What 286 owners told NHTSA about the 2016 Ford F-250 Supercab

The contact's former employer owns a 2016 Ford F-250. The contact stated that while exiting the freeway at 45-50 MPH around a bend, the steering wheel failed to move and crashed into a tree. The contact linked the failure to NHTSA Campaign Number: 22V337000 (Air Bags). The air bags did not deploy. The contact stated that he sustained injuries to his hand, and medical attention was provided the next day at the emergency room. There was no reported fire. A police report was filed. The vehicle was towed to his employer's yard. The contact called an unknown local dealer. The contact was unaware whether the vehicle was diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 140,000.

NHTSA ODI 11713367

On [XXX], I was driving westbound on [XXX], between Kerrville and Junction, Texas. I noticed a diesel fuel smell and pulled off the highway to investigate the source. Upon stopping, fire erupted from the engine compartment and quickly spread to the front dashboard and front passenger seating area. No warning lamps, no high temp or abnormal gage levels. The Mountain Home, TX volunteer fire dept arrived about 30 minutes after we called 911 and extinguished the remaining flames. They commented that a cracked / failed secondary fuel filter housing could be to blame. My insurer, State Farm, under claim #[XXX], now has possession of the vehicle remains. I told State Farm that NHTSA opened an investigation into possible fuel filter housing failures / fires. I do not know what their intentions are with the vehicle remains. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11683811

I placed my truck in Park, exited the vehicle to assist my daughter to the truck. As we approached the front of the truck - the truck started Rolling forward. I tried to enter the driver side door to stop the vehicle but realized my truck was going to collide with the vehicle next to it and I tried to clear my body of the two vehicles. I was caught between the two vehicles near the rear driver side fender and couldn't free myself. My daughter entered the truck from the passenger side and the truck had went from Park to Drive. My daughter put the truck in Park and somehow I was able to free myself. I received injuries to my hip and pelvic area. The entire incident was recorded on a home surveillance system.

NHTSA ODI 11567093

The contact owned a Ford F-250. The contact stated that while driving at approximately 50 MPH the contact heard a loud pop from the engine. The contact stated that immediately after hearing the noise smoke started to emanate from the engine. The vehicle caught fire. The driver sustained a hand injury. Medical attention was needed. The fire department extinguished the fire. The fire and police reports were available. The vehicle was towed to an impound lot. The manufacturer was notified of the failure. The failure mileage was approximately 137,000.

NHTSA ODI 11541185

When driving my truck "2016 F250, FX4) on an open highway at 80mph out of no where, i experience what is known as the death wobble, and went off the road into the ditch. The dealership is telling me I need to pay 2000.00 plus dollars to address the problem which appears to be known and have not issued a recall. This same issue happened to my 2014 F250, and the base warranty covered it.

NHTSA ODI 11440911

VEHICLE WAS PURCHASED FROM PRIORTY FORD IN NORFOLK, VA ON SUNDAY MARCH 21ST 2021. INCIDENT #1 MARCH 22ND 2021: FRONT DRIVER'S TIRE COMPLETELY BLEW ON HIGHWAY EN ROUTE TO TENNESSE AN HOUR AND A HALF OUT OF GATLINBURG, TN. SPEEDOMETER WAS ALSO NOT FUNCTIONING PROPERLY PRIOR TO SAYING WE WERE DRIVING A FASTER THAN ACTUAL MPH (CONFIRMED WHILE USING GPS). SPARE TIRE WAS PUT IN PLACE OF BLOWN OUT TIRE, CHANGED SPARK PLUG WIRE (WHICH DIDN'T REPAIR TICKING NOISE PER MECHANIC) MECHANIC ALSO SAID WE WOULD BE GOOD TO GO WITH SPARE TIRE. INCIDENT #2 MARCH 24TH 2021: WHILE EN ROUTE TO NEXT DESTINATION (NEW ORLEANS, LA) TRED CAME OFF REAR DRIVERS SIDE TIRE CAUSING TRUCK TO GO OUT OF CONTROL ON I-59 NEAR BIRMINGHAM, AL. VEHICLE SPUN INTO GRASS MEDIAN ONTO OPPOSITE SIDE OF INTERSTATE AND WAS NO LONGER DRIVABLE. A POLICE REPORT WAS MADE AND TRUCK WAS TOWED. ADDITIONAL INFORMATION AND PROOF VIA PICTURES AND REPORTS AVAILABLE UPON REQUEST.**

NHTSA ODI 11404759

TL* THE CONTACT OWNED A 2016 FORD F-250. THE CONTACT STATED THAT WHILE HER SON WAS DRIVING 35 MPH AND TOWING A TRAILER WITH HIS ATV ON, A VEHICLE IN FRONT WAS MAKING A LEFT TURN AND THE DRIVER DEPRESSED THE BRAKE PEDAL. AN UNKNOWN WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE VEHICLE IN FRONT THAT WAS MAKING A LEFT TURN. THE VEHICLE CONTINUED 125 FEET DOWN THE ROAD, CROSSED OVER TO THE OPPOSITE LANES, CRASHED INTO SOME TREES WHERE IT EVENTUALLY CAME TO A STOP. NO AIR BAGS DEPLOYED. THE DRIVER SUSTAINED A CONCUSSION FROM HIS FACE HITTING THE STEERING WHEEL DURING THE IMPACT, MUSCLE NECK AND SHOULDER INJURIES WHICH RECEIVED MEDICAL ATTENTION FROM THE HOSPITAL. THE OTHER DRIVER SUSTAINED UNKNOWN INJURIES AND WAS TAKEN TO THE HOSPITAL VIA AMBULANCE. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY GEICO TO THE CONTACT RESIDENTS WHERE AN ADJUSTER INSPECTED THE VEHICLE AND TOWED THE VEHICLE TO A REPAIR FACILITY WHERE IT WAS DEEMED THE VEHICLE A TOTAL LOSS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT NO RECALL WAS UNDER THE VIN. NO FURTHER INFORMATION WAS PROVIDED BY THE MANUFACTURER. NO DEALER WAS CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

NHTSA ODI 11300748

TURNED ON REAR WINDOW DEFROSTER THIS MORNING WHILE PARKED IN MY DRIVEWAY. SOMETHING CAUGHT FIRE AND SHATTERED MY REAR WINDOW.

NHTSA ODI 11277321

VEHICLE WAS PARKED AT HOME AND NOT RUNNING. ENGINE BLOCK HEATER WAS PLUGGED IN. SOME TIME WITHIN AN HOUR OF PLUGGING THE BLOCK HEATER IN THE ENGINE CAUGHT FIRE AND WAS EXTENSIVE ENOUGH TO CALL THE FIRE DEPT. INSURANCE COMPANY DECLARED TRUCK A TOTAL LOSS WITH NO CAUSE OF THE FIRE DETERMINED

NHTSA ODI 11183454

I TOTALED MY 2016 FORD F-250. I SLAMMED INTO A DODGE RAM AT ABOUT 45MPH. MY F-250 BROKE THE SUSPENSION, STEERING, BENT THE FRAME, CRUMPLED THE ENGINE COMPARTMENT AND BROKE THE BRAKES. MY AIRBAGS DID NOT DEPLOY.

NHTSA ODI 11089790

TL* THE CONTACT OWNS A 2016 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED AT HOME, THE CONTACT NOTICED DARK GRAY SMOKE BILLOWING OUT THE WINDOWS OF THE VEHICLE. THE CONTACT OPENED THE DRIVER SIDE DOOR AND NOTICED THE SEATS WERE ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND NOTICED WIRES IN THE SEAT. THE FIRE DEPARTMENT UNHOOKED THE VEHICLE BATTERY, BUT WAS UNAWARE OF WHAT CAUSED THE FIRE. THE VEHICLE WAS TOWED TO A LOCAL COLLISION LOT. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 18,000. THE VIN WAS NOT PROVIDED.

NHTSA ODI 10980457