What 72 owners told NHTSA about the 2018 Hyundai Kona

The contact owns a 2018 Hyundai Kona. The contact stated that while driving it began to smoke, a noise was hear, put in neutral to coast down a hill and had to pull the parking break to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with defective piston oil rings, and the engine was rebuilt. The manufacturer was notified of the failure. The approximate failure mileage was.98,000.

NHTSA ODI 11740814

The contact owns a 2018 Hyundai Koa. The contact stated that while the daughter was driving the vehicle began to sputter and jerk before stalling. During the failure the oil warning light flashed off and on. The vehicle was towed to the local dealer who diagnosed that the engine had failed due to carbon buildup. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 21V301000(ENGINE) The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 90,000.

NHTSA ODI 11736103

The vehicle suddenly stalled while driving on the highway at normal speed without warning. The engine lost power completely, creating a dangerous situation and a risk of collision with surrounding traffic. The vehicle had to be towed to a repair shop, where the issue was diagnosed as engine failure. There were no warning lights or prior symptoms before the incident. This appears to be a serious safety-related defect. I am aware that similar engine issues have been reported in Hyundai vehicles.

NHTSA ODI 11735187

The check engine light came on while driving. Vehicle was assessed by mechanic with strange diagnostic code; full oil and filter change done. Check engine light still on and engine stalled while driving on freeway. Took to dealer and was advised the car requires CVVTS (which is essentially a new engine), serpentine belt and spark plugs (approx 3600). There is a known engine defect with the 2018 Hyundai but they refuse to do as a recall and refuse discounted repair on a vehicle that 8 years old with 92,000 miles. This vehicle is owned by my young adult child and I believe it is undriveable since stalling at full speed is quite dangerous.

NHTSA ODI 11731257

The Kona barely wants to accelerate and stalls out while driving. Even though I recently got a oil change there’s oil consumption and the oil is black as if I never got a oil change. I took it to a hyundai dealer ship, i told them what was wrong they said it’s the timing belt. When that’s not the issue. I recently took it to a mechanic to get a third opinion and to see and fix what is wrong. He declined fixing it saying there’s more to it that is wrong and looks like there’s an engine defect and even complained that the oil was so black. I told him that doesn’t make sense because I’ve been getting my oil consistently. He couldn’t fix it. So now I’m stuck with a vehicle that barely drives and stalls out while I’m on the road and it keeps burning more oil. No one knows what is wrong with it.

NHTSA ODI 11730285

See attached document for complaint.

NHTSA ODI 11728511

The car was burning through oil every 14 -21days. Car has been jerking and taking a while to accelerate. Went to machine to see what’s going he suggested I go to the dealership because there’s no leaks visible. But added more oil so I wouldn’t go without oil there was nothing available for me to come in right away and before my appointment my car started to speed up out of nowhere then completely slowed down then jerked until I could find a safe space to pull over. Check engine came on and the code was reading a misfire. Got a tune up still reading as a misfire now just stuck at the dealership playing guessing games with what’s wrong with the vehicle.

NHTSA ODI 11718344

My vehicle started was burning oil having to add oil frequently. Then a knocking noise started coming from the engine (2.0 L MPI NU).It began to have trouble starting and was not accelerating properly and the check engine light came on . Within two days I brought my car to my mechanic and he stated that there was no sign of an oil leak and felt it was a deeper problem. I brought it to a Hyundai dealership and they stated that the engine needed to be replaced/rebuilt. I feel that the lack of acceleration could have been a safety issue on the highway as it could have prevented me from passing in a timely fashion or just lose all power in traffic. There is an active recall for this type of engine starting with model year 2019.

NHTSA ODI 11712531

Prior to 100,000 miles, I noted knocking in the engine, especially while going uphill. The knocking would appear and disappear, possibly with oil change intervals. No check engine light ever appeared. After 100,000 miles, the engine progressively began knocking, losing power, and eventually stalling on the road occasionally. I have had to put on my hazards and restart my car. One time, I was barely able to pull over to the side. Again, no check engine light ever appeared. I have several videos of the vehicle in motion with audible knocking, and almost stalling. The videos show the dashboard with NO check engine light appearing. There was no sign of oil loss. No smoke. No oil stains under the vehicle. I was due for an oil change when the knocking and stalling became severe. I visited the dealer and informed them of the engine issues. They performed an oil change. And then could not reproduce the problem I experienced. Told me to come back if it happened again. This sounded odd to me given the severity of the knocking and stalling. Or it signaled to me that an oil change including refilling the oil solved the issue. Long story short. An oil consumption test was performed. The engine is consuming oil. I am scheduled for combustion chamber cleaning per the Technical Service Bulletin, as mentioned by the service rep. I am not confident that this will fix the problem. Given that this is the same / similar engine as the recalled 2018-2021 Kona for the same / similar issue. Oil consumption.

NHTSA ODI 11708153

I am having issues with my oil consumption and my car is going through a quart of oil every 1-1.5 weeks. There have been similar recalls on the 2019 Kona’s which have the same 1.6L 4-cylinder engine. My car is currently a little over 126,000 miles

NHTSA ODI 11704368

The component that failed was the connecting engine rod bearing. The engine is currently in the vehicle located at a hyundai dealership. The connecting engine rod bearing failure came after 1 or 2 engine miss-fires. The vehicle suffered poor performance, I was unable to start the car and properly accelerate the vehicle. The vehicle has exhibited poor acceleration/ jerk acceleration since purchase. However, this incident occurred immediately during initial startup in a parked position. The vehicle rode roughly upon initial observance of this engine miss fire which led us to deem the engine and car unsafe to use. The vehicle was initially towed to an independent service center where they identified the engine missfire code. The vehicle was then towed to our frequently used independent servicer where they said the problem related to low compression in the engine possibly something internal in the engine. Next we towed the vehicle to our preferred hyundai dealership. Hyundai confirmed the engine missfires and connecting rod bearing failure. A claim is in process with Hyundai to assess the vehicle further. The check engine light came on when the engine miss-fired initially. An earlier check engine light came on for a missfire earlier in the 2025 and earlier in 2022 and in 2023 which led to a catalytic converter replacement. While not certain, we think that low compression and poor engine performance has plagued the vehicle since purchase. The vehicle drive jerky(poor/delayed acceleration when pressing the gas) and had early catalytic converter issues prior to 50k miles.

NHTSA ODI 11700360

I have gotten a oil change over a month ago and my car is still running low on oil. Sometimes my car would shut off while I’m driving on the road with cars behind me. I have gotten my car oil topped off three different times since getting my oil change. It also makes a fan like noise as well. There’s no leak at all. It’s very bizarre.

NHTSA ODI 11697786

The DCT(Dual Clutch Transmission) has always been an issue since I purchased the vehicle. Anytime I would be going at a slow pace in a drive-thru or traffic on the freeway the car would jolt and shake. I brought my car to a Hyundai dealership in 2021 at 36,000 miles and was told this was normal with the transmissions provided by Hyundai and there was no need to worry. Now, at 72,000 miles I was driving down CA-60 when my car transmission died. The car would not go when I was giving it gas and would make a whirring noise when trying to accelerate across the freeway until I could pull off to the shoulder. It was extremely dangerous and I could've been hit by someone especially a semi-truck as it was sudden and I was in the left hand lane. I've been bringing it to an independent mechanic for years and he always told me to wait until there's a recall as it's a faulty transmission however there has not been a recall for my car yet. The car is now in possession of a Hyundai dealership however I was told since my warranty has passed they are not claiming any responsibility but that their transmission is faulty. There was no warning lamps or messages in the car just the issue of jolting while at slow paces prior to the transmission dying.

NHTSA ODI 11693601

The contact’s daughter owns a 2018 Hyundai Kona. While the contact’s daughter was driving approximately 65 - 70 MPH, the vehicle started decelerating and sputtering before the vehicle coasted to the side of the road and stalled. The check engine warning light was illuminated. The vehicle was towed to a certified mechanic, who diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was informed and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.

NHTSA ODI 11686886

Piston ring failure. No oil in car and no leaks. P0301 code and knocking sound. Unable to drive.

NHTSA ODI 11682651

The engine burns too much oil. I have to put it a quart every 2 weeks.

NHTSA ODI 11682485

On May 5, 2025, my 2018 Hyundai Kona burst into flames in my garage and completely destroyed my Kona, Dodge Ram 1500 parked adjacent to it and my home along with its contents. Both vehicles and my home were deemed “a total loss” by the insurance company. The Kona engine compartment burst into flames after a short trip to the store. If the front door had not been locked, forcing my wife to go through the garage, we would have been unaware of the fire until it had reached the interior of the house setting off the alarms. As it was, I received smoke inhalation and a partially collapsed lung while attempting to put out the fire and while trying to put the burning Kona in neutral to push it out of the garage. The 2018 Kona is not safe as it can burst into flames under normal operation and without any warning potentially resulting in injury or death of the occupants or emergency response crews. Research indicates my 2018 KONA has no recalls; however, it has the same G4FJ engine and is manufactured at the same facility as several other Hyundai models that have been recalled for fires in the engine compartment. The Hyundai Veloster has a class-action settlement for engine failure & fires. Also, the Hyundai Tucson has an ABS module fire recall and shared electrical layout. Furthermore, Australia issued a Kona fire-related recall in 2019 due to brake tube routing near the exhaust system. Fire investigators have inspected the vehicle and determined the origin of the fire is the Kona. Hyundai inspected the Kona and failed to take any responsibility nor notify other 2018 Kona owners. There was no prior warning my 2018 Kona was having any problems. The only indication was a faint burning smell my wife noticed when she got out of the vehicle to collect the mail on the day of the fire. At the time, she contributed the burning smell to the neighbors burn pile. The insurance company has removed the Kona, and it should be available for inspection at their facility.

NHTSA ODI 11677071

my Kona sputters when I put it in gear EVERY TIME. I have purchased gas at several stations so getting bad gas in the tank cannot be an issue. I’ve also had to replace the coil packs twice within 6 months. December 2024 and July 2025

NHTSA ODI 11673219

Purchased in cash at Dan O'Brien KIA for 22,000. This dealership in Concord NH (Owner) was charged w/embezzlement soon thereafter & was found guilty & fined. My cash purchase was never given to Hyundai nor was the promised 10 year powertrain warranty which was told to me from the salesman on the day of purchase in 2019. My 2.0 engine is knocking (undriveable) w/74 ,000 miles. Because Hyundai received no information on my purchase, I was never notified of recalls or class action suit recently won. I spoke to Hyundai (Case #[XXX]) & was told to take it to Irwin Hyundai for a diagnostic at $189. I'm told it does not meet an engine replacement YET it's doing the same exact issue affecting this very engine. I'm told it would cost me $11000. to replace. I'm [XXX], [XXX] & have no money to pay this amount, plus the car is literally listed for the same value give & take a few thousand $$ in value. I was lied to by the salesman about the warranty & had to find out myself there was a warranty but it went no further than my sales agreement which notes there's a warranty w/no explanation as to what it is. I'm now in a crisis: no car, & i just put $600 of tires on & it was inspected a week ago, quietly running - the tech had to ask if it was running as it was that quiet. What steps do I have to resolve this nightmare for engines failing & being told sorry your loss for nothing I have done wrong? If more information is needed I can get it. Dan O'Brien did inspections oil changes & repair work if needed (brakes etc). My email is [XXX]. phone [XXX] secondary or [XXX] primary. Somehow my phone switched to the secondary # & I'm trying to get it back to primary but it's a new phone & I have to figure it out. Please help me. Should I find a lawyer? So upsetting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11672420

My engine started shuddering and stalling out on me. This was very dangerous as the car would stall out at street lights and intersections. The check engine light only came on after the car stalled out and has not stayed on during the times that it stalls out. When I went to get a mechanic to check it out they said that they had seen many Hyundai and Kia cars that had the same issues. The issue was oil consumption. It was consuming oil faster than it should have, even though I was regularly getting my oil changed. This lead to a problem with my pistons. Now the engine needs to be replaced. But Hyundai won’t cover it because there is no recall on it and the power train warranty only last for the first owner. Is there any way we can request for a new recall on this vehicle as it is clearly a problem that Hyundai is having.

NHTSA ODI 11659463

My car started making a noise back in Dec/2024. I scheduled an appointment with Quirk Hyundai in Braintree, Ma on Dec 11, 2024, and paid for a diagnostic the service center came back that it was the oil pan leaking so on this date I had that repaired that same day total cost was $254.76. Please note that my car was under warranty at this time. On [XXX], I brought my car back to Quirk Hyundai in Braintree because the noise had returned and was intermittent, and passenger side makes loud noise when riding over bumps and the car was shaking when driving pass 65 MPH. When I had the diagnostic done on 03/29/2025 the service center came back and said it was the mismatch tires that were put on my car by an outside provider (townfair tire) and that I needed 4 new tires, oil changes, mount and balance tires and four wheel alignment which cost me $959.08. Three days later while driving home from work the noise returned and my car ept shutting off one me. I went to AXP North in Randolph MA on 04/08/2025 (had to make an appt) for a second opinion diagnostic and they told me that my car will need a new engine as the one now is failing. I called Quirk Hyundai back on 04/08/2025 and told them this and they asked to bring the car back so they can recheck my car for misdiagnosis. So, on 4/09/2025 I called Quirk Hyundai for an update the failed engine was confirmed, and now because my car is 40 miles over the warranty it cannot be fixed by Hyundai. This car is a 2018 and should last me longer than 2025. My car is only 8 years old and I have cared for the car whenever it needed maintenance. I need someone to please call me to discuss further at [XXX] . I need a new engine and Quirk Hyundai will not cover the cost despite my several attempts to have this noise resolved when care was under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11654624

My 2018 Hyundai Kona has been dealership serviced since buying it and it had about 115,000 miles on it when these issues began. Vehicle started to burn oil twice as fast as every time i would bring it into the dealership for the routine oil change, they would ALWAYS tell me that I had no oil in it. Therefore, I started to carry a quart of oil in the trunk and fill it up every 3 weeks or so. This went on for a few months until I started to notice a power problem while driving it on the highway on a trip. Tried to pull over at the next stop and then the car began shaking uncontrollably and engine shut off and would not start again. Took it to the dealership and they said your engine is shot and you're going to have to either buy a new car or put a new engine in it. I have seen many complaints and reviews about people having these same issues with the 2018 models. I know that there were a lot of recalls for the 2019 with these same issues with the incorrect heat tampered pistons causing these exact issues that the many of us 2018 owners have had. Please do the right thing and look into this. There are too many people having these same issues and this was my only means of transportation at the time.

NHTSA ODI 11647216

Motor started burning oil at the rate of .5 quarts per week and a few months later vehicle failed to accelerate, had major vibrations and hesitation. Piston rings had failed. Verified by dealer. No other symptoms. Numerous problems with same motor reported by others and repair services. Has been recalled in Australia for same issues.

NHTSA ODI 11636522

Felt a large shudder/vibration go through the whole car while on the highway and lost some power. The check engine light came on immediately after so we took it to a mechanic. Diagnostics came back as Hall sensor and cam shaft timing errors. It was found that the timing chain had slipped a tooth. Additionally, one of the pistons was found to have significantly lower PSI than the rest (105 vs 140) which they said is indicative of a pending total engine failure. A recall was issued for the 2019 model for this exact issue and symptom but Hyundai has said it doesn’t apply to our situation. Hyundai quoted 12-17 thousand dollars for a new engine. The car has 87 thousand miles and is less than 6 years old.

NHTSA ODI 11632679

with no known contact with anything, shark fin antenna cover of hyundai kona blew off at highway speed. this was unknown at the time, but upon further consideration, concern that the detachment could have damaged another car or caused to swerve. dealer, warranty refuse to replace. multiple reports of similar occurrences exist in hyundai forums.

NHTSA ODI 11622442