What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

THE MAIN REAR WINDOW DIDN'T HAVE A PROPER SEAL. ON BOTH SIDES IN THE CORNERS OF THE REAR WINDOW OF THE VEHICLE, THERE IS A LEAKAGE. EVERY TIME IT RAINS, YOU CAN SEE WATER DAMAGE. YOU CAN ALSO SEE THE AFTER EFFECTS OF THE CEILING BEING STAINED. REALIZED THIS AFTER IT RAINED WHILE I WAS DRIVING.

NHTSA ODI 11350887

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE ATTEMPTING TO SHIFT THE VEHICLE TO THE PARK POSITION, THE VEHICLE FAILED RECOGNIZE THAT IT WAS IN PARK, WHICH MADE IT DIFFICULT TO TURN OFF AND LOCK THE VEHICLE. THE CONTACT STATED SEVERAL ATTEMPTS WERE NEEDED TO TURN OFF THE VEHICLE. THE CONTACT STATED THAT AFTER THE MOST RECENT OCCURRENCE, THE VEHICLE WAS DRIVEN TO MORAN CHEVROLET FORT GRATIOT (4511 24TH AVE, FORT GRATIOT TWP, MI 48059, (812) 202-4062) WHO REPLACED THE SHIFTER DUE TO A DEFECTIVE SWITCH. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT THERE WAS NO RECALL FOR THE ISSUE. THE MANUFACTURER OPENED A CASE REGARDING THE MATTER. THE APPROXIMATE FAILURE MILEAGE WAS 19,000. *BF *AS

NHTSA ODI 11350951

SECOND TIME IN LESS THEN A YEAR I HAVE TO TAKE MY CAR INTO THE REPAIR SHOP FOR THIS ISSUE. I WILL PUT MY CAR IN PARK, TURN OFF THE CAR AND A NOTIFICATION COMES ON THE SCREEN THAT STATES 'SHIFT TO PARK' I HAVE TO REPEATEDLY START MY CAR, SHIFT TO REVERSE THEN BACK TO PARK AND THEN SHUT OFF MY CAR UNTIL THE MESSAGE DOESN'T APPEAR. THIS SEEMS TO BE A VERY COMMON ISSUE YET A RECALL HAS NOT BEEN ANNOUNCED.

NHTSA ODI 11349692

THE VEHICLE IS DRIVING NORMAL AND SUDDENLY SHUTS DOWN FOR NO APPARENT REASON. UPON PARKING, YOU TRY TO START THE CAR, AND IT WON'T. WAIT FOR APPROX. 30 MINS AND THE CAR STARTS BUT A BIT ROUGH FIRST AND THEN DRIVES.

NHTSA ODI 11348987

I BOUGHT THIS CAR & DID NOT EVEN HAVE IT A MONTH AND THE SUNROOF WOULD START TO CLOSE AND THEN WOULD STOP AND OPEN OR GET STUCK HALF WAY OPEN. WHEN TRYING TO GET THIS TO CLOSE THE SUNROOF WOULD CLOSE WITHOUT PUTTING BEING PRESSED. THE WIRING HARNESS FAILED AND WAS BAD.

NHTSA ODI 11349073

AFTER I PUT THE CAR IN PARK AND PUSH THE BUTTON TO TURN IT OFF, IT SAYS TO SHIFT TO PARK. I HAVE TO RESTART THE CAR AND PUT IT IN REVERSE AND DRIVE AGAIN. SOMETIMES THIS WORKS, BUT IT IS GETTING MORE DIFFICULT TO GET THE CAR TO SHUT OFF. THE CAR BEEPS AT ME AND WON'T SHUT THE RADIO OFF WHEN I PUSH THE BUTTON TO TURN THE CAR OFF. I CAN'T LOCK THE DOORS BECAUSE THE CAR DOESN'T RECOGNIZE THAT I HAVE SHIFTED TO PARK. THIS STARTED HAPPENING IN JULY, 2020. AT FIRST THIS ONLY HAPPENED OCCASIONALLY. NOW IT IS HAPPENING EVERY TIME I TURN THE CAR OFF.

NHTSA ODI 11348857

TRUNK IS LEAKING AND MILDEW SMELL ALL IN THE CAR. WET ON BOTH SIDES OF TRUNK AND HOLDS WATER. GM HAS BEEN AWARE OF THIS ISSUE FOR SEVERAL YEARS WITH NO RECALLS ISSUED AND THEY WILL NOT COVER THE COST OF REPAIRS.

NHTSA ODI 11348691

MY MALIBU ONLY HAS 34K MILES ON IT AND IS METICULOUSLY CARED FOR. ON AUGUST 10TH, I WENT TO START IT. IT WOULD NOT START OR TURN ON THE LIGHTS. SO I TRICKLE CHARGED IT AND 4 HOURS LATER WHEN IT FINALLY TURNED ON I HAD THE BATTERY CHECKED. THE BATTERY IS FINE. HOWEVER, THE STABILITRAC IS NOT COMING BACK ON ALONG WITH MY CRUISE CONTROL AND LANE ASSIST. THE BACK UP CAMERA, BACK UP CAMERA LINES, CRASH AVERSION SENSORS, AND SCREEN WERE NOT WORKING PROPERLY FOR THE MAJORITY OF THE 10TH OF AUGUST AFTER THE CAR CAME BACK ON. THE SREEN HAS HAD ISSUES IN THE PAST AS WELL WITH NOT TURNING ON ALONG WITH SHOWING THE PROPER TIME, TEMPERATURE, AND MORE.

NHTSA ODI 11348728

I HAVE NOTICED A POPPING NOISE ON THE BACK END OF MY CAR FOR OVER A YEAR NOW. I WENT TO THE CHEVY DEALERSHIP WHERE I PURCHASED MY CAR. I WENT ABOUT 3 TO 4 TIMES BY THE TIME THEY COULD HEAR WHAT I WAS TALKING ABOUT. IN JUNE 2020 THEY INSTALLED WASHERS TO PREVENT CONTACT FROM THE STRUT. THAT DID NOT WORK. WHEN I LEFT THE DEALERSHIP IT WAS STILL MAKING THAT SOUND. IT SEEMS TO BE LOUDER WHEN DRIVING SLOW OR WHEN IT HEATS UP OUTSIDE LATER ON IN THE DAY. IT ALSO MAKES THAT POPPING NOISE WHEN I TAKE MY FOOT OFF BRAKE AT A STOP LIGHT BEFORE I ACCELERATE. IT MAKES THE POPPING NOISE SOMETIMES WHEN I SIT DOWN IN THE CAR. ONE DAY I WAS BOUNCING IN THE DRIVER SEAT TO SEE IF I COULD DUPLICATE THE SOUND AND IT WAS POPPING LOUDLY.

NHTSA ODI 11348495

MY SHIFT TO PARK INDICATOR DISPLAYS ON THE DASH WHEN MY CAR IS ALREADY IN PARK. THE CAR CAN'T BE TURNED OFF UNTIL THE INDICATOR GOES OFF. I USUALLY CHANGE GEARS AND PUT BACK IN PARK OR PUSH IT HARDER WHILE IT IS ALREADY IN PARK. I HAD THIS REPAIRED ON 9/14/18. THE CHEVY DEALERSHIP REPLACED THE TRANSMISSION CONTROL SHIFT LEVEL SELECTOR. IT IS NOW DOING IT AGAIN. IT STARTED THAT SHIFT TO PARK AGAIN ON 8/7/2020.

NHTSA ODI 11348498

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, SMOKE SEEPED INTO THE CAB OF THE VEHICLE. THE CONTACT STOPPED CLOSE BY AND THE VEHICLE WAS CHECKED BY HER SON AND SAW THERE WAS A VERY SMALL AMOUNT OF ANTIFREEZE LEFT IN THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE DEALER RIVERSIDE CHEVROLET (707 W 51ST ST, TULSA, OK 74107 918-446-7700) WHILE IT WAS RUNNING HOT. THE VEHICLE WAS SERVICED BY THE DEALER WITH AN OIL CHANGE AND FLUID CHECKS TWO MONTHS EARLIER. THE DEALER SUGGESTED TO LEAVE THE VEHICLE OVERNIGHT. THE VEHICLE WAS LATER DIAGNOSED THAT THE HEATER COIL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO COST. THE FAILURE MILEAGE WAS 84,000. *TR

NHTSA ODI 11343622

REDUCE ENGINE POWER AND THE BRAKES JUST CUT OFF GOING DOWN ROAD DRIVING NOT SAFE

NHTSA ODI 11343342

VEHICLE TRANSMISSION ISSUE. STABILITRAK SERVICE WARNINGS. ACCELERATION ISSUES.

NHTSA ODI 11342314

WITHIN APPROXIMATELY TWO YEARS OF PURCHASING THE CAR I EXPERIENCED SEVERAL OCCASIONS OF INABILITY TO ACCELERATE. I TOOK THE CAR TO THE DEALER BUT IT DID NOT HAPPEN WHILE THEY WERE DRIVING IT SO THEY SENT THE CAR HOME. AROUND A YEAR OR SO LATER I RECEIVED A NOTICE FROM GM OF A RECALL FOR ACCELERATION PROBLEMS. IT SAID ONLY TO TAKE THE CAR IF I WAS HAVING PROBLEMS, WHICH I WAS NOT AT THE TIME. RECENTLY I EXPERIENCED ACCELERATION PROBLEMS AGAIN AND TOOK THE CAR IN. THEY SENT ME HOME AGAIN SAYING TO BRING IT BACK IF THE LIGHT COMES ON THE DASHBOARD SAYING LACK OF POWER. I CANNOT FIND THE RECALL NOTICE I RECEIVED BUT WANT MY CAR FIXED. ALTHOUGH THIS ONLY HAPPENS OCCASIONALLY, IF IT HAPPENS ON THE FREEWAY OR ON A HILLY ROAD THIS COULD BE VERY DANGEROUS.

NHTSA ODI 11342120

DURING HIGHWAY SPEEDS, ENGINE LIGHT COMES ON, ESC WARNING COMES ON, VEHICLE LOSES POWER AND SHUDDERS. WAS MERGING ONTO FREEWAY WHEN ENGINE LIGHT AND ESC LIGHT CAME ON, CAUSING VEHICLE TO REDUCE POWER, FORCING AN IMMEDIATE REACTIONS TO AVOID COLLISION. DEALERSHIP SAYS ISSUES CANNOT BE FOUND.

NHTSA ODI 11340924

I BOUGHT MY CAR IN APRIL OF 2019. THE CAR HAS BEEN IN TWO DIFFERENT DEALERSHIPS, THREE DIFFERENT TIMES FOR THE SAME REASONS. THE FIRST ISSUE IS THAT WHENEVER THE CAR ACCELERATES FROM A STOPPED POSITION, AND WHENEVER SOMEONE IS IN THE BACKSEAT, THERE IS A KNOCKING SOUND COMING FROM UNDERNEATH THE REAR OF THE CAR. IT SOUNDS LIKE SOMETHING IS LOOSE. I HAVE COMPLAINED ABOUT THE NOISE THREE DIFFERENT TIMES, AND ALL THREE TIMES I WAS TOLD THEY DROVE THE VEHICLE (WITH PEOPLE IN THE BACK) AND COULDN'T "REPRODUCE" THE NOISE. ADDITIONALLY, I HAVE HAD THE GEARSHIFT CHANGED OUT TWICE WITHIN 8 MONTHS, BECAUSE THE CAR KEPT SAYING THAT THE VEHICLE WASN'T IN PARK AND WOULDN'T TURN OFF, EVEN THOSE IT WAS IN PARK. THE NOISE COMING FROM THE BACK IS DEFINITELY THERE, AND BASED UPON WHAT I HAVE READ, IT HAS HAPPENED TO OTHER MALIBU OWNERS AS WELL

NHTSA ODI 11339927

GETTING AN ERROR ( SHIFT TO PARK) WHEN PUTTING THE CAR IN PARK AFTER ATTEMPTING TO GO FROM DRIVE TO PARK TO TURN VEHICLE OFF. I START VEHICLE ON AGAIN AND SHIFT TO DRIVE AND BACK TO PARK AND IT THEN GOES AWAY AND SLOWS ME TO TURN VEHICLE OFF.

NHTSA ODI 11339497

THE CIGARETTE LIGHTER LOOK TO HAVE CAUGHT ON FIRE AND BURNED THE BUTTONS ABOVE IT THE VEHICLE WAS PARKED NO KEY IN THE IGNITION

NHTSA ODI 11339589

I PUT THE CAR IN PARK TURN OFF BUT I GET THE MESSAGE SHIFT INTO PARK. SOME TIMES I DO THIS SEVERAL TIMES BEFORE I CAN LOCK THE DOORS. I LOOKED UP RECALLS THERE IS A RECALL LISTED FOR THIS. BUT IT SAYS MY CAR ISN'T LISTED. THERE IS DEFINITELY A PROBLEM.

NHTSA ODI 11337512

IM GETTING AN ALERT OF AIR BAG PROBLEM AND I RECEIVED A LETTER ABOUT AN AIRBAG PROBLEM RECALL. ALSO THE BRAKE PEDAL WHICH MY HUSBAND FIXED AND A ROOF WATER LEAK WHICH MY HUSBAND ALSO FIXED.

NHTSA ODI 11337376

PROBLEM HAS HUGE ACCIDENT POTENTIAL. *DRIVING ON THE HIGHWAY IN MODERATELY HEAVY TRAFFIC. *TRAVELING AT A 65-70 MPH TO KEEP UP WITH THE FLOW OF TRAFFIC, I BEGAN RECEIVING "ENGINE POWER IS REDUCED" MESSAGE ON MY INFO SCREEN. * THE ENGINE LIGHT COMES ON (AND I IMMEDIATELY START COUNTING HOW MUCH TIME AND MONEY THIS WILL COST ME). * THERE IS A SLIGHT JERK/PULL OF THE CAR WHERE IT IMMEDIATELY STARTS A DRASTIC REDUCTION IN SPEED DOWN TO 20-30 MPH. * I'VE HAD TO PULL TO THE SIDE OF THE ROAD TO STOP THE CAR (I PRAY I AM ABLE TO DO THIS SAFELY). *EVENTUALLY, I FOUND THAT BY SHUTTING THE ENGINE OFF COMPLETELY FOR SEVERAL MINUTES, THE CAR SOMEHOW "RESETS" AND DRIVES NORMALLY. * OCCASIONALLY, THE ENGINE LIGHT WOULD GO AWAY IMMEDIATELY UPON RE-IGNITION. OTHER TIMES THE ENGINE LIGHT WENT OFF AFTER A COUPLE DAY. * THIS HAPPENED SEVERAL TIMES DURING WITHIN A (1) HOUR COMMUTE TO WORK. *TR

NHTSA ODI 11337151

VEHICLE HAS VIBRATION AND MAKES A HUMMING NOISE AT ALL SPEEDS. WHEN HARD BRAKING THE VEHICLE PULLS TO THE RIGHT. TOOK VEHICLE TO A LOCAL DOBB'S TIRE AND AUTO CENTER AND THEN DIAGNOSED VEHICLE WITH EXCESSIVE RIGHT, FRONT MOVEMENT AT THE TRANSMISSION. POSSIBLY AN INTERNAL STUB AXLE? REPAIR SHOP ADVISED THAT THERE WAS A TECHNICAL SERVICE BULLETIN FROM OCTOBER 2019 STATING THE SAME ISSUE. REPAIR SHOP ALSO HAD ANOTHER 2016 MALIBU IN FOR AN OIL CHANGE AND UPON THEIR MULTI-POINT INSPECTION THEY ALSO FOUND EXCESSIVE MOVEMENT WITH THE RIGHT, FRONT AXLE AT THE TRANSMISSION.

NHTSA ODI 11337051

AFTER I PUT THE CAR IN PARK AND TURN IF OFF, IT SAYS TO SHIFT TO PARK. I HAVE TO RESTART, MOVE IT BACK AND FORTH. IT'S GETTING MORE DIFFICULT TO CLEAR THE MESSAGE SO I CAN EXIT THE VEHICLE. THE CAR ONLY HAS 34K MILES. *TR

NHTSA ODI 11331692

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE POWER REDUCED WARNING LIGHT ILLUMINATED, THE VEHICLE DECELERATED AND CAME TO A COMPLETE STOP. THE VEHICLE WAS TURNED OFF AND RESTARTED BUT FAILED TO ACCELERATE ABOVE 30-35 MPH. THE CONTACT ALSO STATED THAT THE CHECK ENGINE WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE VIVA CHEVROLET LOCATED AT 5915 MONTANA AVE, EL PASO, TX 79925, WHERE THE TECHNICIAN DIAGNOSED AN UNKNOWN COMPUTER FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.

NHTSA ODI 11331554

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING OR PULLING OFF FROM A STOP, THERE WAS A KNOCKING SOUND COMING FROM UNDERNEATH THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO OURISMAN CHEVROLET OF BOWIE (16610 GOVERNOR BRIDGE RD, BOWIE, MD 20716), AND WAS DIAGNOSED THAT THE REAR SUSPENSION KNUCKLES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 96,990.

NHTSA ODI 11331027