What 810 owners told NHTSA about the 2016 Chevrolet Malibu Eco

The 3rd brake light broke(high mount stop lamp) which caused water leakage into the trunk and filled the compartment where the spare tire goes.

NHTSA ODI 11419430

Every month my car will randomly say engine power reduced and will go no higher than 30mph. Which has happened on the highway and is super dangerous! I have seen many reports of the same problem but nothing being done about it. I took it to the dealership I got it from and I paid $100 dollars for diagnostics and the mechanic said the car computer needed updated...alright, the next day the message came back up and car couldn’t go higher than 30. I haven’t had this car for a year, and the shocks have popping noises, and whenever I put the car in park a message will appear saying shift car to park. And I have to literally roughly giggle the lever for it to read it’s in park or my car won’t turn off. I truly love this car but it has to many issues that shouldn’t be happening.

NHTSA ODI 11419120

A power reduced engine light came on and slowed the car down to 20 miles per hour very abruptly, it was very dangerous. It keeps doing this, the engine light turns off so it can't be detected, and now we can't take it into a dealership because its out of warranty.

NHTSA ODI 11418370

Transmission problems

NHTSA ODI 11418121

MY CAR WON'T SHIFT INTO PARK SOMETIMES AND THE SUSPENSION IS MAKING A POPPIN NOISE AND MY CRUISE CONTROL IS NOT WORKING

NHTSA ODI 11416676

TL* THE CONTACT OWNS A 2016 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE OVERHEATED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE HEAD GASKET NEEDING TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ODI 11415113

FROM TIME TO TIME, THE VEHICLE DOES NOT REGISTER THE CAR IS IN PARK AND EXHIBITS A "SHIFT TO PARK" MESSAGE. IT CAN TAKE RESTARTING THE CAR UPWARDS OF 10 - 15 TIMES TO GET THE MESSAGE TO DISAPPEAR. THE CAR CANNOT BE LEFT IN THIS CONDITION AS THERE IS NO ASSURANCE THE CAR IS PARKED PROPERLY NOR WILL IT TURN OFF, WHICH COULD DRAIN THE BATTERY. IT IS A KNOWN ISSUE FOR YEARS, AND GM HAS ISSUED TSB 19-NA-206 (REV DEC 11, 2020). THIS IS WELL KNOWN AND PERVASIVE, YET GM HAS NOT ISSUED A RECALL, OR BEEN PROACTIVE ABOUT THE FIX, AND IS NOT COVERING IT OUTSIDE OF WARRANTY.

NHTSA ODI 11415057

SERVICE STABILITRAK AND ABS. IT PREVIOUSLY HAPPENED LAST YEAR AND THE VEHICLE WAS IN PARK. SINCE IT'S BEEN HAPPENING WHEN VEHICLE IS AT A SLOW CRAWL OR IN REVERSE. SOMETIMES THE LIGHT WILL COME ON HOWEVER THE JUST OF THE TIMES, WHEN BRAKING, THE CAR WILL GRIND AND STUTTER WHEN BRAKING

NHTSA ODI 11414666

PRESSING ON BREAK LOST BREAKING POWER. WAS TOLD BY MY MECHANIC BREAK VACUUM PUMP HAD ISSUE. HE SPECIFICALLY MENTIONED THE ISSUE HE FOUND DOCUMENTED.

NHTSA ODI 11414623

I WAS DRIVING IN THE RAIN ON A STREET HEADING TOWARDS THE HIGHWAY AT 40 MPH AND SUDDENLY ENGINE REDUCED POWER NOTIFICATION CAME UP AND I WAS UNABLE TO DRIVE FASTER THAN 20 MPH.

NHTSA ODI 11414529

WE GOT A CHECK ENGINE LIGHT ON. CHECKED FOR CODES AND P2097 CAME UP. VEHICLE HAS SOME HESITATION WHEN ACCELERATING.

NHTSA ODI 11414085

WHILE STATIONARY, AND READY TO SHUT OFF CAR, GET A MESSAGE TO SHIFT THE CAR TO PARK BUT IT ALREADY IS IN PARK. CAR WILL NOT SHUT OFF. HAVE TO KEEP MESSING WITH SHIFTER SEVERAL TIMES BEFORE CAN FINALLY TURN CAR OFF. THIS HAPPENED CONSTANTLY. TOOK CAR TO DEALER, PROBLEM DIAGNOSED AS TRANSMISSION SHIFTER CONTROL PROBLEM AND I HAD TO PAY $445.08 TO FIX. SUPPOSEDLY CHEVROLET RECOGNIZED THE PROBLEM IN JULY 2019 BEFORE THIS STARTED HAPPENING TO ME AND ISSUED A TECHNICAL SERVICE BULLETIN (I THINK NO. 18-NA-297) BUT THERE WAS NO RECALL DONE. MY POINT IS, IN CASE OF AN ACCIDENT AND POSSIBILITY OF FIRE, IT IS A SAFETY PROBLEM IF THE CAR CANNOT BE TURNED OFF QUICKLY. SO WHY DIDN'T THIS PROBLEM DESERVE TO MERIT A RECALL AND FREE REPAIRS?

NHTSA ODI 11413447

REDUCE ENGINE POWER LIGHT APPEARS WHILE DRIVING ON HIGHWAY. THE CAR SLOWED DOWN LIGHTS FLASHED THEN IT STATED SOMETHING ABOUT 25 MPH. IT FLASHED SO FAST

NHTSA ODI 11408008

WAS DRIVING IN 45MPH STREET WHEN I GOT A 'ENGINE POWER REDUCED' MESSAGE AND DROPPED SPEED TO 10MPH. THIS IS CLEARLY A SAFETY ISSUE AND CAN VERY WELL CAUSE AN ACCIDENT IF I'M DRIVING ON HIGHWAY OR UPHILL FOR THE MATTER.

NHTSA ODI 11407388

I WAS DRIVING DOWN THE ROAD AT 55MPH - 2-LANE ROAD (4 DAYS AGO) WHEN A WARNING CAME ACROSS MY DASH THAT STATED "REDUCING ENGINE POWER". IT SLOWED MY VEHICLE DOWN A MININUM OF 20MPH AND WOULDN'T PICK UP SPEED. THE CHECK ENGINE LIGHT CAME ON. I PULLED OVER AND TURNED OFF MY VEHICLE. I RESTARTED IT AND THE CHECK ENGINE LIGHT STAYED ON. I WAS ABLE TO MAKE IT TO AN AUTO SHOP AND THEY HOOKED IT UP. IT READ A P2138 CODE. IF I HAD BEEN ON THE HIGHWAY, THIS COULD'VE CAUSED A DEVISTATING CRASH. I FOUND WHERE GM EXTENDED THE WARRANTY AND THIS FIX SHOULD NOT COST ME ANYTHING - I WILL SEE WHEN I TAKE IT IN TOMORROW.

NHTSA ODI 11407081

ENGINE LIGHT IS ON. INVOLVED IN A COLLISION

NHTSA ODI 11406747

CRACKING IS STARTING ON THE DRIVE SIDE PANEL WHERE THE FRAME OF THE SEAT

NHTSA ODI 11406285

AS I ACCELERATED FROM A STOP, THE VEHICLE LOST POWER AND THE REDUCED POWER WARNING CAME ON ALONG WITH MY ENGINE LIGHT. I COULD NOT GO OVER 30MPH UNTIL I PULLED OVER AND RESTARTED THE VEHICLE. I WAS THEN ABLE TO PROCEED HOME AT NORMAL SPEED THE CHECK GNOME LIGHT IS STILL ON.

NHTSA ODI 11406244

THE HEADLIGHTS CONSTANT COMES ON AND BLINKS ON AND OFF AND WHEN THIS HAPPENS IT UNLOCKS THE DRIVERS SIDE DOOR I HAVE BEEN SITTING IN THE CAR WITH THE ENGINE OFF AND CAN HEAR THE FLICKERING OF THE LOCK JUST THE OTHER DAY I LOCKED THE DOOR MANUALLY IT UNLOCKED BY ITSELF THIS HAPPENED SEVERAL TIMES BEFORE IT ACTUALLY LOCK.I HAVE HAD TO LOCK THE DOORS MANUALLY FOR SOME TIME NOW. BACK IN OCTOBER 2020 IT WAS KILLING MY BATTERY CAUSING ME TO HAVE TO GET A BOOST CONSTANTLY TOOK IT TO THE DEALERSHIP THEY SAID IT WAS THE ONSTAR SYSTEM AND I PAYED TO HAVE IT REMOVED AND STILL THE PROBLEM STILL IS THERE. BATTERY WAS STILL DYING DUE TO THE LIGHTS COMING ON AT ANY GIVEN TIME AND DRAINING THE BATTERY. I DECIDED TO BUY ANOTHER BATTERY NO LONGER NEED A BOOST BUT THE LIGHT PROBLEM STILL REMAINS AN ISSUE

NHTSA ODI 11406255

I WAS COMING TO A STOP AT A TRAFFIC LIGHT. I RECEIVED AN ALERT ON MY DASH "REDUCED ENGINE POWER" AND MY CHECK ENGINE LIGHT CAME ON. MY CAR BECAME MUCH LESS RESPONSIVE TO PRESSING ON THE ACCELERATOR AND SEEMED TO BE HAVING TROUBLE GOING MORE THAN ~30 MPH. AN INSPECTION OF THE PROBLEM GAVE THE ERROR CODE P2138 AS THE SOURCE OF THE ISSUE.

NHTSA ODI 11405011

I WAS DRIVING ON A SECONDARY ROAD GOING ABOUT 45 MPH WHEN ALL OF A SUDDEN MY CAR DECELERATED TO 20 MPH IN A MATTER OF SECONDS. THE DASH SHOWED ME AN "ENGINE POWER IS REDUCED" MESSAGE AND MY CHECK ENGINE LIGHT CAME ON. I WAS ABLE TO SAFELY PULL OFF THE ROAD AND WAS ABLE TO GET HOME SAFELY. I TURNED THE CAR OFF FOR ABOUT 10 MINUTES AND RESTARTED IT AND IT SEEMINGLY IS FINE NOW BUT THIS IS TERRIBLY UNSAFE. TO MY KNOWLEDGE THERE IS NO RECALL OR ANY WORD ON THIS FROM GM.

NHTSA ODI 11405097

SHIFT TO PARK FAILURE AT 40,000 MILES.. MARCH 6, 2018 DIAGNOSED AS SHIFTER ASSEMBLY FAILURE..IN PARK.. ALERT ON DASHBOARD "SHIFT TO PARK"..IF ALERT ON DASHBOARD, AND RADIO AND OR WIPERS ON.. THEY STAY ON WITH CAR OFF. REOCCURED AT ADDITIONAL 50, 000 MILES. ON MARCH 19, 2021 .CORPORATE CHEVROLET AWARE..ISSUED REPAIR BULLETIN #18-NA-297, WHICH WAS REVISED TO 19-NA-206..MALIBU OWERS FORUM REPORT ISSUE WITH YEAR 2016-2019.. ALSO WITH OTHER MODELS..DANGEROUS...EXHAUSTS BATTERY..NOT SURE IF CAR IN PARK OR NOT ? ROLL RISK..CHEVROLET REFUSES TO FIX AS NO RECALL EXISTS..I BELIEVE WITH FREQUENT. ISSUE NEEDS TO BE ADDRESSED AND PARTS RECALLED..I HAVE GRAND CHILDREN IN MY VEHICLE AND AM CONCERNED FOR THEIR SAFETY.

NHTSA ODI 11403830

WHEN I WAS DRIVING HOME FROM WORK TONIGHT. I WAS TAKING THE RAMP TO GET ON TO THE HIGHWAY AND MY CAR GAVE ME A WARNING THAT THE ENGINE POWER WAS REDUCED AND MY CHECK ENGINE LIGHT CAME ON AND MY CAR WAS IMMEDIATELY RESERVED TO ONLY GOING 20 MPH. THIS IS VERY UNSAFE AS I WAS TRYING TO MERGE ONTO THE HIGHWAY.

NHTSA ODI 11403785

WHILE DRIVING ON THE HIGHWAY DOING 55 MPH MY VEHICLE BEGAN TO STUTTER AND THEN IMMEDIATELY DROPPED TO A SPEED OF 20 MPH. IT WOULD NOT ACCELERATE ANY FURTHER. CHECK ENGINE LIGHT CAME ON AS WELL AS'REDUCED ENGINE POWER' MESSAGE. I PULLED OVER AND SHUT THE CAR OFF, WAITED A FEW MINUTES AND RESTARTED. IT DROVE THIS TIME AT A SPPED OF 35. MADE IT HOME WITHIN A FEW MINUTES AND LET THE CAR SIT. THE NEXT DAY THE CHECK ENGINE LIGHT WAS STILL IN BUT THE CAR DRIVE AT REGULAR SPEED.

NHTSA ODI 11403017

WHILE RIDING ON THE HIGHWAY AT 70MPH I EXPERIENCED A TOTAL LOSS OF POWER. THE CAR WARNED ME AND THE ENGINE LIGHT CAME ON. I COULD NOT ACCELERATE BEYOND 30 MPH. WHEN I HAD IT CHECKED WITH A CODE SENSOR IT TOLD ME THERE WAS AN ISSUE WITH THE THROTTLE POSITION SENSOR. THE CODE WAS P2138. THIS CREATED A VERY DANGEROUS SITUATION ON A QUICK MOVING HIGHWAY.

NHTSA ODI 11402725