What 95 owners told NHTSA about the 2019 Lincoln Nautilus

Known structural defect Coolant intrusion into cylinder bores TSB 22-2229 Blown head gasket

NHTSA ODI 11747915

Transmission shutter at 25 to 45 mph. Known issue with the Transmission. Ford has mechanic memos stating the exact issue my car is experiencing. Took it to the dealer ship, got charged $250 to get told I need a transmission replacement and torque converter for $8000. little over 1 year out of warranty car only has 48,000 miles on it. worried the transmission going to go out causing a safety issue while I figure out what to do to get it fixed

NHTSA ODI 11747333

The contact owns a 2019 Lincoln Nautilus. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was driving abnormally rough and sluggish. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a failed telematic control unit. The contact was informed that the telematics control unit needed to be replaced. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The dealer was made aware of the failure, and the contact was informed that there were no available appointments for the next three months. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.

NHTSA ODI 11747481

The engine stalls and shuts down every time the car is stopped. This car has had so many problems and Lincoln has been unresponsive to the multitude of major safety problems

NHTSA ODI 11745007

The contact owns a 2019 Lincoln Nautilus. The contact stated that the front driver's-side seat belt was stuck and failed to extend as needed. The contact used excessive force to extend the seat belt. The vehicle was taken to the dealer, and it was determined that the seat belt assembly needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

NHTSA ODI 11744490

The contact owns a 2019 Lincoln Nautilus. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable. The contact stated that the instrument cluster intermittently blinked and flickered. The "Adaptive Steering Fault" warning message was displayed, and the steering wheel became misaligned. Additionally, while driving approximately 65 MPH, the vehicle experienced a loss of motive power, and the powertrain warning light illuminated. The vehicle was able to restart. The vehicle was taken to several dealers, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 48,000.

NHTSA ODI 11742975

Car recently started clunking when changing from P to D or R. Took to dealer who broke down the transmission only to be told the torque converter was faulty and there’s “excessive damage” meaning I need a new transmission.

NHTSA ODI 11738794

The contact owns a 2019 Lincoln Nautilus. The contact stated that while driving at slow speeds, the power steering assist failed to operate as needed. There was an audible chime with the power steering message flashing on the instrument panel before the steering wheel seized for several seconds. Despite the failure, the vehicle resumed normal operation soon after the temporary failure. Upon investigation, the contact discovered that a low battery voltage might have caused the power steering failure. The vehicle was taken to the dealer, and the battery was tested. The dealer determined that there was no fault found with the battery. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 84,000.

NHTSA ODI 11725548

There was one alert soon after I left Gallup NM, the engine heat light went off very briefly then went off (mile marker 6). The close to Miler marker 340 in AZ the card complete shut down and I had no control over the car. I had to pull over. I was in the middle of no where with no cell service. I was eventually able to reach my father Via Whatsapp/ I tried multiple times to call my husband but had no service. I added water to the radiator and sat the car for several minutes. The outside temperature was 41. I was not near anything. I was able to start the car and drive very slow without the engine light alerting me. I pulled over at the next exit that had a gas station and purchased Antifreeze and water. I called my father again and did a video call to make sure I was doing it correctly. I then drove only 40 miles when the engine light alerted and added more coolant. I drove slowly and once in Flagstaff checked my oil. I was in constant contact with my father and husband. I stopped 8x to fill the vehicle's radiator. I arrived home very late and exhausted. On March 2 I contacted my mechanic but could not get the vehicle into him for inspection until March 9. On March 10, I was notified that there had been recalls and the head gasgette for my car but I do not see any recalls in the system at this time. My mechanic reported the engine was done and he would purchase a used enghine to start a rebuild. He was later alerted to the turbo charge having damage and it needed to be replaced as well. The transmission fluid was black. There are concerns that this car has higher milage on the vehicle due to rust, dark trans fuild and the overall appearance of the engine once it was removed. I proceeded to pay for a Car Fax report. This vehicle has only 53,900 miles and too low for this much damage and concerns. The car was purchased in Nevada and undetermined if known concerns were apparent. It is quite concerning being stranded in the middle of no where and your car stopping.

NHTSA ODI 11725408

Purchased car from a dealer in 2024 with 40k plus miles. Did not notice upon purchasing, but since to 64,750 miles the transmission regularly shifts with harsh,shuddering , or jerking instances. We have not reported this but it is concerning, that it may cause a permanent failure to the transmission. Hoped it had a recall, but no, not for that! Have seen plenty of complaints about this problem, and wish Lincoln would FIX IT!

NHTSA ODI 11724475

Constant shattering/jerking when accelerating and trouble light on indicator on car dash indicating torque converter issues after I diagnostic it with a OBD reader. This is a known issue and should’ve been recalled a long time ago.

NHTSA ODI 11719819

Component: Engine Vehicle: 2019 Lincoln Nautilus – 2.0L EcoBoost Mileage at failure: ~76550 Incident date: August 2025 Narrative (paste this): My 2019 Lincoln Nautilus equipped with the 2.0L EcoBoost engine experienced a sudden low-coolant warning followed by rapid overheating and complete engine shutdown in August 2025 at approximately 70,000 miles. After adding coolant, the warning immediately returned and the vehicle entered reduced-power mode and became inoperable within about 20 miles, requiring towing. An independent repair facility performed diagnostic testing confirming coolant intrusion into the engine cylinders, internal engine failure, and coolant pooling in the cylinder head area. Diagnostic trouble codes included P0217, P0316, and P0128. The engine and turbocharger required full replacement at a cost exceeding $6,900 paid out of pocket. This failure matches Ford Technical Service Bulletins TSB 19-2172 and TSB 19-2346, which acknowledge coolant intrusion in 2.0L EcoBoost engines requiring long-block replacement. The failure created a serious safety hazard because the vehicle overheated and shut down during travel in extreme Arizona summer heat, leaving occupants stranded for hours awaiting a tow truck. This appears to be part of a widespread known defect involving coolant intrusion in Ford 2.0L EcoBoost engines. I am reporting this for safety investigation and defect tracking.

NHTSA ODI 11716472

Component: Power Train / Transmission Vehicle: 2019 Lincoln Nautilus – 8F35 transmission Mileage first noticed: At Test drive and purchase (~61,405 miles) Status: Ongoing defect My 2019 Lincoln Nautilus has exhibited persistent hesitation, jerking, and harsh engagement during acceleration from a stopped position since the time of purchase at approximately 61,000 miles. The condition occurs repeatedly during normal driving and was reported to a Lincoln dealership service department, which stated the concern could not be duplicated and later described the behavior as “normal for that model.” The drivability problem has never been repaired and continues to occur. Ford has issued multiple Technical Service Bulletins relating to harsh shifting, shudder, and drivability concerns in vehicles equipped with the 8F35 transmission, indicating manufacturer awareness of the condition. The hesitation and jerking create a potential safety concern when entering traffic or accelerating from intersections because vehicle response is delayed and unpredictable. I am submitting this complaint to document an ongoing transmission defect affecting safe vehicle operation.

NHTSA ODI 11716478

Transmission is jerking at speeds around 25mph.

NHTSA ODI 11708087

Car consistently jerking as soon as you accelarate. The acceleration takes along time to pick up speed.Can feel the car missing gears or slipping while driving even on the freeway.

NHTSA ODI 11707296

While driving, the entire dashboard and instrument cluster intermittently go completely blank, disabling visibility of speed, gear position, warning lights, turn signals, and other critical information. The failure occurs suddenly and without warning. The cluster then goes through multiple reboot cycles, sometimes several times in a row. In many cases, normal operation does not return until the vehicle is fully shut off and restarted. This creates a serious safety risk, especially at highway speeds or at night. The issue first occurred around 71,000 miles (Oct 2024) and has recurred multiple times. The most recent incident occurred on Oct 31, 2025 at approximately 84,200 miles. The vehicle has been to a Lincoln dealership in Raleigh, NC for four repair attempts (Dec 2024–Oct 2025). Multiple electrical modules have been replaced (battery, fuse junction box, trunk module, telematics module, keyless entry keypad), and Lincoln engineers were consulted, but the defect remains unresolved. No diagnostic trouble codes were stored during the most recent failure. The vehicle is currently covered under a Lincoln ESP PremiumCARE warranty through 2030, and the defect remains intermittent and unresolved.

NHTSA ODI 11700996

Adaptive Steering Fault Service Required - This warning came on while I was driving down the road. The steering wheel automatically went from a center position to the left like I was making a left turn. The vehicle continued going straight with the steering wheel in the left position. Needless to say, It was very alarming when this happened. I drove home and made an appointent for service. The next day the fault code was off and steering was normal but I still brought it to my Lincoln dealership for service and they said a module in the steering column is faulty. In Fords/Lincoln design you cannot just replace the module, you need to replace the entire steering column at a price of $5000.00 (part 3600.00, labor 1400.00). I did find on the interweb that this has been a problem with Ford trucks and a few other Naultilus owners have reported this problem.

NHTSA ODI 11700438

The contact owns a 2019 Lincoln Nautilus. The contact stated that while driving at an undisclosed speed, the driver’s side air bag unexpectedly deployed, and the blind spot and cross-traffic system fault messages were displayed. The contact stated that the vehicle was able to be restarted, and no medical attention was required. The contact’s spouse’s arm was struck by the air bag, and the contact stated that both occupants were shaken up by the failure. The contact stated that following the failure, the windows, heating system, and radio became inoperable. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 60,000.

NHTSA ODI 11699939

Okay let me first start by saying I have had problem after problem with this car in less than a year. I’ve had to replace my purge valve. The transmission on this car is horrible. I had my car less than a year and at not even 70k miles I had to get my transmission replaced because the car would stutter between 25-45mph thankfully my warranty covered everything. Now let’s get to my current issues which is with the adaptive steering malfunction. I got a steering wheel warning light 3 days before my new transmission. As I’m looking into this more this will cost $2000+ to replace and I don’t have money to constantly keep putting into a car especially with everything going on currently.

NHTSA ODI 11697815

Car starts to buck when changing gears

NHTSA ODI 11692925

The Nautilus began shuddering while accelerating from about 15 to 45 mph. I took it to a Lincoln dealer and was told the transmission needed to be repaired or replaced for $7,000 plus. It has 88,000 miles on it

NHTSA ODI 11692017

transmission problems including harsh shifting, shuttering, lurching, hesitating, or slowing down when shifting gears. No warning lights illuminated but after dealer inspection, have been told that both the transmission (harsh shift in all gears) and rear axle (popping and grinding while turning) need to be replaced. The vehicle is not safe to drive. Cost of repairs is quoted at more than $14,000. This issue/defect appears to have a class action associated with it; why has there been no manufacturer recall?

NHTSA ODI 11691824

Both rear sealbelts stopped retracting. They both quit working within 2 days of each other. I did schedule an apt and take to dealership who stayed there was no recall for issue and it would be out of pocket. Suggested I contact NHTSA

NHTSA ODI 11688179

Jerks and stutters 3 months after I bought the car.

NHTSA ODI 11686711

While in cruise control with lane assist on the car slowed down immediately with no cars or any obstacles around. This has happened three times. I’m at the point where I don’t trust it.

NHTSA ODI 11683728