What 131 owners told NHTSA about the 2016 Subaru Crosstrek Wilderness

Within 24 hours of purchase, the exhaust pipe became detached underneath the vehicle and exhaust fumes and odor were entering the cabin while driving. This created a potential carbon monoxide exposure risk to me and passengers. Subaru inspected the vehicle and confirmed the exhaust issue existed before I purchased the car. The selling dealership did not disclose this safety defect and refused to unwind the sale when notified.

NHTSA ODI 11704175

A/C Control Head and connector burned on both ends. Dealer service center stated it was a significant safety/fire hazard if we had not immediately taken in to be checked. No warning, no fuses out. Only indication something was wrong is a/c turned on but only on 1,2 and 4. Then, same day, only on 4. Next day took to Subaru service center. When we asked how would replacing parts stop this from happening again, we were told original parts had a “Design Flaw” and was “Defective”. Replacement/New parts wiring system actually corrects the OEM defect.

NHTSA ODI 11697638

Hood latch failed causing hood to fly open, smashing and breaking my windshield.

NHTSA ODI 11658990

The CVT valve body was diagnosed as defective by the Subaru Dealership service department. The car was taken to the dcealership when the A/T OIL EMP, HILL ASSIST, ABS and TRACTION CONTROL, STABILITY CONTROL lights came up. The valve body is still available for inspection. The car was taken to the dealership for a Brake Light Switch recall that has the same simptoms.

NHTSA ODI 11657595

Full electrical power steering failure

NHTSA ODI 11654714

How was your safety or the safety o others put at risk? On [XXX], I bought a 2016 Subaru Crosstrek. Unfortunately, I fell into the bad and abusive practice of buying a car as is since at no time did that used car dealer in Raleigh inform about the correction and rust that is underneath the car. If they had said so, I would not buy the car since it cannot be fixed and at the Subaru dealer where I live, they told me that the car should not have been sold for use on the road due to the degree of correction and rust it presents. In September, when it did not pass the inspection, I came to find out about the situation of the poor condition underneath the car. It had a leaking muffler and they had to repair it so that the car could pass inspection. I present other situations; but the worst is the state of deterioration. BBB and Consumer Protective, I made complaints and nothing was the result; Because they offered through BBB a settlement at a supposedly low price (I did not accept because I did not trust the sale due to bad faith) and through Consumer Protection, they told me to go to court. I went to court because up to $10,000.00usd, they will see the case without legal assistance; I did not qualify because that dealer sold the car for more than $10,000.00usd. The government could veto the law on car sales as it is, because they abuse and continue selling risky cars and the problem falls on the buyer. Please!! I need a help in this situation. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11628719

Our 2016 Subaru Crosstrek (Automatic Transmission) has had intermittent issues with it losing power despite our foot being on the accelerator. It will typically reengage if we take our foot off the accelerator for a bit and then hit the gas again. However, it has become a more frequent problem and feels increasingly unsafe to drive, particularly with our 2 small children in the car, because it loses power without warning so it leaves us vulnerable for being rear-ended while changing lanes, taking turns, etc. We have been working with our local dealership (Beyer Subaru in Alexandria, VA) to address the issue, but they have only been able to replicate the issue once in a 4-week period and they have not been able to document it. The one time they were able to replicate the problem the car was not hooked up to any computer/system. I have found this forum that documents similar problems with Crosstreks - [XXX] , as well as a Service Bulletin which references a similar issue in 2018-21MY Crosstrek 2.0L MT - https://static.nhtsa.gov/odi/tsbs/2021/MC-10201030-0001.pdf. While the 2nd does refer specifically to Manual Transmissions, I feel like this is indicative of a trend that is not being acknowledged for other Model Year's and transmission types, but presents a serious safety issue.  INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11613015

I have a 2016 Subaru Crosstrek. Unfortunately I have had a couple of issues. The main thing being the horn. The location of the problem is affecting my air bag, AND my rear window defroster. I don’t know if Subaru has a faulty clockspring and relays, that malfunction after a certain amount of time. But for everyone’s safety, it would seem that the Subaru Corporation would implement a recall. As a result of the horn not working, I was involved in a fender bender accident, I was unable to alert a driver that they were merging into my lane of traffic. I’ve searched mechanics and auto parts stores, the cost is exorbitant, especially for a senior on a fixed income. I don’t know to whom these reports are or if they are forwarded, but I certainly hope someone in a decision making capacity will help the loyal owners of Subarus. I still, because I have no other option, drive, however I am so very cautious. And I limit my “outings” to as few as possible. It’s a hindrance, a rather very often at inopportune times. Hopefully there will be a chance for Subaru to do the correct thing.

NHTSA ODI 11601238

Battery drain Bought new battery Got dcm update Pulled dcm fuse Still battery goes dead Thousands of vehicles involved Suburu knows the cause To expensive to fix Please help3/3

NHTSA ODI 11600905

Horn failed to sound. It sounds when hitting the lock button three times, but doesn’t when the steering wheel is pressed. This was identified during a near miss accident when we tried to alert another driving that was weaving into our lane and couldn’t.

NHTSA ODI 11594555

The contact owns a 2016 Subaru Crosstrek. The contact stated that while coming to a stop at a traffic signal, the vehicle was idling roughly. The contact stated no warning light was illuminated. The contact stated that the failure was intermittent but had become a recurring failure. The contact stated that the failure occurred frequently whenever the A/C was running. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the throttle body needed to be cleaned. The vehicle was repaired. The contact stated that the failure returned, and the vehicle was taken back to the same dealer who diagnosed the vehicle and determined that the alternator and belt tensioner needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 32,000.

NHTSA ODI 11584403

I have a 2016 Subaru Crosstrek 5 speed manual transmission and it only has 64000 on it. The clutch went out and I took it to the dealership to have the car worked on and hopefully repaired. At first they said it was the clutch and master cylinder. Then they called me back and said the entire transmission needed to be replaced and it would cost $9000! Seriously? At only 64000 miles? Somehow some kind of "snout" broke off and they needed to replace the whole thing. Blue Book on this car is only slightly over $9000 and I need to spend what it is worth to repair? I may never own another subaru ever again if this is what happens at such a low mileage.

NHTSA ODI 11577815

Since at least 2009 all Subaru models have a faulty air bag Clockspring. The horn doesn’t work due to this. Subaru knows about this issue. Even 2018 Forester is still using the faulty clock spring. We almost had an accident because the horn didn’t work. After researching the issue, I cannot believe a recall has not been issued. Tried to get it fixed at Subaru today. Still not fixed. We cannot drive until the horn is fixed it is dangerous driving in [XXX] and not having a horn to give a warning when you are about to be hit. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11575075

Driving at 55 miles per hour and the hood safety latch failed. Hood smashed the windshield and rained glass down inside the car. The hood hyper extended damaging the fenders on the right and left. It also damaged the plastic around the wipers. Terrifying experience. Zero visibility caused me to slam on my breaks almost causing another vehicle to hit my car.

NHTSA ODI 11570698

In three separate incidents while car only shows 70 in fuel indicator, my 2016 Crosstrek stalled while driving on a highway. I have brought my car to Subaru dealer, but they cannot find anything wrong with my 2016 Crosstrek. In each of the three separate instances after waiting on the side road for 30 minutes, I was able to restart the car and drive home. My car just had a new engine air filter replaced.

NHTSA ODI 11563783

I own a 2016 Subaru Crosstrek with only 37,000 miles. There is a problem with my battery being drained after not driving the car for several days. I have had to call for a jump start 3 times, Aug. 8, 2023, Sept. 5, 2023 and Nov. 14, 2023, each time after returning from vacation. I replaced the battery when it happened the second time, but the problem continued to occur. I have taken my car to the Subaru dealership for diagnostic. They checked the draw level in the vehicle electric system found excessive draw of 350MAH when everything was turned off. The performed DCM (data control module) check and disconnected the fuse. The draw dropped down to 15MAH. I was told I could leave the fuse disconnected, which would leave me with a useless navigation system, loss of front speakers and bluetooth, or replace the DCM that would cost me around $1000. I have done research online and found this is an ongoing problem with Subaru. There were no warning lamps, messages or other symptoms prior to the failure each time. This poses a safety risk if I am in a public parking late at night and I cannot get my car started. I have reported the problem to Subaru of America.

NHTSA ODI 11559145

See attached document from complainant

NHTSA ODI 11551572

Driving down the freeway I had cruise control set. All of the sudden the cruise control shut off and it was like the car was in neutral. When I pushed on the gas it just revved I was able to coast to an exit and right before the top of the hill, all the indicator lights went on and the car shut off. I had the vehicle towed to a Subaru dealership the next morning when they went to work on the car, the car started fine. They were unable to find anything wrong with the vehicle when they plugged it into the computer. My gas levels were low, but I still showed 90 miles to empty.

NHTSA ODI 11549936

While at posted highway speeds through twisting roads, the vehicle developed a wheel vibration. Stopped to inspect the wheels, found right rear wheel missing 4 of 5 lug bolts. Lug bolts were sheared off. Vehicle has 81,000 miles, tires rotated 7 months prior to this event.

NHTSA ODI 11548933

I have a 2016 Crosstrek. It hestitates when you start after a stop. I have taken it to the dealership. They feel the hesitation but do not know what the problem is. The cost they estimated to fix was over $1,000, BUT with no guarantee they could fix it because they do not know what the problem is. It is not the fuel. After looking online Subaru problems, this seems to be a problem with Subaru. The safety issue, I am afraid of, when you are at a busy intersection and start to pull out in traffic what if the car stalls. It hasn't stalled yet, so far just hesitating upon initial acceleration.

NHTSA ODI 11543159

While driving down the highway, the hood popped open and slammed backwards, shattering my windshield, damaging both fenders (to the point where the hood could not be lowered back down), and wrinkling the roof. I was in the middle lane and had to navigate blindly over to the shoulder, while covered in glass; miraculously, I was able to do so safely. It is a miracle I was not hurt or killed and that others around me were not hurt or killed. There was very real potential for a multi car pile up that day. I'm not aware of reproduction or confirmation of the problem. Police responded, but stated since I did not hit anything, there would be no accident report. My insurance inspected the vehicle at least twice, as did my mechanic throughout the course of his estimation and repair. At my last oil change at the dealership (months prior), the desk agent mentioned the auto techs had a hard time getting my hood closed but recommended no further service to me.

NHTSA ODI 11537967

Sunroof exploded - driving on interstate at about 75 miles an hour, Sunday around 11:30a, temperature around 80 degrees, no flying debris, heard something like a small explosion and then shattered car glass blowing along roof. Pulled over to see the sunroof looked like it had blown up and out leaving hole about a foot wide. The interior ceiling panel had been closed so I couldn't see it from the inside, no damage to the interior panel that I could see. The car had been parked under my car port overnight, I'd been on the road about 15-20 minutes, no drastic changes in weather and no sounds from roof before explosion. No apparent damage to car/roof prior to explosion.

NHTSA ODI 11525326

In October 2020, the OEM transmission on my 2016 Subaru Crosstrek failed at 87,500 miles. The transmission was covered under a recent extension of the warranty from 60,000 to 100,000 miles. See website info regarding extended warranty: https://static.nhtsa.gov/odi/tsbs/2018/MC-10146475-9999.pdf After driving the "new" transmission for 18 months and 40,000 miles, the transmission failed again. This time, Subaru America refused, at first, to admit any fault. They initially offered $1000 for replacement, then increased to $3500 as a final offer. My out of pocket was $4710. Now, after 8 months and less than 12,000 miles, the transmission has failed AGAIN. This transmission is under a 1 year/unlimited miles warranty. This will be the 4th transmission in a vehicle with 143,000 miles on it.

NHTSA ODI 11522109

Car caught fire from what seemed to be an electrical issue. Car became engulfed in flames within a few seconds. Fire department was called to extinguish the fire. I was lucky myself to make it out in time. The fire became so big, so quickly, I was concerned for the safety of the surrounding property. Luckily, no one was injured and no property damage took place. Car was inspected and totaled by insurance. The headlights were constantly needing to be changed. Otherwise the car was fine. I had just replaced the battery and just a few hours later the fire happened. The fire appeared to start somewhere under the hood on the passenger side.

NHTSA ODI 11517135

On 3/30 my steering column started to make a grinding sound when I turned my steering wheel over 90 degrees to make a turn. On 3/31 the airbag light went on and I made an appointment to bring it in to get looked at by my nearest Subaru dealership (Tacoma Subaru). I was told the light meant the airbags would not deploy if I got into a car accident so I didn’t drive my car until I needed to pick up grocery order on 4/2. On 4/2 I was making a slow right hand turn into the parking lot and my airbag deployed as I turned and hit/burned my forearm through a heavy sweatshirt. I didn’t bump it, experience an impact or accident of any kind. It simply deployed while I was turning without any warning.

NHTSA ODI 11515282