What 464 owners told NHTSA about the 2019 Toyota Highlander

Hundreds of thousands of 2017–2022 gas-powered Toyota Highlanders (equipped with UA80E/UA80F 8-speed transmissions) are experiencing high-pitched whining noises, hard or erratic shifting, and sudden hesitation. This is caused by a factory defect where a retaining nut and locking tab in the counter drive gear sub-assembly were improperly installed, causing premature internal wear and gear movement

NHTSA ODI 11749409

I have the high pitch whine coming from transmission. It is a known issue with Toyota but they refuse to look into it since my VIN falls outside their recall list. This is the same transmission as previous years and has the exact same issues. This is a safety issue that needs to be addressed immediately.

NHTSA ODI 11749132

Whining sound can be heard while accelerating the vehicle. Maintenance crew is reporting an issue with transmission. UA80F 8 speed transmission on V6 engine in Toyota Highlander has this failure noise. Given that the transmission can fail anytime. It is dangerous to operate the vehicle. No action is taken from Toyota yet.

NHTSA ODI 11747859

Since October 2025 I have had intermittent issues where the car battery suddenly loses power when driving. I have had to pull over on highway medians and shoulders. A few seconds before it loses power, multiple dash alerts go off: pre-collision malfunction, hybrid system malfunction, check engine. It has been seen now by multiple mechanics including Toyota dealership. It is now on its third battery. Replaced yesterday and lost power on highway today. Please investigate this issue.

NHTSA ODI 11747050

The dealership recommended transmission fluid exchange services for my 2019 Highlander SE after the recommended mileage for this service. I wasn’t able to get this service completed because of timing, however later on the service was completed and after three weeks the vehicle started jerking upon acceleration. Took the Benchley back to the mechanic to diagnose the problem. Per the diagnostic test the issue was determined by this code transmission P0745-7F | Pressure Control Solenoid "A" Actuator Stuck Off - Pending DTC.

NHTSA ODI 11745180

My car has been making a whining noise upon acceleration. It stops whining as soon as you release the acceleration I had a mechanic look at it who verified transmission failure.

NHTSA ODI 11743683

The rear air conditioning refrigerant lines on a 2019 Toyota Highlander SE failed due to excessive rust/corrosion, causing the A/C system to leak refrigerant and stop holding a charge. The failure affected the rear A/C lines that run to the rear of the vehicle. The problem was first diagnosed by an independent repair shop and then confirmed by a Toyota dealer. The Toyota dealer documented that the rear A/C lines were leaking due to excessive rust/corrosion. The dealer recommended replacing the rear A/C lines/cooling lines as a set, evacuating and recharging the A/C system, adding dye, and checking system operation. The repair was completed by the Toyota dealer but not covered or reimbursed. The vehicle/component was inspected by an independent service center and by a Toyota dealer. Toyota corporate customer support was also informed of the dealer diagnosis. The failed component may no longer be available for inspection because the repair has been completed, but repair records, dealer diagnosis, invoice, and related documentation are available. Safety concern: The A/C system failure can affect occupant safety and visibility because air conditioning is used for windshield defogging/defrosting and cabin humidity control. Loss of A/C can reduce the ability to clear the windshield in humid or rainy conditions. It can also create a risk to rear passengers, including children, during hot weather because the rear A/C system is no longer functioning as designed. The failure also involved leaking refrigerant from corroded lines. Toyota will not accept that this is a premature and dangerous parts failure. There were no warning lamps or dashboard messages before the failure. The symptom was that the A/C stopped cooling and would not hold refrigerant. The cause was later confirmed, by Toyota, as leaking rear A/C lines due to excessive rust/corrosion. Toyota has refused goodwill repair even after NUMEROUS persons have reported the same issue online.

NHTSA ODI 11743516

My Toyota Highlander 2019 began to produce a whining noise that orginates in the transmission at about 89000 miles. An independent mechanic examined the vehicle and deteremined that the noise is well documented. After conducting research, I found that the issue is caused by improper assembly and the only repair is a complete replacement of the transmission. I also discovered that there is a recall on the 2017-2019 Toyota Highlander due to the 8 speed transmission which is also used in my vehicle. The idea that the 2019-2022 Toyota Highlanders are NOT included in this recall is completely unreasonable. These vehicles utilize the same 8-speed transmission and the whining noise tends to surface after 60, 000 miles - about four to five years based on useage. The whining noise began without warning or symptoms. The vehicle drove without issues and we intended on driving this vehicle into retirement considering the reputation Toyota had on building reliable vehicles. I will never purchase or recommend the purchase of a Toyota vehicle! The idea that repeated transmission failures, without an univeral recall for all years affected, shows that the comsumer is not respected. I would enjoy understanding the logic and data that enabled Toyota to limit the recall to just three production year when the 8-speed transmission spanned six years of production (2017-2022). I am now forced to look into replacing the transmission with potentionally another faulty, improperly assembled 8-speed transmission.

NHTSA ODI 11743535

8 speed transmission faulty

NHTSA ODI 11743106

I am reporting a potential premature transmission failure in my 2019 Toyota Highlander AWD. At approximately 89,000 miles, the vehicle developed a noticeable and persistent whining noise coming from the transmission/drivetrain area. The noise continued despite transmission service and has progressed to the point where the vehicle requires a transmission replacement. I have had the vehicle evaluated by three separate repair facilities, including transmission specialists. All three independently determined that the transmission has failed and requires replacement. Repair estimates range from approximately $7,200 to $12,000. A complete transmission failure at approximately 89,000 miles is unexpected and raises concerns about a possible design or manufacturing defect. A transmission failure while driving could cause loss of power, inability to accelerate, reduced control of the vehicle, or create a dangerous situation while merging, entering traffic, or traveling at highway speeds. The vehicle has been maintained and used normally. I am submitting this complaint because I believe this issue may affect other Toyota Highlander owners and should be investigated for a potential safety-related defect.

NHTSA ODI 11743301

My 2019 Toyota Highlander XLE V6 developed a serious transmission-related safety problem that ultimately resulted in a sudden loss of propulsion while driving. For some time before the failure, I had noticed an unusual startup noise during cold starts and mentioned this concern during routine service visits at an authorized Toyota dealership. I was advised that the condition was normal. Prior to the major failure, the vehicle otherwise remained drivable. On December 2, 2025, the vehicle underwent scheduled maintenance at an authorized Toyota dealership, including a transmission fluid service. Within the following days, during cold weather conditions (approximately 35°F), the vehicle began exhibiting transmission shudder, RPM flare, harsh torque converter engagement, and illuminated both the Check Engine and Traction Control warning lights. I immediately returned the vehicle to the servicing dealership and reported that these symptoms had appeared following the maintenance visit. After inspection, I was informed that the torque converter clutch actuator had failed and that the transmission would require replacement or rebuilding. The vehicle was released to me, and I was not advised that it was unsafe to drive or that it should not be operated. On the morning of December 11, 2025, while driving home from work in approximately 31°F temperatures, the vehicle suddenly lost propulsion. The engine RPM increased, but the vehicle would not move under its own power. I narrowly avoided being rear-ended by a truck traveling behind me. I believe this created a significant risk of a serious collision. The vehicle was towed and remained out of service for approximately two months because replacement transmissions were difficult to obtain. The transmission was ultimately replaced with a used transmission assembly at a total repair cost of approximately $7,220. After the transmission replacement, the unusual startup noise that I had previously reported completely disappeared,

NHTSA ODI 11742621

I am filing this safety complaint regarding a known defect in my 2019 Toyota Highlander Hybrid related to the high-pressure fuel system. My vehicle triggered a Check Engine Light with Diagnostic Trouble Code P107B - Fuel Rail Pressure Sensor ‘B’ Circuit Range/Performance. This code appeared multiple times (3 stored faults). Toyota has formally acknowledged this defect by issuing Technical Service Bulletin T-SB-0050-20 specifically for 2018-2019 Highlander Hybrid vehicles. This is a fuel system pressure issue that directly affects the safe and reliable operation of the vehicle. A failure in the fuel rail pressure system can cause: •Sudden loss of engine power while driving •Unexpected stalling at highway speeds •Inability to accelerate when needed, creating a dangerous situation in traffic Despite Toyota acknowledging this defect through TSB T-SB-0050-20, Jim Coleman Toyota (10400 Auto Park Ave, Bethesda, MD 20817, Phone: 301-618-0480) quoted me nearly $3,000 to repair this issue rather than covering it under warranty. I believe Toyota should issue a formal recall to protect all owners of affected vehicles. I am requesting that NHTSA investigate this matter and pressure Toyota to issue a recall covering all 2018-2019 Toyota Highlander Hybrid vehicles affected by this known fuel system defect.

NHTSA ODI 11741155

Transmission is whining on speeds between 25-55 mph. Pointing to pre-mature internal failure of components in Transmission.

NHTSA ODI 11740619

Transmission is giving a whining noice when accelerating. Took it to Toyota dealer, they said the transmission needs to be changed and it will cost me $11,000 . There are many complaints online about these UA80 Transmissions and the root cause is listed to an assembly problem during production but Toyota will not accept this and will not help to replace it

NHTSA ODI 11739457

My 2019 Toyota Highlander has taken on water from a leaking Panoramic Sunroof. Both times the dealership ran it through a car wash and it did not leak after cleaning the sun roof drains. Took my car in on 5/4/2026 after a thunderstorm and they cleaned (Tom O’Brien Toyota) the roof drains. Then on the evening of [XXX], we had a heavy thunderstorm which resulted in 3 quarts of water that my husband cleaned off the liner. It was also dripping inside on the armrest. Now I have a sagging liner with water stains. We took the car in again on 5/22/2026 and they cleaned the drains again.We are expected to have rain for the next 3 days. If I leave the liner back it could result in water pouring in the cabin, shorting out the electrical heat warmers on my console. What about MOLD and discoloration? Talk about safety concerns.!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11739522

When accelerating, started hearing a whining noise. Took to mechanic, said it was the transmission. Called Toyota and they had us bring it in for diagnostics. Also said we needed a new transmission. Quoted at over 13K - could fail at any time. This should not be happening in a 2019 vehicle and seems to be a known issue that Toyota is not doing anything to address.

NHTSA ODI 11739004

Vehicle has experienced sudden stalling while driving and an intermittent Check Engine Light with Diagnostic Trouble Code (DTC) P107B — Fuel Rail Pressure Sensor “B” Circuit Range/Performance. This is the exact condition covered by Toyota Technical Service Bulletins T-SB-0050-20 and T-SB-009-23, and Customer Support Program 23TE04 (Denso low-pressure fuel pump settlement coverage, valid until July 15, 2036 or 150,000 miles). Timeline: • Late April 2026 (while driving ~300–400 miles from home): Vehicle stalled without warning at a red light. • May 5, 2026 (while driving on freeway ~50–75 miles from home): Check Engine Light illuminated. AutoZone scan and dealer diagnostic tool both confirmed DTC P107B. • May 5, 2026: Dealer performed health check using Toyota GTS+ tool (see attached screenshot taken at 15:58:01). Screen clearly shows “PERMANENT: YES” confirming a permanent stored fault code. • May 5–15, 2026: Crown Toyota (Ontario, CA) confirmed the code was present on arrival (Repair Order 2842115 dated 05/15/26). They later cleared the code, performed a short test drive, could not duplicate the fault at that moment, and closed the repair order as “inconclusive.” They refused the low-pressure fuel pump replacement under Customer Support Program 23TE04 even though corporate cases #260505002096 and #260515002110 had previously confirmed eligibility based on the prior pump replacement (9/11/2021, RO #1764477). The issue is known to be intermittent and occurs under load/highway conditions. This creates a serious safety risk of sudden loss of power while driving. T-SB-0050-20 specifically directs dealers to replace the low-pressure fuel pump assembly when P107B is present on 2018–2019 Highlander Hybrids, and T-SB-009-23 provides the official repair procedure under CSP 23TE04. I have attached: (1) the dealer repair order RO 2842115, and (2) the May 5, 2026 GTS+ diagnostic screenshot showing the permanent DTC. Please investigate this as a potential safety defect.

NHTSA ODI 11738304

Whining noise on a cold start and at acceleration. Transmission fluid was replaced less than 1000 miles ago and noise has gotten louder.

NHTSA ODI 11737598

The contact owns a 2019 Toyota Highlander. The contact stated while driving 70 MPH, on the highway. the contact notice an abnormal noise coming from the transmission. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure and they informed him this will not b escalated and offered no further assistance. The approximate failure mileage was 133, 000.

NHTSA ODI 11737673

The contact owns a 2019 Toyota Highlander. The contact stated that while driving approximately 60 MPH under a local under path the vehicles the braking system suddenly activated causing the vehicle to come to a complete stop. Previously the while driving at the same location the vehicle suddenly reduced speeds. The contact indicated that each time the failure had occurred the cruise control feature was activated. The cause of the failure was not determined. The manufacturer and local dealer were not yet contacted. The failure mileage was 80,000.

NHTSA ODI 11736940

Around Halloween 2025 my Toyota’s Transmission started slipping. I called a few places and no one except Toyota would address the issue except a local shop in [XXX] , Ridge Auto Repair who after checking out the vehicle said they can’t repair it because the parts are not available November 6th, 2025, The Shop LAG LLC was recommended to me by a family member, and they came to check out the Toyota, and they were convinced it was the Torque Converter and wanted $1300 to fix it. I paid them and after a few weeks they claimed it was the Transmission and wanted more money which they were paid. Weeks went by and no updates from them and they weren’t responding to my messages. When they finally responded they started saying the starter was bad, the differential, the fly wheel, etc, Again, we paid them more money, and again weeks went by without any updates. We paid a total of $9000.00 Their last attempt to fix the vehicle also failed and I’m left with a vehicle with no transmission, the entire front end taken apart and scattered all over my property and this was their last response. “Oh lord. So the original place we got the transmission from denied the warranty, but at the time it wasnt a problem we have insurance. So we summited a claim and thats why it was going to be shipped from another place. Well they kept telling me that it was coming this day then that day. I got a letter denying the claim Instead. I have tried to fight it, but they ended up dropping us after that. We are willing to install one in for free if your able to get your hands on one, because this whole ordeal has been a nightmare, but we got denied due to mileage with the claim. There was a difference in our timestamped pictures and the adress of where it went once it left. So they said it was driven on with a problem, because it was moved to there with a problem thats what they are denying my claims to fight it. I didn't want to say anything until it was final and we kne INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11735861

My car all of a sudden has this sudden humming/high pitch sound. I had mechanic checked and he said coming from the transmission. I checked the Toyota forum and there's a widespread issues with their transmission. The issue started with the year 2017, These vehicles are equipped with the UA80F (AWD) and UA80E (FWD) 8-speed automatic transmissions. My 2019 is equipped with the UA80E. Toyota already recognized that they have problems with the transmission but only issued a recall for vehicles 2017-2018. They need to include Toyota highlander 2019.

NHTSA ODI 11735699

This vehicle safety complaint is regarding my 2019 Toyota Highlander XLE, VIN [XXX] . A Toyota-authorized dealership, Sansone Toyota in Avenel, New Jersey, documented that the front driver axle is prone to freezing in the differential. This is a serious safety concern because if the axle seizes while the vehicle is in motion, it could cause sudden loss of control. This vehicle is used regularly as our family vehicle, including to transport our family of 6 with our young children. I am extremely concerned about continued operation of the vehicle while this documented condition remains unresolved. In addition to this safety-related axle issue, this vehicle has a broader history of serious mechanical problems. On May 13, 2022, after a recent service visit at DCH Brunswick Toyota, I reported that when I pressed the gas the vehicle was making an unusual noise like an old car, that the car delayed to speed when I pressed the gas, that I had to press the gas all the way in order for the car to move faster, and that it was not like this prior to service. At approximately 25,000 miles, I also asked that the brakes be checked because when we drove the vehicle and used the brakes, the car made a startling sound. In 2023, I also reported hard/heavy steering and jerking while driving. I reported transmission-related abnormal noises and drivability concerns while the vehicle was still within Toyota’s powertrain warranty period, but the condition was not properly diagnosed at that time. The transmission has since been confirmed by authorized Toyota dealerships to require full replacement. The vehicle also has a documented engine oil leak, leaking shock absorber, and prior recall history involving a stalling condition. I've filed this complaint with NHTSA due to the axle-related safety risk. Toyota is now on written notice of that condition. Mileage: approximately 101,000 Documenting safety issue: Sansone Toyota, Avenel, NJ Please review this potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11734722

Hi. I have a Toyota 2019 Highlander EXL. My problems is the transmission started to have the small whining noise every time I accelerates and I it's happened over 18 months ago and I didn't know that is the issues until I brought it to the Toyota Dealer for 75k maintenance. The Dealer has told me that the noise was abnormal and it's from the transmission and it's will cost me $13 K to replace with a new one. I believe in Toyota quality but now I will have to really think about it again for the next purchase ?. I don't understand why Toyota has known this issues because of many reported but never intend to fixed it. I'm not so happy with this . Please ask ToyoTa Corp to answer and do take the responsibility before someone is getting hurds Thanks Tom le

NHTSA ODI 11733240

Traveling at approximately 60-65 mph on interstate 95 in Wakefield the vehicle suddenly downshifted causing a rapid deceleration to around 40 mph. It would not upshift requiring us to pull into the breakdown lane.

NHTSA ODI 11732599