What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

Loss of power not wanting to go faster than 25 missing and spitting and sputtering bad

NHTSA ODI 11507964

Car loses speed from 60mph to 15mph while driving. Engine Reduce Power light comes on after the fact. This is very dangerous when driving on a busy highway/interstate.

NHTSA ODI 11502981

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving 65 MPH and depressing the brake pedal, the brake pedal was firm. The contact used the parking brake to slow and stop the vehicle. The contact was able to continue driving to the residence. The vehicle was diagnosed by an independent mechanic, and the contact was informed that the vacuum pump needed to be replaced. The vehicle was repaired. On another occasion, while driving 60 MPH, the vehicle started overheating and smoking with the check engine warning light illuminated. The contact pulled over to the side of the road and turned off the vehicle. The vehicle was towed to the residence. An independent mechanic diagnosed the vehicle and stated that the engine needed to be replaced due to metal fragments from the defective vacuum pump. The dealer was contacted and stated that the vehicle needed to be diagnosed by an authorized dealer. The manufacturer was contacted and stated that the vehicle was not under recall. The failure mileage was 141,943.

NHTSA ODI 11502490

Engine/Pistons Car has 80,000 miles and the engine/pistons have gone out on this car. I have had the car inspected by the Chevrolet dealership and they were shocked that a car that has been taken care of so good with so little miles is giving me a problem so major and expensive

NHTSA ODI 11496025

The low oil pressure - cut engine off notification appeared on the speedometer & as i was getting on the freeway the car literally cut off. All the electrical worked but power to the engine & everything stopped completely.

NHTSA ODI 11495405

UNKNOWN the air bag on my dash board come on and off ALL THE TIME even if I have no one sitting in my passenger seat.I got this vehicle for the winter thinking it was going to help me save gas and be a good reliable car for my daily routine to work, school, and my kids school. But it’s definitely the opposite. I’m struggling financially and In a hole now the engine light is on and I can’t get to my destination without going more then 30-40mph because “engine speed reduce” appears on my dash board and reduced the speed and not only is this inconvenient and annoying but also dangerous I dam almost got into accident because of this I was driving in the highway about 65-70 mph when this happen with a 18-wheeler behind me not only was my daughter’s life and mine put in danger. But the person driving the 18-wheeler. He definitely lost somewhat the control to swerve my vehicle it was a miracle of god no other cars where next to us and that nothing happened.their is so many 2016 Chevrolet malibu like this that I hope from the bottom of my heart that their is some compassion for this issue where they can make the issue get recalled. To help people like me I’m struggling to make ends meet day to day and I have forcefully have to keep using my car on the daily. I have no other transportation. And like i said not only for my safety but everyone around I am not the only one with this issue if the make in model. Their is hundreds of us !

NHTSA ODI 11493400

Reduced engine power alert. Ongoing issue since 2019

NHTSA ODI 11490415

I have had several issues with my 2016 Malibu. 1st: Putting my vehicle in park sometimes it does not register that it is in park. I have to turn the car on again and try moving the shifter until it registers. 2nd: when accelerating at times i get a stabilitrak error and a check engine light that causes a loss of power. This can happen in the middle of the highway which will cause an inevitable accident. 3rd: saving the best for last. Thw vehicle has recently lost power while driving and won't allow acceleration. Once i stop the vehicle stalls out completely and won't register the gears so i can't out it into park or anything. I was stuck at an intersection and couldn't move. It wouldn't turn fully off because it didn't register it was in park. And it won't turn on or start because it isn't on or off. I maintain my vehicles and correct all fixes recommended. Brought it in to have the issue looked at and was told that there were A LOT of error codes. They cleared them. But this has gotten ridiculous. GM needs to figure their stuff out..

NHTSA ODI 11487941

The engine light has illuminated due to a cylinder 1 misfire and ECM lost connection with the fuel pump which also caused problem with the pistons on the vehicle. All of these issue are related to the engine and it’s only 94,343 miles on the car

NHTSA ODI 11483843

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving approximately 55 MPH, the vehicle stalled. The contact stated that the engine power reduced warning message was displayed. The vehicle was towed to the residence. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 166,132.

NHTSA ODI 11483213

I was sitting at a stop light and all the sudden my car just died in the middle of the road. I to tried to restart and my brake pedal was very hard to push down and on the dashboard it said Engine Power is Reduced. I was not able to start my car at all and had to be towed. Lights and radio were still working.

NHTSA ODI 11482712

I was sitting at a stop light and all the sudden my car just died in the middle of the road. I turned my car off and tried to turn it back on and my brake pedal was very hard to push down and on the dashboard it said Engine Power is Reduced. I was not able to start my car at all and had to be towed.

NHTSA ODI 11480673

When the vehicle is in drive, the display will say "reduced engine power" and will drop the car to 25mph even on the highway. I've almost wrecked from this issue. I've seen where GM has had class actions on this prior but it was never recalled.

NHTSA ODI 11476653

When I accelerate, it hesitates to pick up speed. Once I made it to 75mph, a warning message came on that said engine power reduced and the check engine light came on. I looked up the issue and saw that several people with the same car were having the same issues. I added a gas treatment like they suggested but the light is still on. I have not been to a dealership or mechanic shop yet due to not having the money. But if this is a common problem then Chevrolet needs to pay for repairs. If my car fails while I’m driving, I could cause an accident.I have had the throttle body cleaned before and the wheel sensors but I am still having issues.

NHTSA ODI 11474027

I was driving on the freeway at about 65mph, and the car shut down on me. It was extremely dangerous to get over on the freeway with no power. 2 warning lights came on. The Stabilatrak, & the check engine light. I pulled over & called for help. I had the car taken to the service department at the dealership. They contacted me & informed me that a piston was cracked, & the ECM had to have a software update. They are charging me $5,389 to repair it. The car only has 8,000 miles on it. There are recalls for this exact problem, but do not apply to my specific VIN#. My car is a 2016, so I am out of warranty, but this should not happen with a vehicle with this low of mileage.

NHTSA ODI 11473764

Car began to lose power while driving down the road, then began sputtering gas and creating black smoke. Engine pistons appear to be shot. Car has a little over 100k miles.

NHTSA ODI 11470910

This is not a safety issue but potentially it could be & I want GM to take action. I drive a 2016 Chevy Malibu. Beginning 2017, I started getting this message after ignition “SHIFT TO PARK”. This is purely GM’s mistakes in designing the part. Solution is to replace the shifter asm completely irrespective of the warranty coverage. This is a common issue on multiple cars between 2016 to 2019, I suppose. I took the car to Ed Rinke dealer in MI back in 2018 timeframe & they said the shifter cable needs to be replaced. I did pay around $200 for the service & issue was gone for a while. It was back again in 2019-2020 timeframe intermittently. Its pretty bad now, I cannot shut the engine off & have to wait for quite sometime to get rid of the message & seriously do not know what to do. If I close the door & leave, message is still ON & battery drains out. I want GM to cover for expenses because dealership would want to diagnose when we all know what the issue is.

NHTSA ODI 11470031

All of a sudden my Pistons just went in my car the whole engine block actually. There was never any warning or anything I got an oil change and after the oil change the check engine light came on plus it said service stabilitrak. Without the stability track you can get into an accident because the car is not in control the way it's supposed to be. The Pistons being worn in the engine block going. Without any notice of anything being wrong. Causes bad emissions leaks etc. The dealership knows about it. They can't give me a reason why the Pistons and the engine block went. Or why this service to stabilitrak came on. They're trying to say it's a pipe that has a dent in it. But the entire system is rotted out it only has 34,418 mi on it.

NHTSA ODI 11467658

Bought car 4/27/22 with 94,602 miles. Within a week vehicle shown problems in the engine leaking oil most likely from the oil cooler causing a bad smell of burnt tire, the shocks most likely cause the car to shake once you hit 50 mph or let go off the break pedal they need to be replaced and the tail light is retaining or holding water on the inside also the hose connected to the coolant reservoir has a small leak I don’t think the clamp was placed properly by the last person who worked on it, plus how long should it take my car to cool up so far minutes and has to be on max and 2 tires are different brand

NHTSA ODI 11465600

I purchased this car new and continue to own it. During the past 6 years I have had this engine issue several times. I purchased this car from a Chevy dealership, [XXX] u now [XXX] in Flint, who denied there was a problem several times. In the past week, I was driving North on I75 from Edgewood KY and, once again, my engine power cut out. I had a semi behind me, a semi ahead of me and a semi at left side of me, all driving at 70 miles an hour. I was near the Middleton exit. My car would not go faster than 35 mph. I immediately put on my flashers and exited the expressway in about 3 miles. I and my dog could have been killed. This engine issues has occurred more than a dozen times, with no assistance from NHTSA. I ashamed that your organization has Never addressed this issue with a recall. [XXX] “INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11462953

being unable to shift the vehicle into park. And when it is in drive and my car turns off because of the auto stop feature and turns back on it stated to act crazy and glitch …this really scares me because when I am on the road and my kids are in my car the car shuts off. Very dangerous situation and I can’t believe that there is no recall in place for this. This is such a liability on GM knowing about this issue and not paying for the repairs and leaving it up to the owners expense knowing that this is a malfunction in the Chevy Malibu‘s

NHTSA ODI 11461894

I was driving to the clinic I go to everyday in the mornings I was in the freeway going about 70mph when suddenly I get a msg saying “engine power reduced” also engine light came on and the car starts slowing down and it’s not letting me go more than 20mph on the FREEWAY! I could have caused an accident, (this is very unsafe specially since my 2 and 4 year old were in the car with me) I got off on the next exit and pulled in to a gas station and turned the car off and waited about 10 mins I turned the car back on and the msg was gone but the engine light was still on about a minute or 2 later the msg comes back on so I have to pull over again, it did it about 5x before I can make it to my destination not to mention the way back home I had to stop about 3x more. This is very unsafe and something has to be done as it is not only my car with this problem.

NHTSA ODI 11458678

May car loses power when acceleration I don't why but there is something going on

NHTSA ODI 11458124

I was driving my car home from work and all of a sudden my car starting showing in the dash engine power reduced. My car literally couldn't go anywhere. So I pulled over and shut the car off for a minute started it back up and it was running great and then I happen again a few minutes later. So I took it to the dealership were i purchsed it and they replaced the gas pedal they said a sensor was bad and that was causing the problem.So picked up the car a couple days later and it happen again about two weeks later...

NHTSA ODI 11458179

My problem started with the engine first sending me a code “reduced engine power” and this code would appear one week and gone the next. I have taken it to mechanics and had parts replaced and temporary fixes. After getting it back from the mechanic and them telling me that the cylinder one isn’t holding the correct pressure and the exhaust value is burnt due to the consistent auto engine shutoff. The day I got it back on the road the engine went full shutdown at a stop light and would not turn on immediately. I was lucky enough to get it running long enough to crawl into a gas station and get a tow truck to come pick it up and tow it back to the mechanic shop and that’s where it’s been sitting there till I find a new engine to replace it.

NHTSA ODI 11457568