What 201 owners told NHTSA about the 2017 Chevrolet Cruze Limited

Noticed the roof seems to be separating from the body and rusting.

NHTSA ODI 11533381

The contact owns a 2017 Chevrolet Cruze. The contact stated that the vehicle was designed with the Auto START/STOP feature; however, while at a complete stop, the engine turned off but failed to restart. The contact shifted into park (P) and restarted the vehicle. The contact stated that the failure occurred intermittently. Additionally, the contact stated that while driving between 35-65 MPH and depressing the accelerator pedal, the vehicle jolted and hesitated to respond. The contact stated that the failure occurred intermittently. The contact also stated that the check engine warning light illuminated intermittently. The vehicle was taken to an independent mechanic, where it was diagnosed but no issues were found. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 42,000.

NHTSA ODI 11532083

Douglas all seasons is usually sold in Walmart is a good brand but there's some times that are just goes out of it completely when it hits a tire or nail and can cause a major accident and doing the time whenever the potholes you can barely feel if your tire has air in it and another thing is very hard to get that tire off of your vehicle and you have to be to have a special tool or something like that in order to take that tire off and it don't always erupt with a regular air pump outside and you have to try to rush to a detour somewhere to get are so I kind of feel like it's an inconvenience having that type of tire or vehicle I usually purchase for room they run between the amount of $55 all the way up to 65 what tire rotation I think the warranty is up to like 3 months the warranty is up to 3 months or a year depending on how much you spend

NHTSA ODI 11531236

I purchase this car in 2017 apprentices 2017 Cruze at the time it only have four thousand miles it has 80,000 MI it was a fuel injector pump replaced next to the engine at everybody there knew that the car was defective due to the fact that they have several men that don't know what they're doing and working on these cars are unprofessional workers and everybody here knows that they keep repairing cars and they need to send them back to the manufacturer for DFCS and numerous problems they said everybody here got nothing but junk cars and they need help to replace them immediately in this car the cruise and the Malibu the odometer kept sticking and going bad and they did replace it once and then they replaced it again and they left the park open in the vehicle you always have to get so many oil changes with this and then the one-time the Auto stop feature had got stuck on a train track and it was very hard to get that car off we had got frightened and had jumped off the car over here in Milwaukee off of 2nd street or 1st Street we're trying to report whatever we can so I can get a replacement vehicle or sometimes the rear camera was defective to it didn't always come on right away

NHTSA ODI 11531233

Car very suddenly started having slow acceleration, and vibration felt during acceleration. Check engine light on with StabiliTrak warning message on dashboard. Rough idle and vibration felt in cabin. Difficulty accelerating at traffic light and car seemed to almost stall at one point. Diagnosed at the dealer with cracked pistons in engine with code P0300 for random misfire. 2017 Chevy Cruz has passed the power train warranty by 1 year. Mileage odometer reading is about 58200. GM is not willing to replace without charging $4700 for replacing the faulty piston components in the engine even though this poses safety hazard for regular driving. After some research, this seems to be a widely known problem of this generation Chevy Cruz and GM has even changed the part number of the piston assembly to replace the faulty pistons in engine. This needs to be a recall!

NHTSA ODI 11530514

I was at a stop light. The cars feature that shuts off the engine when stopped at a light failed as it completely would not start again. This has happened to me a few times now. One of those times it was at a busy intersection and I was almost hit. I had to shut off the car and turn it back on again to get it to move. I spoke to someone at Chevrolet and I was told this feature can not be turned off in this model and there have been known issues. I do not know why with this being known that nothing has been recalled on the vehicle. I can not remember if lights turned on as it was extremely stressful to go through.

NHTSA ODI 11529475

Seal on rear break lights malfunctioning causing water to leak into light and trunk causing mold and mildew buildup and possible electrical issues.

NHTSA ODI 11528977

The clutch pedal got stuck while driving. There is a factory defect with this vehicle's Clutch Slave Cylinder and it's a huge safety hazard since it can happen at any time on all the manual transmission models. This is a known issue that hasn't been addressed by GM

NHTSA ODI 11524203

It started with a check engine light stating I needed to replace a fuel injector. I had that replaced and continued to have the same problem. I had a compression test performed and stated that I had a cracked cylinder leaking compression in cylinder one. The engine needs to be replaced or rebuilt. As you can imagine that is expensive. After finding this out, I continued to drive the vehicle hoping to get a new a vehicle. I was unable to and the vehicle stalled on me while driving several times. This put my safety in jeopardy as I could've have gotten hurt on the road and other safety if I got hit. Luckily, neither happened. General motors intentionally inflates the PSI in the engine to compensate for the turbo engine, resulting in the breakdown of the engine quicker and makes it unsafe for the road. In my case, I just bought this vehicle a year ago and has under 100k miles. I have been unable to get a GM technician to diagnose the vehicle due to finance reasons. After research, this is common issue with my vehicle and I am reporting this issue.

NHTSA ODI 11523519

The contact owns a 2017 Chevrolet Cruze. The contact stated while he was attempting to start the vehicle, and while attempting to turn the vehicle off, he observed that the "remote key not detected" message was displayed. The contact stated that he had gone through several replacement key fobs. The contact had taken the vehicle to a local dealer, where he was sold a new key fob. The vehicle was not diagnosed and only the key fob was replaced. The manufacturer had not been informed of the failure. The contact researched online and related the failure to manufacturer Technical Service Bulletin Number: 16-NA-396 (Intermittent Operation of Key Fobs - Electrical System). The failure mileage was 117,000.

NHTSA ODI 11520224

The contact owns a 2017 Chevrolet Cruze. The contact stated that the check engine warning light was displayed on the instrument panel. The vehicle was taken to the dealer where the contact was informed that the O2 sensor was defective and needed to be replaced. The vehicle was the repaired; however, the failure persisted. The vehicle was taken back to the same dealer two additional times for the same repair however, the failure persisted. The manufacturer was notified of the failure and the contact was given credit towards another vehicle. The vehicle was not repaired. The failure mileage was 4,378.

NHTSA ODI 11519999

The contact owns a 2017 Chevrolet Cruze. The contact stated that while driving at approximately 60 MPH, the engine started to misfire. The contact stated that the vehicle was hesitating while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated. The contact stated that the vehicle stalled while driving into the driveway; however, the vehicle was able to restart. The contact stated that she attempted to call a local Chevrolet dealer however, her calls were not returned. The vehicle was taken to an independent mechanic who stated that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 35,000. The VIN was not available.

NHTSA ODI 11515599

The number one cylinder piston cracked causing it to idle rough and possibly blowing up causing the car to come to a stop. The problem has been reproduced and confirmed by a licensed Chevy dealer/ repair shop. Was told that it’s a common problem with the car and also told that it will just explode

NHTSA ODI 11514420

I purchased a 2017 Chevrolet Cruze RS Premier hatchback from Mastria Kia in Raynham, MA in January 2023 and it was missing the rear seat headrests (they were neither installed in their OEM position or in the car upon delivery). I would like to know if this is a violation of NHTSA regulations. To date, they have been unwilling to provide the proper headrests as installed by the Original Equipment Manufacturer. Thank you.

NHTSA ODI 11505573

Clutch pedal does not return, cannot change gears. Chevy issued a TSB, however they do not warranty the repair. The problem is with a clogged orifice which is a engineering defect. This is a well know problem and is extremely dangerous. I assume enough people haven't died yet from this issue for a recall.

NHTSA ODI 11498668

I HAVE A 2017 CHEVY CRUZE, WITH 38,000 MILES. MY PISTON CYLINDER IS BROKEN. I HAD BOUGHT IT OFF A DEALERSHIP WITH 24000 MILES ON IT4 YEARS AGO. AT 38000 MILES WITH ONLY PUTTING VERY LITTLE MILEAGE ON IT, I HAVE TO HAVE THE ENGINE REPLACED WHICH IS A VERY EXPENSIVE FIX. I SHOULD NOT HAVE TO HAVE TO HAVE MY WHOLE ENGINE REPLACED AT 38,000 MILES. I HAVE DONE MY RESEARCH AND THIS IS A COMMON PROBLEM WITH THE 2017 CRUZES. THIS IS SUPPOSE TO MAKE A GREAT FAMILY, REALIABLE CAR! I AM VERY UPSET WITH CHEVY! THERE WAS NO PRIOR WARNINGS OF MY CYLINDER PISTON BREAKING. STABILITY SERVICE LIGHT CAME ON AND IMMEDIENTLY AFTER THE ENGINE LIGHT DID TOOK IT TO A SHOP THE NEXT DAY. AND MY CYLINDER IS BROKEN. WITH LABOR IT IS EASIER TO JUST REPLACE THE WHOLE ENGINE. I AM VERY DISAPPOINTED! I WAS DRIVING WITH MY KIDS WHEN THIS HAPPENED. LUCKY MY CAR ENGINE DIDNT BLOW UP IN THE PROCESS AND I WAS ABLE TO GET HOME SAFELTY!

NHTSA ODI 11497678

Chevy Cruze 2017 manual transmission clutch pedal stuck to the floor while driving preventing changing of gears. Was able to lift pedal with toe, but was still not fully able to then depress clutch to get the car in gear. Pumping the pedal helped loosen and eventually allowed it to work normally temporarily. For the past year, occasionally the clutch would be slow to return after depressing, but did not cause any safety issue and since it could not be reproduced for dealer, no repairs were made. Having an experience of not being unable to change gears in traffic caused a significant safety issue, which will need to be remedied. Appointment for service is scheduled for tomorrow and will find out more what the problem is, but based on online forums, it likely is a faulty slave cylinder which has been reported in other Chevy Cruze cars of this year.

NHTSA ODI 11494507

The car shut down in the middle of the highway which made me pull to the side and not so long after this incident the brakes stopped working for some time causing me to crash.

NHTSA ODI 11490066

During rain or carwash, water leaks into rear passenger cabin along ceiling. Suspect coming from cracked rear third brake light which is a known Cruze issue that may also cause battery issues. My third brake light has two cracks (one on each side).

NHTSA ODI 11479150

Have filed an earlier complaint and never heard back. But the engine was stalling and not maintaining speed without heavy acceleration. First week of August 2022 the car finally gave out after diagnosis of faulty knock sensor. Was displaying knock sensor code intermittently and finally stayed on. Anyway first week of august it stalled completely at a stop sign and would not crank back up. I finally started checking relays and found the engine functions relay faulty by accident. There are two square grey relays under the hood in the fuse block. One says engine function s relay and one says something to do with defrost controls. Had to swap the two relays to get my car running. No problems since. Only had 87,000 miles on car.

NHTSA ODI 11477899

My Chevy Cruze LT Hatchback has an acceleration issue. I’ve read blogs where people complain of the same problem. There is a delay from the time you press the acceleration peddle to when the vehicle actually responds. This is dangerous because in the time it takes for the car to respond to the acceleration, oncoming traffic could collide with me causing an accident. I’ve had more than a few ‘near misses’ because of this issues. Something needs to be done about this before someone gets killed over it.

NHTSA ODI 11477771

I should have filed a complaint here after the catastrophic failure. The next time I may not be so lucky and it could cause loss of life. I was driving at approx. 65 MPH on the frwy when bang! An explosion under my hood that caused my car to jump over a lane, I slammed on the breaks, swerved but couldn't push the brake pedal down anymore. It felt hard and would barely move. i had no way to slowdown or stop! And traffic infront of me was slowing fast. I put all my weight on that pedal even tried pumping it, but it would only move alittle. Luckily the car in front sped up just enough for me to swerve onto the shoulder. As I slowed i could depress pedal alittle if I stood up on it out of my seat but stopping distance was like 15ft while maybe going 15 mph. This all happened in a matter of minutes i still dont know how I was able to avoid an accident. The engine sounded really rough. So I called the dealership they said to bring the car in. I had already spoke. With them that week due to traction control system and transmission causing instability and brake issues. I was mortified when I found out what happened I had cracked 2 pistons & the force was so strong it blew thru the membrane that seperates the break system, got oil in my break lines! This is a new car! Dealership said it was a known issue & GM determinedtitle was a design flaw. I had 2 pistons replaced and my break system flushed my car has never been the same. There's always something little and intermitten still with the transmission & Now the engine jumps while idling and stopped in drive it jumps so hard the car jumps fwd, feels like ill hit whats in front of me. I lost significant value at only 26,290 miles, i cant afford to trade it in on disability, covid turned into long haul covid, no affordable extended warranty. I have no piece of mind in a car I dont feel safe in. What happens when the pistons fail they didnt fix. How many injuries or lives must be sacrificed before they do something.

NHTSA ODI 11477451

The contact owns a 2017 Chevrolet Cruze. The contact stated that while idling or while driving at various speeds, the vehicle would hesitate while attempting to accelerate. The check engine warning light illuminated and turbocharger under boost message was displayed. The failure recurred several times. The failure was independently corrected after driving for a while; however, the self-correction was intermittent. The contact stated that whenever the vehicle failed to self-correct the contact would have the vehicle towed. The vehicle had been taken to several independent mechanics who diagnosed the turbocharger under boost had failed and needed to be replaced along with an unknown part. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 123,370.

NHTSA ODI 11475769

While driving down the Interstate my clutch failed and remained on the floor and I was unable to shift. Luckily there was an open lane next to me and I was able to pull off the highway. I checked the fluid reservoir it was full and no air bubbles I managed to limp it home after manually hand pumping the clutch to get it back up and I would get two or three shifts out of it maybe and then have to do it again once I was forced to stop at a light or a stop sign. I just have not been able to get the car in as it is out of warranty and I'll have to pay for tow and for it to be fixed. I just had the engine replaced (under extended warranty) roughly 5000 miles ago. There was no accident but there certainly could have been a Harry Chapin type situation. There were no warning lights or messages that appeared and the clutch is currently inoperable on the floor.

NHTSA ODI 11475209

Car has a lot of difficulty accelerating even when pressing on the gas all the way to start to go. Car rolls back when stopped. Brakes sometimes aren’t working as they should. Car isn’t breaking properly. Doesn’t stop all the way sometimes. When driving the car also, burning smell comes from under the hood after stopping the car. Please help!

NHTSA ODI 11471072