What 228 owners told NHTSA about the 2015 Toyota Sienna

There is an EVAP emission leak and the P0456 error states the gas cap is faulty. I had it replaced and replaced again. So I am waiting for another brand new gas cap-3rd brand new one. So 4th overall for this van. A smoke test was done and there is no leaks per the test. So if this continues after the brand new gas cap, then there should be a recall as the gas cap is an issue. Started to happen after 95,000 miles. The AWD is shut off and goes to 2 wheel drive, traction control is turned off, Check Engine light comes on and Message Check AWD system comes up on the screen. Any recommendations

NHTSA ODI 11586715

The front tires are wearing out to an unsafe tread in under 15000 miles due to the suspension in the front of this vehicle. If people are not vigilant the tires become unsafe quickly due to poor engineering on the front end.

NHTSA ODI 11586260

This vehicle is a tire eater. It does not matter what the brand of tire it is- Michelin, Bridgestone, or Yokohama, tires last, at best, 18 months of local soccer mom driving. After five sets of 50K mile, or better rated tires, at $800 to $1200 hundred per set, I think it is time that Toyota owns up to the fact that something is wrong with this model (4x2) vehicle. In my mind thjis is similar to the Toyota airbag situation only on a smaller scale. The manufacturer always has an out, such as, did the customer have the vehicle aligned, have the tire pressure checked, rotate tire on schedule, was it driven off road? My concern is that just about any driver would expect to get 30 to 40 thousand miles of normal driving from a set of premium tires. If the tires wear abnormally quickly while expecting "normal" tire mileage, this puts the driver in danger due to unexpected tire failure and possible tire related accident. This needs some data analysis.

NHTSA ODI 11579032

The intake valve became burnt/stuck, causing my car to lose all compression on cylinder 3. The CEL came on, flashing, and the car immediately started driving rough and not accelerating. I had the vehicle brought to 2 different auto shops that confirmed the issue. My and my childrens' safety were at risk as soon as we tried to turn right onto a high speed road and my car started the flashing CEL and would not accelerate. There was no warning before this incident.

NHTSA ODI 11573361

I bought this carseat in March and began using it August 2nd for my infant who was born July 31st. The straps have slowly become an issue. We try so hard to tighten the straps but to no avail. This puts my child at risk if we were to get in accident as he is not secure and the straps are still loose. I did reach out to graco who informed me I had to do a warranty claim. I am not sure yet if thet plan to do anything in regaurds to this issue.

NHTSA ODI 11557037

Cable that controls sliding door broke. Door now pops open about 1cm, not enough that you notice that it is open and when you drive it slides open more. It also can't be closed with the button and it's not easy to close.

NHTSA ODI 11550327

All interior dome/lights (door side lights, visor mirror lights, all overhead passenger lights, etc) not lighting up at all. Fuse in engine compartment is good. Vehicle has been at auto dealership where originally purchased. Safety concerns are that at night, unable to determine if there has been access by person or if person is actually in vehicle. Vehicle diagnoses was begun on 6/12/2023 and is still in process of issues. Received a call from the service representative on 6/19/2023 that water had accumulated under the fuse box in the engine compartment causing corrosion at the connection of the wire harness to the underside of the fuse box. Initially this caused the the internal lights to fail. There is much more corrosion occurring which will eventually cause a complete electrical failure and possible engine failure/fire. Current recommendation from service manager is to completely replace the wire harness at a cost of $7,000+. Insurance may or may not cover the cost of repair. The insurance adjuster is meeting today with the service manager. In my opinion, this is a serious defect in Toyota Sienna manufacturing, design and materials used.

NHTSA ODI 11527828

Door to gas tank fill breaking off. Very common problem noted online by several owners of this vehicle. If it does not close properly the engine will not start. As it begins to break at the hinge the door sticks out. I fear it will fall off one day. Dealer acknowledges this is a problem and knows there is no recall for it. I have seen other exact vans that the door has been removed completely.

NHTSA ODI 11520423

Due to poor design, air system intakes (eg under front seats) and outlets have not been protected by grilles, allowing intrusion of rodents into air system blower motor and heat box. I had rodent feces in my air filter system and blower motor and dead rodents in my heat box in Oct 2022 and has recurred in Feb 2023. Rodent intrusion in air system presents serious risk of respiratory illness to humans. Rodent infestation in vehicle can also cause startling to driver which presents an additional safety risk. Air system access should be protected by grilles at all inlet and outlet points.

NHTSA ODI 11506919

The contact called on behalf of his mother who owns a 2015 Toyota Sienna. The contact stated while his mother was driving 15 MPH, the brake pedal was depressed but failed to respond, causing the vehicle to crash into the rear of another occupied vehicle. There was no warning light illuminated. The air bags did not deploy. Both the contact's mother and the other driver received assistance from emergency units. The contact's mother sought medical assistance and was informed that she had sustained soreness in the neck muscle. The contact was unsure whether the other driver sustained any injuries. The vehicle was towed to a tow lot. The vehicle was then towed to an autobody shop but was not repaired. The vehicle was then towed to the residence. A police report was filed. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 93,955.

NHTSA ODI 11505051

My vehicle had been repaired for the recall involving the power sliding doors. The entire cable assembly was replaced. That repair has now failed and the sliding door is inoperable. The cable snapped and the driver side door will not open. I am afraid that it may open while driving, which caused the recall in the first place. I don't want to drive the vehicle for fear of the other sliding door failing as well. These repairs should last much longer than 5 years, especially something as important as the sliding door, where all the children sit. What a huge safety issue for what is supposed to be a vehicle for hauling children around. Luckily the incident happened in a parking lot.

NHTSA ODI 11500414

On a warm day after driving the van about 15 minutes then stop for 15 minutes or more. It is taking longer than usual to crank the van. I have search around online. It seems like a common problem Sienna's fuel pump. People on "SiennaChat - https://www.siennachat.com/threads/engine-starts-great-cold-or-hot-long-crank-when-warm.59549/page-2 " website is talking about it. My concern is that one day it could stall while driving on the highway. Since, it is fuel related issues. Without fuel supply engine will halt.

NHTSA ODI 11500084

We got into an accident today, and none of the sliding doors would not slide open. It would not even allow us to pull the doors opens. The vehicles electrical was damaged, but that should not prevent the other doors from opening. This is a very bad situation if someone is needing to evacuate the vehicle. The rear passengers would be trapped. Please address this issue with Toyota asap. People who usually have Vans have big families and small children. This would be a very bad situation if vehicle needed to be evacuated asap. The rear passengers would be stuck.

NHTSA ODI 11481046

I was at a stop light when I slowly started to lift my foot from the brake pedal. The engine started revving up and accelerate. I pressed the brake pedal normal , then harder when it would not stop revving. I looked down to see if I was hitting the gas pedal by accident. I was not, about after 5 seconds it stop revving. I went about a foot and nobody was in front of me. I going to have it checked out by my dealer. This happened before and I thought it was driver error .When I thought I was hitting the gas pedal and brake pedal. I searched for incidents like mine, but could not find something exactly just similar. I did not look at the dashboard so i do not know if there was a message . So I'm reporting this incident to get answers and alert others of this issue.

NHTSA ODI 11475590

When vehicle is in reverse the rear breaks on passenger side start squealing and making a loud noise when applied specially when vehicle has been stopped for while however on occasion it does it every time you back up when applying break.

NHTSA ODI 11448497

We recently had two Dunlop P 235 / 50 R 19 tires fail on our car. On 11/5/21, the front passenger-side tire tread and belt began to unravel while driving at freeway speed. This happened suddenly, with no warning lights, and we became aware of the problem when we heard a loud thumping noise from the unraveled tire striking the underside of the vehicle. We immediately exited the freeway, found a tire shop, and had the tire replaced. The following week, I inspected the other tires and found that the front drive-side tire was failing in exactly the same way. We immediately had that one replaced too. Neither tire shop that replaced the tires could identify a cause of the tire failures other than possible defects in the tires.

NHTSA ODI 11445435

Head unit kept rebooting.

NHTSA ODI 11444950

The contact owns a 2015 Toyota Sienna. The contact stated that the vehicle failed to start after several attempts. The contact stated that she was quadriplegic and was unable to exit the vehicle because the door lock switch was disengaged but failed to respond. There were no warning lights illuminated. The contact stated that she was able to jumpstart the vehicle with assistance. The contact then engaged and disengaged the door lock switch and she was able to exit the vehicle. The contact stated that she notified the modifier of the vehicle, but they said they could not assist with the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 48,000. The VIN was not available.

NHTSA ODI 11444159

The vehicle rear sliding door had a recall. I had the recall preformed at Smithtown Toyota. After the correction was done. I continue to have same issues with the drivers side rear sliding door. Where it will not open when pushing the open button on my controls in the front. Or when my child 12 years old attempts to manually open the door. As this does not happen all the times. The dealer says they can not replicate the problem and it is working to manufacture standards. I spoke with Toyota corporate and they are aware of continued problems with the sliding rear doors. the have a customer support group, but I would have to pay for the dealer to inspect the vehicle. I have extended warranty so they said I wouldn't then have to pay. However every time you take it in with a problem they can never replicate the problem. They are not the only dealer with this response. It must be a set line throughout all brands as its always that answer until your warranty expires. When it expires then all of a sudden they can find all problems and fix everything.

NHTSA ODI 11442282

The contact owns a 2015 Toyota Sienna. The contact stated while starting the vehicle he noticed that the vehicle was shuddering and shaking uncontrollably. The check engine warning light was illuminated. The contact attempted to restart the vehicle however, the failure persisted. The contact took the vehicle to an independent mechanic to be diagnosed. The contact was informed that the failure was due to low cylinder pressure on cylinder #6. The mechanic was not able to do the repair on the vehicle, so the contact took the vehicle to the local dealer who diagnosed and confirmed the failure as a misfire and low-pressure cylinder #6 and that the spark plug was damaged. The vehicle was repaired however, the failure persisted. The dealer recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 87,000.

NHTSA ODI 11440475

sunroof exploded while driving

NHTSA ODI 11436200

When I drive this van downhill on a curve not fast slower than 40mph, the antilock brakes engage violently and hard and jerky I do not have my foot on the brake when this happens. I'm not going fast. But the ABS is so violent it causes me to lose control of the steering. It happened 3 times in 24 hours and always in same situation. Only lasts a few seconds. Other Sienna owners have had same issues. 119k miles on the van. Bought it used. Had no idea. Of course dealership can't replicate the problem and won't help us. I'm scared to drive the car.

NHTSA ODI 11436113

For at least 4 years, water collects in the driver side pillar and soaks the seat belt. Toyota tells me they have never heard of this problem, although I do see it on You Tube. I don't know if the water is damaging other components. But when I pull out seat belt water pours from the pillar and onto the floorboard behind driver seat. I keep a towel in van to keep water off driver and to mop up floor & pillar. The problem is ongoing. I keep a tarp over the roof when rain is expected.

NHTSA ODI 11433547

We purchased Nokian WrG3 225/60 R18 tires as replacements for the original tires, because we wanted all weather capability. They were installed in November of 2016. One tire subsequently was damaged due to road hazard; was replaced with same Nokian tire. In August, 2021, the tires needed balancing. The dealer (same place we bought them) could not balance them because three of the tires had belt separation. I did not check tire serial number, but assume them to be the original three we purchased new. We are awaiting Nokian's response, as the tires are warranted five years from installation. It is unusual three tires would all suffer belt separation, all made at the same time. Logic would say it is a manufacturing defect.

NHTSA ODI 11432340

I have a 2015 Toyota Sienna LE that I purchased new from the dealer. The original Michelin tires had excessive wear after less than 2yrs and ~28K miles. I replaced these with Continental tires(rated for 70K miles) and after 2years and at ~63K on the vehicle miles I had to replace those with General Altimax (rated for 75K miles). Each time tires were replaced it received and alignment. I now need to replace the third set of tires at ~88k for set number four. Additionally I had to replace the Rank and Pinion (Complete unit), both tie rods and both suspension control arms and ball joint assembly and a wheel alignment. Can is adult driven mostly in town but has one long road trip on it (6K miles). This will be the fourth set of tires on a vehicle with less than 100K miles along with 5-6 alignments. All tires have been maintained and rotated. This has to be a vehicle defect as I have multiple tire manufactures, all rated for more than double the tire life I'm getting. I have $2000 in tires so far (not counting the originals) $1250 in replacing the front end components noted and now have to spend another $1k on tires.

NHTSA ODI 11430201