What 1,734 owners told NHTSA about the 2018 Ford Escape Gas

Multiple instances of low power to ignition coils (all of have been replaced with new coils and plugs). Transmission immediately stopped transmitting power to the wheels and would not re-engage. Transmission would sometimes go into gear, but slam into gear, lurch, or only shift into 1 or 2.

NHTSA ODI 11749236

Request for NHTSA Investigation – 2018 Ford Escape 1.5L EcoBoost Coolant Intrusion Engine Defect ​Vehicle Information ​Year/Make/Model: 2018 Ford Escape ​Engine: 1.5L EcoBoost ​VIN: [XXX] ​I am submitting this complaint regarding a well-documented coolant intrusion defect affecting my vehicle’s 1.5L EcoBoost engine. The vehicle is experiencing coolant loss without any visible external leaks, and an authorized Ford dealership has confirmed that coolant is entering the engine, causing internal damage. ​The dealership noted that this matches the exact defect Ford has acknowledged in multiple Technical Service Bulletins (TSB 19-2375, TSB 20-2100, SSM 48106, SSM 48150) and Customer Satisfaction Program 21N12. However, I am told my specific VIN is excluded from coverage, leaving me financially responsible for a full engine replacement. ​This defect is a severe safety concern. It can cause sudden engine misfires, overheating, and a complete loss of power while driving, placing my family and other motorists at immediate risk. As a single mother rebuilding my life after leaving a domestic violence relationship, I cannot afford to pay thousands of dollars to fix an inherent, manufacturer-acknowledged design flaw. ​The high volume of consumer complaints proves this is a widespread manufacturing defect, not normal wear and tear. I respectfully request that the NHTSA investigate this further and require Ford to issue a full safety recall or extend coverage to all affected vehicles, regardless of VIN eligibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11748094

The transmission has very harsh and delayed up shifts. It has been maintained by Ford since new. The transmission appears to be defective.

NHTSA ODI 11748221

The vehicle experienced a coolant intrusion failure involving the 2.0L EcoBoost engine. While driving, the engine began to misfire and run rough, and the check engine light illuminated. Diagnostic testing confirmed a cylinder misfire. A dealership inspected the vehicle and confirmed that coolant was leaking internally into one or more cylinders due to engine coolant intrusion. The dealership advised that the manufacturer recommends replacing the engine short block rather than performing a head gasket repair because the underlying engine design is the cause of the failure. This condition creates a significant safety concern because the engine can suddenly lose power, run unpredictably, or stall while driving, increasing the risk of a crash, especially in traffic or at highway speeds. Continued operation also risks catastrophic engine failure. The condition has been confirmed by an authorized dealership and is available for inspection upon request. Prior to diagnosis, symptoms included rough engine operation, a check engine light, and a confirmed cylinder misfire. The coolant intrusion was verified during the dealer's inspection. Based on the dealership's findings, this appears to be an internal engine defect rather than normal wear or maintenance-related failure.

NHTSA ODI 11747737

My pregnant wife and 2 year old daughter we driving to daycare the morning of June 22nd 2026 and the car flashed an engine overheating message while they were on the highway. They were luckily able to pull off safely and get the car home. Then on June 23rd I went to take the car into the shop to get it looked at and the car completely broke down in traffic on my way to get the car serviced. The engine is completely seized up due to the coolant leak known issue with these engines.

NHTSA ODI 11746407

I have a vehicle whose refrigeration is going into the motor. It started with the check engine light came on notifying the third spark plug was damaged and showed the codes P0303, P04DB, P0316, P0339. Later a warning sign came on the dashboard with the phrase "ENGINE MALFUNCTION, SERVICE NOW". It had a recall almost immediately after it was acquired and was seen by the manufacturer about two years.

NHTSA ODI 11744892

1.5 L eco boost engine FORD- COOLANT INTRUSION, cylinder 3 misfire, check engine light at 59,800 miles - known defect by Ford- needs new engine. Some models recalled but not this one (?? Why??). Cannot safely drive this vehicle. Problem diagnosed by dealer[ as well as by independent garage] and dealer acknowledged a recall should be done but they cannot help except to replace the engine at my expense. So many others having the same issue! Can you please help us get Ford to take responsibility for selling us vehicles with defective engines? Please?? Thank you for your attention to this urgent matter.

NHTSA ODI 11741776

Componet System that Failed: Engine and engine cooling Complaint Description:The vehicle experienced a sudden internal engine failure due to a manufacturer design defect causing coolant intrusion into the engine cylinders. A professional mechanic diagnosed the issue with Diagnostic Trouble Code (DTC) P0303, confirming a Cylinder 3 misfire caused by coolant leaking into the block. The vehicle requires a total engine replacement at just 48,406 miles. This internal coolant leak poses a severe safety hazard, including sudden engine stalling, loss of motive power while driving, and potential thermal runaway/engine fire risks. The vehicle is currently rendered unsafe to drive and is parked at my residence.

NHTSA ODI 11741011

Engine displayed overheating, after diagnostic test by Corwin ford in nampa, Idaho, they said it needs gaskets and short block replacement and that there was a technical service bulletin issued by ford for my vehicle. The cost is astronomical and I feel it should be a recall issue since it is a known problem.

NHTSA ODI 11740439

Bought the vehicle used and two months later engine and transmission needed replacement after several transmission faults and check engine light stayed on due to coolant intrusion in the cylinders and the known transmission defects in this model.

NHTSA ODI 11739270

I was driving my 2018 Ford Escape with my wife and two toddlers in the vehicle when the car suddenly stopped moving in the middle of the road. The vehicle had to be towed and I was later charged over $4,800 for a transmission replacement. After the repair, I received Recall 22S43 from Ford regarding the transmission shifter cable bushing, which describes symptoms including the vehicle not moving or not engaging gears properly. The symptoms in the recall match exactly what happened to my vehicle. I am concerned this defect may have caused or contributed to a dangerous situation for my family and may have resulted in a costly misdiagnosis. I am requesting that this issue be reviewed for safety concerns and potential consumer impact.

NHTSA ODI 11738858

The contact owns a 2018 Ford Escape. The contact stated that when turning her steering wheel to either the left or right, an abnormal thumping noise would emit from the vehicle without warning. The vehicle was taken to an independent mechanic where the contact was informed that the rear differential was defective and needed to be repaired. The mechanic referred the contact to the dealer who informed the contact that the failure may likely be the rear differential based off the symptoms the contact described. Upon investigation, the contact discovered NHTSA Campaign Number: 24V102000 (Power Train); however, the vehicle was not included in the recall. The manufacturer was notified of the failure and confirmed the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 47,000.

NHTSA ODI 11736601

A metallic clinking/rattling noise developed from the engine/transmission area while the vehicle was running. The issue was diagnosed as a failed flexplate. The flexplate is a critical component that connects the engine to the transmission. Continued operation with a failed flexplate can lead to further mechanical failure and could result in loss of propulsion or inability to move the vehicle, creating a potential safety risk, particularly in traffic or when acceleration is needed. The problem was confirmed by a dealership service center. The vehicle was still operable at the time, but the noise was persistent and indicated a failure condition. No warning lights or messages were observed prior to the issue. The noise appeared suddenly. The component was replaced during repair. It is unknown if the failed part is available for inspection. There are reports of similar flexplate failures in comparable vehicles, raising concern this may not be an isolated issue.

NHTSA ODI 11735352

The contact owns a 2018 Ford Escape. The contact stated that while driving at various speeds, the vehicle was jerking, and the vehicle hesitated while accelerating. The vehicle was taken to the local dealer who diagnosed that the transmission torque converter had malfunctioned and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 59,000.

NHTSA ODI 11734536

On 3/15/2026 I was on my way home from Massachusetts to Pennsylvania, and about 35 minutes into my drive I got an alert stating "High Engine Temperature Stop Safely", so I pulled over immediately and turned the car off. After allowing the engine to cool down, I opened the hood and started the car to see if I could identify any issues, the "Engine Fault Service Now" alert came up. This was the first time this ever happened, this put me, my two dogs who were in the car with me, and possibly others on the road at risk, had the conditions escalated. (i.e. under hood fire). The vehicle was towed to an Authorized Ford Dealership, Mathieu Ford Sales, Inc. who diagnosed the issue on 3/17/2026. The dealership removed the spark plugs to inspect cylinders and found coolant intrusion into cylinders significantly on cylinder 2. Dealership referenced TSB 22-2322, is recommending short block assembly and related parts to remedy concern. Dealership advised it was safe and okay to drive the vehicle slowly to a nearby residence (to store the vehicle/retain possession), noting to pull over if an alert pops up and to have it towed if I received another message like before. The dealership advised it was not safe to drive the vehicle back to Pennsylvania. There weren't any issues driving the vehicle back on 3/17/2026 following the dealership's guidance; the car hasn't been driven since. The car needed to be jumped to start the vehicle on 4/17/2026 for a tow truck to load the vehicle onto its bed. The vehicle is currently back in possession of the dealership who diagnosed the issue. Upon doing research, this appears to be a widespread manufacturing design defect that Ford has failed to properly address/recall. My vehicle met the criteria under their Customer Satisfaction Program in 2022 - the vehicle is an Escape, 2017-2019, assembled in Louisville, that was Built before April 8, 2019, and which exhibited a covered condition, having low coolant. Ford Motor Co is failing to remedy-cure.

NHTSA ODI 11733916

My 2018 Ford Escape has diagnostic codes P0302 and P0316 cylinder 2 misfire and no compression on cylinder 2 due to coolant intrusion into the engine block. This is a known defect documented in Ford TSB 22-2322 and Customer Satisfaction Program 21N12. My VIN was excluded from this program despite having the identical failure and identical fault codes as covered vehicles. This engine failure occurred at highway speed creating a dangerous safety hazard. Ford has refused goodwill assistance despite this being a known manufacturing defect.

NHTSA ODI 11731700

Check engine light on. code = P0303. Safety issue for overheating with potential engine fire. Local dealership service has diagnosed as coolant intrusion into cylinder #3 and coolant loss. vehicle has not been inspected by manufacturer, police, insurance representative or other. Vehicle was serviced on January 29th of 2020 for customer satisfaction program 19B37. Vehicle has failed at 88000 miles due same design issue addressed by Ford Motor Company under customer satisfaction program 21N12.

NHTSA ODI 11730261

Keep getting an error code for P0303 cylinder 3 misfire. I have replaced everything to correct this problem but keep getting the same error. Started noticing that coolant is leaving reservoir and only returns when I remove the cap. When I turn the car off I hear water rushing behind the dashboard. There are no leaks seen. I've started having very quick and sudden overheating that cools quickly after stopping the car. I get a dash message "engine fault service now" message that goes away after I remove the cap from the coolant, thus allowing the reservoir to refill. I've been dealing with the P0303 code off and on for a year now, but the coolant issue started a couple of months ago. Yesterday was the first overheating of the engine and the only place I could pull over was very dangerous and I was not able to fully get out of the road. I saw there is a recall on 2018 Ford Escapes for coolant intrusion. Why is this one not included?!

NHTSA ODI 11729867

My 2018 Ford Escape, which has experienced catastrophic engine failure due to the well-documented coolant intrusion defect in the 1.5L EcoBoost engine. In early March 2026, without any prewarning or engine light, my vehicle displayed an “Engine Fault Service Now” warning and stored diagnostic trouble code P2601 (Coolant Pump A Control Circuit Performance/Range). I immediately took the vehicle to Bidwell Automotive in [XXX] , where on March 10–11, 2026, technician Gannon performed a thorough inspection. The findings were as follows: the coolant level was critically low; the water pump showed signs of leaking; the top of the piston in the affected cylinder appeared washed clean (a hallmark of coolant entering the combustion chamber); and the technician detected an odor consistent with combustion gases in the cooling system. The diagnosis was a suspected failed head gasket consistent with internal coolant intrusion. I then brought the vehicle to Future Ford Lincoln of Roseville, your authorized dealership, on March 12, 2026 (RO #XXX, Service Consultant [XXX] , Certified Technician [XXX] ). Future Ford verified the coolant intrusion into Cylinder 2 by removing the spark plugs and performing a borescope inspection. The dealership’s own technician referenced TSB 22-2322 and recommended either a short block replacement ($9,396.45) or a long block replacement ($13,331.01). The dealership confirmed that my vehicle has no remaining warranty coverage and offered no assistance beyond the paid repair estimate. Ford’s Documented Knowledge of This Defect Ford Motor Company has long been aware that the 1.5L EcoBoost engine in 2017–2019 Escape vehicles suffers from a structural design defect in the engine block’s cooling passages that causes coolant to intrude into the cylinders. Ford’s own actions confirm this knowledge. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11727527

The component that is failing in my vehicle is the engine, specifically the 1.5L EcoBoost engine short block, which is experiencing coolant intrusion into the cylinders. This defect causes misfires, rough running, loss of coolant without visible leaks, and can lead to catastrophic engine failure. The car and all its components are available for inspection upon request. My safety, my child's safety, as well as the safety of others on the road, has been put at risk because this engine defect can cause sudden misfires, loss of power, or complete engine failure while driving. I rely on this vehicle to transport my special needs toddler to and from essential care appointments and therapies. I have experienced sudden intermittent powertrain loss that has resulted in the vehicle randomly stopping on highway. A local auto shop diagnosed the issue free of charge. It was explained to me that this is a known defect that Ford has documented, and other owners have reported to the National Highway Traffic Safety Administration, demonstrating that it is reproducible in vehicles with this engine type. My vehicle has not been inspected by Ford for repair coverage, nor have police or insurance representatives been involved. Ford has reviewed my VIN internally but refused coverage based on a narrow eligibility range, leaving me responsible for repair costs that are financially burdensome and urgently needed for the safety and care of my child. As of now I experience random misfires, rough running, white thick smoke expelling from the exhaust, random powertrain loss, and unexplained loss of coolant. These symptoms appeared gradually but are consistent with the documented defect in other vehicles with the same engine type, model, and assembly plant, making it clear that my vehicle is affected by the same issue.

NHTSA ODI 11724635

I was driving on the highway, and there was an abrupt loss of drive and failure of the car. The transmission failed suddenly when I was traveling at highway speed, and there was no prior warning. This nearly caused an accident with the cars behind me, but I managed to get off the road into the shoulder. This is a safety concern, since there were no prior signs at all of this happening. The transmission failure was immediate. I purchased the car new, and I'm the only owner. I kept up well with maintenance, even doing the oil changes prior to the oil light coming on. I spoke to several Ford dealers, including the Ford dealer I purchased my car in 2018. He admitted that the transmission in this make and model needs often replacement. The miles on my car is approximately 116,000.

NHTSA ODI 11720539

Transmission Fault in red letters came on. Turned car off and then turned back on after 20 minutes and the message disappeared. Three days later same things happened- repeated what I did before and message went away. I've noticed when I try to accelerate it sounds as if I'm accelerating but I'm not getting passed 20 mph. Car does a hard jerk when trying to accelerate.

NHTSA ODI 11717246

I was on my way to work on 2/4/2026 and all of a sudden the RPMs went up really high and wouldn’t accelerate and then down shifted really hard so I pulled over. It then showed on the dash “System Fault: Transmission Fault Service Now” I ended up needing a tow truck. This is NOT ok! It’s also apparently a common occurrence which means it should be recalled and fixed!

NHTSA ODI 11715956

Flywheel detached and destroyed our engine and transmission while we were traveling 75 mph in traffic. We were nearly rear-ended and side-swiped due to immediate loss of power. A dealer inspected the vehicle and told us about the flywheel detachment. They referred us to Ford Customer Service, who said nothing could be done as we were a few thousand over the warranty. Repairs would cost 14,500. The transmission is 6F35, which has had several class action lawsuits due to its failure according to Internet sources. There was a clicking noise at idle but the car was running fine at that point. This may have been loose dowels that eventually detached.

NHTSA ODI 11715049

While driving on highway the trouble light "Engine Fault Service Now" engaged and the engine started to lose power. Another trouble light came on saying to pull car over immediately and restart. By this time the car was dying of power and eventually lost all forward motion. After sitting for a couple hours the engine started with no trouble lights. Had towed to Ford dealer and they say there are no codes logged. This is two weeks after we had to have a new long block engine installed due to faulty motor due to fluid intrusion into cylinders. This latest problem is definately a safety issue with vehicle just dying on the road.

NHTSA ODI 11710641