Apr 16, 2025SteeringElectrical systemEngine1 injury
The truck would just shut off while driving or not start whenever you need it to. It acts like a dead battery but the battery is fine. It has been at the dealership for 45 days plus straight for this issue. When it cuts out, we lose all steering all breaking all power. I’m very lucky it hasn’t taken my life or one of my family members lives. There are some innocent person on the road because of The lack of quality and workmanship. In my opinion the truck needs to be recalled because it’s been nothing but a hassle for us.
NHTSA ODI 11655086
Jan 21, 2024Electrical systemFire
While using remote start, the rear sliding glass window shattered and set the defroster on fire. The fire was above the rear seat where my child's car seat was.
NHTSA ODI 11566751
Jun 14, 2023Electrical systemFire
After being park for over 6 hours, Truck spontaneously started to smoke, sparked, and caught fire at 1253am. This ignition was inside the engine compartment on the passenger side. All was recorded on 24hr video monitoring and my truck was in stock condition without any aftermarket parts and no warning lights on. Incidentally my truck had just been routinely serviced with the past month by the dealership and all was fine. Within minutes the truck was engulfed in flames, my neighbors and I attempted to extinguish the flames until the fire company arrived within 6 minutes. Within this short less than 15 minute window the entire engine and cab was destroyed. If this truck was parked in a garage this incident would have been catastrophic. Luckily no one was injured and the prompt response of my neighbors and the fire company prevented this from catching my home on fire. The police and fire company reviewed the video and informed me to notify any safety board and The Ford company directly. In review this problem is not new and well document in the past. There are recalls in place for the same make and model vehicles with the same fire starting in the front passenger side. Unfortunately my VIN was not included in this recall.
NHTSA ODI 11526923
May 3, 2022Electrical systemDriver assistanceFire
My electrical system failed and then caught fire. The entire situation started 4 days ago where my "dome" or "cargo" light kept turning on even though the car was off. 3 days ago my alarm would go off every 15 minutes until I unplugged the battery. I disconnected the battery over night hoping to reset the computer. After reconnecting the battery I got a rear "LEFT REAR door ajar" message on the dash. After inspecting the sensor and wiring harness in LEFT REAR door, I found no issue. However, now "FRONT LEFT door ajar" message appeared on dash along with "LEFT REAR door ajar." Also a litany of other warning lights involving cameras, emergancy braking, etc. came on. While attempting to drive to dealership to have them inspect the issue. The wiring harness behind the back seat on the RIGHT SIDE of the vehicle began smoking. Smoke began billowing from behind the seatbelt opening in the plastic trim on the backside of the door frame.
NHTSA ODI 11463171