What 95 owners told NHTSA about the 2019 Lincoln Nautilus Fhev

Known structural defect Coolant intrusion into cylinder bores TSB 22-2229 Blown head gasket

NHTSA ODI 11747915

The engine stalls and shuts down every time the car is stopped. This car has had so many problems and Lincoln has been unresponsive to the multitude of major safety problems

NHTSA ODI 11745007

The contact owns a 2019 Lincoln Nautilus. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable. The contact stated that the instrument cluster intermittently blinked and flickered. The "Adaptive Steering Fault" warning message was displayed, and the steering wheel became misaligned. Additionally, while driving approximately 65 MPH, the vehicle experienced a loss of motive power, and the powertrain warning light illuminated. The vehicle was able to restart. The vehicle was taken to several dealers, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 48,000.

NHTSA ODI 11742975

There was one alert soon after I left Gallup NM, the engine heat light went off very briefly then went off (mile marker 6). The close to Miler marker 340 in AZ the card complete shut down and I had no control over the car. I had to pull over. I was in the middle of no where with no cell service. I was eventually able to reach my father Via Whatsapp/ I tried multiple times to call my husband but had no service. I added water to the radiator and sat the car for several minutes. The outside temperature was 41. I was not near anything. I was able to start the car and drive very slow without the engine light alerting me. I pulled over at the next exit that had a gas station and purchased Antifreeze and water. I called my father again and did a video call to make sure I was doing it correctly. I then drove only 40 miles when the engine light alerted and added more coolant. I drove slowly and once in Flagstaff checked my oil. I was in constant contact with my father and husband. I stopped 8x to fill the vehicle's radiator. I arrived home very late and exhausted. On March 2 I contacted my mechanic but could not get the vehicle into him for inspection until March 9. On March 10, I was notified that there had been recalls and the head gasgette for my car but I do not see any recalls in the system at this time. My mechanic reported the engine was done and he would purchase a used enghine to start a rebuild. He was later alerted to the turbo charge having damage and it needed to be replaced as well. The transmission fluid was black. There are concerns that this car has higher milage on the vehicle due to rust, dark trans fuild and the overall appearance of the engine once it was removed. I proceeded to pay for a Car Fax report. This vehicle has only 53,900 miles and too low for this much damage and concerns. The car was purchased in Nevada and undetermined if known concerns were apparent. It is quite concerning being stranded in the middle of no where and your car stopping.

NHTSA ODI 11725408

Component: Engine Vehicle: 2019 Lincoln Nautilus – 2.0L EcoBoost Mileage at failure: ~76550 Incident date: August 2025 Narrative (paste this): My 2019 Lincoln Nautilus equipped with the 2.0L EcoBoost engine experienced a sudden low-coolant warning followed by rapid overheating and complete engine shutdown in August 2025 at approximately 70,000 miles. After adding coolant, the warning immediately returned and the vehicle entered reduced-power mode and became inoperable within about 20 miles, requiring towing. An independent repair facility performed diagnostic testing confirming coolant intrusion into the engine cylinders, internal engine failure, and coolant pooling in the cylinder head area. Diagnostic trouble codes included P0217, P0316, and P0128. The engine and turbocharger required full replacement at a cost exceeding $6,900 paid out of pocket. This failure matches Ford Technical Service Bulletins TSB 19-2172 and TSB 19-2346, which acknowledge coolant intrusion in 2.0L EcoBoost engines requiring long-block replacement. The failure created a serious safety hazard because the vehicle overheated and shut down during travel in extreme Arizona summer heat, leaving occupants stranded for hours awaiting a tow truck. This appears to be part of a widespread known defect involving coolant intrusion in Ford 2.0L EcoBoost engines. I am reporting this for safety investigation and defect tracking.

NHTSA ODI 11716472

Car consistently jerking as soon as you accelarate. The acceleration takes along time to pick up speed.Can feel the car missing gears or slipping while driving even on the freeway.

NHTSA ODI 11707296

Jerks and stutters 3 months after I bought the car.

NHTSA ODI 11686711

I brought my Lincoln Nautilus to an authorized Lincoln dealership due to a serious transmission issue. The dealer kept the vehicle for four days, diagnosed a potential transmission failure, and told me that the transmission could “blow.” However, they returned the car to me unrepaired and admitted they could not fix it anytime soon. The reason: the dealership has only one transmission technician, and that person is currently working through a backlog of transmission jobs from March. My vehicle — with a known safety risk — was effectively placed at the back of a months-long line, with no estimated repair date. I contacted Lincoln Concierge, who opened a case but informed me there was “nothing they could do.” I now have a car that is unsafe to drive due to a transmission issue that the manufacturer and dealership both acknowledge but are unable to address in a timely or safe manner. This presents a serious safety risk. A transmission failure while driving could result in loss of control, sudden deceleration, or breakdown in active traffic. I am requesting that NHTSA investigate this issue as a systemic safety failure — both in terms of the defect itself and Lincoln’s inability to service it promptly.

NHTSA ODI 11666735

The contact owns a 2019 Lincoln Nautilus. The contact stated while driving approximately 25 MPH, the vehicle was shuddering and losing motive power. The contact stated that the message "Engine Overheating" was displayed on the instrument panel. The contact stated that the vehicle stalled. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the 12-Volt battery and the EGR system had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 23V378000 (Engine); however, the VIN was not included. The failure mileage was approximately 75,000.

NHTSA ODI 11661466

The component that has failed is the Transmisson. The vehicle is available for inspection upon request. We are at risk of being stranded on major highways with small children every day. This vehicle problem has been inspected by both the dealer and two independent service centers. There was one symptom noted that behaved like there may have been water in the gasoline tank. After several attempts to solve the problem, including a Tune-up, we began to see symbols that suggested a more severe problem. These symptoms began the Spring of 2024. There are still warning lamps, messages and frightening symptoms that have resulted from this system failure. I LOVE my vehicle. Imagine my disappointment to learn that many FORD vehicles are under a "silent recall" for such repair that the company is well aware of, yet you sold me this vehicle anyway. Please notify me that you will replace the Transmission or give me full trade in value toward a 2025 Lincoln Nautilus. Our family has been a FORD family for many years. We'd like to remain. What can you do? Thank you for your careful consideration.

NHTSA ODI 11656351

My vehicle is experiencing the exact symptoms of the recall [XXX] although my VIN is not listed under this recall. The vehicle shutters and jerks upon acceleration up to around 30 miles per hour. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11577987

12/30/20 STOPPED AT RED TRAFFIC LIGHT WITH FOOT BRAKE. ENGINE AND ELECTRICAL SHUT DOWN. VEHICLE WENT TO PARK AND WOULD NOT START AGAIN OR SHIFT OUT OF PARK. NOTHING WORKED! HAD TO BE TOWED TO LINCOLN DEALER. THE MILEAGE WAS 6,000! JULY 2020 I HAD COMPLAINED OF TRANSMISSION BANGING SHIFTING TO DRIVE OR REVERSE. DEALER SAID ALL WAS FINE. IT HAS BEEN 34 DAYS, DEALER REPLACE A MODULE WITCH DID NOT FIX PROBLEM. THEY ARE NOW REPLACING THE TRANSMISSION. THE INCIDENT OCCURRED AT A SHOPPING CENTER LIGHT TO ENTER HIGHWAY 525. APPROACHING THE SIGNAL VEHICLE WAS ONLY TRAVELING 2-3 MPH.

NHTSA ODI 11394542

MY CAR HAD BEEN IN TWICE FOR REPAIR AND COMPUTER SOFTWARE UPDATE. I WAS ROUNDING A CORNER AND THE ENGINE SHIFTED INTO NEUTRAL, STOPPING THE CAR. THE PRECOLLISION AID WAS DISABLED. LUCKILY NO ONE WAS BEHIND ME OR THEY WOULD HAVE PLOWED INTO MY CAR.

NHTSA ODI 11282211

TL* THE CONTACT OWNS A 2019 LINCOLN NAUTILUS. WHILE AT A RED LIGHT, THE VEHICLE STALLED AND SHUT OFF COMPLETELY WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE WITHOUT INCIDENT. THE CONTACT STATED THAT THE FAILURE RECURRED ON THREE SEPARATE OCCASIONS. THE CONTACT TOOK THE VEHICLE TO AL PACKER FORD WEST PALM BEACH (1530 N MILITARY TRL, WEST PALM BEACH, FL 33409, (561) 689-6550) WHERE THE CONTACT WAS INFORMED THAT THE DEALER WAS WAITING FOR A PART TO REPAIR THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE HAD BEEN IN THE DEALER'S POSSESSION FOR CLOSE TO A MONTH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT A MANAGER WOULD CALL BACK. THE CONTACT HAD NOT HEARD BACK FROM A MANAGER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000.

NHTSA ODI 11278266