What 136 owners told NHTSA about the 2019 Kia Soul EV

The contact owned a 2019 Kia Soul. The contact purchased the vehicle four months ago. The contact stated that while driving at 40 MPH, there was an abnormal knocking sound coming from the engine. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal and stalled. The contact was close to the residence and pushed the vehicle to the driveway. The contact called the Salesperson and informed the Salesperson of the failure. The Salesperson stopped by the residence and took the vehicle away. An independent mechanic hired by the Salesperson informed the contact that the failure was related to the engine. The contact had purchased a 2013 Ford Fusion from the same dealer and while driving 60 MPH, the vehicle stalled, and there was a large amount of oil leaking from the vehicle. The vehicle was towed to the dealer where the vehicle was purchased and diagnosed with transmission failure. The vehicle was then replaced by the 2019 Kia Soul. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000.

NHTSA ODI 11692206

My 2019 Kia Soul is experiencing severe and abnormal engine oil consumption. This issue requires frequent refilling of engine oil to prevent damage. The malfunction is in the powertrain system, likely within the GDI engine, specifically related to the piston rings. This type of structural defect can lead to a sudden and catastrophic engine failure while driving, which poses a serious safety hazard to occupants and other motorists. The problem has been confirmed by me, the vehicle owner, through the observation of consistent and rapid oil level depletion. Prior to a complete failure, there were no specific warning lamps or messages related to this issue. The manufacturer, Kia Motors, has declined to perform a proper technical review, citing an expired warranty and my status as a second owner. I have opened three separate cases with Kia regarding this matter, all of which were closed without a proper resolution. I am requesting an investigation into this defect by NHTSA.

NHTSA ODI 11691781

I was in a collision while stopped at a red light. Other vehicle impacted the entire drive’s side including back passenger rotating the vehicle over 90 degrees and pushing vehicle about 25 yards out into the intersection. The airbags didn’t deploy and experienced head, neck, and back injuries.

NHTSA ODI 11691975

Engine shut off while driving, Would not restart, vehicle VIN included in PI2107 campaign, Kia refused to cover repair. This is a serious safety hazard.

NHTSA ODI 11691579

There is water filtration in the upper stop lamp. This happens while driving under heavy raining conditions.

NHTSA ODI 11689719

The engine is having oil consumption since May 2025. It is a 2019 Kia Soul, 1.6L GDI engine. I have taken it to get oil changes, however there is no leak. It is also making a rattling noise and having a hard time to accelerate. I was informed by a mechanic that it is the pistons knocking around, due to the overheating and oil consumption. Even the dealership told me that it is dangerous to drive. I bought the car brand new and am the only owner, it's crazy that it's falling apart after 6 years.

NHTSA ODI 11689360

On Sunday, September 21st, 2025, my engine stalled and would not start. AAA looked at it and tried to jump it, and could not get it to start. I was stranded an hour and a half away from home, so I had to have it towed to my home. On Monday, September 22nd 2025, I had a mechanic come look at my car. He ran diagnostics,a compression test, replaced my spark plugs, literally every test he could do, and said there was an issue with my engine. I know there was a class-action lawsuit against Kia, and tried to find out of my car qualifies for the extended warranty, but upon searching my VIN, was told it does not. Even though I have all the same symptoms. And I have been excessively burning oil for a few months, having to put about two (2) quarts of oil in my car a week.

NHTSA ODI 11689282

Excessive oil consumption leading to complete engine failure. My wife bought this car to be her daily commute to work. When we took the car for its first oil change after hitting the change sticker milage, the mechanic noted that the engine had no oil. We filled it up with full synthetic. History of the Vehicle showed proper and on-time maintenance schedule, that's why we bought it. At the time of purchase there were no codes or engine lights. Clean title and no accidents. The engine had oil at the time of purchase. There were no indicators of problems. We also took the car to the Kia dealership for recalls and campaigns, they told us nothing about this issue. One day, first came the engine light, my wife was driving to work, the car started shaking heavily, then the vehicle failed to supply enough power to go above 50 mph. She was in the middle of the interstate, she felt that she was going to crash, or someone will crash into her. She was terrified, rightly so. When she finally reached a safe place to stop, she called me. When I came to check it out, I let the engine cool down first then checked the oil, it was very low. I put some oil and took it again to the same Kia dealership for diagnostics - the engine turned off multiple times on me at traffic lights (when near stop), the dealership took about a week to diagnose it and they finally told us that the cylinders misfired and the pressure in the cylinders were lower than capacity; they said the engine must be replaced and quoted us a used Engine of 114k at $7k replacement fee. Kia must be held responsible for their engines. We did everything in our capacity to ensure the vehicle is maintained as best as we could, my wife took loans from her family to pay for this car, and we are left with a lime.

NHTSA ODI 11688646

In february 2025 I had taken to the garage the first moment the check engine light came on and had to have the catalytic convertor replaced, costing me over 4300.00 It could have caught on fire the garage said. I have all documention and reciepts for all work since I have had the vehicle I am the 2nd owner and still making payments on this. I have kept up to date on every oil change and have the proof of that also. The car has been burning oil excessively and now the garage has determined it needs a engine replacement or rebuild costing over 5000.00 and the car only has 93,000 miles on it. I know KIA is known for issues with their engines burning excessive oil , but i found no recalls of it for my VIN.

NHTSA ODI 11686360

For some reason my 2019 Kia Soul is not included in the previous engine recall. My vehicle is experiencing severe oil burn which has caused the failure of a second catalytic converter. The first was replaced on 11/25/2024 and it is being replaced again on 8/28/2005. This failure is due to improperly heat-treated piston oil rings that lose their ability to seal, leading to cylinder wall damage, increased oil consumption, and potentially engine failure or fire.

NHTSA ODI 11683721

Hello, my oil rings in my engine failed, which there is a recall of 2021 and newer but same issues, causing my oil to burn and get trapped in the catalytic converter, then burning it out the exhaust, also I kept loosing oil. Under further diagnosis from a mechanic, I had to get a full rebuild of my engine at a cost of $5,000, and also I had to get a new catalytic converter with a cost of 500.00. PLEASE look into this and let me know what I can do further. Thank you!

NHTSA ODI 11679647

Engine burns oil at a rapid rate. Has been inspected & confirmed by dealer. Was informed it may be a piston issue that has been located on similar Kia vehicles, but is not on the recall list. No warning lights appear. No warning light indicating low oil either, which means I must check the level daily & add oil as needed (about one quart per week).

NHTSA ODI 11679458

The contact owns a 2019 Kia Soul. The contact stated that while the vehicle was at an independent mechanic receiving an undercoating, the independent mechanic performed an inspection of the vehicle. The contact stated that during the inspection, the independent mechanic identified that there was severe corrosion on the fuel tank straps. The contact was informed that the fuel tank straps needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but provided no assistance. The vehicle was scheduled for inspection. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 46,200.

NHTSA ODI 11672843

I tired to let the KIa dealer in Evans Ga know my Kia was consuming oil about a quart a week. They did an oil consumption test and stated it was within normal range. That’s 4 quarts of oil a month. This was done before the warranty ran out. Now they are saying it’s 14000 to replace the engine. I looked up the 2019 Kia Souls and there are recalls on this model and year but not by the VIN. It is now using 5 plus quarts of oil a month with no visible oil leak.

NHTSA ODI 11672373

Burning oil have to put a quart in every 500 miles

NHTSA ODI 11668529

The contact owned a 2019 Kia Soul. The contact stated that while his daughter was driving at 50 MPH, the brakes failed to operate upon depression as heavy, black smoke began to emit from the under the hood of the vehicle. The contact's daughter managed to pull off to the shoulder of the highway as all occupants quickly exited the vehicle. The vehicle quickly became engulfed in flames as police arrived immediately on the scene. The fire department also arrived on the scene and extinguished the fire. No injuries were reported. A police report was filed but when the contact called for a copy, he was informed that the report was not yet produced. The vehicle was towed to an independent tow yard were the vehicle was deemed a total loss. The contact went to view the vehicle and linked the failure the engine's connecting rod which he saw hanging from what remained of the engine. The manufacturer was notified of the failure but offered no assistance. The vehicle was destroyed. The failure mileage was approximately 65,000.

NHTSA ODI 11666014

Excessive oil consumption

NHTSA ODI 11661764

My 2019 Kia Soul had an engine misfire, breaking down and requiring new spark plugs. My car has been consuming oil excessively for the past 8 months, causing me to change the oil myself once a week. The engine light has been on, leading me to fix both catalytic converters. The engine light came back on right after this and pulled up two codes related to the camshaft position. I asked Kia for an oil consumption test and was told they do not perform that. The oil continues to burn excessively and requires constant changing. Other mechanics have informed me that this could lead to a serious fire hazard and engine issue, posing a high safety concern.

NHTSA ODI 11661126

My 2019 Kia Soul has had excessive oil consumption issues since we bought it in 2022 or 2023. This week, the check engine light came on, and the mechanic says it is the catalytic converter. This could be a potential fire hazard if we don't take care of it, and the cost to do this is almost as much as the car is worth.

NHTSA ODI 11661316

The contact owns a 2019 Kia Soul. The contact stated that while driving at various speeds, the vehicle stalled on several occasions. After restarting the vehicle, the vehicle operated normally; however, the failure persisted. The vehicle was taken to the local mechanic who diagnosed the vehicle and determined that cylinder #3 was faulty. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not contacted. The failure mileage was 67,000.

NHTSA ODI 11659550

The contact owns a 2019 Kia Soul. The contact stated while driving at various speeds, the check engine and oil warning lights became illuminated. The vehicle was taken to an independent mechanic however, the mechanic was unable to retrieve a fault code. The contact stated that an abnormal clanking sound was coming from the engine while driving at various speeds. The contact checked under the hood and discovered that the engine oil level was extremely low. The contact topped off the engine oil; however, the oil level was extremely low two days later. The vehicle was taken back to the independent mechanic where the vehicle was diagnosed with engine failure. The vehicle was not repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 106,000.

NHTSA ODI 11656542

My car is burning oil fast. 3 times a month I have to add oil. Sometimes it doesn't even register on my dipstick. When I take my car to kia of muncie for a oil change, they keep saying its my oil pan gasket that needs resealed. I park my car in my garage, I have no oil spots in my garage. When I take my car to midas for a pill change, they don't say anything about the oil pan gasket. I don't understand why my car keeps burning oil so fast.

NHTSA ODI 11651594

I am experiencing excessive oil consumption and potential engine failure in my 2019 Kia Soul. Despite regular maintenance, my vehicle has suffered from multiple major repairs, including a top-end engine rebuild and catalytic converter replacement in 2024. The excessive oil consumption issue persisted, ultimately requiring a full engine replacement in 2025. Kia has delayed repairs and provided minimal support, leaving me without a vehicle for extended periods. Service History & Progression of the Issue: March 11, 2024: Took my vehicle to Planet Kia dealership after noticing excessive oil consumption and performance issues. Kia initiated an oil consumption test but did not approve immediate repairs. May 2024: Kia performed a top-end engine rebuild instead of replacing the engine, even though significant oil loss continued. December 2024: The catalytic converter was replaced, likely due to prolonged oil burning and engine inefficiencies. January 22, 2025: Returned the vehicle to Kia as the excessive oil consumption issue worsened, and the engine was struggling to function properly. March 2025: Kia finally approved a full engine replacement, but my vehicle has now been in service for over 137 days, and the repair process has been delayed due to missing parts. March 26, 2025: Planet Kia has not provided clear updates on beginning or completion of engine replacement despite having all parts in-house. Safety Concerns: Risk of Engine Failure: If the engine runs low on oil, it can seize while driving, creating a dangerous situation. Potential Fire Hazard: Excessive oil consumption could lead to overheating and increased fire risks, as seen in similar Kia engine-related recalls. Manufacturer Delays & Accountability: Kia has known about oil consumption issues for years but continues to delay solutions for affect

NHTSA ODI 11650756

The contact owns a 2019 Kia Soul. The contact stated while driving 75 MPH, the RPM revved extremely high, and the vehicle lost motive power. The contact stated that the vehicle failed to accelerate above 65 MPH. Additionally, the check engine warning light flashed on the instrument panel. The vehicle was steered to the side of the road where the contact saw smoke coming from the engine compartment. The vehicle then stalled. The vehicle was towed to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed that either cylinder #1 or the entire engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 115,932.

NHTSA ODI 11650873

The contact owns a 2019 Kia Soul. The contact stated that while driving approximately 75 MPH and attempting to overtake a Commercial Semi-Truck, the vehicle suddenly lost automotive power and started to decelerate. The vehicle coasted to the side of the road and stalled. The vehicle was later towed to a nearby dealer who diagnosed that the fuel injectors had failed and were stuck in the fully opened position. The fuel injectors were replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 37,754.

NHTSA ODI 11648755