What 687 owners told NHTSA about the 2017 Chevrolet Malibu Eco

shift to park

NHTSA ODI 11532546

Issues with fuel pump

NHTSA ODI 11531512

Issues with fuel pump. Other 2017 Chevrolet Malibu's already have this recall

NHTSA ODI 11531513

I was traveling at 55 mph and hit a deer with my car's front end. The impact affected about 60% of my front end. I couldn't escape from my vehicle through either front doors, I had to use the rear passenger doors. Upon impact, the front dash Indicated "airbag" buy not 1 airbag deployed. Even the car dealership indicated that they noticed the airbag light, but assured me it was okay.

NHTSA ODI 11530617

1) brake system failed , yes it’s available for inspection 2) the brakes became very hard not being able to push down to use brakes , had to go to the right into ditch to avoid many vehicles that were ahead of me , this was very scary for my family and I , I’ve had nightmares since . 3) brake booster has been confirmed by the dealership as the problem 4)inspected at the hm dealership 5) There was no warning lights before incident happen

NHTSA ODI 11528989

Engine reduced while on the highway.

NHTSA ODI 11528633

Fail to ingage into park Car can roll away if not staying park mode. Yes dealer Inspected and repaired by dealer Dashboard stater shifter not engaged, first appeared 10/27/2022

NHTSA ODI 11528306

I notice water leaking inside the trunk and roof, after carefully checking the outside car i have found a cracked 3rd brake light( rear), no accident , no impact nothing happened.

NHTSA ODI 11528179

Shift to park warning continues to come on daily when I go to put my car in park. I have to fidget with the shifter to get the computer to recognize that my car is in park and the car will then shut off. Recently I was stopped at a red light, tried to accelerate at the green light and my car completely shut off, while I was still in drive. I could not accelerate and had to place my car in park. Then my stabilitrak sensor came on, along with a notice that my battery saver was on. I had to call a police offer to help me off the road. The car was then able to turn on and I drove it home but this is not safe.

NHTSA ODI 11527915

The day I bought the vehicle in 2019 the engine light came on, I took the car back to the dealership and was told they couldn’t do anything. I took it to them and the shop here in town and I was told by both shops on multiple occasions they could not fix any of the issues. They treated me like I’m just a paycheck for them. My car for 3+ years now shuts completely off when I slow down or stop, including on highways. “Engine speed reduced” message comes up every time I drive. Now I am being told my brakes are going to go out and nobody can help me. I have to step on my gas after I start the car or it just sputters.

NHTSA ODI 11526493

The contact owns a 2017 Chevrolet Malibu. The contact stated that upon cleaning her rear windshield, she noticed that the third rear brake light plastic housing had cracked on both sides. The vehicle was taken to the dealer where the contact was informed that the third brake light needed to be replaced to avoid future water intrusion that might enter through the roof of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 78,000.

NHTSA ODI 11526584

Driver door will not unlock from outside of car when car is sitting out in the heat and sun. Yes car Is available for inspection If I need to get in car while out somewhere I can’t in a hurry. I went to dealership in November 2022 when it happened 3 times it was hot outside. No warning message or symptoms before failure. Hot weather when sitting in sun lock will not work. Now that it is very hot lock is not working again June12, 2023 happened 2 times today

NHTSA ODI 11526644

I was driving my car at a normal rate of speed when all of a sudden it slowed down to a crawl and almost caused an accident, reduced engine power and engine came one after getting the codes they were 2122 and 2097

NHTSA ODI 11526672

My car has reduce engine speed. I’m driving on the highway and out of nowhere the car shots down and a symbol appears on my dashboard that says Reduce Engine Speed. Literally the car slows down to a minimal speed until I can’t drive anymore. I have to stop and turn off the car for 5 minutes until I can turn it on and drive to my destination in a reduce speed.

NHTSA ODI 11525760

Reduce Power Engine appears on the dash board. The car starts slowing down, I can’t speed up, I Have to park on the side of the heavy traffic in the Highway. I have to wait around 5 minutes and then drive. I still have the engine symbol on. This happens regularly like 2 to 3 times a week.

NHTSA ODI 11525764

The contact owns a 2017 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the reduced speed warning light and the check engine warning light were illuminated. The vehicle decelerated and the brake pedal became stiff while depressed, while the RMP’s fluctuated. The vehicle was taken to the dealer, where the vacuum pump was replaced; however, the contact stated that the RPM’s was still fluctuating. Additionally, the contact stated that while driving, if the accelerator pedal was not depressed, the vehicle would shut off. The contact stated that the vehicle failed to exceed 60 MPH while driving. The contact stated that a DTC code for the camshaft was illuminated. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,000.

NHTSA ODI 11525893

The contact owns a 2017 Chevrolet Malibu. The contact stated while driving approximately 65 MPH and attempting to depress the brake pedal, the vehicle failed to stop as needed. The contact was able to get to the side of the road but ended up in a ditch which stopped the vehicle. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the brakes had failed and that the vacuum pump needed to be replaced. The vehicle was repaired; however, due to the manufacturing of the braking system, the damages was extensive, and the vehicle was undrivable. The contact stated that additional parts were needed to fix the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 121,000.

NHTSA ODI 11525439

the secondary battery that sits in the trunk, above the back driver side tire had a short. the cable bunt out and my car reduced speed and it had me pull over. I did not know this is what had happened until i drove it again and i could no longer start it. the shift knob is locked and cant put it on drive or neutral. initializing wait to shift, theft deterrent system, transport mode on, stabilitrak, among other things popped up. Had that short sparked up into an actual fire, yes, my life could have been at risk as the car could have caught on fire. Due to it being a long weekend (memorial day weekend) I couldn't take it to a Chevy dealer. I am on an out of town trip for my kids soccer tournament. i currently have it sitting a tow yard waiting to take it to my house, and then towed to Chevy dealer in Hemet, CA, where I live.

NHTSA ODI 11524202

shift to park message appears most often

NHTSA ODI 11523101

Brake failure, turning into my parents driveway I had to swerve to miss a truck and drove in the yard because of it. It has been diagnosed a faulty brake vacuum pump that caused this failure. I am getting it looked at by a mechanic of Friday and hope that this issue didn't cause further problems with the engine/camshaft. From doing research it seems that many other people have experienced the same issue with the same year vehicle (2017 Chevrolet Malibu). I have also in the past had to get my car fixed by a GM mechanic for the issue of the car giving the "reduced power mode" and basically shutting off while driving down the street. That has now been fixed but was also an issue GM was aware of but I never received a letter or anything about the issue or that there was a recall on it.

NHTSA ODI 11522296

Vehicle has trouble turning off once in park. Vehicle doesn't acknowledge the shift change in order to allow the vehicle to shut off the engine.

NHTSA ODI 11521801

My car Engine failed on me and I have Taken this car Back to dealership over and over again and they kept telling me nothing was wrong and kept clearing my codes on the car and now out of a car I have to still pay on this car cost me 22,000 dollars I bought the car with 34,000 miles in Dec of 2019 and have had problems since the first power loss i cant remember exact date I found out this car had a recall and at 3,300 miles with the valve and gotten fixed I had loss of power with the gas pedal which was also recall car felt like it was gonna stop on me multiple times with power loss engine was riding rough I wold smell a burning smell at times my shift into park as well needed fixed the dealership said I needed a new computer and they couldn't do nothing about it I even Contacted GM and nothing was done before my car engine went out on me every time I took the car in the codes that came up was in the car history which i asked why do codes keep pop up in history if you keep clearing them that means something wrong and they couldn't give me a answer My extended warranty denied my claim they had a inspector come out and take a look due to consumption of oil and bent valve is a part in the engine they wont cover and I even asked my advisor all the times I brought my car in this could of been issue and he said possibly I have all my invoices as well have I dont have a way to upload them at the moment

NHTSA ODI 11521623

I purchased a 2017 Chevrolet Malibu LT for my son Memorial Day weekend in 2019. The first night we got the vehicle home it rained overnight. We checked the trunk and found water in the trunk. After a search online we found that this was a known issue for the Malibu yet Chevrolet/GM did not issue a recall. After putting pressure on the dealership that sold the vehicle to us they agreed to send us to a Chevrolet dealership to have the issue fixed at no charge. Last Monday, April 24, 2023, my son was driving his vehicle and the StabiliTrak came on and his car would not accelerate. He took the car into the dealership and they determined his pistons were cracked and it would be $6,900.00 to repair the pistons/engine. After doing an internet search I found a letter on a commercial attorney's website and on the GM website that was sent to Malibu and Cruz customer's in 2017. The piston damage was a known issue. The letter from 2017 stated it was a misfiring of an ECM module that could lead to piston damage. Owners of the Malibu and the Chevy Cruz were given to March 31, 2019, to come in and have the module reprogrammed and new oil placed in the vehicle. We bought the care at the end of May 2019 so there was no way to know of this issue. There was no recall so the information was not readily found. I did not find out this was a known issue until I did the Google search last week. I have reached out to Chevrolet and filed a claim. Chevrolet at first said they could maybe pay 20% for the repairs. They should be paying 100% due to the fact they knew of the issue and should have issued a recall.

NHTSA ODI 11519806

Rear suspension knuckles damaged. Make loud clunking noise when entering/exiting vehicle and anytime I ride over bumps

NHTSA ODI 11516907

2017 Chevy Malibu has P2138 showing up.. I was on the highway loss half the power to my car, almost causing a major accident, went from 65 mph to 30mph in seconds.. This is a safety issue & needs to be address ASAP!! I have my vehicle at the dealership, the service teams seems to have no clue that there is an issue with the mailbu's !! The P2138 is defined as “Throttle/Pedal Position Sensor/Switch “D”/”E” Voltage Correlation.” It is triggered when the vehicle's Engine Control Module (ECM) detects that the signals from the two throttle position sensors or the two accelerator pedal position sensors don't correlate.

NHTSA ODI 11516303