What 1,022 owners told NHTSA about the 2015 Ford Focus RS

TL* THE CONTACT OWNS A 2015 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE AND OIL INDICATORS ILLUMINATED OCCASIONALLY AND THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURES. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 46,000.

NHTSA ODI 11162906

ON THE DAY OF 12/7/18I WILL GO TO WORK. WHEN I GOT OUT OF MY FRIEND'S HOUSEI DROVE OUT A JUNCTION AND FOUND THAT MY STEERING WAS DIFFICULT TO TURN.THEN I STOPPED AT THE ROADSIDE AND RESTARTED THE CAR.WHEN I CONTINUED DRIVING,THE SYSTEM SHOW ME STEERING LOSSSTEERING STOP WORK.I TRIED TO RESTART MANY TIMES, THE SYSTEM STILL DIDN'T ALTER, I WAS SURE THAT MY STEERING WHEEL HAD BROKEN. BEFORE THAT, ON THE DAY OF 02/20/2018, I TRIED TO DROVE OUT MY HOUSE GARAGE. THE STEERING WHEEL BROKE DOWN ONCE, I WAS ALSO ON MY WAY TO WORK. TWO TIMES I WAS UNABLE TO GO TO WORK.I HAD TO WASTE TIME CALL THE TOWING AND CALLED MY COMPANY A LEAVE OF ABSENCE. THIS CAR SERIOUSLY AFFECTED MY WORK AND LIFE. THIS IS A TERRIBLE THINGS, IF I DRIVE SUCH A CAR ON THE HIGH SPEED,I MAY BE DEAD. THANK GOD JUST LET ME STOP IN A SAFE PLACE.THE FIRST REPAIR COST $880, AND THE SECOND REPAIR COST WAS $20504.03 (THE STEERING COST WAS $1758.05).THIS CAR HAS MAJOR HIDDEN DANGERS AND ALSO BROUGHT LOSSES TO MY ECONOMY.I HOPE THAT I CAN SAVE MY LOST.

NHTSA ODI 11162384

TL* THE CONTACT OWNS A 2015 FORD FOCUS. WHILE STOPPED ON A HILL, THE VEHICLE ROLLED BACKWARDS AND THEN FORWARD BEFORE STOPPING. THE DEALER (WEBER HARRIS FORD, 433 BALDWIN ST, MEADVILLE, PA 16335, (814) 350-7309) STATED THAT THERE WAS NO FAILURE; HOWEVER, THE FAILURE RECURRED. THE DEALER STATED THAT A DIAGNOSTIC TEST WOULD COST APPROXIMATELY $1,500. THE FAILURE RECURRED AND THE NEW OWNER OF THE DEALER DIAGNOSED THAT THE VEHICLE HAD DUAL CLUTCHES, WHICH WOULD COST $1,300 TO REPAIR. THE VEHICLE WAS REPAIRED A WEEK LATER, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE CONTACT WAS ADVISED TO KEEP THE REPAIR RECORDS FOR REIMBURSEMENT. THE FAILURE MILEAGE WAS 43,000.

NHTSA ODI 11162414

MY VEHICLE BUCKS EVERY TIME I ACCELERATE. I WAS TOLD IT IS SUPPOSED TO BE THIS WAY, BUT IT FEELS LIKE IT THE TRANSMISSION IS SLIPPING WHEN I FIRST ACCELERATE AND SOMETIMES AS I GO THROUGH THE GEARS.

NHTSA ODI 11162064

COOLANT RESERVOIR CRACKED, LOST A LOT OF COOLANT WHICH CAUSED MY ENGINE TO OVERHEAT. WAS DRIVING DOWN ROAD AND NOTICED MY COOLANT ENGINE SENSOR OVERHEATING. STOPPED THE CAR IN A PARK.

NHTSA ODI 11161876

I HAVE THIS ERROR CODE FROM A OBD-2 CODE READER FROM AUTOZONE. DEALERSHIP DIDN'T GIVE ME ANY FEESBACK ON THE CHECK ENGINE ISSUE WHEN I HAD IT IN FOR A FUEL TANK ISSUE. ERROR CODE IS 'U0109 LOST COMMUNICATION WITH FUEL PUMP CONTROL MODULE (FPCM)' THE CAR SAT IN THE DRIVEWAY ALL SUMMER LONG WITH A FULL FUEL TANK OF GASOLINE. THE CHECK ENGINE LIGHT FOR THAT ISSUE CAME ON SHORTLY AFTER I STARTED DRIVING THE FORD FOCUS AGAIN. READ MORE AT: HTTPS://WWW.OBD-CODES.COM/U0109 COPYRIGHT OBD-CODES.COM

NHTSA ODI 11157204

THE UPPER HALF WHEN I ADJUST IT SOMETIMES DOESN'T CLICK IN ALL THE WAY AND AS I'M DRIVING ONE SIDE WILL GIVE OUT AND CLICK INTO ONE BEHIND THE ONE I SET IT AS AND IT'S ONLY ONE SIDE.

NHTSA ODI 11156748

TL* THE CONTACT OWNS A 2015 FORD FOCUS. WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED AND REMAINED LIT. ALSO, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V735000 (FUEL SYSTEM, GASOLINE). THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,500. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 11155956

ON THURSDAY EVENING, 11/22/2018, I WAS COMING TO A STOP AT A LIGHT ON A CITY STREET (SPEED LIMIT 35) WHEN MY CAR STALLED WITHOUT WARNING. MOVING AT MOST 25 MPH WHEN IT OCCURRED, THE OIL AND BATTERY LIGHTS CAME ON AS I SLOWED. I TRIED ACCELERATING SLIGHTLY TO DIAGNOSE THE ISSUE, AND NOTHING HAPPENED. I ATTEMPTED TO PULL INTO THE LEFT TURN LANE (MOSTLY OUT OF TRAFFIC) BUT FOUND MY POWER STEERING WAS COMPROMISED. I TURNED ON MY HAZARDS, PARKED, AND TURNED OFF THE CAR, WAITED 5 SECONDS, AND RESTARTED THE CAR WITH NO TROUBLE. I WAS SHAKEN, BUT THANKFULLY NO DAMAGE TO THE CAR OR INJURIES TO MYSELF OR OTHERS. 2 WEEKS PRIOR TO THE STALL, I HAD MY TRANSMISSION SERVICED, AND I WAS MADE AWARE OF FORD MANUFACTURER RECALL NUMBER 18S32 AND THAT MY CAR WAS ONE OF THE AFFECTED. WHEN MY CHECK ENGINE LIGHT CAME ON A WEEK AFTER SERVICE, ERROR CODE P2195 (BANK 1/SENSOR 1 LEAN) CAME UP, AND THEN WENT AWAY. I WAS TOLD IT WAS STILL SAFE TO DRIVE AND CONTINUED TO DO SO. I WAS ON MY WAY TO MY PARENTS' HOUSE FOR THANKSGIVING WITH THE INTENT TO STAY OVERNIGHT AND HAVE MY DAD WORK ON THE CAR IN THE MORNING WHEN THE CAR STALLED WITH A 3/4 FULL TANK OF GAS, DESPITE FORD'S ADVICE THAT THE CAR SHOULD BE SAFE TO OPERATE WITH MORE THAN A HALF TANK. MY AIR FILTER WAS REPLACED, AND 5 DAYS LATER THE ENGINE LIGHT COMES ON AGAIN, SAME CODE. I SCHEDULED SERVICE WITH FORD, AND THEY VERIFIED THAT THE ENGINE CODE AND THE STALL ARE RELATED TO THE RECALL.

NHTSA ODI 11155252

CHATTERING,SLIPPING OF TRANSMISSION WHEN ACCELERATING FROM STOP.DOESN'T ALWAYS HAPPEN.

NHTSA ODI 11155267

I WENT TO THE STORE JUST FINE WHEN I LEFT THE STORE IT WAS ALMOST IMPOSSIBLE TO TURN THE WHEEL AND A ALERT CAME ON THE SCREEN AND SAID SOMETHING ABOUT THE POWER STEERING ASSIST FAIL THANKFULLY I WAS NOT FAR FROM HOME I HAD TO USE EVERY MUSCLE I HAD TO STEER IT AND MAKE TURNS. I TOOK IT IN FOR DIAGNOSIS I WAS QUOTED OVER $2200 AND WOULD STILL NEED AND ALIGNMENT AND COMPUTER REST 😡 MY CAR IS STUCK IN THE DRIVEWAY TILL I GET THE EXTRA $2200 TO PAY FOR IT THANKS FORD FOR MY FIRST CAR EXPERIENCE.

NHTSA ODI 11154575

WHILE PARKED (STATIONARY) I COULD NOT TURN THE ENGINE OFF EVEN THOUGH I PRESSED THE ON/OFF BUTTON. (THE BATTERY WOULD DRAIN DOWN TO ZERO. I COULD RECHARGE IT 100% BUT IT WOULD NOT HOLD THE CHARGE.) I BROUGHT IT TO FORD SERVICE. THEY CHARGED IT UP AND SAID IT WAS WORKING FINE. I TOLD THEM TO LET IT SIT OVER NIGHT. THEY CHECKED IT THE NEXT DAY AND IT WAS DRAINED. THEY TOLD ME THAT THE PROBLEM WAS A DEFECTIVE "BODY CONTROL MODULE" WHICH NEEDED TO BE REPLACED. I INFORMED THEM THAT FORD ALREADY RECALLED THE 2015 FOCUS BECAUSE OF DEFECTIVE BODY CONTROL MODULE. THEY SAID THAT MY FOCUS WAS NOT COVERED BY THAT RECALL. I TOLD THEM THAT A CAR THAT KEEPS RUNNING AND CANNOT BE TURNED OFF IS DANGEROUS, THEREFORE SHOULD BE RECALLED. WHAT MAKES IT PARTICULARLY DANGEROUS IS THAT THE ENGINE IS RUNNING AND YOU CAN'T EVEN TELL BECAUSE ELECTRIC CARS ARE SILENT. (THEIR REPAIR PAPERWORK IS DISINGENUOUS. IT SAYS THE CAR WOULD NOT START (WHEN DRAINED). I BROUGHT IT IN BECAUSE IT WOULD NOT STOP. AFTER THEY INSTALLED A NEW MODULE, THEY GAVE ME THE OLD DEFECTIVE ONE WHICH I HAVE IN MY POSSESSION.

NHTSA ODI 11154365

TL* THE CONTACT OWNS A 2015 FORD FOCUS. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED THAT THE FUEL GAUGE FLUCTUATED AND THE READINGS WERE INCONCLUSIVE. THE CONTACT STATED THAT THE BATTERY, CHECK ENGINE, AND OIL WARNING INDICATORS ILLUMINATED. THE CONTACT ALSO STATED THAT THE VEHICLE STALLED ON SEVERAL OCCASIONS SINCE MAY OF 2017. IN ADDITION, THE VEHICLE EXPERIENCED A SUDDEN LOSS OF ACCELERATION. FURTHERMORE, UPON FILLING THE FUEL TANK, THE ENGINE BEGAN TO SHAKE/TREMBLE AND THE VEHICLE STALLED WHILE STATIONARY. THE CONTACT RESTARTED THE VEHICLE SEVERAL TIMES AND APPLIED PRESSURE TO THE ACCELERATOR PEDAL IN AN ATTEMPT TO CORRECT THE FAILURE. AN INDEPENDENT MECHANIC REMOVED THE FUEL TANK TO ASSESS THE VEHICLE, BUT WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURES. WALDORF FORD (2440 CRAIN HIGHWAY, WALDORF, MARYLAND 20601, (301) 843-2400) WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 18V735000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

NHTSA ODI 11154080

TL* THE CONTACT OWNS A 2015 FORD FOCUS. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE CRASHED INTO A DEER. THE FRONT END OF THE VEHICLE WAS SEVERELY DAMAGED, BUT THE AIR BAG DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE RIGHT LEG AND BACK AND WAS TRANSPORTED TO THE LOCAL HOSPITAL FOR MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

NHTSA ODI 11152457

TL* THE CONTACT OWNS A 2015 FORD FOCUS. THE CONTACT STATED THAT EACH TIME THE VEHICLE WAS FUELED, IT FAILED TO START AND THE CHECK ENGINE, BATTERY, AND OIL WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO RAY VARNER FORD (LOCATED AT 2026 N CHARLES G SEIVERS BLVD, CLINTON, TN 37716, (865) 457-0704) WHERE IT WAS DIAGNOSED THAT THE VAPOR CANISTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 49,185.

NHTSA ODI 11149540

I CONTACTED FORD REGARDING SAFETY RECALL NOTICE 18S07 / NHTSA RECALL 18V-169 AND ASKED WHY MY VIN NUMBER WAS NOT INCLUDED IN THIS RECALL. MY FORD FOCUS 2015 WAS MANUFACTURED ON MARCH 20, 2015, IN THE SAME MICHIGAN PLANT AND IS EXPERIENCING THE SAME CLUTCH SHUDDERING AS DESCRIBED IN YOUR RECALL NOTICE. FORD'S ANSWER WAS THAT VIN NUMBERS ARE THE SOLE METHOD FOR DETERMINING RECALLS. THEY CLEARLY DID NOT THROW THE NET FAR ENOUGH TO COVER THEIR QUALITY AND DESIGN ISSUES. AFFECTED VEHICLES EQUIPPED WITH 1.0L FOX GTDI OR 1.6L SIGMA GTDI ENGINES WITH B6 MANUAL TRANSMISSIONS MAY EXPERIENCE CLUTCH SLIP WHICH CAN LEAD TO A POTENTIALLY DANGEROUS SITUATION. THIS VEHICLE IS DRIVEN BY MY DAUGHTER AND SHE EXPERIENCES SHUTTERING WHEN SHE ACCELERATES THE VEHICLE. SHE DOESN'T HAVE ENOUGH POWER TO ACCELERATE QUICKLY WHICH COULD EASILY CAUSE AN ACCIDENT AS SHE PULLS OUT IN TRAFFIC. I HAVE READ ABOUT MANY OTHER PEOPLE HAVING THE SAME SCARY EXPERIENCE WHILE ACCELERATING AND THEIR FRUSTRATION AND CONFUSION ABOUT WHY THEIR FOCUS WAS NOT INCLUDED IN THE RECALL. I WOULD LIKE FORD TO RE-EXAMINE HOW THEY DETERMINED THE VIN NUMBERS AFFECTED AND WHY MY VEHICLE WAS NOT INCLUDED SINCE IT CLEARLY HAS THE SAME POTENTIALLY DANGEROUS ISSUE. YOUR HELP WOULD BE APPRECIATED.

NHTSA ODI 11144914

MY CAR WAS DRIVING VERY SLUGGISH ON 10/24/2018, I HAD MY CAR TOWED 42 MILES TO THE LAST FORD DEALERSHIPS THAT WORKED ON MY CAR LAST FOR A ENGINE ISSUE. AFTER THEY DID SOME TEST THEY SAID THAT MY ENGINE HAS BLOWN DUE TO THE HEAD GASKET WARPED AND THE CYLINDERS WARPED WHICH CAUSED COOLANT TO LEAK INTO MY ENGINE. UPON TALKING WITH THE FORD DEALERSHIP THEY SAID THAT I DID NOTHING TO CAUSE THIS, THE SERVICE ADVISORY SAID IT WAS A DEFECT OF THE DESIGN SINCE MY CAR SHOWED NO SIGNS OF ISSUES. FORD SAID THAT MY CAR SHOULD HAVE OVERHEATED OR HAD WARNING SIGNS APPEAR.

NHTSA ODI 11143984

WHEN ACCELERATING MY CAR SHUTTER LIKE CAUSING THE CAR TO SHAKE.

NHTSA ODI 11143769

THE CAR SHAKES AND STUTTERS IN LOWER GEAR AND IT IS VERY DANGEROUS. WHEN I GO FROM A STOP INTO FIRST GEAR THE CAR WILL NOT IMMEDIATELY START AND WHEN IT DOES, IT SHUTTERS. THE WHOLE CAR SHAKES WHEN I AM DRIVING IN THE CITY BECAUSE OF THE START/STOP. THIS IS GOING TO CAUSE AN ACCIDENT. OTHER FORD FOCUS CARS FROM 2015 ARE RECALLED, BUT MINE IS NOT FOR SOME REASON. THE TRANSMISSION IS GOING TO FAIL AND I ASKED FORD TO HELP RE-SET THE TRANSMISSION OR REPLACE IT, AND THEY WILL NOT. PLEASE HELP ME.

NHTSA ODI 11143330

AIR CONDITIONING SYSTEM, AFTER ABOUT 45 MINUTES OF USE, WILL GREATLY REDUCE FAN SPEED. DEALER SAYS CONDENSOR MAY BE FREEZING UP DUE TO A BAD SENSOR. THE CAR DOES NOT STORE A CODE FOR THE DEALER TO DIAGNOSE WHICH SENSOR IS BAD SO THEY WON'T FIX IT. DEALER SAYS NEXT TIME IT IS IN FAILURE MODE, BRING IT IN TO TRY TO GET A CODE.

NHTSA ODI 11143341

TL* THE CONTACT OWNS A 2015 FORD FOCUS. THE CONTACT STATED THAT WHEN HE DEPRESSED THE ACCELERATOR PEDAL TO DRIVE FORWARD, THE VEHICLE SEIZED. THE FAILURE OCCURRED INTERMITTENTLY AND WITHOUT WARNING. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT RETURNED TO NORMAL. THE VEHICLE WAS TAKEN TO DCH FORD OF EATONTOWN (67 NJ-36, EATONTOWN, NJ 07725, 732-982-4222) WHERE IT WAS DIAGNOSED THAT THE CLUTCH FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

NHTSA ODI 11142632

THE CAR IS OWN 3 YEARS OLD AND I HAVE ALREADY REPLACED THE FUEL EMISSION VALVES, THE COOLING SYSTEM, AND NOW THE UNAFFORDABLE TRANSMISSION CONTROL, CATYLATTIC CONVERTER, AND TRANSMISSION CLUTCH HAVE GONE OUT TO WHERE MY CAR WONT CHANGE SPEEDS WHILE ON THE HIGHWAY, NOR REVERSE.

NHTSA ODI 11139378

ON OR ABOUT 9/23/2018 AND WHILE DRIVING MY FORD FOCUS HB SE, I RECEIVED AN ERROR MESSAGE ON MY DASH THAT READ "TRANSMISSION FAULT SERVICE NOW". I WAS ABLE TO PULL OVER SAFELY AND LATER WAITED FOR A TOW TO MY HOME. ON 9/25/2018 I CONTACTED A FORD DEALERSHIP NEAR MY HOME (SUBURBAN FORD OF FERNDALE) IN MICHIGAN. THE CAR WAS TOWED ON 9/28/2018 TO SUBURBAN FORD DEALERSHIP FOR SERVICE. INITIALLY, THE THINKING WAS THE TRANSMISSION MODULE (TCM) NEEDED SERVICING, HOWEVER THE SERVICE DEPARTMENT INFORMS ME THAT THE DUEL-CLUTCH COMPONENT IS DEFECTIVE AND NEEDS REPLACING. I FURTHER UNDERSTAND THAT I'M NOT ALONE WITH THIS ISSUE. THE CAR HAS 62,056 MILES ON THE ROAD AND HAS HAD TYPICAL MAINTENANCE (TIRES, OIL CHANGE, ETC.). WHILE FORD'S EXTENDED WARRANTY COVERS TCM, CUSTOMERS, SUCH AS MYSELF, HAVING ISSUES WITH DEFECTIVE DUAL-CLUTCH ARE HAVING TO COME OUT OF POCKET FOR REPAIRS. THIS VEHICLE HAS MERELY 62,056 ROAD MILES NOT 162,056 MILES.

NHTSA ODI 11132663

2015 FORD FOCUS SE SHUDDERS WHEN STARTING FROM 1-2ND GEAR, I FEEL LIKE THIS IS A SAFETY ISSUE. IT DOES EVERYTIME THE CAR STARTS FROM STOP POSITION.

NHTSA ODI 11132228

DRIVER SIDE DOOR LATCH WILL NOT ACTUATE AND THE DOOR WILL FLY OPEN WHILE DRIVING. FORD CLAIMS THIS PROBLEM IS NOT COVERED ON THIS VIN FOR A FOCUS ST EVEN THOUGH 2015 FOCUS DOOR LATCHES ARE LISTED ON AN EARLIER RECALL.

NHTSA ODI 11132195