What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

I was sitting at a stop light and all the sudden my car just died in the middle of the road. I to tried to restart and my brake pedal was very hard to push down and on the dashboard it said Engine Power is Reduced. I was not able to start my car at all and had to be towed. Lights and radio were still working.

NHTSA ODI 11482712

When shifting into park a dash message appears saying shift to park. The gearshift is in the park position but the message still appears and some electrical devices remain on and you cannot lock the doors.

NHTSA ODI 11481616

I was sitting at a stop light and all the sudden my car just died in the middle of the road. I turned my car off and tried to turn it back on and my brake pedal was very hard to push down and on the dashboard it said Engine Power is Reduced. I was not able to start my car at all and had to be towed.

NHTSA ODI 11480673

The contact owns a 2016 Chevrolet Malibu equipped with Michelin Tires, Tire Line: The Defender, Tire size: 205/65/R16, and DOT number: B5EV01TX4919. The contact stated that the tire tread was worn in an untimely manner. The contact stated that the tires were replaced two years ago. The vehicle was taken to an independent mechanic where it was diagnosed that the quality of the tires was of a different material. The vehicle was taken to the dealer where service was denied due to the tires still having half the tread. The manufacturer was notified of the failure and informed the contact of the warranty. The failure mileage was 68,618.

NHTSA ODI 11479742

The contact owns a 2016 Chevrolet Malibu. The contact stated that there was a popping noise in the rear-end of the vehicle. The vehicle was taken to the local dealer where it was diagnosed that the rear shock absorber outer housing was coming into contact with the shock. The vehicle was not repaired. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 41,000.

NHTSA ODI 11477611

Car will not completely power down, radio and headlights stay on draining batter due to an error stating “shift to park”. Car shows that it is in park. Moving gear shift through gears and turning on and off does not reset. Only way to get car to turn off is to disconnect battery.

NHTSA ODI 11476877

When the vehicle is in drive, the display will say "reduced engine power" and will drop the car to 25mph even on the highway. I've almost wrecked from this issue. I've seen where GM has had class actions on this prior but it was never recalled.

NHTSA ODI 11476653

I was driving all of a sudden my car goes from drive to park on the freeway. Then it goes into reverse.

NHTSA ODI 11475636

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving approximately 55 MPH, the gear selector indicator started fluctuating between park(P) and reverse(R). The vehicle started to jerk and hesitate while driving. The contact was able to stop and turn the vehicle off. After restarting the vehicle, the message "Shift to Park" was displayed. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 159,000.

NHTSA ODI 11475639

The contact owns a 2016 Chevrolet Malibu. The contact stated that while her daughter was driving at an undisclosed speed, the brake pedal was firm while depressed. Additionally, the vehicle made abnormal grinding sounds with the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with brake vacuum pump failure. The dealer replaced the brake vacuum pump. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.

NHTSA ODI 11475786

The dash will say my car is in park, by listing 'P' by the odometer and the shifter is lighted 'P', but my car doesn't want me to turn it off. It tells me to 'Shift to Park'. I purchased this car from a dealership about 10 days ago, and it only has 17,000 miles on it

NHTSA ODI 11475460

my car will not go into park. i have had this problem repaired while under warrenty and now its happening again!!

NHTSA ODI 11475065

When I accelerate, it hesitates to pick up speed. Once I made it to 75mph, a warning message came on that said engine power reduced and the check engine light came on. I looked up the issue and saw that several people with the same car were having the same issues. I added a gas treatment like they suggested but the light is still on. I have not been to a dealership or mechanic shop yet due to not having the money. But if this is a common problem then Chevrolet needs to pay for repairs. If my car fails while I’m driving, I could cause an accident.I have had the throttle body cleaned before and the wheel sensors but I am still having issues.

NHTSA ODI 11474027

The contact owns a 2016 Chevrolet Malibu. The contact stated upon shifting the gear shifter into park(P), the message Shift into Park was displayed though the gear shifter was already in park(P). The contact stated that he restarted the vehicle and continuously shifted into park(P) until the vehicle registered that the gear shifter was in park(P). The contact stated that the failure was intermittent. The dealer and the manufacturer were notified of the failure and advised the contact to take the vehicle to the dealer for a diagnostic test as the VIN was not included in a recall associated to the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 46,000.

NHTSA ODI 11473855

I was driving on the freeway at about 65mph, and the car shut down on me. It was extremely dangerous to get over on the freeway with no power. 2 warning lights came on. The Stabilatrak, & the check engine light. I pulled over & called for help. I had the car taken to the service department at the dealership. They contacted me & informed me that a piston was cracked, & the ECM had to have a software update. They are charging me $5,389 to repair it. The car only has 8,000 miles on it. There are recalls for this exact problem, but do not apply to my specific VIN#. My car is a 2016, so I am out of warranty, but this should not happen with a vehicle with this low of mileage.

NHTSA ODI 11473764

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving approximately 30 MPH, the vehicle lost power steering functionality. The contact stated that the traction control and steering reduced warning lights were illuminated. There was also a message stating reduced power; drive with care. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 109,800.

NHTSA ODI 11473526

When I was driving to work, a light appeared on my dashboard stating that my "Engine Power Reduced". When I was in the left lane passing a vehicle, my car slowed down to 40pmh instead of accelerating when I had pressed the gas pedal. The car behind me almost re ended me in the process. This has happened now on a couple of occasions afterwards.

NHTSA ODI 11473369

Check engine light. Loss of power/acceleration and can’t go above 45 mph. Transmission control module?

NHTSA ODI 11472158

Car began to lose power while driving down the road, then began sputtering gas and creating black smoke. Engine pistons appear to be shot. Car has a little over 100k miles.

NHTSA ODI 11470910

Tires came on vehicle OEM Firestone FT140. 205/65/R16. The vehicle, a 2016 Chevy Malibu LS, has 25, 652 miles on it. The tires are maintained, rotated regularly, correct tire pressure etc. No signs of uneven wear, cupping etc. no wheel alignment needed etc. as per dealer. The tire tread is down to 4/32 in the rear and 6/32 in the front. Tread wear seems to be excessive for the rear tires on a vehicle with only 25K on it. I reached out to Firestone and Chevrolet. OEM tires should not be wearing out this premature. When I asked the Firestone rep about tread life they told me that they did not know what the expected tread life was on OEM tires because they were made to specifics provided by vehicle manufacturer. If I were to buy the same again now as a replacements, they have a 50K tread life warranty, nut I am concerned about the premature tread wear. I will need to replace the tires at close to $1000, an an unexpected cost with such low mileage.

NHTSA ODI 11470729

This is not a safety issue but potentially it could be & I want GM to take action. I drive a 2016 Chevy Malibu. Beginning 2017, I started getting this message after ignition “SHIFT TO PARK”. This is purely GM’s mistakes in designing the part. Solution is to replace the shifter asm completely irrespective of the warranty coverage. This is a common issue on multiple cars between 2016 to 2019, I suppose. I took the car to Ed Rinke dealer in MI back in 2018 timeframe & they said the shifter cable needs to be replaced. I did pay around $200 for the service & issue was gone for a while. It was back again in 2019-2020 timeframe intermittently. Its pretty bad now, I cannot shut the engine off & have to wait for quite sometime to get rid of the message & seriously do not know what to do. If I close the door & leave, message is still ON & battery drains out. I want GM to cover for expenses because dealership would want to diagnose when we all know what the issue is.

NHTSA ODI 11470031

When I turn my ignition button off, the dashboard on my vehicle will have the letter P showing that it is in Park, but will have a message pop up on the dash that says "Put in Park". I have to wiggle my transmission lever around while it is in park until it finally clears the message.

NHTSA ODI 11469634

All of a sudden my Pistons just went in my car the whole engine block actually. There was never any warning or anything I got an oil change and after the oil change the check engine light came on plus it said service stabilitrak. Without the stability track you can get into an accident because the car is not in control the way it's supposed to be. The Pistons being worn in the engine block going. Without any notice of anything being wrong. Causes bad emissions leaks etc. The dealership knows about it. They can't give me a reason why the Pistons and the engine block went. Or why this service to stabilitrak came on. They're trying to say it's a pipe that has a dent in it. But the entire system is rotted out it only has 34,418 mi on it.

NHTSA ODI 11467658

While in drive and at stop sign the car starts to shut off. It can be very dangerous due to the fact it completely cuts off at while in drive. There are multiple reviews on this issue on youtube and chevy review websites regarding this issue. If I did not put my hazard lights on I could have been badly hurt and even worst. Someone came to assist me off the road and I had to call pop and lock to come jump start the car and after I did that I made it home but tired to restart the car it was completely dead. By the way I have a new battery. And not Starter or alternator issues during being tested. I am so thankful my children were not in the car. This can be a life threatening situation.

NHTSA ODI 11466985

Bought car 4/27/22 with 94,602 miles. Within a week vehicle shown problems in the engine leaking oil most likely from the oil cooler causing a bad smell of burnt tire, the shocks most likely cause the car to shake once you hit 50 mph or let go off the break pedal they need to be replaced and the tail light is retaining or holding water on the inside also the hose connected to the coolant reservoir has a small leak I don’t think the clamp was placed properly by the last person who worked on it, plus how long should it take my car to cool up so far minutes and has to be on max and 2 tires are different brand

NHTSA ODI 11465600