What 158 owners told NHTSA about the 2017 Volkswagen Jetta Hev

The contact owns a 2017 Volkswagen Jetta. The contact stated that while attempting to start the vehicle, an abnormal fuel odor was detected, and the vehicle failed to start. Additionally, there was a puddle of fuel underneath the vehicle. The vehicle was towed to the dealer, where it was diagnosed that there was a fuel leak coming from the fuel injector seal, and that the fuel rail and fuel injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that NHTSA Campaign Number: 20V648000 (Fuel System, Gasoline) had previously been performed. The failure mileage was approximately 54,000.

NHTSA ODI 11496043

The fuse that controls the exterior lights (tail, marker,etc.) and interior lights at first interment would blow/burn out. Sometimes after a few days or a few months for the past year. In the past few weeks the fuse blows immediately once replaced. The car was brought to a VW dealer a year ago who changed the fuse and ran a diagnostic. It was brought back 4-5 months later and they again changed the fuse and ran a diagnostic. The second time was not given a slip indicating it was was there for the service and was not charged. While I understand no charge there is no no proof of service. As the fuse controls all the lights the car is dark at night.

NHTSA ODI 11494819

Vehicle has only 10,000 miles. Developed unidentified leak. Shortly after the car was on the freeway in 6th gear and started smoking and revving the engine. Car would not shift into gear and the car stalled. Clutch, flywheel, throwout bearing, and pressure plate were completely destroyed. Towed to dealership.

NHTSA ODI 11490399

Many fault lamps lite up on panel. List: Brake light, Adaptive cruise control, ASC, Power steering lamp, Seat belt lamp and sometimes the seat belt alarm goes off when seat belt is clicked IN!,ABS,Air bag lamp is intermittent,EPC lamp is intermittent. Problems have been confirmed by: Independent auto repair center and Vista VW of Pompano Beach, FL. As far as safety sometimes the engine goes into limp mode during driving a few minutes after starting. Having to pull over quickly to get out of the flow of traffic. To stop the engine after a few minutes it does restart.

NHTSA ODI 11489249

When driving the vehicles power dropped suddenly, especially above 3000 RPM. The actuator arm on the waste gate for the turbo charger broke. Error P2263 was seen on an OBD reader. A quick search online seems to show this is a prolific issue with Volkswagen 1.4 TSI engines between 80,000 and 90,000 miles. My wife and daughter could be seriously hurt down a highway onramp and the power cuts out.

NHTSA ODI 11476662

We own a 2017 Volkswagen Jetta. While driving at 55 MPH, he heard a loud Bang noise and experienced difficulty steering the vehicle. There was no warning light illuminated. We pull over to inspect the vehicle, We did not see any problems with the tires and they looked ok. But there was smoke coming up from the front passenger side. We were able to drive the vehicle another mile before more smoke was coming from under the passenger side. When we pulled over again we realized the right front tire on the passenger side was shredded. We called AAA. replaced the tire with the spare and went home. We called the VW dealer and took the car in. They said it was a front suspension coil spring that broke and punctured the right front tire.

NHTSA ODI 11471680

My check engine line came on; code P05A0. A scan showed that it is my active radiator shutter assembly that is causing the error. My car only has 26K miles, and it seems strange that it would be having an issue. When I took my car to the dealership, the service rep told me it is a very common issue. It is also going to cost around $900 to repair. My car is perfectly drivable (the service rep confirmed it), but I won't be able to pass emissions in AZ with my check engine light being on. The shutters remain open at all times. I can hear it open and close and reopen sometimes when I start my car or while I'm driving, but it will always remain open. My dealership is so backed up that I'd have to leave my car for several days before they could even get to it. I do not have the time or money to do the work, so I didn't leave it for it to be repaired. I have found others on VW forums that have gotten the same error message at about the same mileage I am at. Your organization released a technical bulletin for this issue for 15-16 Jettas, and I appreciate it if you could look to see if the issue continued through the 17 models.

NHTSA ODI 11469271

Car won't start. I have had to call AAA every other day because my car is not starting. It won't start unless I drive it every day. One month after buying the car I was having trouble with it starting. Purchased a new battery,in2020.Drivetime should be investigated for taking advantage of a senior citizen.having had cars in the past I have never had anything like this VW Jetta.It was not because of the weather either.

NHTSA ODI 11457134

The contact owns a 2017 Volkswagen Jetta. The contact stated that while driving at 55 MPH, he heard an abnormal rattling noise and experienced difficulty steering the vehicle. There was no warning light illuminated. As the contact attempted to pull over to inspect the vehicle, he noticed that the rattling noise was coming from the front driver’s side spring. Despite the failure, the contact was able to drive the vehicle home without further incidence. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 99,000.

NHTSA ODI 11452707

The seat belt anchor will not grip, click and lock right away. It takes several times before it locks. Afraid it will become dislodge while traveling. Auto dealer will have to remove and replace entire seat belt mechanism and was advised not to drive the vehicle due to safety concerns.

NHTSA ODI 11449424

Airbag wiring under front seats deteriorate over time causing an error to the airbag system, disabling the airbags.

NHTSA ODI 11447557

My daughters car was hit on highway on drivers rear quarter panel. Major damage, frame and axle on car bent. Airbags did not deploy. No serious injuries. Occupants head hurts from impact, w steering wheel, seat belt was on.

NHTSA ODI 11432973

Battery died. Went to dealer in another vehicle to purchase a battery. Installed the new battery and now have an airbag light. Called dealer to learn how to reset airbag, and they said it requires a special tool to reset along with a service charge ($80 to $160). Should an airbag system require special tool and/or knowledge when the car is required to have them? Everything else is operating normally, but airbags are out of service.

NHTSA ODI 11429794

The contact owns a 2017 Volkswagen Jetta. The contact stated while operating the vehicle, it was discovered that the horn was inoperable and there was no longer an audible sound while activated. The vehicle was taken to the local dealer who was unable to duplicate the failure. The vehicle was not repaired. After retrieving the vehicle, the failure continued intermittently. The manufacturer was not notified of the failure. Additionally, the TPMS warning light would remain illuminated even though the tire air pressure levels were at the correct air pressure. The cause of the failure was not yet determined. The approximate failure mileage was 15,000.

NHTSA ODI 11418504

Dealer does not have parts to fix recall. Received fuel rail recall notice in March. It is late May and have called dealer multiple times with same response. Recall is for fuel rail that may leak.

NHTSA ODI 11418227

CAR CAN BE TURNED OFF EVEN IF THE VEHICLE IS NOT IN PARK. THE CAR WAS TURNED OFF WHILE STILL IN DRIVE UNBEKNOWNST TO THE DRIVER. THIS RESULTED IN THE CAR ROLLING INTO ANOTHER VEHICLE IN A PARKING LOT. THIS COULD HAVE CAUSED A LOT OF DAMAGE TO PEDESTRIANS AND OTHER VEHICLES. A ACCIDENT DID OCCUR ON FEB 12, 2021 IN SPROUTS GROCERY STORE PARKING LOT IN LA MESA, SAN DIEGO CA. INSURANCE COMPANIES HAVE BEEN INVOLVED TO REPAIR THE OTHER PARTIES VEHICLE INVOLVED. THE DAMAGE TO THE MENTIONED CAR INCLUDES DAMAGE TO THE BUMPER, TAIL LIGHT AND SIDE BODY. THE OTHER VEHICLE INVOLVED NEEDS THE ENTIRE SIDE PANEL REPLACED.

NHTSA ODI 11413464

TL* THE CONTACT OWNS A 2017 VOLKSWAGEN JETTA. THE CONTACT STATED WHILE DRIVING 25 MPH, SHE STARTED TO SMELL A FUEL ODOR INSIDE THE CABIN OF THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. SHORTLY AFTER, SHE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V648000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS TAKEN TO THE LOCAL DEALER BROOKLYN VOLKSWAGEN SERVICE CENTER (599 E 56TH ST, BROOKLYN, NY 11203, (718) 484-7788) AND WAS INFORMED THAT THE RECALL REPAIR WAS PREVIOUSLY COMPLETED. THE VIN STILL SHOWED THE VEHICLE AS UNREPAIRED. THE CONTACT STATED THAT THE FAILURE PERSISTED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 26,000.

NHTSA ODI 11413338

I WAS PARKED AND SUDDENLY MY CAR DID NOT WANT TO START, NO WARNING LIGHTS CAME ON BEFORE EXPERIENCING THIS ISSUE. AFTER BRINGING IT TO THE DEALERSHIP ACCORDING TO THEM BATTERY NEEDS TO BE REPLACED AGAIN AND IT HAS BEEN ONLY ABOUT 2 YEARS OR LESS FROM LAST REPLACEMENT. THIS ISSUE CLEARLY NEEDS TO BE ADDRESS IMMEDIATELY AS BATTERIES SHOULD LAST FOR MINIMUM OF 3 YEARS. ALSO AFTER EXPERIENCING PROBLEMS WITH THE BATTERY THE AIRBAG WARNING LIGHTS CAME ON AND VOLKSWAGEN DEALERSHIP IS STATING I MUST REPLACE FAULTY AIRBAG INDICATOR LIGHT AND PAY IT FROM MY POCKET WHICH I FIND UNACCEPTABLE. THIS ISSUE NEEDS TO BE FURTHER INVESTIGATED AS AIRBAG WARNING INDICATOR CAN ALSO BE RELATED TO ' VOLKSWAGEN'S CLOCK SPRING PROBLEMS'.

NHTSA ODI 11406805

I WAS DRIVING ON ROAD & I HIT A MAJOR ROCK OR A POTHOLE I WAS IN HYATTSVILLE. I WORK & LIVE IN THE CITY OF HYATTSVILLE. I DRIVE THOUGH THE BLADENSBURG/HYATTSVILLE TO DO MY DELIVERIES WORKING BUT THIS ONE JUST DAMAGED MY VEHICLE & STARTED A MAJOR LEAK FROM MY TRANSMISSION PAN. I LEFT WORK CAUSE I NOTICED IT WAS LEAKING CONSTANTLY DROVE IT HOME AND SAT IT DOWN.

NHTSA ODI 11406281

WHILE THE VEHICLE WAS IN MOTION IT TURNED OFF ON ME AND STARTED LEAKING FUEL.

NHTSA ODI 11403802

AS I BRAKED FOR A STOP SIGN IN MY TOWN, THE CAR BEHAVED AS IF ON ICE OR SNOW, IT WASN'T. THE LIGHT WITH THE SKIDDING CAR, THE ABS LIGHT, AND THE AIRBAG LIGHT CAME ON. AS I CONTINUED, IT HAPPENED TWICE MORE ON MY WAY HOME.

NHTSA ODI 11402649

I WAS DRIVING DOWN THE FREEWAY AT 70 MPH AND THE CAR LOST ALL POWER. THE CHECK ENGINE CODE CAME ON AS WELL AS THE EPC LIGHT. THE CAR WOULD TRY TO START BUT WOULD RUN VERY ROUGHLY. WHEN I GOT IT HOME I STARTED IT AND NOTICED FUEL POURING FROM THE FUEL RAIL

NHTSA ODI 11399727

I PURCHASED THIS VEHICLE FROM LARSON AUTOMOTIVE GROUP IN MID JANUARY 2021 AND, ONLY AFTER CHECKING YOUR SITE, FOUND THE RECALL. I NOTIFIED THEM AND THEY RETURNED THE CAR AND I PURCHASED A DIFFERENT JETTA THAT I HAVE NO PROBLEMS WITH. MY CONCERN IS THAT THEY ARE STILL SELLING THIS VEHICLE AND AT LEAST 4 OTHER JETTA 1.4 TS ON THEIR SITE. I AM WORRIED OTHERS WILL NOT CHECK AS I DID AND BE SOLD A CAR THAT IS UNSAFE, WITH AN ACTIVE RECALL.

NHTSA ODI 11391167

TL* THE CONTACT OWNS A 2017 VOLKSWAGEN JETTA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V648000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED VOLKSWAGEN OF SALEM COUNTY (815 US-40, MONROEVILLE, NJ 08343) AND THE MANUFACTURER, AND WAS INFORMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CONTACT STATED THAT HE WAS CONCERNED FOR HIS SAFETY AND HAD STOPPED DRIVING THE VEHICLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 11390467

TL* THE CONTACT OWNS A 2017 VOLKSWAGEN JETTA. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 20V648000 (FUEL SYSTEM GASOLINE) HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE PART TO DO THE REPAIR WAS NOT YET AVAILABLE. THE CONTACT RECEIVED THE RECALL NOTIFICATION DECEMBER OF 2017. THE CONTACT SPOKE WITH A KIA DEALER THAT ALSO SERVICE VOLKSWAGEN VEHICLES, (OVERTURF KIA 1016 W COLUMBIA DR, KENNEWICK, WA 99336 PHONE NUMBER (590) 586-3185), THE DEALER ADVISED THE CONTACT IF THE VEHICLE WAS NOT EMITTING A FUEL ODOR THE CONTACT SHOULD NOT BE CONCERNED AND THAT THE REMEDY WAS NOT YET AVAILABLE FOR REPAIR. THE MANUFACTURER WAS NOT CONTACTED. VIN TOOL CONFIRMS REMEDY NOT YET AVAILABLE.

NHTSA ODI 11389303