What 78 owners told NHTSA about the 2018 BMW 5 Series Gt

The passenger restraint system warning along with the airbag warning is displayed on the screen as a defect.

NHTSA ODI 11501672

- Passenger Airbag and passenger restrain system malfunction. - Malfunction of passenger airbag not deploying during accident even passenger seat is occupied with recommend weight. - Issues has been reported to Dealer. In turn dealer responds to as "External Factors" with issue could be presence of moisture in the seat. - Passenger Airbag light illuminates - Warning was never consistent. After reporting to dealership warning stays permanent and advised to replace seat mat sensor. - This has been a know issue over a decade and 2017-2018 manufactured BMW 5 series (G30). - This is clearly a poor material and workmanship costing people life's.

NHTSA ODI 11495361

Engine suddenly lost most of power, causing risks of losing control. Diagnosis suggests a bug in Digital Motor Electronics (DME) unit. Per TSB SI B12 08 18, the correction is to update software. This should be a recall to make sure drivers don't experience sudden engine malfunction during driving.

NHTSA ODI 11489856

Vehicle reports "Passenger restraint system malfunction" upon startup, even when passenger is not in seat. Passenger airbag light turns on. In this state the vehicle defaults to deploying the passenger airbag no matter what, even if passenger weighs less than 45 lbs. BMW of North Scottsdale inspected and recommends replacing the passenger seat sensor mat for $3600, not covered outside of factory warranty.

NHTSA ODI 11488264

Passenger seat indicator light keeps going off intermittently. Dealer says its a seat pad issue. We identified it in 2018 but dealer was not able to fix it and it continually keeps happening and didn't do anything because dealer did not fix it at that time. Now dealer is re-diagonising it saying it is a different diagnostic code but we have seen the same issue since we got the car. After reasearching this, there was a recall in 2017 with similar issues. It is related to the sensor and if not properly working, the airbags may not deploy when needed. This appears to be a safety feature of the car so should be recalled like previous. Please investigate.

NHTSA ODI 11480988

There is an exhaust leak which has developed in the turbo. This causes untreated fumes and soot to be emitted in the engine compartment. This untreated exhaust makes its way into the passenger cabin, putting passengers at safety risk due to untreated exhaust fumes entering the cabin. The dealership has acknowledged the issue and describes it as follows: "The soot that you have seen and the smell is coming out of the wastegate shaft which by design there is a tolerance for it to move, but due to back pressure from the soot build up before the regen has occurred there is some soot that comes out." This problem happens every time I start and drive the car. The dealership is stating that this is not covered by the factory warranty. An exhaust leak like this is a serious passenger safety issue.

NHTSA ODI 11474850

The vehicle was at a complete stop, when the gas pedal was tapped to move forward slightly the vehicle suddenly accelerated out of control. There was an attempt to apply the brakes, but the vehicle continued to accelerate and "Drive Train Malfunction" began to flash on the dashboard of the vehicle. The vehicle proceeded to accelerate as it jumped a curb, crashed into a ditch, before finally becoming lodged in a fence and coming to a complete stop when half of the vehicle was lifted off of the ground. The driver of the vehicle suffered a fractured back as a result of the incident. We have reported this incident to BMW and are awaiting a response from the manufacturer. The vehicle has been inspected by the driver's insurance and, while we do not have a report from them yet, the vehicle was totaled.

NHTSA ODI 11460740

Passenger Restraint System Malfunction. This is what randomly and constantly pops up. The fasten seat alert goes off the whole time I’m riding, although no one is in the passenger seat. I took it to the BMW service center twice and each time they keep my vehicles for hours, just to say they couldn’t duplicate the issue.

NHTSA ODI 11429174

Passenger seat belt warning light activates even though there is no one or anything in the passenger seat.

NHTSA ODI 11427961

Passenger restrain system malfunction where airbags will not deploy if car is in accident. this seems as an issue with BMWs and they had recall before on certain models and years, dealers do not want to process claims under manufacturing warranty to fix an issue even the car is still under manufacturing warranty. claiming that water could have been spilled seems very convenient not to fix this issues. i took my car to dealer and they ran diagnostic test and charge me $200 to tell me to turn heat in the seat because moisture, sound unfair. week after that same message came on i am not sure how it is legal for BMW dealers to clear code and send people home and tell them to turn heat in the seat and hopefully problem goes away. which it did not and there should be recall for this issue especially if airbags are concern.

NHTSA ODI 11418662

WHEN BRAKING TO COME TO A STOP AT A LIGHT, THE ENGINE REVVED UP TO OVER 5000 RPM. I HAD TO SHUT OFF THE CAR TO GET IT TO STOP. WHEN I TURNED THE CAR BACK ON, IT IMMEDIATELY REVVED UP TO OVER 7000, WHILE I STOOD ON THE BRAKE TO PREVENT IT FROM MOVING. SHUT IT OFF AGAIN, PUT FLASHERS ON AND WAITED A MINUTE. RESTARTED AND IT PERFORMED NORMALLY.

NHTSA ODI 11383989

MY CAR HAD UNDER 17,000 MILES AND HAD BEEN SERVICED ON SCHEDULE BY AN AUTHORIZED DEALER. I HAD BMW ANCHORED DRIVER'S FLOOR MAT IN PLACE. MY MOTHER-IN-LAW AND I WERE WEARING OUR SAFETY BELTS. WE WERE APPROACHING A FOUR-WAY INTERSECTION WITH A TRAFFIC LIGHT. THE SPEED LIMIT ON THE ROAD IS 35 MILES AN HOUR. I WAS DRIVING SLOWER THAN THAT SPEED. AS I WAS APPROACHING THE INTERSECTION WITH A RED LIGHT , I HAD TAKEN MY FOOT OFF THE ACCELERATOR. ALTHOUGH MY FOOT WAS NOT ON ANY PEDAL, THE CAR SUDDENLY ACCELERATED. I HIT THE BRAKES BUT I COULD NOT SLOW THE CAR. I WAS RAPIDLY APPROACHING THE INTERSECTION AND OTHER VEHICLES. TO THE RIGHT OF THE ROAD WAS A HOUSE. I STEERED THE CAR OFF THE ROAD AND INTO THE FIELD ON THE LEFT. I AM CERTAIN THAT MY FOOT WAS ON THE BRAKE PEDAL BECAUSE OF ITS POSITION AND RESISTANCE. THE CAR HAD ACCELERATED WITHOUT MY FOOT ON ANY PEDAL. DUE THE CAR'S SPEED AND AN INCLINE AT THE ENTRANCE TO THE FIELD, THE CAR BECAME AIRBORNE FOR A SHORT DISTANCE BEFORE LANDING HARD AND CONTINUING TOWARD A DUMPSTER. ALTHOUGH I WAS UNABLE TO SLOW THE CAR, I WAS ABLE TO STEER THE CAR AWAY FROM THE DUMPSTER AND TOWARD A STEEP HILL AT THE END OF THE FIELD. THE CAR WAS SLOWED BY THE INCLINE AND CONTACT WITH THE GROUND. MY FOOT WAS STILL ON THE BRAKE PEDAL. I WAS ABLE TO PLACE THE CAR IN NEUTRAL. I PLACED THE CAR IN PARK AND TURNED OFF THE IGNITION. I CALLED 911. THE AIRBAGS DID NOT DEPLOY. MY HUSBAND AND THE POLICE OFFICER BOTH CONFIRMED THAT THERE WAS NOTHING IMPINGING UPON THE ACCELERATOR PEDAL. MY MOTHER-IN-LAW WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL WHERE SHE WAS ADMITTED FOR ACUTE LUMBAR SPINAL COMPRESSION FRACTURE. I WAS EVALUATED IN THE ED AND RELEASED. BMW IS TO SEND AN ENGINEER FROM BMW TO EVALUATE MY CAR. THE BODY SHOP TOLD MY HUSBAND THAT AN EMPLOYEE STARTED MY CAR WHICH INITIALLY REVVED AT A HIGH RATE. UNINTENTIONAL ACCELERATION

NHTSA ODI 11350816

SUDDEN UNINTENDED ACCERLERATION

NHTSA ODI 11297810

BACKUP CAMERA DOES NOT RELIABLY ACTIVATE WHEN PLACING THE CAR IN REVERSE. SCREEN ON INSTRUMENT PANEL IS BLANK WHEN IT SHOULD BE DISPLAYING THE BACKUP CAMERA. THIS PROBLEM HAPPENS INTERMITTENTLY. THE DEALER PREVIOUSLY UPLOADED NEW SOFTWARE TO ADDRESS THE ISSUE BUT THE PROBLEM STILL EXISTS, EVEN WITH THE NEW SOFTWARE.

NHTSA ODI 11243141

THIS IS THE SECOND OCCURRENCE OF THE RIGHT FRONT DOOR OPENING WHILE MY CAR WAS IN MOTION. DURING THIS OCCURRENCE, WITHIN A COUPLE MINUTES OF STARTING THE CAR AND DRIVING, FIRST THROUGH A PARKING LOT, AND THEN TURNING RIGHT AND ACCELERATING ON A STREET, AT APPROXIMATELY 15-20 MPH THE RIGHT FRONT DOOR OPENED BY ITSELF. NO ALARMS, TONES OR WARNING LIGHTS WERE PRESENT UNTIL THE DOOR OPENED ON ITS OWN.

NHTSA ODI 11205857

VEHICLE WILL INTERMITTENTLY DISPLAY A FASTEN SEAT BELT WARNING MESSAGE WITHIN THE INSTRUMENT CLUSTER ALONG WITH A WARNING TONE EVEN THOUGH THE DRIVER'S SEAT BELT IS BUCKLED AND NO OTHER PEOPLE ARE IN THE CAR AND NO WEIGHT IS ON THE OTHER SEATS. MESSAGE OCCURS WITHIN A COUPLE MINUTES OR DRIVING AND WILL SELF-CLEAR AFTER ABOUT A MINUTE. PROBLEM OCCURS SEEMINGLY RANDOMLY AND INTERMITTENTLY.

NHTSA ODI 11205860

RIGHT FRONT DOOR OPENED BY ITSELF WHILE CAR WAS IN MOTION. WHEN DOOR OPENED BY ITSELF, A LIGHT ON THE INSTRUMENT PANEL ILLUMINATED AND A WARNING TONE SOUNDED. PULLED THE CAR OVER TO THE SIDE OF THE ROAD AND SLAMMED DOOR SHUT.

NHTSA ODI 11205614

AFTER HAVING MY BMW 530E RUN THROUGH A HAND AND SEMIAUTOMATED CAR WASH, THE CAR WAS DRIED AND DETAILED. WHEN I GOT IN THE CAR AND BEFORE TURNING THE 530E ON, THE IDRIVE SCREEN WAS DISPLAYING A WARNING MESSAGE INDICATING THAT "BATTERY CANNOT BE RECHARGED" AND TO "STOP CAREFULLY: POWER SUPPLY." THE UNDERCARRIAGE WASH WAS NOT DONE ON THIS TRIP TO THE CAR WASH AS IT IS AN ADDED FEATURE. CONTACTED BMW THROUGH THE IDRIVE SYSTEM AND SPOKE TO A MASTER TECHNICIAN WHO ADVISED TO NEVER DO A AN UNDERCARRIAGE WASH. HE ALSO ADVISED TO TURN OFF THE CAR FOR 10 MINUTES. AFTER 10 MINUTES THE MASTER TECH CALLED BACK AND I RESTARTED THE CAR AND ALL WARNINGS WERE GONE AND IDRIVE VEHICLE STATUS WAS "ALL SYSTEMS OK." MY 530E DROVE HOME 10 MILES WITHOUT ANY FURTHER ISSUES.

NHTSA ODI 11186895

WHILE DRIVING ON A CITY STREET, DASH WARNING LIGHTS ILLUMINATED, ADVISING TO DRIVE IMMEDIATELY TO THE NEAREST BMW SERVICE CENTER. AT THE SAME TIME THE VEHICLE BECAME HARD TO STEER. WHILE TRYING TO PULL OFF THE ROADWAY THE STEERING WHEEL LOCKED UP, NEARLY CAUSING AN ACCIDENT. OBVIOUSLY A SERIOUS SAFETY CONCERN. CURRENTLY AT THE DEALER FOR REPAIR.

NHTSA ODI 11155176

WHILE DRIVING MESSAGE WILL POP UP REGARDING PASSANGER'S SEAT BELT AND EVEN DRIVER WAS FASTEN THE SEAT BELT MESSAGE WILL POP UP IN THE SCREEN TO FASTEN THE SEAT BELT. IT WILL START AFTER 20 MINUTES OF DRIVING.

NHTSA ODI 11133641

PASSENGER RESTRAINT MALFUNCTION ERROR. THIS SHOWS UP ON STARTUP. I HAD THIS PROBLEM EARLIER AND SOME HOW THAT GOT GOT CORRECTED.

NHTSA ODI 11124360

THE REAR CROSS-TRAFFIC/PEDESTRIAN ALERT SYSTEM IS DYSFUNCTIONAL. I HAVE HAD TWO OTHER VEHICLES WITH THIS FEATURE AND AM QUITE FAMILIAR WITH IT. THIS VEHICLE IS INCAPABLE OF EFFECTIVELY DETECTING AND WARNING OF APPROACHING REAR TRAFFIC AND/OR (AND WORSE) PEDESTRIANS. REPEATED EFFORTS TO HAVE MY BMW DEALER ADDRESS IT HAVE BEEN FRUITLESS. BMW USA SIMPLY CIRCLES ME BACK TO THE SAME DEALER WHO IS UNABLE OR UNWILLING TO ADDRESS THE PROBLEM. THE NET RESULT IS "SAFELY TECHNOLOGY" THAT, IF RELIED UPON, HAS THE POTENTIAL TO DO MORE HARM THAN GOOD.

NHTSA ODI 11111740

FOR A FEW MONTHS NOW, MY CAR HAS BEEN THROWING A "PASSENGER RESTRAINT SYSTEM MALFUNCTION" ERROR. IT HAPPENS SPORADICALLY AND ONLY STAYS UP FOR BETWEEN 1 AND 5 MINUTES AT A TIME. IT WILL HAPPEN WHETHER THE CAR IS MOVING OR NOT, AND EVEN SOMETIMES AS SOON AS I TURN THE CAR ON. I HAVE BEEN SUBMITTING THE TELECOMMUNICATIONS SINCE IT STARTED. I TRIED TO HAVE IT FIXED BY THOMPSON BMW, ONLY TO BE TOLD, LIKE THE OTHER USER WHO HAS THIS PROBLEM ON HERE, THAT THEY THINK MOISTURE IS THE CULPRIT. I HAVE NEVER HAD ANY RAIN OR ANY OTHER MOISTURE GET INTO THE CAR, AND EVEN IF IT DID, THIS WOULD BE A HUGE SAFETY RISK. THOMPSON REFUSED TO FIX IT AND SAID I WOULD HAVE TO COME OUT OF POCKET FOR THE SEAT, WHICH IS RIDICULOUS. I HAVE BEEN IN CONTACT WITH THE SERVICE MANAGER, AND THE CAR IS SCHEDULED TO GO BACK TO THE SHOP SOON. I WILL UPDATE WITH ANY DEVELOPMENTS, BUT IT WOULD APPEAR THAT MINE IS NOT AN ISOLATED INDECENT.

NHTSA ODI 11110925

RECEIVED AN ERROR MESSAGE ON BMW 540I 2018, WITH 10600 MILES. PURCHASED AS FACTORY DEMO A LITTLE OVER A MONTH AGO. WILL BE TAKING IT TO SERVICE SOON. HOWEVER I UNDERSTAND THIS IS A LONG STANDING ISSUE WITH BMW-S THAT THE MANUFACTURER IS NOT CORRECTING OR ISSUING RECALLS.

NHTSA ODI 11109656

I WAS DRIVING ON THE HIGHWAY TO WORK AT 9AM, IT WAS A BEAUTIFUL MORNING TRAFFIC WAS MOVING VERY SMOOTH I WAS GOING 50MPH APPROXIMATELY WHEN ALL OF A SUDDEN MY CAR JERKS FORWARD AND BACKWARD THEN A BEEPING SOUND AND STOP SUDDENLY ON THE VAN WYCK EXPRESSWAY I SAW MY LIFE FLASH IN FRONT OF MY EYES. LUCKILY THE PERSON BEHIND ME WAS LIKE TWO CARS AW1 CAR AWAY SO NO ONE COLLIDED IN ME , HOWEVER WHEN I LOOK THROUGH MY REAR VIEW MIRROR I SAW ALL THE TRUCKS AND CARS COMING DOWN I DON'T KNOW HOW I WAS ABLE TO MOVE THE CAR OVER INTO THE SERVICE LANE, THE CRAZINESS IS THAT EVEN THOUGH THE CAR STOP IT WAS STILL IN DRIVE I WAS UNABLE TO PUT THE CAR IN NEUTRAL. IT'S BEEN A WEEK SINCE THIS HAPPEN AND I'M STILL HAVING ANXIETY. I AM HAVING A HARD TIME CHANGING THE CAR BECAUSE BMW INSISTED. THEY SAID SOME COLLISION AVOIDANCE WAS ON VERY SENSITIVE AND IT'S FIX NOW. BUT THE WHY WOULD A CAR STOP SUDDENLY ON A HIGHWAY WHEN NOTHING WAS IN FRONT ON ME AND NO OTHER VECHICLE WAS CLOSE BY I THANK GOD THAT I'M ABLE TO WRITE THIS I NEED SOME SERIOUS HELP BECAUSE IF I GET BACK IN THAT SAME CAR I'M GOING TO BE DRIVING IN FEAR FOR THE NEXT 3 YEARS WHO DO I SPEAK TO REGARDING THIS ISSUE. I DIDN'T EXPECT TO GET THIS TYPE OF TREATMENT FROM BMW IS LIKE THEY DON'T CARE HOW IT'S AFFECTED ME IT'S ONLY 1 MONTH ALL THEY HAVE TO DO IS CHANGE THE CAR I DID NOT PULL SLOT OF MILEAGE ON THE CAR I JUST GOT THE CAR I WAS I LOVE WITH THE CAR BUT AFTER THIS INCIDENT I DON'T KNOW IF I'LL EVER FEEL A 100% SAFE DRIVING A BMW. I NEVER HAD ANY ISSUE WITH MY 528I IT WAS PERFECT BUT IT'S SAD TO SAY THAT NOT THIS TIME AROUND. WHY AM I GOING THROUGH SO MUCH STRESS AND HEADACHE TO CHANGE THE VECHICLE IT'S JOT MY FAULT. I'M SO DISAPPOINTED IN BMW.

NHTSA ODI 11093265