What 84 owners told NHTSA about the 2014 Hyundai Veloster

My driver airbags have been deactivated for quite some time. My radio touchscreen doesn't work, and the electrical issue has drifted all the way into my steering wheel where I can't control any type of cruise control properly.

NHTSA ODI 11740430

The second cylinder is not firing. The car stalled when on highway.

NHTSA ODI 11704367

While driving at approximately 70MPH on the highway, my 2014 Hyundai Tucson Limited suddenly locked up with no warning lights, no noise and no prior symptoms. The engine completely seized, causing immediate loss of power. I was barely able to coast off the highway exit to a final stop on the feeder shoulder, in a desolate area. The vehicle has always been properly maintained and is in excellent condition. Upon research, I learned that Hyundai has known of internal engine defects caused by metallic debris left from manufacturing since 2010, which can cause bearing failure and engine seizure. My Tucson's failure matches the same pattern described in Hyundai's Theta II engine recall and warranty extension campaigns. This sudden failure created an extremely dangerous situation at highway speed and possibility of injury while being stranded on an open road. Many owners, myself included, were never properly notified of the risks. I am filing this report because this incident represents a serious safety defect and potential recurrence among similar vehicles that may not yet be covered by recall. I respectfully request that the National Highway Traffic Safety Administration investigate this issue and ensure Hyundai expands its recall and warranty coverage to include affected 2014 Hyundai Tucson Limited vehicles exhibiting this defect that was well-known to the Hyundai Corporation. Date of Incident: October 23,2025 in Houston Texas. Vehicle towed to Hyundai dealer which diagnosed Engine Seized and currently awaiting Warranty Extension Approval (TXXC/TXXI)

NHTSA ODI 11697541

Knock sensor code p1326

NHTSA ODI 11679871

The connector that connects to the air conditioning temperature knob melted this is the second time in the 4 years I have owned the vehicle

NHTSA ODI 11669871

The contact owns a 2014 Hyundai Veloster. The contact stated that the rear passenger's side door failed to open as needed. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided because the vehicle was not covered under warranty. The failure mileage was approximately 126,000.

NHTSA ODI 11661517

The contact owns a 2014 Hyundai Veloster. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle failed to accelerate above 50 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the vehicle required an engine fluid flush. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 135,000.

NHTSA ODI 11649270

The contact owns a 2014 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the Reverse Park Aid (RPAS) warning light illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the Reverse Park Aid Sensor (RPAS). The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V132000 (Electrical System); but the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 135,000.

NHTSA ODI 11649276

The contact owns a 2014 Hyundai Veloster. The contact stated while driving at an undisclosed speed, the contact noticed an extremely loud knocking sound coming from the vehicle which increased louder while driving. The contact drove the vehicle to the shoulder of the road. The vehicle was towed to an independent mechanic however, the vehicle was not diagnosed or repaired. The vehicle was taken to another independent mechanic where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 98,000.

NHTSA ODI 11639966

The car lost power gradually ;when I was driving ; We were on the freeway and I couldn’t continue driving 60 miles per hour , therefore I turned on the turn signals cause I just could drive at 35 miles per hour and the car just start shaking ; I just look for the next exit by the time We were on risk on the emergency lane for along time cause the next exit was to far from there .and the car was too slow ,when we finally got exit I call and I stop my car and call the mechanic to ask for help and he help me plug in the scanner machine to my car and there was a problem with some cylinders and one valve and I decided to called to the dealer to get an appointment:. My Vehicule already was checking for Hyundai but they just text me a message ; they said my car needs to replace a motor ,turbo ; some broken valves causing zero pounds of compression on cylinder 4-long block repair-new intake and exhaust manifolds (including turbo)required due to broken valve sending metal through the entire system -quote long block/intake and exhaust manifolds /turbo /all necessary gaskets and fluids for repair : I just was noted my car was consuming too much oil, cause the car board showed me 3 weeks ago and I need to add oil ,and the mechanic plugged in the scanner; but it doesn’t showed something else ;therefore 3 weeks ago I added 1/4 or more ; then was 2 week ago; I added 1/4 of oil again and then just last week I added 1/4 or more oil again ;I just was checking the oil constantly.; and it should be noted that the car was not leaking oil but I didn’t understand why it was running out so quickly .

NHTSA ODI 11616768

I have not "yet" had an incident but, because of the safety recall, I have been parking my vehicle outside for almost a year (since October 2023). It is now August 2024 and a part for my Hyundai Veloster 2014 is still not available. For an issue that may cause a fire, or indeed any recall issue, this is way too long for a remedy to become available! This has caused considerable inconvenience: scraping frost and cleaning off snow, constant dirt, and inability to park in parking garages. Additionally, the additional wear will reduce the value of the car when I sell it.

NHTSA ODI 11610608

The contact owns a 2014 Hyundai Veloster. The contact stated while driving at an undisclosed speed and coming to a stop light, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The dealer stated that no failures were found after the vehicle was inspected. The contact also stated that the vehicle was consuming an excessive amount of engine oil. The manufacturer was notified of the failure. The failure mileage was approximately 89,000.

NHTSA ODI 11597303

The Hyundai recall doesn't fix the problem, which is the ABS Module leaks brake fluid internally which can catch fire. The claimed "fix" puts in a low current fuse that supposedly electrically will lower the risk of a fire when the ABS leaks brake fluid internally and shorts out the electrical power to the ABS Module. The problem is that the ABS Module can develop an internal leak which causes a short that fries the ABS Module and can cause a fire by igniting the brake fluid. The lower current rated fuse can still cause a fire, so I don't see the NHTSA Recall No. 23V651000 as a real fix. I want a replacement of the brake fluid leak-prone ABS Module in my 2014 Hyundai Veloster Turbo so I can safely use and park my car indoors without the potential of a fire while parked or driving. I have not experienced a fire in the recalled vehicle, but I think I am entitled to a proper "fix". I am an electrical engineer with an MSEE degree and many US patents. I have been greatly inconvenienced by following the recall warning to "park the vehicle outside (outdoors) away from structures". The outside exposure to hot temperatures, harsh sunshine, and salt air degrades the finish and mechanicals of my vehicle by following the recall warning. So Hyundai's faulty ABS Module costs me money (value of the vehicle) besides the risk and inconvenience. Make Hyundai really fix the problem by replacing the ABS Module as a minimum.

NHTSA ODI 11596564

The contact owns a 2014 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11587207

The contact owns a 2014 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11584424

Engine started knocking at 117,xxx miles with oil changes less then 5,000 miles. Dealership acknowledged and confirmed that the rod bearings were bad. If requested could remove the rod bearings. Dealership and corporate Hyundai acknowledged the problem, but would not help cover any of the costs. The vehicle was also losing around 1 quart for every 1,000 miles which was not addressed by the dealer. This is a huge safety risk, if the bearing completely failed the vehicle would have stalled on the interstate. No check engine light is present or was present. The issues with the Veloster Turbo is well know and document from 2012-2017 regarding the failure of rod bearings prematurely. Other Kia and Hyundai vehicles have recalls for this same problem, unfortunately the Veloster does not.

NHTSA ODI 11581821

Hyundai recall [XXX], since there is no remedy available, how will Hyundai compensate me? I purchased my 2014 Veloster Turbo Jan 20[15 for $23,500, dealer tells me its safe to drive, however recall tells me not to park it in my garage as it can cause a fire. If it can start a fire when it is parked, what can it do when I am driving it? [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11575753

There is a current recall since September, 2023, with no remedy to date. In addition, I have driven this vehicle very little after last having my car serviced at the dealership, just over a year now, which seemed to not be sounding right in the engine, so it alarmed me, and all started feeling overwhelming since going to the dealership for repairs. I see there is an engine recall on the 2015 Veloster, though not the 2014? Yet they are claiming that both issues can cause fires. My vehicle has less than 100K miles if I remember correct from when I last looked. it's been months since I've even driven the vehicle, as I've not felt safe or comfortable doing so. My vehicle seems to have a lot of the same symptoms as the 2015 Veloster recall. i have been nervous to take it back to the same dealer, though I've also been too nervous to let just any mechanic look at it. When the dealer last changed my oil, a bunch leaked out in my driveway, and I was told there's a safety overflow. In addition, my oil light came on, and I was simply told they forgot to reset it.

NHTSA ODI 11570451

The Rods are going bad , and Hyundai doesn’t want to admit that they did a horrible job with the engine and they don’t want to replace the engine , unless the car is a 2013 or 2016 which is ridiculous. They don’t want to honor their word.

NHTSA ODI 11570171

Unknown

NHTSA ODI 11564069

I was driving and then all the sudden my APS light came on and my battery light next, I was driving and my car stopped moving in the middle of the road.

NHTSA ODI 11563694

The contact owns a 2014 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11554884

The climate control switch on my vehicle as well as many others has burned up the wiring that plugs into it behind the dash and started smoking and actually almost burned my car to the ground.

NHTSA ODI 11545022

The sunroof spontaneously shattered. I was driving on an interstate highway with the sunroof tilted forward for ventilation.

NHTSA ODI 11543472

My ac unit switch melted due to the wires getting too hot and causing the unit to no longer work. I believe this is a safety issue due to possible fire with the wires getting burned. After doing some research this is a common issue in my car and I believe hyundai should be required to replace my unit before it causes more damage inside the unit.

NHTSA ODI 11536772