What 1,536 owners told NHTSA about the 2016 Hyundai Tucson Fuel Cell

The contact owns a 2016 Hyundai Tucson. The contact stated while the vehicle was parked, the contact attempted to open the rear driver’s side door from the inside and the door failed to open. The contact exited the vehicle from the rear passenger’s side door. The next day the contact attempted to open the door and the rear driver’s and passenger’s side door would not open. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 103,000.

NHTSA ODI 11434133

The doors on the passenger side of the car will not open from the outside or inside. My car was not hit. I have been in no accidents, but the just do not open anymore. My driver side door takes two attempts before it opens. The only door that works like it should is the back-seat driver side door. No warnings. This happened months ago, but I was out of warranty. The dealership service department told me $350 per door to repair. Found that hundreds of owner of this make/model experience the same. Totally unsafe that only 1 of 4 doors function properly.

NHTSA ODI 11433958

This vehicle is under recall for its antilock braking system. I brought the vehicle to a dealership on 10 April for the repair. They didn't have the necessary parts in stock. When I called back two months later. Still no parts. It's now been more than 5 months. Which I believe to be proof that the dealership is "unable to remedy the defect within a reasonable time." Instead of responding to calls, Jim Ellis Hyundai of Atlanta (5785 Peachtree Blvd, Atlanta, GA 30341) puts me on hold indefinitely. I'd really like to be able to use my garage again.

NHTSA ODI 11433598

The vehicle issue began with needing an engine check light. Searched for a recall but there wasn't any engine recalls online for my VIN number. Took the car to the dealer for a recall and they did the recall on some electrical wire that was separate from the engine issue but they just overlooked the engine check light on my dashboard and made no mention of it. They actually bypassed it and so I thought maybe they fixed the issue since the light isn't present anymore. However the engine light came and the problem developed into a transmission failure. Upon pressing the gas pedal, the vehicle wouldn't run over 30 miles per hour and could only go up to 4 rpms.. I took the car to the mechanic and he replaced the transmission and he said that the root cause was a result of a burnt gasket. So we had that replace also.. After spending $5000 in repairs, the motor or the engine completely overheated and now the car is just a potato. Another issue is the doors on my car and not opening anymore. I have to manually ply them open by pulling on some mechanical wiring inside the door. Why do I have to pay for bad engineering? This is an obvious risk.

NHTSA ODI 11433599

Both of my rear doors will not open. It started with the rear passenger side door and as of two days ago now my rear driver side door will not open either. I am also having some problems with my driver door, sometimes it won’t open until the second try. I searched online and this seems to be a common problem. This is a safety concern, I am not sure how there isn’t a recall for this.

NHTSA ODI 11433515

Back rear doors do not unlock. No matter how many times you press the unlock button they just do not unlock. Nothing has been done to the doors or just started out of no where. This is a huge safety problem. If there is a crash or emergency there's no way for the back doors to open. It started with one door and now the second is doing the same thing. You have to either push the door in trying to get in or pull the door towards you if your trying to get out. I looked into this and there are several other complaints about the same thing.

NHTSA ODI 11433379

Once my car door is unlocked from the outside it WILL NOT open! My son also owns a 2016 Hyundai Tucson and the SAME thing is happening. I have been hearing of this happening for many, many more Hyundai owners. IT IS A SAFETY ISSUE as one is unable to get into the car or get out of the car. This could pose a risk in the event that my granddaughter is stuck in the car under dangerous circumstances or that I am or if someone with a physical limitation is in the car...needing to quickly exit the car OR even to quickly gain entrance to the car. I have read other owners' posts about the blasé, even bored, responses from Hyundai and that just diagnosing the issue costs around $100. Also, even if the car is still in warranty and the item is replaced, one still has to pay for labor! It will also cost around $4000 to get all 4 doors repaired. RIDICULOUS!! While this is a major inconvenience, it also puts the driver and passengers in DANGEROUS risk of injury just to get out of the car! Hyundai HAS AN OBLIGATION TO MAKE THEIR VEHICLES SAFE. This should be a safety recall and 100% covered by Hyundai. Thank you

NHTSA ODI 11433237

The vehicle is slow to accelerate on and doesn’t change gears quickly, often stays in a neutral mode which doesn’t allow acceleration. Vehicle doesn’t move when gas is pressed which can cause a major issue when driving on the roads. It is very dangerous and I believe my vehicle should be included in the August 29, 2016 recall.

NHTSA ODI 11433283

Both front doors no longer open from outside. Started off as intermittent and has gotten progressively worse sometimes I cant get them to open from inside either. This is a huge safety problem.

NHTSA ODI 11433053

The lock actuator on the driver's side door failed. The door cannot be opened, even when the car is unlocked. This creates a hazard if one is required to exit the vehicle in an emergency. There have been numerous owners reporting the same issue on different door in the 2016 Tucson.

NHTSA ODI 11433106

The transmission will fail to deliver power to the wheels when starting from a stop. You will hit the gas and nothing will happen for a beat, before kicking in suddenly. this creates a safety issue, especially when turning left, as it can leave you stranded in front of traffic. Multiple Tucson owners have reported the same issue with their transmisison.

NHTSA ODI 11433107

The transmission on this vehicle has always functioned erratically. There has been a recall on the transmission control module. On June 12th, as I was driving the vehicle in traffic, I heard an odd clanking noise and felt a loss of power. I was driving up a hill with traffic behind me. The car stalled for several seconds, and I was unable to make it move. It then reengaged and lurched forward. It drove normally for several seconds and then did the same thing two more times, all while climbing this hill with traffic behind me. I was able to make it to a friend's house close by, but when I went to leave, it turned out that the transmission was non-functional. I was unable to put the car in reverse, or move it in any direction. It had to be towed to a Hyundai dealer and a new transmission installed. The vehicle had 81K on it when this happened.

NHTSA ODI 11432770

The front driver door handle on the outside is not opening! I have to pull on it about 25 times for it to open. This is a safety issue because I cannot get in or out of my car. This is very unsafe and the manufacturer is quoting me over 200$ to fix this commonly known issue!!

NHTSA ODI 11432531

Both back doors fail to open from the inside or outside and the front doors are starting to fail as well.

NHTSA ODI 11432343

The contact owns a 2016 Hyundai Tucson. The contact stated while driving 40 MPH, the vehicle lost motive power with the check engine warning light illuminated. The contact pulled over and had the vehicle towed to a local dealer. the vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and was awaiting a response. The failure mileage was approximately 116,000.

NHTSA ODI 11432211

We have had 3 doors malfunction to the point where they can't be opened (even from the inside) and need to be repaired. This is a safety issue because it could prevent safe exit from the car in the event of an accident. This is a commonly reported issue with 2016 Tucsons and should be the subject of a recall. For more information see here: https://www.hyundai-forums.com/threads/rear-passenger-door-wont-open.603329/page-4

NHTSA ODI 11431958

Very common problem in the 2016 Hyundai Tucson that is a safety hazard. The locking mechanism becomes unresponsive and the doors can only be unlocked from within. The driver door in this vehicle specifically can no longer be unlocked from the outside. In case of an emergency situation the driver would ne be able to be pulled by opening the door, the window must be broken or someone else must enter the vehicle to unlock the driver side door from within, assuming the doors are unlocked.

NHTSA ODI 11431821

The contact owns a 2016 Hyundai Tucson. The contact stated while driving 35 MPH, the TPMS warning light illuminated. The contact was able to drive to her destination. The contact stated that currently there were multiple warning lights illuminated. The contact was unable to start the vehicle or shift out of the park. The contact took the vehicle to the local dealer who was made aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 71,000.

NHTSA ODI 11431633

Three months ago my driver's side window stuck in the up position, the next time I drove it worked fine but the time after that it stuck again. The window lock is not on, it is now permanently stuck in the up position and will not go down. One month ago my passenger side rear door stuck in the closed position. No attempt to lock and unlock worked to release it and the child safety lock is not on. It seems the handle is not engaging. These issues are not covered under warranty or by recall. I think both these issues are safety hazards.

NHTSA ODI 11431537

The latch mechanism in all doors is malfunctioning. The rear doors do not open at all and the front drivers side door only opens sometimes. This is a known defect in the design of the Hyundai Tuscon door latch mechanism. This is a safety issue because the doors are inoperable, possibly trapping a person in a vehicle.

NHTSA ODI 11431151

Rear driver side door could not be unlocked and opened. Faulty door actuator lock which has been replaced by dealer at a cost. Do not have the failed part. No ones safety put at risk. However I feel it is a safety issue as emergency egress from the rear could be affected.

NHTSA ODI 11431127

I have been having problems with the oil burning very quickly in-between oil changes. This last time, I was driving the car and it started shaking really bad. I was at a stop and when the light turned green, my car would barely accelerate. Once it did start going, it felt as though it did not want to go into the correct gear. Hyundai states that it will take about 2 weeks to fix as they have 15 other cars in with the same complaints.

NHTSA ODI 11431140

The contact owns a 2016 Hyundai Tucson. The contact stated that the vehicle failed to accelerate over 20 MPH while driving. There were no warning lights illuminated. The vehicle was taken to the local dealer and was diagnosed with a dirty catalytic converter. The vehicle was not repaired. The vehicle was taken to an independent mechanic and the contact was informed that the transmission needed to be replaced. The manufacturer was not contacted. The failure mileage was approximately 94,000.

NHTSA ODI 11431023

First, in 2019, my front driver’s side door stopped working. I could only open it from the inside if I kept my doors unlocked and eventually couldn’t open it at all and I had to crawl in and out of the passenger seat when it wasn’t working. The dealership repaired it because it was under warranty but I still had to pay for everything but the part. Now, In 2021 my front passenger door is doing the same thing. What’s worse? My rear passenger door won’t open AT ALL. I have two children and I have to pull them out of the window on occasion. We had to pull over on the freeway in an emergency and I had to PULL MY CHILDREN OUT OF THE WINDOW. If we’re in an accident I’m terrified of what will happen since we can’t use half of the doors. This is a major safety issue and I’m terrified for my family to use this vehicle. Since my warranty expired 3 months before the second and third door had the issue, it’s going to cost me over $1400 to get this repaired. I’m a single mother of two and this is causing hardship in addition to the safety issue. I’m getting it repaired and I can update with the invoice of the repairs.

NHTSA ODI 11430248

In late 2020 my airbag had to be replaced for numerous malfunctions, at the same time my passenger side front door would not open on the first try with the key fob. 8 months later, now my driver door is doing the same thing and I'm no longer under warranty. It's ridiculous this isn't a recall with so many similar complaints. My doors unlock but still won't open until I tug on it numerous times. If it stops working completely it is a real safety hazard.

NHTSA ODI 11429972