What 90 owners told NHTSA about the 2018 Nissan Titan

The contact owns a 2018 Nissan Titan. The contact stated that upon starting the vehicle, the traction control, ABS, check engine, parking sensor error, 4-WD Error, and parking brake warning lights were illuminated. The contact was able to continue driving the vehicle; however, the back-over prevention camera was intermittently inoperable while shifted into reverse. The contact stated that occasionally the front driver’s and passenger’s side cameras failed to operate as needed. The contact stated that the failures were intermittent. Additionally, the contact stated that occasionally the vehicle failed to turn off as needed. The contact stated that the engine remained running while other features were turned off. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.

NHTSA ODI 11621804

Oil doesn’t get to the 7th cylinder causing unrepairable damage. It’s a known issue by Nissan

NHTSA ODI 11620600

Vehicle was well maintained and only drive it around 10,000 miles per year or less. Had no issues or warning signs, my truck just bogged down while going 65mph on the highway. By the time I pulled over and cut it off I checked all fluids and tried to turn it over again, all you hear is a heavy knocking sound like the engine was struggling. Took it to a mechanic shop and found out it had a broken crankshaft, it has under 50,000 miles!

NHTSA ODI 11619830

Traveling 65mph down the highway, engine started shaking extremely bad and smoke pouring from the exhaust.

NHTSA ODI 11619885

In November of 2022 we heard a knocking noise from the engine and then the low oil warning came on. Vehicle would then not start. When we towed it to the dealership they found noise from the bottom end and low oil pressure code P0524 and verified engine will not start and does make a bad knocking noise during short crank period. Determined the engine came apart internally and had large rod and main bearing material in oil pan loose metal ran through engine and engine will need to be replaced. We had all necessary warranty work done at the certified dealership and all oil changes were done as recommended, all documentation sent to dealership. Nissan would not cover the damage, we were 12,370 miles over warranty and still owed $24,000 on the vehicle. On April 4/17/2023 we paid $17,977 for a new engine on the truck. Upon our research this is a "known" issue with this engine and the crank shaft failing.

NHTSA ODI 11609980

The vehicle has loss of power and goes into limp mode unexpectedly. It has done this numerous times on the interstate and regular roads. It is a safety hazard. This has occurred on several dates and we were lucky to be able to pull over safely. We we traveling in Georgia last month and Nissan didn't even have a qualified diesel tech with 3 hours of where we were. We have had ten of thousands of dollars of work to the truck and it still is not fixed. They replaced the computer screen, wiring harness, and I believe parts of the exhaust system. They had the truck for months.

NHTSA ODI 11605686

TRUCK WOULD NOT START IT IS A 2018 NISSIAN TITAN XD WITH 41000 MILES ON IT AND HAD TO HAVE TOWED TO A NISSIAN DEALER AND THEY DIAGNOSED IT AS THE LIFTER FUEL PUMP BAD CALLED NISSIAN CORP HELP NUMBER AND THEY WOULD NOT COVER IT SINCE FACTORY WARRANTY RAN OUT 3 MONTHS AGO SO HAD TO PAY $2300 OUT OF POCKET TO REPLACE AND AS I HAVE READ THIS IS A KNOW ISSUE WITH THESE LIFTER PUMPS IN THESE NISSIAN TITAN TRUCKS

NHTSA ODI 11605342

Engine started vibrating and shut off on expectantly at highway speeds. Leaving vehicle disabled in traffic. The crank was found to have cracked.

NHTSA ODI 11604864

I was driving down the interstate and my crankshaft broke. It happened suddenly and I lost all power and luckily no one ran into the back of me as I slowed down and made my way to the shoulder. There I sat for 2 hrs waiting for the tow truck. There were no signs or warning lights prior to the engine loosing all power. Nissan inspected and has confirmed it is a broken camshaft and will not warranty it.

NHTSA ODI 11604544

While traveling at highway speed, engine suddenly started making noise, shaking, and lost power without warning or check engine light. Vehicle was towed to dealer, suspected crankshaft failure, quoted $31,000 by dealer to replace engine.

NHTSA ODI 11598894

Earlier this year my 2018 Nissan Titan experienced catastrophic engine failure at only 56,376 miles. I then learned it was due to a manufacturing defect that is very common on 2017-2019 Nissan Titans and other Nissan models with the same engine. This issue is well known to Nissan as evidenced by Nissan Service Bulletin NTB19-057 which was first issued in July 2019. Most failures have occurred when the vehicles are so new that the manufacturer’s warranty provides engine replacement. Mine, unfortunately, occurred three months after the powertrain warranty expired. I filed a complaint with Nissan Consumer Affairs and Nissan took no responsibility and provided no financial assistance. I was forced to pay for engine replacement at a cost of $8,755.03. The website [XXX] has numerous forums relating to this issue with the main thread having 3000+ posts from owners who have experienced catastrophic engine failure. As these vehicles all have expiring powertrain warranties, Nissan is leaving owners like me to pay extremely high repair bills due to this known factory defect. As premature catastrophic engine failure is an obvious safety issue, Nissan should have the responsibility to issue a recall and repair these vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11595874

High pressure fuel pump failed (CP4 pump) and put metal through the entire fuel system causes over 10k in repairs and the truck only has 54,000 miles

NHTSA ODI 11586177

Crankshaft failure resulting in complete engine failure. I still have both halves of the crankshaft laying on my bench. During the engine failure experience the truck lost all engine power and came to a stop alongside of interstate barrier wall. I couldn't even open my door without obstructing a lane of interstate traffic. No warning lights led up to the event or any symptoms leading to the catastrophic engine failure.

NHTSA ODI 11584153

Fuel sender unit doesn’t work. Doesn’t log when the tank is full stays on empty at all times. Research shows this is a known issue with other Nissan models but I don’t see a recall for this model.

NHTSA ODI 11573741

There is a known issue with the engine where the cylinder 7 is scored. If left untreated it is possible that the engine could misfire or stop working all together due to oil entering the engine. Tried contacting Nissan about it and was told that it is not their problem since it is out of warranty. Currently the engine produces a loud ticking and there is lack of power. A dealership has inspected and confirmed the issue and stated it does need repaired or it is not safe to drive.

NHTSA ODI 11573178

Crankshaft broke on the freeway seizing the motor vehicle 101,000 miles

NHTSA ODI 11565617

Traveling home from working nightshift. I fueled up my truck with diesel and started my commute home which is 85 miles to my residence from work. 60 miles into my commute without warning and no alerts my truck suddenly lost power to everything… engine, steering, acceleration, and electrical. Final able to pull off the road with difficulty steering. Came to a stop and everything shuts off. All the warning lights lit up but no exact detail to what caused it. Had it towed to service shop after failure to start and the sound it made trying to start wasn’t normal. Technicians ran my codes and found nothing that could diagnose the problem.

NHTSA ODI 11564773

The crankshaft broke on original engine then my warranty company CARS plus protection sent another engine with 80k miles and mechanic installed and made it 60miles and the crankshaft broke on that engine as well. Warrenty after that did nothing and has still done nothing this incident start on April 28th 2023. I have still been making payments and kept insurance up to date have no choice I don’t have $20k to buy a new engine. Truck is still at mechanics shop

NHTSA ODI 11558179

The truck left me stranded on the side of the road resulting in a total engine failure. Zero warning signs. Truck was towed at my expensive resulting in 29 days without the vehicle while nissan replaced the engine

NHTSA ODI 11557966

I was driving the truck down the interstate with the cruise set at 70-75 mph and without warning, the truck starts shaking violently and making very loud noises from the wngine and then the engine shuts off and power steering is lost while traveling at highway speeds in traffic. The failure was diagnosed as a crankshaft failure which snapped the crankshaft in the engine. The quote from Nissan to replace the engine out of warranty varies between 35k-42k which TOTALS this vehicle for an engine failure that they are at fault for. Nissan knowingly sold vehicles with faulty engines by putting the safety concerns and financial burden for the public to the wayside. This needs to be addressed soon before someone is seriously injured due to Nissan’s negligence and recklessness for customer safety.

NHTSA ODI 11557420

While travelling at 80km/h down a slight hill and towing my caravan the vehicle started shuttering vigorously and then the engine just shut down, had to pull up the vehicle using the caravan brakes, Had the vehicle towed back to the Australian Importers as I am located in Australia and they have told me it has a crankshaft failure.

NHTSA ODI 11557551

My vehicle was driving down the highway at 70 mph when without any warning the engine shut off resulting in the loss of power steering. I had to navigate through traffic to get to the shoulder of the road. I had the vehicle towed to Nissan dealership after a couple weeks I was made aware that the engine needed to be replaced. The truck suffered. A broken crankshaft and main fuel components were replaced as well.

NHTSA ODI 11555884

Engine failure with a broken crankshaft. - Front driveshaft replaced. - Rear driveshaft replaced. - Transfer case replaced. - Real output shaft seal replaced. - Steering gearbox replaced. - Idler arm replaced. - Body wiring harness replaced. - Lift Pump replaced.

NHTSA ODI 11555824

My rack and pinion it’s leaking the power steering and the Nissan or no auto parts store make it so not even Nissan can get the problem fix

NHTSA ODI 11554711

Was driving down the interstate going 70 mph truck started loosing power without any warning or check engine light's. Truck started vibrating violently to the point almost lost control of truck. Dealer says broke crankshaft in motor truck only has 77k miles on it. This should be looked into as it’s happening a lot with models with the Cummings diesel motor. Please look into this before someone is killed. Thank you for keeping us safe.

NHTSA ODI 11545509