships do it. Made an appointment and will have to pay to have it towed to the dealership

NHTSA ODI 11743035

I purchased my 2020 Chrysler Pacifica in January 2020. By April 2021, I began experiencing ongoing issues that have never been fully resolved. In the six years I have owned this vehicle, I have gone through six batteries. The vehicle has stalled in the middle of the road and, at other times, has failed to start altogether. The vehicle also does some jolting randomly which can be very harsh to the passengers inside. I specifically purchased this vehicle because of its safety features, as I have young children. Unfortunately, these repeated failures have left me feeling unsafe and concerned about the reliability of the vehicle. Each time I have brought the Pacifica to the dealership, the battery has been replaced or recharged and I have been told the issue was fixed. However, within six months to a year, the same problem returns and the vehicle is back in the shop. The issue has occurred again, and I am at a loss as to what to do next. It is clear that there is an underlying problem that has not been properly diagnosed or repaired. After six years of recurring breakdowns and unsuccessful repair attempts, I have been unable to fully enjoy or rely on this vehicle. I am requesting that this matter be taken seriously and that a thorough investigation be conducted to permanently resolve this ongoing issue. Given the repeated repair history and the safety concerns involved, I believe this situation warrants immediate attention.

NHTSA ODI 11741930

On October 7, 2024, my vehicle was serviced at Coastal Chrysler Dodge Jeep Ram for a front-end rubbing/scrubbing noise that increased with speed. The dealer diagnosed both front hub assemblies as failed and replaced both front hub assemblies. I was charged a total of $2184.41 for the repairs, including parts and labor. In less than two years, I again experienced significant front-end noise and safety concerns. On May 19, 2026, because I urgently needed the vehicle and was unable to obtain a timely appointment with the dealership, I took the vehicle to a well-regarded independent repair facility, Koala Automotive Repair LLC. Their findings were extremely concerning. The mechanic documented that: The front wheel bearing was completely worn out. The axle had ripped due to contact with the strut assembly. Bolts on the hub bearing assembly were “very loose” and reportedly “finger loose” The vehicle owner stated that the hubs had recently been replaced by the dealership The independent mechanic further advised that the components replaced in October 2024 should still have been under dealer warranty, and that the second repair involved the same components and directly related failures. I am deeply concerned that: Components replaced by the dealer failed again prematurely; The loose hub bearing assembly bolts may indicate improper installation or insufficient torque procedures during the prior dealer repair; and The subsequent failure created additional damage to the CV axle and related front-end components. This situation caused: Significant unexpected repair expenses: I had to spend a total of $1,932.71 for the second repair. Loss of use of the vehicle. Safety concerns for myself and my passengers. Additiona

NHTSA ODI 11739575

car goes into park while driving

NHTSA ODI 11739262

Driver side air bags did NOT deploy resulting in injury

NHTSA ODI 11738242

I am writing to formally express my dissatisfaction with the handling of repairs on my Chrysler Pacifica and the significant financial and personal impact this situation has caused my family. The issue began when the engine suddenly stopped, leaving us stranded. The vehicle was first taken to an insurance-recommended shop that could not diagnose the issue, then transferred to Wischsnewsky Dodge in Baytown, TX. There, we were told the problem was the starter and fuse box. Based on their professional assessment, we approved costly repairs, which required financing. However, just one day after picking up the vehicle, it failed to start again. This not only showed a lack of proper diagnosis, but also placed my wife and children in an unsafe situation. We were also forced to cancel a prepaid family trip due to lack of transportation. The dealership retrieved the vehicle and promised a loaner, but none has been provided after more than two weeks. We have since incurred additional expenses for rentals and rideshare services. We are now being told the issue may be a head gasket failure—something that could have been identified earlier with a basic test and is reportedly a known issue with this model. The estimated cost to replace the engine per the dealership is $16,000. At this point, we have taken on debt for ineffective repairs and continue to face mounting costs without a clear resolution. I am requesting immediate assistance from Chrysler to address this situation and provide a fair outcome.

NHTSA ODI 11736724

Back up camera works intermittently and freezes or shows incorrect image. Wife almost backed into another car/family because the camera froze showing a clear driveway when there actually was a car there. We have an appoint with the dealership next week to investigate. Has not been inspected by police or insurance. No warning lights or messages came.

NHTSA ODI 11736162

I have a 2020 Chrysler Pacifica. There was a recall last year and I brought it in to the dealership. At that time, I wasn't even sure what the recall was for. This year, about a month ago, I was driving (I take XXX to work everyday) and the display had a notice that said "Stop safely, the engine will turn off". I pulled over and turned the car off and turned it back on. The check engine light came back on but it drove fine. The check engine light eventually went off but the same thing happened again a few days later. I brought it into my mechanic who couldn't read the diagnostics. I brought it back into the dealership and they said I just needed a software upgrade so they did that. Unfortunately, the engine died again on the road. I shut the car off and turned it back on. I brought it back to the dealership and said the issue wasn't fixed. They haven't taken the issue seriously so I started searching and found this issue. It sounds like Chrysler is aware of the issue but I'm nervous even a new transmission won't fix the issue. In the meantime, I've had to rent a car as the dealership doesn't do loaners. This is a pretty big safety issue as now my car has shut down on the middle of the highway multiple times! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11735452

Driver side airbags failed to deploy during total loss head on collision.

NHTSA ODI 11733109

Third row randomly closes on my kids who are buckled in them. I've reported this to the dealer shortly after getting my van in 2021. Brought it back to them twice where they found "no problem", then I made an additional report here last year after it closed on them an excessive amount of times and I felt helpless. I was forced to move the child who was sitting in the back to front seat after it closed on them multiple times in one ride. A head on collision occurred a few miles down the road with my child in front seat. He was injured more than he should have ever been, due to needing to be moved from the rear of the van. Furious Chrysler did not take my previous complaints more seriously.

NHTSA ODI 11733112

Vehicle steering locked up while driving causing driver to end up in oncoming traffic. Also, vehicles remote start turns on, but after a few seconds car shuts off.

NHTSA ODI 11731522

When driving on highway, electrical system started beeping and showing various signals, could no longer keep speed or accelerate. Had to put on warning lights and coast to side of road with four small kids in car. Was able to pull off to side and slowly get to safe location by resting vehicle in between events. When fully charged, didn’t seem to have issue so was able to drive to dealer. Thought was related to engine switching from electric to gas power. Dealer checked and performed two software updates. On way home from dealer, same problem occurred on highway. Super dangerous to loose all acceleration or same speed on highway! I got a video of second event as I was a passenger and my husband was driving. But as can see in video the car has a charge so the incident is not related to the switch from electric to gas power. Now we are very concerned whether Chrysler has the means to fix this at all and or whether the dealership will be actually able to identify the issue given the car was literally being driven home from the dealer. Attaching photos but have a full video. First time happened on April 4, 2026. Second on April 16, 2026

NHTSA ODI 11731725

The contact owns a 2020 Chrysler Pacifica. The contact stated that while driving approximately 45 MPH, the vehicle started losing motive power. The vehicle stalled with the check engine light and several other unknown warning lights illuminated. The vehicle was restarted; however, the check engine warning light remained illuminated. The vehicle was taken to a local dealer to be diagnosed, and it was determined that there was an electrical failure in the transmission. The vehicle was not repaired. The contact stated that prior to the failure, the vehicle was repaired under NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System); and associated the failure with the recall. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 113,000.

NHTSA ODI 11728627

The contact owns a 2020 Chrysler Pacifica. The contact stated that while turning to the right, the steering wheel seized, and the vehicle became difficult to maneuver. The contact stated that force was needed to maneuver the steering wheel. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the failure persisted and became a worsening failure. The steering wheel seized while turning to the right or the left. The vehicle was not taken to the dealer or an independent mechanic. Upon further investigation, the contact became aware that the failure was most common with similar vehicles between 60,000 and 90,000 miles. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

NHTSA ODI 11725945

The start/stop system fails while car is running. Power not delivered appropriately resulting in check engine light coming on and entire car shaking. Only 62k miles. Started at 58k.

NHTSA ODI 11724371

Many times over the past 6 months the power steering assist goes away while driving at highway speeds. The steering wheel sort of locks up and it becomes difficult to turn. After much effort the wheel will turn and the steering returns to normal. It has happened at speeds as low as 40 mph and as high as 50 mph. This has occurred in heavy traffic situations. I have never had a dealer look at the problem. No warnings or messages from vehicle.

NHTSA ODI 11722897

The hybrid propulsion system on my 2020 Chrysler Pacifica Plug-In Hybrid has repeatedly failed, resulting in sudden and complete loss of power while driving at highway speeds. The vehicle enters full limp mode, displays a red turtle warning light, and the motor cuts out entirely, creating a serious collision risk. The failure occurs without warning and has happened on multiple occasions. The root cause has been traced through escalating component failures: first the Power Inverter Module (PIM) was found to have an internal failure disabling regenerative braking and causing the motor to cut out; subsequently the battery charging module was found to be failing, causing the high-voltage battery to drain to 0% and stall the vehicle. Both components were replaced by an authorized Stellantis dealership under warranty. Despite replacement of the PIM, the charging module, and ultimately the transmission, the defect has not been resolved. The vehicle has been confirmed defective by the authorized dealer on each visit and has been subject to a STAR (engineering escalation) case with Stellantis. Warning symptoms include the red turtle warning light, check engine light, and sudden power loss. The vehicle has been out of service for cumulative warranty repairs exceeding 130 days, including a continuous period exceeding 90 days. The vehicle remains unrepaired and in dealer custody as of the date of this filing. The dealer has confirmed the defect on each visit and has conducted multiple rounds of diagnostic testing and component replacement, none of which have restored safe and reliable operation. The component failures are available for inspection upon request.

NHTSA ODI 11721939

While driving in suburban traffic vehicle engine began running rough and lost most power with about 58000 mi on the vehicle. Received check engine light and vehicle entered 'limp mode' with Turtle Icon displayed on screen. Brought to dealer and it was diagnosed with a P0304 Cylinder #4 Misfire and leaking head gasket causing coolant contamination to engine oil. Dealer repaired the head gasket under warranty. About 2 months after the head gasket was repair at 60,098 miles while drive on the Interstate the engine began running rough. Check Engine Light came on and then Oil Pressure Light came on. We were able to exit the highway, had the vehicle towed to the same dealer where the head gasket was repaired under warranty. This time the engine was diagnosed with a failed #4 Cylinder connecting rod. Chrysler and Dealer refused to repair or replace the engine even though both leak and failure occurred on same cylinder.

NHTSA ODI 11719903

This submission supplements my prior NHTSA ODI complaint regarding the same vehicle and loss-of-motive-power condition. On Nov 8, 2025, the vehicle experienced a loss of propulsion at highway speed, creating an immediate safety risk. The vehicle could not maintain speed and required evasive action with no propulsion to avoid traffic hazards. Following the incident, the vehicle was inspected and stored diagnostic trouble codes P0A3F-00 and P0A43-00 were retrieved, relating to drive motor position sensor / resolver signal loss or degradation. These fault codes are associated with loss of propulsion and indicate a propulsion control signal-path fault, rather than a condition resolved by software calibration alone. The vehicle remains available for inspection and is out of service at a dealership due to unresolved safety concerns. Since my prior ODI complaint, I provided formal written notice to the manufacturer describing the incident, the retrieved fault codes, and the safety implications, and requested a written response. Receipt was confirmed by USPS certified mail on January 6, 2026. No written response was provided, and repeated attempts to contact the manufacturer through customer service channels were not returned. The manufacturer authorized only a recall firmware update and declined to authorize or perform the intermittent wiring and resolver diagnostics identified in its diagnostic procedures for these fault codes. The firmware update does not inspect, repair, or replace the resolver, wiring, or related hardware indicated by the stored codes, and does not determine whether the underlying propulsion fault has been corrected. As a result, the vehicle has been out of service for more than two months, and the risk of another loss-of-propulsion event remains unresolved. This update documents the manufacturer’s non-response after notice and reliance on a software-only remedy that does not address the indicated propulsion system fault.

NHTSA ODI 11714584

WHILE DRIVING DOWN MAJOR HIGHWAY, THE POWER STEERING LIGHT WENT ON. IMMIDIATELY MY POWER STEERING SHUT OFF AND I COULD NOT TURN WHEEL AT ALL. HIGHWAY WAS 55 SPEED LIMIT AND I COULD NOT EVEN PULL OVER. HAD VAN TOWED TO DAYTON ANDREWS CHRYSLER DEALERSHIP FOR DIAGNOSIS AND THEY TOLD ME THAT THE POWER STEERING MECHANISM NEEDED TO BE REPLACED AND IT WAS GOING TO BE $4,500.00. THIS VAN HAS 14,400 MILES ON IT. AFTER LOOKING ON LINE IF OTHER PACIFICA OWNERS HAD THE SAME PROBLEM, IT SEEMED THIS IS A GLOBAL PROBLEM. I OBVIOUSLY CANNOT AFFORD TO FIX THIS ALMOST BRAND NEW VEHICLE AND THE SALESPERSON INDICATED THAT EVEN IF I DID WANT TO FIX THE PART IS ON BACKORDER AND THEY DON'T KNOW WHEN THEY COULD GET THEIR HANDS ON THE PART. THE FACT THAT THIS PART IS ON SUCH AN EXTREME BACKORDER TELLS ME THIS PART IS IN DEMAND BECAUSE MANY PEOPLE ARE HAVING THIS SAME ISSUE. PLEASE HELP ! i AM GOING TO CONTACT MY ATTORNEY TO SEE MY OPTIONS. THIS VEHICLE IS BASICALLY NEW AND FOR SAFETY REASONS, BEYOND ANY FAULT OF MY OWN, IS UNOPERABLE.

NHTSA ODI 11713077

Transmission shifts very hard from 2nd to 3rd gear and 4th to 5th gear at random times and at random speeds. Sometimes it occurs in parking lots at less than 15mph and other times at highway speed above 65 mph while cruising. This has caused the engine and transmission mounts to fail prematurely. When it was taken to the dealership multiple times, the service department said they could not replicate the issue but opted to reset the computer anyways. This fixed it for about 2 weeks before the issues came back. A computer reset will wipe the transmission shift learning but with normal daily driving it comes back. This should not be considered "normal" or expected behavior.

NHTSA ODI 11712272

The contact owns a 2020 Chrysler Pacifica. While the contact's wife was driving at an undisclosed speed, the engine seized in the middle of the road. The contact stated that there was no power to the vehicle. The contact stated that the failure occurred close to the residence, and there was not a lot of traffic. The driver was able to exit the vehicle and get to a safe area. The contact's brother-in-law was contacted for assistance; however, the driver became impatient waiting for assistance. The driver attempted to restart the vehicle, and the vehicle started. The help arrived, disconnected and reconnected the battery cables, and the vehicle was driven to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer; however, the dealer was made aware of the failure. The contact was informed that a recall was issued, but for Hybrid vehicles. In addition, the contact referenced an open investigation for the failure. The contact stated that the failure had occurred twice within two weeks. Additionally, the warning light that the “Auto START/STOP Unavailable” had remained illuminated since August 2025. The manufacturer was not made aware of the failure. The failure mileage was approximately 52,000. The VIN was unavailable.

NHTSA ODI 11711098

The vehicle is unsafe to operate and presents an immediate highway safety risk. Shortly after purchase, the vehicle experienced multiple safety-related failures. Headlights were inoperable from the time of delivery, requiring use of high beams at night to see the roadway. This created visibility and traffic safety issues from day one. Within the first month of ownership, the vehicle required towing. The vehicle is a hybrid and could not be shifted into neutral, yet it was dragged with the wheels locked during towing rather than transported on a flatbed. This caused damage to multiple systems. Following the tow, all four tires developed visible bulges consistent with being dragged while immobilized, creating a significant risk of tire blowout at highway speeds. Steering and alignment became unstable, with grinding noises and loss of predictable control. The hybrid underbody shielding was also damaged, leaving components exposed. These conditions have persisted despite repeated notice to the seller and service administrator. A repair facility has confirmed the vehicle is not safe for long-distance or highway travel. The vehicle must regularly be driven at interstate speeds, and continued operation poses a serious risk of crash or injury. The vehicle remains in service only due to lack of alternatives, despite known safety defects affecting steering, lighting, and tires.

NHTSA ODI 11706885