What 184 owners told NHTSA about the 2018 Ford Mustang Mach-e Bev Bev

TL* THE CONTACT OWNS A 2018 FORD MUSTANG. WHILE DRIVING, THE VEHICLE MADE AN ABNORMAL CLICKING NOISE. THE DEALER (FIVE STAR FORD, 6618 NE LOOP 820, NORTH RICHLAND HILLS, TX 76180) AND THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 6,500.

NHTSA ODI 11161423

HOURS FROM HOME AND POWER STEERING FAILED. DEALER SAID THE STEERING ASSIST SYSTEM IS GONE 16523 MILES ON THE CAR. HAD TO LEAVE THE CAR THERE AND WAS GIVEN A RENTAL. NO ESTIMATED TIME OF REPAIR, PART IS ON NATIONAL BACK ORDER. NO WARNINGS STEERING JUST FAILED SUDDENLY.VEHICLE WAS IN MOTION WHEN IT QUIT. OUR DEALER WHERE WE LIVED SEARCHED AND FOUND 1 PART AVAILABLE IN THE COUNTRY. HAVE TO PICK UP MY CAR. NO LONGER FEEL SAFE OR CONFIDENT IN DRIVING THE CAR BECAUSE WHEN IS IT GOING TO HAPPEN AGAIN.

NHTSA ODI 11140105

ENGINE STALLS WHILE DRIVING (3) INCIDENTS: ENGINE STALLS, BATTERY INDICATOR/THEN DASH BOARD MESSAGE; 'PUT IN NEUTRAL TO START ENGINE.' SO FAR HAS ALWAYS RE-STARTED WHILE DRIVING AT HIGHWAY SPEEDS: 1.JUNE 25, ESTIMATED MILES: 800, I-77 ON-RAMP EXIT 19, 55 MPH, DECELERATING AROUND TURN, 10 MINUTES AFTER STARTUP (NO SERVICE APPOINTMENT SCHEDULED) 2.JULY 11, ESTIMATED MILES: 1200, SOUTH TRYON APPROACHING CANTON, STRAIGHT, STEADY 45 MPH, 5 MINUTES AFTER STARTUP (SERVICE SCHEDULED) 3.AUGUST 8, 1800 MILES: 1-77 ON-RAMP EXIT 19, 50 MPH, DECELERATING AROUND TURN, 10 MINUTES AFTER STARTUP (SERVICE SCHEDULED). SERVICE REPRESENTATIVE: TOWN & COUNTRY FORD, CHARLOTTE, NC 'SERVICE 1: JUNE 18: OUT MILEAGE: 1393 MILES, INSTALLED MISSING BACK SEAT BRACKET. CHECKED FOR STALL FIX: NO CODES/ NO FIX DETERMINED FOR STALLS. NO CODES/NO SERVICE. 'SERVICE 2: AUGUST 13: RE-CHECK STALL ISSUE: TBD. SUGGESTED ON LINE CHECKS/REMEDIES FOR MUSTANG STALLS ISSUES: NO CODES FOUND / NO SERVICE PERFORMED. ISSUE UNRESOLVED. SERVICE REPRESENTATIVE: HUNTERSVILLE FORD, HUNTERSVILLE NC 'SERVICE 3: AUGUST 27: TECH TEST DRIVES, NO ISSUES DETECTED. CHECK CODES/NO CODES/NO SERVICE. DEALERS COULD NOT FIND ERROR CODES OR REPLICATE STALLING THEREFORE NO SERVICE WAS ATTEMPTED.

NHTSA ODI 11124080

I PURCHASED A NEW 2018 FORD MUSTANG 2 DR 4 CYL ECOBOOST ON JULY 9TH 2018. ON AUGUST 15, AFTER HAVING DINNER WITH PARENTS AT THE HOUSE, I WENT TO VISIT SOME FRIENDS IN DAVIE AND IT WAS APROX 7:45 PM WHILE DRIVING ON A 4 LANE ROAD DIVIDED BY A MEDIAN. ROAD HAS FREQUENT SPEEDBUMPS AND THE MEDIAN HAS MATURE TREES. WHILE TRAVELING ON THIS ROAD - I FELT NAUSEOUS AND PLACED BOTH HANDS ON THE STEERING WHEEL AND SUDDENLY THE ROAD BECAME BLURRY AND I LOST CONCIOUSNESS AND STRUCK A TREE IN THE MEDIAN. THE CAR CAUGHT ON FIRE AND ACCORDING TO A POLICE OFFICER, HE TRIED TO REVIVE ME AND TO HELP ME GET OUT, HOWEVER MY LEGS WERE BROKEN AND INJURED. MY RIGHT LEG WAS BROKEN AND MY LEFT LEG WAS BADLY INJURED. I WAS WEARING A HIGH BOOT ON THE LEFT FOOT AND NO BOOT ON THE RIGHT FOOT IN ORDER TO BE ABLE TO DRIVE COMFORTABLY. SECONDS AFTER THE POLICE OFFICER REMOVED ME FROM THE CAR, THE CAR EXPLODED. I BELIEVE THAT I WAS SOLD A DEFECTIVE CAR THAT LEAKED POISENOUS GASES WHICH CAUSED ME TO PASS OUT AND CRASH I TO A TREE. HAD IT NOT BEEN FOR THE POLICE OFFICER, I WOULD HAVE DIED TRAPPED IN THE BURNING CAR.

NHTSA ODI 11121499

TL* THE CONTACT OWNS A 2018 FORD MUSTANG. WHILE THE VEHICLE WAS UNOCCUPIED AND PARKED IN THE DRIVEWAY, IT ROLLED AWAY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 4,700.

NHTSA ODI 11104536

SIGNIFICANT ENGINE RATTLE BETWEEN 2000-2500 RPM UNDER LIGHT LOAD. RATTLE IS LOUDEST IN THIRD GEAR AT 2200 RPM. SERVICE TECHNICIAN DUPLICATED THE ENGINE RATTLE AND FOUND DAMAGE TO CYLINDERS 5-8 AND SUBMITTED HIS REPORT ALONG WITH PHOTOS TO FORD. THE TECHNICIAN RECOMMENDED FULL ENGINE REPLACEMENT. FORD ONLY APPROVED A NEW SHORT BLOCK.

NHTSA ODI 11092220

2018 MUSTANG GT WITH MANUAL TRANSMISSION. ENGINE STALLS WHEN SHIFTING INTO NEUTRAL (MANUAL TRANS) AT HIGHER ENGINE SPEEDS. FOR EXAMPLE, COMING UP TO A RED LIGHT (WAS TRAVELING APPROX 50MPH) OR WHILE EXITING THE FREEWAY (WAS TRAVELING 65MPH AND THEN WAS TURNING AROUND AN OFF-RAMP). HAS OCCURED AT ANY DRIVING SPEED (IF REVVING ENGINE AT FULL STOP, OR WHILE TRAVELING). STALLING DOES NOT OCCUR IF THE TRANSMISSION REMAINS ENGAGED WHILE SLOWING DOWN. IF I SHIFT TO NEUTRAL WHEN THE ENGINE IS NEAR IT'S NORMAL IDLE SPEED (500 RPM AFTER WARM-UP), IT WILL NOT STALL. THE PROBLEM ONLY OCCURS WHEN SHIFTING TO NEUTRAL ABOVE ~2,000 RPM, AND ONLY AFTER THE ENGINE IS WARMED UP. THE PROBLEM WAS PRESENT FROM THE TIME THE VEHICLE WAS BRAND NEW. AT 1500 MILES I RETURNED TO THE DEALER AND WAS ABLE TO SUCCESSFULLY REPRODUCE THE ISSUE TOGETHER WITH THE SERVICE ADVISOR. IN SOME INSTANCES, THE ENGINE SPEED WILL DROP BELOW IDLE SPEED AND THEN WILL RECOVER AND NOT STALL. I MADE A RECORDING OF THE CAN BUS TO TRY TO DIAGNOSE THE ISSUE ON MY OWN, WHICH IS AVAILABLE UPON REQUEST. IT SEEMS THAT THE ENGINE CONTROLLER IS REQUESTING MORE TORQUE FROM THE ENGINE WHEN THE SPEED DROPS, BUT THE THROTTLE WILL NOT RESPOND TO THE REQUEST AND THE ENGINE WILL STALL. NO DTCS OR WARNING LIGHTS WERE GIVEN TO INDICATE THAT THERE WAS AN ISSUE. NO MODIFICATIONS WERE MADE TO THE CAR, AND IS IN COMPLETELY 'STOCK' CONDITION.

NHTSA ODI 11091047

THE COLLISION AVOIDANCE SYSTEM HAS BRAKED HARD ON ME THREE (3) TIMES WHEN THERE WASN'T A CAR IN FRONT OF ME. THE FIRST TIME A CAR HAD ALREADY TURNED RIGHT ONTO AN INTERSECTING STREET, THE SECOND TIME A CAR HAD TURNED LEFT INTO A DRIVEWAY AND THE DRIVER WAS ALREADY GETTING OUT TO GET HIS MAIL, AND THE THIRD TIME A CAR HAD STOPPED IN THE LEFT TURN LANE AND I WAS APPROACHING IN THE LANE NEXT TO IT. I'M CONCERNED THAT THIS MAY CAUSE THE CAR BEHIND ME TO REAR END ME SINCE THE CARS WEREN'T NEAR ME AND THERE WAS NO REASON TO BRAKE. ON 3/15/18 I TOOK THE CAR TO THE SERVICE DEPARTMENT OF CROSSROADS FORD IN WAKE FOREST, NC (REF. INVOICE NO. FOCS964640) WHO EXAMINED THE CAR AND DETERMINED "CRUISE CONTROL WORKING AS DESIGNED AT THIS TIME."

NHTSA ODI 11088966

2018 MUSTANG GT BRAND NEW LESS THAN 300 MILES. DURING THE COURSE OF DRIVING ONE MORNING THE CAR ENGINE SHUT OFF 7 TIMES WHILE THE CAR WAS BEING DRIVEN. BROUGHT THE CAR BACK TO THE DEALER WHO WAS ABLE TO RECREATE THE CONDITION AND SUBSEQUENTLY DETERMINED THAT THE PROBLEM WAS A DEFECTIVE THROTTLE AND IT NEEDS TO BE REPLACED. WAS TOLD BY THE DEALER THAT FORD HAS A BACKLOG AND WOULD TAKE THREE WEEKS TO GET THE PART AND THE CAR FIXED.

NHTSA ODI 11064856