What 451 owners told NHTSA about the 2019 Ford Ecosport

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11648986

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11649051

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted and refused to service the vehicle if the vehicle had not experienced a failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11648796

The contact owns a 2019 Ford EcoSport. The contact stated while driving 50 MPH, the vehicle inadvertently lost motive power and was unable to accelerate above 10 MPH. The contact stated that the temperature gauge indicated that the engine was overheating and there was smoke coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired, but the failure reoccurred. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); the VIN was included, but parts were not yet available. The manufacturer was notified of the failure, and a case was opened for a possible buy back. The failure mileage was 77,000.

NHTSA ODI 11648096

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11648128

Car is real sluggish, hard to shift, stalls out, hard to crank up after fueling

NHTSA ODI 11646139

The contact owns a 2019 Ford Ecosport. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the transmission failed to shift above second gear. In addition, the contact became aware of an abnormal ticking sound. The contact stated the sound was like the sound of a sewing machine. The vehicle was taken to the dealer; however, the vehicle was not inspected. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 26,000. VIN tool confirms parts not available.

NHTSA ODI 11645925

The contact owns a 2019 Ford EcoSport. The contact stated that while driving through a snowstorm on the highway at 35 MPH, there was an abnormal popping sound coming from the engine, and the vehicle experienced a loss of automotive power and decelerated to 20 MPH. The check engine and engine temperature warning lights were illuminated. The contact pulled off on the next exit and parked the vehicle at a nearby gas station. The vehicle was then towed to a local dealer where it was diagnosed, and the contact was informed that the thermostat was faulty and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING) as a possible cause of the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 50,000.

NHTSA ODI 11646088

The contact owns a 2019 Ford EcoSport. The contact stated while driving at an undisclosed speed, the transmission was hesitating before shifting gear. The check engine warning light was illuminated. The contact stated that the transmission was slipping. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was towed to a dealer, but the vehicle was not diagnosed. The contact stated that the vehicle was awaiting repair. The manufacturer was not notified of the failure. The failure mileage was approximately 123,000.

NHTSA ODI 11645331

The contact owns a 2019 Ford EcoSport. The contact stated that while at a stop light and depressing the accelerator pedal, the vehicle failed to respond as needed. There was an abnormal ticking sound coming from the engine. The contact stated that several unknown warning lights were illuminated. The dealer was contacted, and the vehicle was taken to be diagnosed; however, the technician was unable to determine the cause of the failure. The contact stated that the engine was replaced; however, the contact was informed that the repair was temporary. The contact stated that after the engine was replaced, the vehicle was retrieved; however, three weeks later the failure reoccurred. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 49,000.

NHTSA ODI 11645341

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact stated while driving 40 MPH, the vehicle failed to respond. The check engine and the wrench warning lights were illuminated. On another occasion, while driving the vehicle at an undisclosed speed, the vehicle shut off without warning. An independent mechanic diagnosed the vehicle with engine failure. The vehicle started to lose motive power and progressively continued to stall and shut off. The vehicle was taken to the dealer and received undisclosed repairs; however, while driving to the residence the vehicle shut off three times. The dealer informed the contact to stop driving the vehicle and a tow truck was sent to pick up the vehicle. The vehicle had been with the dealer awaiting the repair until May 1, 2024. The failure mileage was approximately 69,576. VIN tool confirms parts not available.

NHTSA ODI 11645342

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11644843

My car went to the dealership service department to be fixed because the recall piece broke in December. Middle of February they told me it was all fixed I picked it up and within 8 hours it wasn’t driving right and had a bunch of alerts. I tried to drive it home it broke down in 2 degrees weather, I was stranded for 35 minutes with no heat. The dealership got the car back had it for a few more weeks. Today they called saying they think it will be fixed. They called this afternoon saying they took it for the test drive and it wouldn’t work.

NHTSA ODI 11643999

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving 40-50 MPH, the suddenly decelerated to 9 MPH unintendedly and stalled in the middle of the road. The contact activated the hazard lights. The vehicle failed to restart and was pushed to the side of the road with assistance. The contact stated that the failure recurred several times while driving. The check engine warning light was illuminated. The message "engine coolant overheating" was displayed. The vehicle was towed to the dealer, where unknown engine parts were replaced several times; however, the failure persisted. The dealer informed the contact that they were waiting for an unknown part for the engine replacement. The vehicle was not repaired. The contact stated that vehicle rental assistance was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 59,000. VIN tool confirms parts not available.

NHTSA ODI 11643330

On Dec 20, 2024 at 1:51PM my vehicles check engine light turned on as I was driving an Uber rider to their destination. I was unable to accelerate my gas pedal to get on the freeway. I immediately pulled over to the side of the road and saw my check engine light pop up on my dashboard. I checked my Ford App, stating check engine light is on due to low fuel system pressure, poor fuel quality/restricted fuel filter causing limited engine power until resolved. I immediately had my car towed in this case of emergency to the Frontier Ford Dealership to get this resolved. I was told after diagnostic I will be notified if under recall. I was emailed to pay out of pocket for the diagnostic repairs on 1/29/25. Then emailed by CARFAX about the new recall #23V905 that is overdue for my car on 2/14/25. I am currently paying for a car without a free rental and have been out of work for 3 months. I can't afford to pay out of pocket to Frontier Ford Dealership. I need to get back to work and I need my transportation.

NHTSA ODI 11643568

The contact owns a 2019 Ford EcoSport. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer, where the pulley tensioner was replaced; however, the failure recurred approximately three months later. The contact was informed by the dealer that the engine was previously replaced as an interim repair under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the final recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000. VIN tool confirms parts not available.

NHTSA ODI 11642544

Component that failed was engine oil belt and tensioner. Car almost died right on highway. Dealer has confirmed. Dealer has inspected it.

NHTSA ODI 11641524

The contact owns a 2019 Ford EcoSport. The contact stated while driving approximately 30-35 MPH, the vehicle stalled. The low-pressure oil light illuminated. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer opened a case and declined the buyback. The failure mileage was approximately 67,000. VIN tool confirms parts not available.

NHTSA ODI 11641259

The contact owns a 2019 Ford EcoSport. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power in the middle of the roadway, and the vehicle failed to restart. The contact was assisted by a bystander in pushing the vehicle to the shoulder of the roadway to a safe location. The low oil and check engine warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired, but the failure reoccurred. The contact stated that a month later upon entering the vehicle, the vehicle failed to start as intended. The vehicle was towed back to the independent mechanic, who diagnosed a failure with the starter. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); the VIN was included, but parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue, confirmed that parts were not yet available, and a case was opened regarding a possible buyback however, the request was denied. The failure mileage was 70,000.

NHTSA ODI 11641314

The contact owns a 2019 Ford EcoSport. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was restarted; however, the failure reoccurred. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer where it was diagnosed that the oil pump drive belt or drive belt tensioner had failed and needed to be replaced. The vehicle was not repaired. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 43,000. VIN tool confirms parts not available.

NHTSA ODI 11640893

The contact owns a 2019 Ford Ecosport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while stopped at a traffic light, the light turned green, and the accelerator pedal was depressed, and the vehicle stalled. The contact was able to restart the vehicle; however, the check engine warning light was illuminated, and the “WRENCH” symbol was displayed. The contact had taken the vehicle to an independent mechanic who cleared the warning light and advised the contact that if the check engine warning illuminated again, the vehicle should be taken to a dealer. The contact stated that the check engine light illuminated again while driving at approximately 30 MPH. The contact had taken the vehicle to a local dealer who diagnosed the failure and determined that it was related to the NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the vehicle would only be repaired if the engine failed. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

NHTSA ODI 11639572

The contact owns a 2019 Ford EcoSport. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The dealer was contacted and confirmed that parts were not yet available. The contact was informed by the dealer that parts would be ordered once the contact had experienced an engine failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 53,640. VIN tool confirms parts not available.

NHTSA ODI 11638414

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11637692

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while starting the vehicle, the low oil pressure message was displayed. The contact stated that while driving 20 MPH, there was an abnormal sound coming from the engine. The vehicle was taken to the dealer and was diagnosed with engine failure due to low oil pressure. The contact was informed that the recall repairs would begin in 2025. The vehicle remained with the dealer unrepaired. The manufacturer was not made aware of the issue. The failure mileage was 92,810. VIN tool confirms parts not available.

NHTSA ODI 11637725

The contact owns a 2019 Ford EcoSport. The contact stated that while driving at approximately 30 MPH, the vehicle experienced a loss of automotive power. The check engine oil warning light illuminated. In addition, the contact noticed smoke coming from under the hood and pulled into the residence. The vehicle was diagnosed by a local independent mechanic on scene, that the vehicle had a lack of lubricant causing the oil the build up and damage to the engine. The vehicle was diagnosed and determined that the engine needed to be replaced. The local dealer was not contacted. The vehicle was not repaired. Upon further investigation, the contact discovered NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) and later confirmed that the VIN was included in the recall; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000. VIN tool confirms parts not available.

NHTSA ODI 11637772