What 1,022 owners told NHTSA about the 2015 Ford Focus RS

Power train in the car. Yes the car is available for inspection if requested. 1) The car shakes, jerks, and shudders. It will randomly cut off/stall. First and Second gear upon take off makes a winding up noise then gives a big/quick jerk. When I drive down the highway there have been numerous times these issues have occurred while driving my car on the interstate at interstate speed. 2) The car was purchased from Autonation in Sanford, FL in 2017 as a used vehicle. After purchasing the car the the above mentioned issues began to occur. Upon returning back to Autonation several times with concerns regarding the issues above there was an attempt each time to correct the issue by replacing parts. Invoice is available upone request, such as sensors, and the transmission clutch. Your prompt attention to this matter and issuing a recall for the 2015 Ford Focus with the above mentioned VIN number, is necessary and should not be delayed due to safety concerns. Respectfully, Cathy Herrera (407) 715-3288

NHTSA ODI 11532082

My car stopped working on the freeway due to a recall. Multiple Ford dealerships have refused to fix it.

NHTSA ODI 11532143

I have a customer satisfaction program 19N08 for Transmission clutch shudder -transmission clutch warranty extension,I have 96000 miles and was told I have to pay for a new clutch

NHTSA ODI 11531516

The contact owns a 2015 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle shuddered. No warning light was illuminated. The contact stated that the dealer had previously replaced the clutch; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed that the clutch needed to be replaced a second time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 82,000. The VIN was unavailable.

NHTSA ODI 11531256

My driver rear door does not shut. The latch is not broke but it will not latch on the metal part it is suppose to.

NHTSA ODI 11530095

When driving in stop and go traffic 0=5 mph for about 30 mins the car began to act as if was slipping and revenge up without moving and engine light came on and would sometimes slam into gear. I placed vehicle in sport mode and it idled irratically to the point I felt it was going to shut down. Upon arrival home I realized that now reverse had went out when attempting to put car in driveway. I will be taking it into Ford today for the 1 recall on the fuel canister software but I feel that it is not related and hope they will make some discovery and fix it accordingly.

NHTSA ODI 11529703

The contact owns a 2015 Ford Focus. The contact stated while driving 5 MPH in traffic, the air condition vents started to blow hot air inside the vehicle. The contact stated that the engine overheated, and the “Pull Over Safely” message was displayed. The contact stated that the temperature gauge rose to the HOT level. The contact was able to park the vehicle safely and waited approximately 15 minutes before being able to drive to her destination. A dealer was not contacted. The contact stated on June 26, 2023, she became aware that the vents were not blowing any air when the vehicle was started. The contact stated that within 30 minutes the failure recurred. The contact had experienced the failure four times. The contact took the vehicle to an independent mechanic and was informed that the cooling fan was not functioning properly. The vehicle was not diagnosed or repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with Manufacturer Recall Number: 21N01; however, the VIN nor the year, make, or model was included. The manufacturer had not been informed of the failure. The failure mileage was approximately 127,000.

NHTSA ODI 11529600

The contact owns a 2015 Ford Focus. The contact stated while driving 50 MPH, the vehicle decelerated, and the check engine warning light illuminated. The contact was able to pull over on the side of the road. The contact turned off the vehicle and after the vehicle cooled down the contact was able to restart the vehicle and the vehicle operated normally. The vehicle was taken to the dealer, but no cause for the failure was found. The manufacturer was not contacted. The failure mileage was 97,000.

NHTSA ODI 11529655

Radio and speakers have not worked for over a year- making loud popping and screeching sounds. Automotive center #1 stated it was a computer system fail and they could not fix it because they did not have the proper software. Then I went to get a new fuse for the cigarette lighter and was told something is leaking. Took it to Firestone automotive center to be told nothing is leaking and I should go to Ford because it is most likely a sensor issue. Car says it is overheating when it is in idle. And no one I go to seems to care to help me get things fix. Ford can't help for 2 weeks due to availability. This has been the worst experience with a car I have encountered with trying to figure out the problem.

NHTSA ODI 11528399

As I was driving and slowing down to come to a stop my car completely quit moving. I was informed my TCM has gone out. I've had issues previous with my Focus not wanting to reverse

NHTSA ODI 11527654

The engine light is on. The car shakes a lot, jerks and acceleration is slow. I don’t feel safe driving it.

NHTSA ODI 11527723

I was in a vehicle crash in my 2015 Ford focus none of my airbags deployed. My seatbelt did not lock and my driver seat they came sideways.

NHTSA ODI 11527746

The contact owns a 2015 Ford Focus. The contact stated that while attempting to shift into reverse(R), the transmission failed to respond as needed. Additionally, the contact stated that while driving at an undisclosed speed, the vehicle was shuddering. The contact stated that the failure was intermittent. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 94,000.

NHTSA ODI 11527036

I am having issues with the company Ford in regards to my vehicle. It has been at Dowling Ford, in Cheshire, Connecticut for 5 weeks. I believe I am one of the unlucky 2015 Ford Focus owners who was sold a one of the cars that has a faulty transmission. After doing some research, I discovered that Ford has a lawsuit against them for unloading Ford Focus' with faulty transmissions. I will attach the link to the article stating this information. Ford is trying to charge me $5900.00 to fix the car that wasn't even brought in for the reasons that they are trying to charge me with. I bought the car for just under 7,000. It is only a 2015 and has 106,000 miles on it and should not be running into these problems. I have contacted the corporate office of Ford multiple times and they refuse to offer any help what so ever. I have only had the car for two years. My car was only brought in because the wipers weren't working properly and it was overheating while only in idle. It was diagnosed that the transmission module needed to be replaced which was covered under the warranty. Well, the bad news began there when I had to wait 2 weeks for that part to come in because it was "back ordered". Once that was replaced, they tried to tell me now that something else needs to be replaced which was the clutches on the transmission and it would cost $3200. Then once they fixed that which took 4 more days, they now are saying something else is wrong which is the transmission case and would be an additional $2700. My car was not brought in for any of these issues and now all of a sudden, my car needs them all replaced. Ford, hasn't even offered me a loaner during the last 5 weeks. I don't feel safe in this vehicle, and I know that I am driving an unsafe vehicle that shouldn't have even been sold to anyone.

NHTSA ODI 11526280

The contact owns a 2015 Ford Focus. The contact stated that the clutch was slipping. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the transmission control module needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the dealer, where it was diagnosed that the clutch needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V169000 (Power Train). The manufacturer was contacted and provided a case, but no additional assistance was provided. The failure mileage was approximately 105,000.

NHTSA ODI 11525993

The transmission on the 2015 Ford focus has given us issue from day one. We have replaced the transmission on two occasions the latest being done in 2021. The car has very low mileage and is now requiring a third transmission. The car has always been service and repaired by a Ford dealer - when we took the car in for a scheduled oil change, we informed them once again of the transmission slipping. They told us that we were approximately four weeks beyond the warranty and that the car is requiring a third transmission. This is an unfortunate situation as this car has been diligently cared for. The car has 49,000 miles on it and we have never replace a transmission in a car before let alone for a third time. I am looking for some sort of resolution with Ford motor company to replace the transmission at their cost.

NHTSA ODI 11526095

We are having the same transmission slipping issues as the 3 previous years focus and fusion. Ford hasn't recalled the 2015 Focus. Every other gear goes out. The transmission has problems shifting up or down to the next gear. This is dangerous on the expressway and even highway. They obviously haven't fixed the root cause. I've spoken several mechanics and been on several forums where plenty others are having the same issues. They need to fix root cause and include the 2015 Focus in the recall.

NHTSA ODI 11525722

The contact's son owns a 2015 Ford Focus. The contact stated while driving 45 MPH, the vehicle began decelerating independently. The contact stated no warning light was illuminated. The contact parked in a parking lot and called her husband. The contact's husband drove the vehicle to an independent mechanic, where it was diagnosed with needing the clutch and the transmission control module (TCM) to be replaced. The vehicle was not repaired. The contact towed the vehicle to her residence and then to the local dealer, where the vehicle was diagnosed with needing the clutch and the transmission control module (TCM) to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 96,000.

NHTSA ODI 11525413

Transmisión slip when taking off. Dealer replaced clutch and replaced / repaired components. After 7,000 mile, problem occurs again. This time, taking 2 weeks to get an appointment.

NHTSA ODI 11525176

Car began losing power particularly at low speeds. AAA inspected vehicle and determined that clutch and transmission would need to be replaced (~$10K repair). This is the second time the transmission and clutch have been replaced. The car has a total of 50,000 miles on it (ie, it is still, mechanically, very, very young ) Manufacturer seems to have known about the issue.

NHTSA ODI 11524734

The contact owns a 2015 Ford Focus. The contact stated while driving approximately 35 MPH, the vehicle felt like the transmission was slipping before the vehicle lost motive power. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was informed of a power train recall and was advised to take the vehicle to a Ford dealer. The vehicle was taken to a dealer and the contact was informed that the vehicle was not included in NHTSA Campaign Number: 18V169000 (Power Train). The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 58,828

NHTSA ODI 11523828

The contact owns a 2015 Ford Focus. The contact stated that on several occasions while driving at an undisclosed speed, the vehicle hesitated. The vehicle was taken to the dealer where the failure could not be determined. The contact stated that on a separate occasion while driving at an undisclosed speed, the vehicle hesitated. No warning light was illuminated. The vehicle was taken to another dealer where it was diagnosed that the clutch assembly failed and needed to be replaced. The vehicle had not yet been repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was not covered under the Customer Satisfaction Program: 19N08, and advised to call the NHTSA Hotline. The failure mileage was approximately 90,000.

NHTSA ODI 11523542

The contact owns a 2015 Ford Focus. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle shuddered significantly. The vehicle was taken to the dealer, where it was diagnosed that the TCM and the transmission clutch needed to be replaced. The dealer informed the contact that the TCM would be replaced under Ford Campaign Number:14M02, however, he would be charged a repair fee for the transmission clutch replacement. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not cover the transmission clutch replacement as the warranty for the transmission clutch had expired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.

NHTSA ODI 11519286

The contact owns a 2015 Ford Focus. The contact stated while driving 20 MPH, the vehicle started jerking and shaking and the contact felt that there was delay on the transmission shifting gear. The vehicle was taken to the dealer and the clutch was replaced; however, the failure reoccurred, and the check engine warning light illuminated. The vehicle was taken to the dealer and the dealer stated that the clutch needed to be replaced and the TCM module needed to be updated. The dealer also stated that the vehicle was not included in NHTSA Campaign Number: 18V169000 (Power Train). The manufacturer was contacted and stated that the vehicle was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 95,000.

NHTSA ODI 11518747

The contact owns a 2015 Ford Focus. The contact stated while driving approximately 45 MPH and attempting to accelerate, the accelerator pedal was depressed, and the vehicle hesitated and shuddered before responding as needed. The contact stated no warning light was illuminated. The contact stated that the failure had become a recurring failure and happened at various speeds. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission clutches needed to be replaced. The contact related the failure to Customer Satisfaction Program: 19N08 Transmission Clutch Shudder (Power Train); however, the vehicle was no longer covered under the Warranty Extension. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was 98,551.

NHTSA ODI 11517687