What 1,835 owners told NHTSA about the 2018 Ford F-150 Supercab Diesel

Door Latch Freezing during cold winter months(every year) where temperatures drop below 32°F even after Ford Recall done on both front door latches. Inability to open door, then after door opened there is an Inability for door to latch until it warmed up.

NHTSA ODI 11674698

Pant is flaking off roof and tail gate in 1/8 to 1/4 inch pieces. Offord white paint. Clearly a manufacturing defect . 2018 F150 has approx. 27,000 miles on it, Filed a claim with ford dealer Gosch in Murrieta Ca 92563.

NHTSA ODI 11661636

The doors do not close when cold i have to use the seatbelt to rap around doors to keep them shut. I have brought to ford multiple times no fix. The transmission erratically shifts through multiple gears and downshifts into low gears when at high rate of speed. Which i have been told is due to a faulty cdf drum in transmission that ford wont take responsibility for. It is a very dangerous vehicle

NHTSA ODI 11650858

Door latching system is often inoperable when temperatures are below freezing. The door will not latch and must be held close while driving. Vehicle has been repaired once by dealer per bulletin 18N03 but the problem persists.

NHTSA ODI 11643105

The doors do not properly latch in cold weather. Yes available for inspection. The door came open while we driving down the road. The dash light came on indicating door was ajar. Door was not able to be closed after repeated attempts of closing. Passenger has to hold the door closed. Same occurrence happened to the driver side door and it would not latch so the vehicle couldn’t be used that day otherwise driver would have to hold door closed.

NHTSA ODI 11640043

Doors will not latch in temps below 30degrees F.

NHTSA ODI 11634820

Rear doors get frozen and will not latch to stay shut. My daughter almost flew out of the vehicle when we went around a corner. I literally had to turn the heat on high hood the door closed for 30 minutes to get it warm enough to latch and stay shut. This is usually following a car wash within a 7 day span. I am not sure how there cannot be a recall for this. Everyone that I know with an F150 has had the same issues.

NHTSA ODI 11634076

At cold temperatures driver side door will not latch.

NHTSA ODI 11633577

Driver door cable sticking open when low temps occur. Driver door does not latch until vehicle is locked or key is inserted into door and manually positioned or key fob is used to lock the vehicle.

NHTSA ODI 11633720

THE PASSENGER BACK DOOR LATCH, SOMETIMES WHEN THE DOOR CLOSES IT SAYS REAR RIGHT DOOR AJAR. IT TAKES A FEW TIMES TO OPEN AND CLOSE IT FOR THE LIGHT TO GO OFF.. NOONE'S SAFETY HAS BEEN PUT AT RISK YET DOOR STILL LOCKS BUT COULD BECOME UNSAFE OVER TIME. THE VEHICLES HAS NOT BEEN INSPECTED BY MANUFACTURER OR INSURANCE OR OTHERS YET. THE DOOR LIGHT COMES ON IF DOOR IS NOT CLOSED PROPERLY AND WILL STAY ON SOMETIMES.

NHTSA ODI 11628056

The door latches was not latching in cold weather until they are warmed up and then they latch. It is a safety thing for me and my kids and wife.

NHTSA ODI 11627969

Took my vehicle to ford dealership to have leaking sunroof checked, had it repaired for broken track, but the amazing things was the price that ford charge me for the repair of the sunroof track which was $5507.49, wasn’t really told why it cost me so much being that it’s a 2018. I do have the receipt, and has been trying to find a lawyer to try and recover some of my losses. Please let me know what I should do about this repair

NHTSA ODI 11625401

Tailgate keeps falling down while traveling down the road. This has happened several times. This time after it hit the trailer after backing it up at the end of the trip.

NHTSA ODI 11594341

The tailgate on my truck has opened while driving down the road. This has happened several times since I have owned the truck. There are several recalls for 2018 F 150 tailgate issues. I have taken it to the Ford dealer, but was told there is no recall on trucks in my VIN range.

NHTSA ODI 11583379

Door lock freezing recall, still freezes. After performing this recall for my door latches freezing, they still freeze. Once I get them open, the door will not latch shut and I would have to drive while holding the door shut until it unfreezes. Forums verify that I am not the only one with doors still freezing after recall. I am confident the recall was performed correctly, but fords fix is not a proper fix and I am still left with frozen door latches in an unsafe vehicle.

NHTSA ODI 11571809

The hood latch has failed on my ford F-150. My security system alarms when it happens. It has happened while I have driven and during times when there are changes in temperature. When searching for this, I came across a number of others that have had similar issues with their ford F150/ F250s and Expeditions. I am surprised ford has not recalled it due safety hazard of a failing hood latch. Additionally the main horn has failed. Again searching has found that other people with similar models and years from ford have the same issue with the horn. Both are safety concerns.

NHTSA ODI 11570439

when the temp outside is below freezing the driver-side door will not latch shut and the doors will not lock.

NHTSA ODI 11566186

The contact owns a 2018 Ford F-150. The contact stated that upon entering the vehicle, the contact became aware that the driver's and passenger's doors had failed to latch securely. The door ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the door check arm attachment point. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 42,000. The VIN was unavailable.

NHTSA ODI 11566276

Passenger door actuator would not reingange the door after opening. Temperature was around 15 Farenheit for awhile. Door opened with some effort, but would not latch back. If vehicle was in motion door would need to be held to prevent opening. The vehicle could be locked for the door to stay in place, but it would not sit flush with the body of the vehicle.

NHTSA ODI 11566382

Tailgate actuator sometimes does not open completely. Pressin the button engages the operation, I can hear it trying to unlatch, but the tailgate does not completely release. If the tailgate is not in use for awhile, opens as intended for few times.

NHTSA ODI 11566383

Doors keep freezing and they won't stay shut when you drive if it gets below 25 degrees

NHTSA ODI 11566031

This is the 6th winter I have had my truck. Every winter, the door locks freeze to the point the doors won't close. I have called ford, they have replaced the door locks. The problem still persists. I went to warm them up with a torch today to get them working again. I left and once again the door flew open under braking. I have called ford on this, they need to fix it before something really bad happens. This has happened at least once every winter. I am afraid to drive the thing when it freezes for fear of the doors flying open. the only warning lamp happens once the door is open. It won't go into gear. That's great and all but it doesn't let me know when the door may be compromised due to freezing. The dealer and ford have both confirmed this a known problem. I believe there was even a recall. They replaced all my door locks. The problem still persists. I believe this is a huge safety risk. Alls it take is for one person not wearing their seatbelt to make a right hand turn. If the door swings open, they very well could fall out and possibly get run over and even worse send a 5,000 pound unmanned vehicle into who knows what.

NHTSA ODI 11565317

Frozen door latches. When its cold and you open the door, then close the door it does not latch.

NHTSA ODI 11563326

The vehicle as of 12/9/2023 at 3:19pm CST is at a mileage of 79,523. Around the time we bought out the lease on our truck in April 2021, we reported to the dealership that the tailgate latch on occasion would not latch. They did a repair for it, but it has happened a few times since. We saw a recall notice for other Ford F-150 models from 2018 that had issues with latches/linkages/locks on the tailgate where the tailgate would become unlatched like ours.

NHTSA ODI 11559305

The vehicle as of 12/9/2023 at 3:27pm CST is at a mileage of 79,528. We reported to the dealership in April 2021 and services prior to April 2021 that the sunroof would randomly become misaligned with the sunroof track when opening. There will be excessive noise coming from the sunroof when it’s misaligned. We are concerned that there might be a larger problem with potential exposed areas/leaks when that is misaligned. We feel strongly that it is either the alignment (misalignment) of the panels, an issue with the track, or an issue with the brackets. It was brought into the dealership, and they said they fixed it, but it continues to happen.

NHTSA ODI 11559307