What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

REAR SEAT BELT WILL NOT RETRACT. WILL NOT ENGAGE INTO PARK WHEN CAR IS TURNED OFF. TRUNK, BACK SEAT, HEADLINER, ENTIRE CARPETED FLOOR, FRONT SEATS GET WET WHEN CAR IS WASHED OR IT RAINS. MOLD IS BEGINNING TO GROW INSIDE TRUNK AND HEADLINER.

NHTSA ODI 11569220

Shift to park message appears on dash screen when car is attempting to shut off ignition when shifter is in park position. Can't turn off car.

NHTSA ODI 11560964

Shift to park message while in park position when attempting to shut off car; I can't cut off car without making many tries. this has happened before dealer repairing the problem and within two years dealer installing new "fix.".

NHTSA ODI 11560968

*Accelerator Pedal Position Sensor- It is available upon request. * Due to the malfunction of the accelerator Pedal Position Sensor, the check engine light comes on and it flashes "engine reduced power" which slows the car down to a very low rate of speed not allowing the driver to go any faster. I was on the highway going speeds of around 75mph and that light came on and slowed my vehicle down which caused the car behind me to almost run into the back of my vehicle. I've had this occurrence with this problem several times. * UNKNOWN *UNKNOWN *No, absolutely nothing prior to the check engine light and "engine reduced power". The issue is sporadic and happens at any given moment. There is no warning that alerts when this happens.

NHTSA ODI 11560801

My car enters a reduced engine power mode causing my car to slow down during high speeds with a potential acciden…. the Malfunction Indicator Light (Check Engine Light) will illuminate, the ‘Engine Power is Reduced’ message will display. I have called GM and was told it wouldn't be covered, I have talked to the dealer and taken it in before but I can't afford to keep paying a $150 fee to have my car looked at. I have been having this issue since April

NHTSA ODI 11558039

My 2016 Chevy Malibu that does not have many miles on it is shifting into, Reduced Engine Power Mode. When this comes on I cannot accelerate up to speeds and can only go about 25 MPH. It is dangerous that my car can go from highway speeds to this slow. I have had 0 issues before this started happening and other Malibus have been recalled for this same issue.

NHTSA ODI 11554408

I'm having a problem with the car going into park. When it's in park, the doors will not lock in the vehicle will Just drain the battery.

NHTSA ODI 11550242

My 2016 Malibu is a piece of shit. Randomly, and this cannot be anticipated or reproduced, I will be driving and the car will say "engine power has been reduced". This is dangerous! It takes me from 70 mph on the highway to 15 mph almost immediately. I cannot speed up. It has almost caused at lease 5 accidents. It happens on the freeway, regular roads etc. and Chevrolet refuses to issue a recall to fix it. I can't take it into a dealership because it cannot be reduced and Chevrolet was EXTREMELY rude. They said you issue recalls and I need to contact you. The most recent date this happened was 9/25/2023 but it has happened many other times.

NHTSA ODI 11547033

The accelerates by itself while driving the car cut off and won’t crank. While driving all kind of light a signals come across the dashboard. It’s dangerous for me to drive I’ve replaced battery, alternator and map censor. My sister has a Cruze and her car is doing the something my friend has a Malibu and it is doing the same thing as my vehicle. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11535596

When the vehicle is shifted (manual transmission) from any gear into park, and the vehicle is turned off, the "Shift into Park" warning appears. I verified it was in the park. Warning stays on from 1-5 minutes, leaving all outside marker and headlights on until the sensor engages and the vehicle returns to proper state (outside marker and headlights shut off and interior dome light turns on for exiting the vehicle. This occurs each time the vehicle is driven, and the malfunction has caused a reduced battery power (eventually replacement) and outside light replacement from unnecessary use. Losing battery power has left us stranded, and the loss of outside lighting reduces our visibility for other drivers to see the vehicle. Upon research, this has been reported and reproduced numerous times to the manufacturer, dealers, and NHTSA with no solutions reached except charging the customer to repair the issue (this is unacceptable). There were no warnings and the symptoms started approximately 2-3 years after purchased in 2016 and still continue (brand new car).

NHTSA ODI 11531544

Shift to park displayed when gear was already in park I was traveling on the highway when I felt the speed decline and engine speed reduced was then displayed. Thank you.

NHTSA ODI 11531104

Ever time I put car in park it say shit to park I have to restart the car 3 or 4 time and move shift stricken more then 3 time to finally make it go off

NHTSA ODI 11527495

While driving, my car will read reduce power engine, and go to 40mph and then i have to pull over and turn off my car and restart, sometimes it will dismiss the problem and drive normal but sometimes it goes right back to reduce power engine and 40mph again. My gears sometimes will be stuck in park.

NHTSA ODI 11520091

Intermittent "Shift to Park" message started to show up when attempting to turn off vehicle. GM does have a special bulletin 19-NA-206 but doesn't have the coverage stated in it. There is also class action law suits as well so this is a common concern.

NHTSA ODI 11512691

The contact owns a 2016 Chevrolet Malibu. The contact stated that she noticed water markings located on the inner hood lining of the vehicle and water had saturated the trunk of the vehicle. As a result, the alarm started to malfunction. No warning lights were illuminated. The vehicle was taken to a body shop where it was determined that water had entered the vehicle by the windshield enclosure. The contact stated that she had the windshield replaced and the screws tightened; however, the failure recurred. The dealer was notified of the failure however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

NHTSA ODI 11511199

Problem with losing power in auto stop

NHTSA ODI 11509022

The contact owns a 2016 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle lost motive power and decelerated with the check engine warning light illuminated. The vehicle was taken to the local dealer who diagnosed that an electrical failure and power train failure was present. No additional information was available. The vehicle was not repaired. The manufacturer was not yet notified of the failure. The failure mileage was 53,000.

NHTSA ODI 11497431

Numerous times my vehicle has not allowed me to shut it off, start it, or move the vehicle because it says that the vehicle is not in park when it very clearly is. I googled the issue and found that numerous other owners have had this issue, and the tech advisor at the dealer confirmed numerous people have had this issue as well. The issue was a faulty switch in the transmission control. 2 different major safety concerns resulted because of this. First, I was unable to start my car in a very bad neighborhood for over a half hour because it kept saying shift to park to start vehicle. Second, I could not shut the car off while parked in the garage because it said shift to park to shut off the vehicle. Both times I was fully in park. This problem is widespread as a simple google search will confirm, however, GM continues to deny it is a problem.

NHTSA ODI 11491573

My vehicle accumulates moisture and has done so for the past three years or more. As a result there was mildew in the vehicle which was covered under the manufactures warranty and the vehicle was cleaned. Now fast forward a few years there’s a problem with the electrical system as a result of the moisture accumulating in the vehicle. I believe there is a manufacture defect with the Chevrolet model that is causing moisture to accumulate in the vehicle does causing electrical issues with the car

NHTSA ODI 11491629

The engine light has illuminated due to a cylinder 1 misfire and ECM lost connection with the fuel pump which also caused problem with the pistons on the vehicle. All of these issue are related to the engine and it’s only 94,343 miles on the car

NHTSA ODI 11483843

I was sitting at a stop light and all the sudden my car just died in the middle of the road. I turned my car off and tried to turn it back on and my brake pedal was very hard to push down and on the dashboard it said Engine Power is Reduced. I was not able to start my car at all and had to be towed.

NHTSA ODI 11480673

When the vehicle is in drive, the display will say "reduced engine power" and will drop the car to 25mph even on the highway. I've almost wrecked from this issue. I've seen where GM has had class actions on this prior but it was never recalled.

NHTSA ODI 11476653

I was driving all of a sudden my car goes from drive to park on the freeway. Then it goes into reverse.

NHTSA ODI 11475636

my car will not go into park. i have had this problem repaired while under warrenty and now its happening again!!

NHTSA ODI 11475065

I was driving on the freeway at about 65mph, and the car shut down on me. It was extremely dangerous to get over on the freeway with no power. 2 warning lights came on. The Stabilatrak, & the check engine light. I pulled over & called for help. I had the car taken to the service department at the dealership. They contacted me & informed me that a piston was cracked, & the ECM had to have a software update. They are charging me $5,389 to repair it. The car only has 8,000 miles on it. There are recalls for this exact problem, but do not apply to my specific VIN#. My car is a 2016, so I am out of warranty, but this should not happen with a vehicle with this low of mileage.

NHTSA ODI 11473764