What 2,636 owners told NHTSA about the 2014 Jeep Cherokee

The vehicle bucks and stalls after filling up the fuel tank to full. I don't lose accessories or anything, I lose engine power. My battery light comes on and my dash says, "battery voltage low put car into park and then desired gear". The car will start up after the excess fuel in the engine is burned off which can take a few tries. It will buck like it wants to stall out or it dies again completely while I'm driving. This is a very dangerous situation to be driving down the road to have the vehicle suddenly stall out. The vehicle will continue to stall until the fuel hits a certain level in the tank.

NHTSA ODI 11507358

For the last 12-months I have been dealing with the vehicle stalling after filling it up. It first started a year ago and was sporadic but for the last 6-months it has been happening every time I fill up. This is a very dangerous situation to be driving down the road to have the vehicle suddenly stall out. The last time this happened was on Saturday, 2/11/23 and I spent the day fighting a stalling vehicle. Since 2020 the check engine light sporadically comes on. Supposedly there is a small evap leak. After looking into this earlier today I discovered this is a well known issue with all Jeep vehicles. Seeing how this seems to be a manufacturer issue the consumer should not have to keep paying out to fix what was not done right to begin with. Please look into both of these concerns.

NHTSA ODI 11507162

Similar to NTSB 11504810, when I fill up with gas, my jeep stalls out and dies. I don't lose accessories or anything, I lose engine power. My battery like comes on and my dash says "battery voltage low" "put car into park and then desired gear" it takes a few tries to get it started again and it will buck like it wants to stall out or it dies again completely while I'm driving. Also there are times it is rough changing gears (jerky).

NHTSA ODI 11505465

Recently, after evertime I fill up with gas, my jeep stalls out and dies. I don't lose accessories or anything, I lose engine power. My battery like comes on and my dash says "battery voltage low" "put car into park and then desired gear" it takes a few tries to get it started again and it will buck like it wants to stall out or it dies again completely while I'm driving!

NHTSA ODI 11504810

Every time I fill the fuel tank and start driving the car dies, lurches or drops out of gear. I get a message on the instrument display that I cannot shift without a compete stop (I did not shift) It's in drive but will not move. This is dangerous as it gets me to the middle of an intersection and its dead. I know this sounds crazy but it's a repeatable problem. And apparently, I'm not the only one.

NHTSA ODI 11502727

Beginning of this year vehicle was taken into mechanic for issues. It had rear differential, exhaust and motor mounts all repaired/replaced! The vehicle still had alot of vibration and just 3 weeks ago wouldn't start! Was towed to dealership since my machanic couldn't work on code issues that was code that came up on Diagnostic machine! Was told by dealership today that the pcm, fuel pump and battery are all faulty! There were multiple recalls since 2020 for the pcm, fuel and electrical the 2014-2020 jeep cherokees. It was taken in for the two recalls we received and wasn't repaired, was just looked at! Now we are having more issues with the vehicle! I have reported this to Chrysler, they are supposed to return my call after making claim and speaking to dealership! This vehicle has had a new engine and transmission put in by dealership in 2016 under warranty. We spent over $3000 in repairs since then to the rear differential, exhaust and engine mounts! Was told this new repair will be another $3000 for the fuel pump, pcm, and battery!

NHTSA ODI 11496669

We purchased this vehicle in 6/2020. Last year had to replace the fuel system because of the vehicle randomly stalling after filling up the tank. This happened randomly so it could have caused a life threatening situation. The cause of this stalling is fuel getting into the EVAP system, and requires replacing the fuel pump and evaporative charcoal canister to rectify. No recall on this even though numerous complaints, it costed us $1700. We now have been having issues of the vehicle hesitating when pulling into traffic and issues with the automatic gear shifting randomly since about 70,000 miles on the car. Recently it got so bad the vehicle would slow down while pressing on the accelerator. We took it into the dealership and they were able to uncover a transmission issue even though there were no warning lights or system warnings. If we didn’t take it in it could have caused a serious injury and accident. There are recalls on more expensive and newer models of this same model 9 speed transmissions but all Chrysler is doing for this model is doing a cheap software update that has NOTHING to do with the issue many cars are having. The below article explains the issues that Chrysler is not helping customers out at all, just putting peoples life’s in jeopardy to avoid paying for the transmission recall on all 2014 Jeep Cherokee vehicles even though it is a MAJOR safety risk. https://www.vehiclehistory.com/articles/2014-jeep-cherokees-problems-and-recalls-cover-powertrain-failures-cruise-control-malfunctions-and-faulty-airbags I am attaching their response which basically says sorry, Chrysler doesn’t care if the vehicle is unsafe and we don’t care how much money it is costing our customers to make it safe because Chrysler is making money off those repairs.

NHTSA ODI 11495738

What component or system failed or malfunctioned, and is it available for inspection upon request? - When you fill up the gas tank, the car will buck and stall and turn off until the gas tank is less than full (usually about 3/4 full before it starts driving properly again). This has caused the car to shut off completely and not restart even in the middle of driving / in traffic and is a major safety hazard. How was your safety or the safety of others put at risk? - The car stops unexpectedly and will not restart on the road. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes, I have documentation from several trips to the dealer and the mechanic. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - No

NHTSA ODI 11491469

After filling up the gas tank the engine stalls at stop light. I must quickly place car in park and restart the engine. This happens multiple times as I drive home. Then as I start driving again the engine seems to be hesitant and feels like it is "bucking" me. After the first time this happened it seemed to go away after fuel level in tank went down. When I filled the tank again the problem reappeared. This has happened twice to me. This is really a life threatening hazard.

NHTSA ODI 11467834

At a stoplight or red light, the car will sometimes start revving up, like it wants to go, while my foot is on the brake. The check engine light will then come on, and It'll then come up with a notification on the dash saying "Shift to P then desired gear". The photo is also attached. This is very annoying, as it happens while driving too. When it comes up during driving, when you press the gas, it will not go any faster and starts slowing down. This is dangerous and needs fixed. Took it to the garage, and they couldn't figure out what is happening, even with the check engine light!

NHTSA ODI 11464944

When the fuel tank is filled, to the first click off of the pump. The vehicle will stall, sputter, and is hard to accurate. The dealer has all ready replaced the fuel tank, evap line, and a puger valve, but still has the same problems. I have almost getting rear ended when it stalls a couple of times. Still has been going on for 2+ year. Vehicle drives fine after 30ish miles after filling it up.

NHTSA ODI 11462531

Leaving to go get Wife's computer today my Jeep ran terrible, kept trying to stall I just filled up at Costco to top off the tank yesterday. In the next subdivision after passing through the back gate the transmission "D" light started blinking. Pressing the gas pedal at 15 miles an hour did nothing. No forward acceleration nor any acceleration at all. Just coasted to pull over where I could safely as the Jeep coasted powerless. Pressing the gas peddle barely raised RPMs like a throttle car would have done. I had to stop the Jeep put it in park and then put it back in "D" drive and it at least my jeep moved forward when pressing the gas peddle. As I continued to drive out through the subdivision towards a main street, the transmission kept clunking and thumping. Felt like the transmission was loose and dangling under the Jeep, but it is still securely bolted to the Jeep. I decided to go back get Wife's car and drop the stupid Jeep off at the dealer again to find out what's wrong with it. At least if it broke down on the side of the road I could run our errands. This constant problem is a major safety concern. If this happens on the interstate it can easily cause a major crash. The dealer can't figure out what is wrong, or so they claim. This happens every couple of months. I don't trust Jeep to keep me safe while driving. This needs to be investigated so owners know the truth.

NHTSA ODI 11459451

After filling my jeep with gas this will cause the jeep to stalls then shuts off and all kinds of warnings and code appear. It will radom shut off and is extremely dangerous. Dealership could not diagnose . This is happening regularly. Goggle says many others have experienced this problem as well

NHTSA ODI 11455633

When trying to fuel the vehicle, the pump continually shuts off. Jeep repaired this once while under warranty, but it has happened a second time and an internet search confirms this is a known issue. It could be an issue with the evap hose design. The safety concern is the rate at which fuel is added to the tank. With this issue, the flow rate has to be reduced enough to allow the fumes to escape through the down flow spout which is a fire hazard if there are any sparks. At the lower flow rate, it's easy to overflow the tank as it's the only way to bypass the automatic shutoff.

NHTSA ODI 11449691

I am the sole owner of 2014 Jeep Cherokee Trailhawk. No miles when purchased. All recalls were kept up, all oil changes were made and vehicle has been taken care of. Without warning, my jeep started not excepting fuel or verily at all. Jeep was taken to the local dealership, that sold me the jeep. The air line that allows for vapor locking was completely filled with sediment and mud. After investigation by the dealer they the line had allowed for sediment and mud to overflow into the gas tank line, plugging it. I am now looking at a $2,000 repair bill to replace the air line and my gas tank as there is no way according to the dealer to get the sediment out because of the blockages. The air line and tank are in line with the back wheel well so it is poor manufacturing placement for this on the jeep and even if I do fix it, it will do it again in the future because of the way it was built. No warning lights, no recalls or help so from the Jeep company. Fortunately in my case I was not traveling and was within distance of the dealer otherwise it would have left me and my family stranded.

NHTSA ODI 11446151

The fuel tank has an abnormal amount of seepage. When filling with 87 octane gasoline, intermittently shortly after filling, the cars engine will completely stall while in motion. Also afterwards it may have trouble starting or be unable to start at all until waiting many minutes.

NHTSA ODI 11446064

The contact owns a 2014 Jeep Cherokee. The contact stated that the vehicle would intermittently stall after refueling with the "shift vehicle into neutral" warning message displayed on the instrument panel. The contact took the vehicle to an independent mechanic who discovered that raw fuel would enter the charcoal canister due to a defective liquid air separator located on top of the fuel tank. The contact was also informed that the separator could not be replaced separately, and the entire fuel tank would need to be replaced. The manufacturer had been notified of the failure on two occasions and a complaint was filed. The vehicle had yet to be repaired. The failure mileage was approximately 96,000.

NHTSA ODI 11444419

This vehicle has a known issue that has been ongoing for years. If the gas tank is filled (but not topped off) the car will stall when you begin driving when it sits idle at a traffic light or stop sign during the first 30 minutes of use until some gas burns off. When this car was purchased used in Dec 2017 it happened immediately after the first full tank. When idling or right as you step on the gas the car starts “puttering” and stalls. A message states something like “put car in park and restart”. The only way to restart the car is to put it in park, turn it off completely, and restart it. The when you try to go again, it might stall or it might not. This can happen over and over again. When we determined what was the cause we got in the habit of not filling the tank completely, but sometimes you forget. Then as you start driving, it stalls…multiple times. This is an extremely dangerous situation to be in when the car stalls in the middle of an intersection and will likely end up causing a fatal accident. During a recent recall appointment at Jeep service department, the car stalled as I was pulling into the service department parking lot, so they first hand experienced the issue…in fact the service advisor had trouble starting the car. Jeep service called me later and told me there was an existing “Star Case” with Jeep corporate. Case number S1814000002. This symptom in the document are exactly what I am experiencing. The suggested repair to is replace the fuel pump, fuel pump “O” ring, and the Evaporative Charcoal canister totaling about $1400. If you google “jeep S1814000002” you will find dozens and dozens of other complaints about the same issue, and not just for the Cherokee, it is other Jeeps as well. While this is a known issue, Jeep refuses to fix or issue a recall on this extremely dangerous safety issue.

NHTSA ODI 11443104

I was driving on the highway approximately 60mph, suddenly the service 4wd light appears. I took it to a Jeep dealership service center and diagnose and needed a 2 speed transfer case unit. It was replaced costing a little under $3000. The problem was not fixed and garage said it was misdiagnosed and still doesn’t know what’s wrong. Now the vehicle stalls while I’m driving and will not start immediately. I’m afraid this is going to cause an accident! Also it will have a sudden acceleration or a delayed acceleration while driving or when moving from a complete stop. This is very scary!

NHTSA ODI 11441674

After filling the vehicle up with fuel there is a good chance the you will experience shutter, stalling or even have engine failure. This has happen in the filling station parking lot and in main traffic. Luckily I live in a small city and have been able to move to safety when it has happened..

NHTSA ODI 11440038

Gas cap warning light. The night it appeared, got gas filled up the car gas tank. Put cap back on tank , pulled out drove approx. 1/4 mile car completely shut down at a red light and has several times. I ask dealership about it. They cleared code. Said I could buy a new cap I did. Did not help. Have it at mechanics today for testing. He thought there was a recall for this problem but I did not find one.

NHTSA ODI 11436907

2014 Cherokee Limited with a 2.4L I am the original owner, and have had all services done. Car is in good shape. This is now a persistent problem each time I refuel. Within a few minutes or miles, the car engine will stall, tell me that I have to put the car in Park to restart. This is extremely dangerous and has happened to me in the middle of intersections or driving down a street. I fill the tank, I don't overfill it. When the pump clicks off, I am done and don't add more. Then I drive off and for about 5-10 minutes, I am at risk of the car stalling. I have had it happen while driving, and more often when I stop at a light. It will restart. But this happens ONLY after I refill the tank.

NHTSA ODI 11425274

3/1/2021: Rough idle and overheating after filling up gas tank that morning upon arriving at work. Jeep had problems when leaving work at roughly 1630. Idles poorly, very rough and dipped from 900 rpm down to 200 rpm while almost stalling. I decided to drive home and thought it may be a little water in the gas from filling up that morning on MacDill. Ran rough on the way out of MacDill. At the home depot traffic light, the transmission would not engage and I had to switch to park and back into drive. Once onto Gandy Blvd the temperature started to overheat. I turned on the heater to act as a second radiator and decided to shoot for Jeep dealer in St. Pete. I made it there and caught a ride home with Wife's sister. Dealer drove Jeep on Tuesday a total of 23 miles without any temperature above 202. Told that lot boy and service supervisor drove it. No charge since St. Pete Jeep couldn't find any faults. I had Wife take me to pick it up. On ride home got up to 207. No rough idle. ***Rough idle and stalling while driving in traffic continued. Noticed this always occurred after filling gas tank up to full*** Jun 29, 2021: Got gas again at MacDill Monday morning upon arrival at work. Monday afternoon car ran terrible. Remote start stalled before I got to Jeep. Started up again when I got to car and engine ran rough. Nearly stalled several times. Engine almost stalled at final left turn while heading to gate. Transmission indicator flashed again and transmission failed to work. Display showed to place in park to select drive. Had to coast up onto median to keep from blocking traffic when engine started to stall again when light turned green and I proceeded through light. Occasionally Ran rough all the way home for the 43 miles and 1 hour drive. This time there was no significant overheating. Just went up to low 200s. Decided to submit a NHTSA complaint since dealership said they wouldn't be able to find anything wrong if no check engine light came on. Dangerous

NHTSA ODI 11425007

The contact owns a 2014 Jeep Cherokee. The contact stated that after filling the fuel tank, the vehicle would stall. The vehicle was restarted, and functionality returned. The contact stated that there was no warning light illuminated. The vehicle was not diagnosed nor repair. The manufacturer was informed of the failure and informed the contact that the Vin was not under recall. The failure mileage was approximately 106,000.

NHTSA ODI 11423236

Had just filled gas tank (1st time since we purchased the vehicle on 6/9/21). Stopped at traffic light. Engine quit and dashboard message advised to put car in park and push start button. Car started but quit almost immediately. While in park tried to rev engine, but got minimal response. When traffic light changed, proceeded forward. "Transmission Service Needed" message appeared, and D (Drive) on gearshift and on dashboard started blinking. Check Engine light was, (and remains) on. Car quit 3rd time, same "Transmission Service Needed" message appeared. When I got home, put car in reverse to back into driveway, got aloud clunking sound. Shut off engine and kept it off for 30-40 minutes. Started the car again and took it around the block, but none of the previous issues repeated.

NHTSA ODI 11420967