What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

My car was started shaking really bad and the stabili trak sensor came on. My engine had to be replaced in February 2023. My car was at 66K miles. I rarely drove it. I worked from home for 3 years due to the pandemic. I purchased the car with about 12K miles. I was on my way home and my car just shut off. I could not get it to start at all. The stabili trak light came on. This was in January 2024 with 75K miles. The tow truck driver told me he had picked up multiple Chevrolets experiencing this same issue. It took the dealership almost two months to figure out that the crank sensor needed to be replaced.

NHTSA ODI 11585903

I bought this car August 2013 and I have been constantly having issues with it I contacted the BBB they showed them a check off list of the problem I was having to quiet them I was having rear in issues that they claim they did a full exspection of the vehicle which isn't true they tried to give me excuses now the car shows it's in part but it's saying action is required the car isn't in parking made a video on my phone so they can't make a excuse this should be a recall because I have read reviews with people having the same problem not once but two times after the first repair and it's not fair to the consumer someone need to investigate the dealerships.I can't get my video to upload I do have a short video on my cell phone

NHTSA ODI 11581998

The contact owns a 2016 Chevrolet Malibu. The contact stated that while driving at approximately 55 MPH, the vehicle began shaking violently and she observed a loud noise emanating from the engine compartment. The vehicle was stopped but the failure persisted. The vehicle was taken to an independent mechanic who stated that there was no oil in the vehicle, and several unknown codes appeared on the diagnostic machine. Oil was administered to the vehicle. The contact stated that two days later the failure persisted. The vehicle was taken to an independent mechanic where it was diagnosed that the blown head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 176,051.

NHTSA ODI 11578631

Reduce engine power warning ️ losing power on highway and shift to park warning ️

NHTSA ODI 11577823

Vehicle engine light reported codes P050F, FE8:engine, and FE9. It was determined the Brake Booster Vacuum Pump was leaking oil and was faulty. It has been replaced and brakes better. Engine light went off. The other diagnostic by my mechanic showed the Oil Control Intake and Exhaust Variable Valve Timing (VVT) Solenoid needed to be replaced too.

NHTSA ODI 11575171

I am very upset right because I purchased this Chevy Malibu 2016 from Vroom. It was fine at first and then things start to go downhill. For starters my tire light came on first only a week after having the car, then the shift into was appearing on the dashboard as well as the engine light. Then my husband spent almost 2000 on the brakes because the car was making this horrible sound and I almost couldn't stop the car because the pedal was stuck and would not push down. Thank God no one was hurt. Then my car just shut off twice one day at a busy intersection, it went completely dead with my children in the car. This is a ongoing issue. Now I had a diagnostic test ran on my vehicle and it was said I needed a new motor only after having the car for only a year. This car is very dangerous and I wish they would take it off the market, because it will also reduce your speed while driving out of nowhere. Chevrolet should be responsible for all problems before they are aware of these issues!

NHTSA ODI 11571862

My car enters a reduced engine power mode causing my car to slow down during high speeds with a potential acciden…. the Malfunction Indicator Light (Check Engine Light) will illuminate, the ‘Engine Power is Reduced’ message will display. I have called GM and was told it wouldn't be covered, I have talked to the dealer and taken it in before but I can't afford to keep paying a $150 fee to have my car looked at. I have been having this issue since April

NHTSA ODI 11558039

I was driving about 70mph on a highway trying to pass a semi-truck. As I signaled right blinker to merge back into the right lane, the speed reduced to 40mph without notice. I then seen a notification on the dashboard saying "Engine Power Reduced". The car would not accelerate fast enough to clear the truck therefore almost causing a collision of 2 semi-trucks and myself. I was forced to drive off road to help avoid the collision. My fiancé was in the passenger seat when this happened on 11/25/2023. He then began telling me this happened to him a few months prior but he didn't mention it because it resolved itself. This was actually the 3rd time it had happened in this car over the last 2 years. I spoke to the chevy dealership about it the first time I experienced this and they advised that it had not been made a safety recall at that time yet, but the technician who helped me said his son experienced the same thing and it was becoming quite common. It still has not been recalled but there is currently a class action lawsuit because of this. I feel this is very dangerous and what I considered to be reliable transportation, is no longer the case for my family after this experience. This needs to be recalled immediately before people lose lives. Especially since the parts were Manufactured incorrectly and Chevrolet had knowledge prior to releasing 2016-2018 vehicles.

NHTSA ODI 11556784

Bulletin 19-NA-122 that General Motors posted about my specific car having future engine issues happened to my car right after their mile limitation. They said due to my miles being pass the number and although I’m with in the 10 year window they cannot do anything for my car. I was driving in the high way using cruise control then my car just randomly slowed down on the highway, my stabilitrack sign came on and my check engine sign started to blink and my engine started to shake my car. Very dangerous and I was not notified about these issues a single time I took my car to the dealership when it was within the time frame.

NHTSA ODI 11555111

My 2016 Chevy Malibu that does not have many miles on it is shifting into, Reduced Engine Power Mode. When this comes on I cannot accelerate up to speeds and can only go about 25 MPH. It is dangerous that my car can go from highway speeds to this slow. I have had 0 issues before this started happening and other Malibus have been recalled for this same issue.

NHTSA ODI 11554408

Engine losing power going highway speed acceleration will not work

NHTSA ODI 11547596

Acceleration to the engine malfunction no power to engine going excessive speeds on interstate failure light appeared car shut off one stopped car turn right back on. I’ve reported this incident of the last two years to the dealership GMC to 2016 Chevy Malibu that has already had this instance back in 2019 and now has occurred at once again mileage since the last engine was replaced is 10,000 miles on the new engine

NHTSA ODI 11547600

My 2016 Malibu is a piece of shit. Randomly, and this cannot be anticipated or reproduced, I will be driving and the car will say "engine power has been reduced". This is dangerous! It takes me from 70 mph on the highway to 15 mph almost immediately. I cannot speed up. It has almost caused at lease 5 accidents. It happens on the freeway, regular roads etc. and Chevrolet refuses to issue a recall to fix it. I can't take it into a dealership because it cannot be reduced and Chevrolet was EXTREMELY rude. They said you issue recalls and I need to contact you. The most recent date this happened was 9/25/2023 but it has happened many other times.

NHTSA ODI 11547033

The engine only has 78K miles on it. I took it in because I received a notification that said stabilitrack. First I had a mechanic change the spark plugs, then I was told I had to take it in for a bigger issue with the engine. I was told it would cost $2500 just to break down the engine and diagnose it. Then I was quoted 11k on top of that to completely replace the engine. 78k miles and the engine needs replacing for more then the car is worth. The diagnosis was that I had a piston crack and the whole engine was ruined.

NHTSA ODI 11542541

What component or system failed or malfunctioned, and is it available for inspection upon request? The engine oil pressure control circuit is stuck. How was your safety or the safety of others put at risk? I was driving when all of a sudden my car would not let me speed up to the speed limit and almost caused someone to rear end me. Has the problem been reproduced or confirmed by a dealer or independent service center? Dick Allen's in Meadville as well as AutoZone who read the code Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning until the light came on and the car slowed down. This is the 3rd time this has happened. Previously I was told to put Cataclean into my fuel to help which it did but it seems to only be a temporary solution.

NHTSA ODI 11542260

I was driving down the interstate when all of a sudden my information center on my was driving down the interstate when all of a sudden my information center on my 2016 Chevy Malibu popped up a warning, reduced engine power and drop me down to 20 mph without warning. I barely made it to the side of the road before being run over by 18 wheelers all around me. Once I got it home I read the code, and it shows there’s not enough power going to the turbo in the engine that’s caused by the accelerator sensor. When I start at low speed or from a stop in attempt to accelerate the car hesitates to the point I can’t pull out with any cars around because I will be hit. I’ve been told this is a known problem for the vehicle and it’s a $500 part to fix. It’s extremely dangerous and I am so shocked there has not been a recall for this, it is putting everybody that is in one of these vehicles in danger

NHTSA ODI 11540588

Shift to park displayed when gear was already in park I was traveling on the highway when I felt the speed decline and engine speed reduced was then displayed. Thank you.

NHTSA ODI 11531104

When driving the car and when stopping at either a stop sign or stop light, turning a corner the car will lose power and will not go for at least 10-15 seconds. when letting the brakes go and pressing the gas pedal the car does not move, pressing all the way on the gas pedal the car will take about 10-15 seconds before moving. It’s like the engine lose power and the car will not accelerate.

NHTSA ODI 11530448

Lights that alert inside the vehicle at random times but more often in the last few months are: stability trek, power steering reduced and check engine. Acceleration decreased/reduced after being idle. This prompts serious danger for myself and children when there is no power being given to the car when sitting in traffic. Multiple mechanics have diagnosed the issue. Dealership gives me the run around and isn't specific with detail if check light engine goes off.

NHTSA ODI 11527854

Intercooler pipe coming loose at multiple locations. While driving in traffic on multiple occasions the intercooler piping has “come loose” from the plastic intercooler connection and the throttle body. This causes the car to go from full power to no power instantly. I have had 3 occasions when an accident involving a semi and large passenger vehicles was narrowly avoided. This has been looked at by my local Chevrolet dealership and they say it is a very common issue and actually had a recall for the SAME ENGINE IN THE SAME VEHICLE but for 2019 models only. Please include the other years in this recall before anyone else gets hurt or worse.

NHTSA ODI 11523112

While in rush hour traffic going 75 MPH on an interstate free way in the most left lane the car entered low engine power mode without warning resulting in the car being only able to go 40 MPH and with losing the ability to easily steer. Thankfully the driver was skilled enough to manage maneuvering through traffic moving at high speeds without getting hit and able to pull over to the side of the road. After traffic slowed down the driver was able to get the vehicle home without issue and investigate the problem. As it turns our there have been multiple reports of the car having this problem due to a faulty sensor on the pedal system that GM has acknowledge through extending the warranty on that specific part but has not been required to issue a recall on it despite the chance of death from an accident at high speeds that could occur from this issue happening without warning. The vehicle was taken to a dealer who confirmed it was the defective sensor.

NHTSA ODI 11520408

While driving, my car will read reduce power engine, and go to 40mph and then i have to pull over and turn off my car and restart, sometimes it will dismiss the problem and drive normal but sometimes it goes right back to reduce power engine and 40mph again. My gears sometimes will be stuck in park.

NHTSA ODI 11520091

The contact owns a 2016 Chevrolet Malibu. The contact stated that the check engine warning light would illuminate intermittently whether the vehicle was idling or while driving at various speeds. The contact stated there was an abnormal sound of liquid moving around in the dashboard and underneath the hood while driving, especially while accelerating. The contact took the vehicle to the dealer who diagnosed the vehicle and determined that there was an engine misfire. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 92,500.

NHTSA ODI 11512938

Reduce engine power on dash I have received this message twice. Car goes to 60mph and it drops down dramatically to 20 mph this could case a big accident and gm needs to fix this problem immediately. This is a car I do not recommend it's been nothing but problems.

NHTSA ODI 11510918

Problem with losing power in auto stop

NHTSA ODI 11509022