What 296 owners told NHTSA about the 2015 Ford F-250 Super Crew

The contact owns a 2015 Ford F-250. The contact stated while driving 50-65 MPH, the vehicle experienced the death wobble, almost causing the contact to lose control of the vehicle. There was no warning light illuminated. The contact depressed the brake pedal and came a complete stop. The contact was able to continue driving; however, the failure reoccurred several times while driving. An unknown dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 92,000.

NHTSA ODI 11510996

On 4 separate occasions over the past 2 months, the vehicle began to shake violently at highway speed, 60-65 mph, after going over a minor rough surface of roadway, The first 3 were on state highways, with the most recent and most violent on US67 heading north through Duncanville TX. The shaking is uncontrollable until speed is reduced well below safe travel speeds and caused me to get to the shoulder and exit the highway at the first opportunity. I first thought it might be a bad shock/strut, but just read about a known condition called “death wobble” which perfectly describes the phenomenon I experienced.

NHTSA ODI 11509623

Truck will begin doing the Death Wobble on the highway with speeds around 60-65 mph. Cab and steering vibrate vigorously causing loss of steering control.

NHTSA ODI 11509295

the back up camera only works part of the time. it does not work every time

NHTSA ODI 11507847

While driving between 50 and 60 mph the steering wheel begins to violently shake until you slow below 50 MPH. This is known as the Death Wobble.

NHTSA ODI 11499198

Going down the freeway, I ran over a couple of pot holes. The truck began to vibrate and the vibration got so bad I thought I was going to lose control. I was able to slow down and pull off the freeway causing the vibration to disappear, and returned to the freeway without further incident. This is the 6th or 7th time the rattle was felt, although this incident was worse than any other event.

NHTSA ODI 11497831

I have experienced a "death wobble" on 2 occasions in 4 weeks. The truck's front end uncontrollably bounces when driving on the freeway causing me to have to immediately let off the gas and gently brake causing a dangerous situation not only for me and my family but potentially for others on the road.

NHTSA ODI 11496979

The contact owns a 2015 Ford F-250. The contact stated while driving approximately 65 MPH, the vehicle drove over a slight bump on the roadway and the steering wheel began to move left to right and the vehicle was shaking and unable to maintain a straight line in the lane. The contact stated he was not aware of any warning lights being illuminated. The contact pulled off the road and placed the vehicle in park(P) and waited with the engine running. The contact was able to drive the vehicle to a dealer. The dealer diagnosed the vehicle and determined that the ball joints and the steering dampener needed to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 144,000.

NHTSA ODI 11496285

When driving over speeds of 50mph or after driving over bumpy/ wavy roads, the truck starts shaking violently. It was bouncing so hard it almost shook the steering wheel out of my hands. I had to completely stop and pull over off the left side of the interstate. This has happened multiple times.

NHTSA ODI 11495868

I was driving at approximatelly 60mmph when the left front end starte shaking and vibrating so bad I could not keep it on the road. Luckly it was a two lane road with an emergency lane. when I came to a stop the vibration and shakinf stopped. I took it to the ford dealership. They told me I needed frontsuspension tie rods, ball joint assy shock absorbers drag links . Plus $1,156 dollars labor. Told me the truck was fixed to come and get it. They test drove it 5 miles. I picked it up. I had an appointment to go to. I went to it, and on my return the truck did the same thing on my return, this time it pushed me into the right hand lane, barely missing a car beside me. The drive stopped and asked me wht the hell as going on.. I explained and he said you better get the damn thig fixed. This was a Friday night. I parkd it and took it back to the dealer Monday morning. They did not beleive me. I took the tech on a drive, it happened right where it happened to me. I drove back a different way to the dealership to avoid the freeway. I happened again on this road. They went back to work on it. This time they installed a dual steering stabilizer, another $842 dollars, no charge for labor after i bitched. As a 30 year degreed mechanical engineer with years of buying and having machines and equipment repaired I beleive the first fixed the effects of the issue and then with the stabilizer hopefully fixed the cause. There was no warning it just happened out of the blue. I haveread up on th death wobble, and feel lucky I did not get killed.

NHTSA ODI 11495499

I was driving at approximately 55mph when my Ford F-250 started violently shaking. I had a difficult time steering it and almost crashed.

NHTSA ODI 11494674

Known Faulty Bosch CP4 fuel pump placed on vehicles with Fords knowledge of the issue. This fuel pump is known to fail and cause thousands of dollars in damage and repair cost. As a good business practice Ford should issue a recall on all vehicles that this faulty fuel pump was installed on

NHTSA ODI 11492802

Violent shaking in front end (commonly referred to as “ death wobble”) usually associated with hitting a rough spot in road. Happens between speeds of 50-60 mph. Ford replaced steering stabilizer under a service bulletin and it did nothing to help. Tires have been replaced and tire rotation is done every 5,000 miles. Ford acts like there is no problem but there is a serious and dangerous one. This has been a problem with the truck since it was bought brand new in 2015

NHTSA ODI 11491878

I have been experiencing what is known as the Death Wobble. The death wobble is a violent shaking that happens to the front end of many Ford F250 and F350 Super Duty trucks. It typically occurs at speeds over 50 miles per hour. It can also happen after going over bumps or grooves in the road. To stop the shaking, drivers must quickly slow way down or even stop completely. In addition to the shaking potentially causing the driver to lose control of the truck, slowing or having to stop on fast-moving highways also puts both truck occupants and other vehicles at risk. I have taken this Vehicle to NTB for repairs and even had new tires put on in the event that was the issue. They have replaced all the steering linkages, tie-rods, ball joints, etc dealing with steering to no avail. I have taken this pickup back into the repair shop on 10/24/2022 once again as this has made me have to stop on major freeways to get the wobble to stop. This is putting me and others in danger.

NHTSA ODI 11490544

The contact owns a 2015 Ford F-250. The contact stated that while driving at an undisclosed speed, there was smoke coming from underneath the hood with an unknown fluid splattering onto the front windshield. Additionally, an abnormally strong diesel odor was detected while the vehicle was parked and while driving. Upon inspection, the contact noticed there was fluid leaking underneath the hood and dripping down to the fender. The vehicle was taken to an independent mechanic who diagnosed that the engine block was cracked. The vehicle was then towed to the dealer where it was diagnosed with a faulty fuel filter housing and that the fuel filter assembly needed to be replaced. The dealer replaced the fuel filter assembly. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 50,000.

NHTSA ODI 11489998

The contact owns a 2015 Ford F-250. The contact stated that while driving approximately 60 MPH, the vehicle suddenly experienced a death wobble causing the vehicle to violently shake and vibrate. The contact indicated that the failure occurred while driving on a smooth and level roadway. Additionally, the vehicle had not driven over any bumps in the roadway prior to the failure. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 103,000.

NHTSA ODI 11489250

after hitting grooves or holes in the road the vehicle vibrates violently, known in the industry as the Ford Death Wobble. It's getting progressively worse. It makes lane control very difficult and often times requires immediate braking which causes a hazard on the highway to those following behind in addition to sudden lane departures caused by pulling forces.

NHTSA ODI 11489266

I was driving 65mph on I16 to get on I75 in Macon, GA. The truck started shaking as if I had blown all four tires. After taking it to a repair shop, I was told it is called a "Ford Death Wobble."

NHTSA ODI 11487613

The vehicle violently shakes at speeds above 60mph. I must abruptly slow down on highway or come to a complete stop. This is dangerous to me and other drivers.After further research I have found this issue has caused serious injury and death.

NHTSA ODI 11486971

Death Wobble again after repair at 200,000 miles at local Ford dealer.

NHTSA ODI 11485982

When I hit any kind of bump in the road, especially when you change lanes the truck shakes so violently you have to slow down to about 10 miles an hour to get it to stop. This has been happening for years & on a few occasions it almost caused an accident. On one occurrence it was so bad the truck shook me off of the highway. This is an ongoing issue, I have tried many repairs to try to alleviate this problem with no luck.

NHTSA ODI 11481984

The contact owns a 2015 Ford F-250. The contact stated that while driving at various speeds, the contact experienced the death wobble. The contact stated that the vehicle shook violently after driving over and unknown object on the roadway. The contact stated that he had previously taken the vehicle to an independent mechanic for repairs to address the failure. The contact stated that several front-end components were replaced; however, the failure returned over time. Neither the dealer nor the manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11480953

Unknown Death Wobble- The truck starts shaking uncontrollably. I have to slowly stop the truck and pull off of the road each time this happens. Happens more and more often, and I have to drive slow and in the lane closest to the shoulder just in case.

NHTSA ODI 11473750

Unable to steer, vehicle was wobbling almost losing control while on highway vehicle began to bounce side to side.

NHTSA ODI 11467790

The contact owns a 2015 Ford F-250. The contact stated that while driving approximately 60 -75 MPH, the vehicle experienced the death wobble. The contact would aggressively apply the brakes to reduce the speed to 25 MPH. The contact took the vehicle to the dealer who replaced the drag linkage, track bar, tie rod ends, stabilizer, and bushings. The failure had progressed since the repairs. The manufacturer was not made aware of the failure. The approximate failure mileage was 135,000.

NHTSA ODI 11462742