What 1,362 owners told NHTSA about the 2014 Ford F-150 Supercab Diesel

[XXX] was driving the 2014 F150 on a multi lane state road in the afternoon on a sunny and dry afternoon. The vehicle was traveling straight with steady traffic at an intense rate of speed (approximately 45-50 mph) when it all of a changed gears and became difficult for the [XXX] to control, causing the vehicle to hit a guard rail. There was no contributing factors to the accident other than the vehicle's malfunction (i.e. no negative weather, road signals, other vehicles, animal or plant obstructions, intersections, driver error, etc.). At the time of the impact, all of the vehicle's airbags deployed and the driver's seatbelt locked in place. There were no personal injuries - only property damage to the outside of the vehicle, the airbags and seatbelt. Thus far, Ford has refused to replace the airbags, seatbelt/repair the vehicle's property damage despite repeated requests. Ford only fixed the software problem associate with the recall and has taken the position that is the only remedy they are required to do. ( I will locate the police report and provide subsequently if needed) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11655274

It is 2014 F150 platinum it has a recall on the transmission. I took it in. They programmed it. I left with it. It was worse. and said that they had to get my truck was there for over a month and a half after the part was put on it. The transformation was worse now it’s back in the shop again for another two weeks. They’re telling me I need a new transmission. Anybody with common sense would know that if you’re driving 60 to 70 miles an hour and your truck shifts from six gear to first gear it’s going to tear something up in the transmission. I got it out and it was hard shifting out of first and the second out of fifth and the sixth and reverse was whining. All I’m asking for is help they want me to pay $6600 for a new transmission that I don’t have I’m on disability. Please help

NHTSA ODI 11627825

The contact owned a 2014 Ford F-150. The contact stated while the vehicle was parked, the vehicle rolled backward and crashed into the neighbor’s home. The vehicle damaged the neighbor's home and damaged the connecting gas. A Police report was filed. There were no injuries sustained, and no medical attention was needed. The vehicle was deemed a total loss. In addition, the contact stated that the vehicle was serviced two weeks prior to the failure, by the dealer. The contact stated that an unknown recall repair for the transmission control module update was completed at the time. The manufacturer was not made aware of the failure. The failure mileage was approximately 92,000.

NHTSA ODI 11613963

The contact's boyfriend owned a 2014 Ford F-150. The contact stated that the check engine warning light was illuminated. Additionally, the contact stated while her boyfriend was driving 60 MPH, the transmission downshifted unintendedly, and the vehicle jerked, causing the contact's boyfriend to lose control of the vehicle. The vehicle crashed into the rear of another occupied vehicle. The contact was unsure whether the air bags were deployed. The ambulance transported the contact and the other driver to the hospital, where it was confirmed that no major injuries were sustained and both drivers were checked out of the hospital. The contact stated that both her boyfriend and the other driver sustained body pain. Both vehicles were towed and totaled. A police report was filed. The contact became aware of NHTSA Campaign Number: 24V444000(Power Train), which the contact related to the failure. The dealer and the manufacturer were not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11608020

The contact owns a 2014 Ford F-150. The contact stated that while driving at 45 MPH on a two-lane highway, the vehicle seized on low gear and the rear of the vehicle seized. The ABS did not engage to bring the vehicle to a stop, the rear remained seized causing the contact to rear-end the vehicle in front. No air bags deployed. A police report was filed. The contact sustained a fractured finger, head, and back injuries that required medical attention via the hospital. Due to cost, the contact could not continue his medical treatment. The other vehicle was able to be driven from the scene and the occupant sustained unknown injuries that required medical attention but no further information was available. The vehicle was driven home after the crash. The vehicle was taken to an independent mechanic where the frame was repaired and replaced the damaged front end parts. The vehicle was repaired. The contact mentioned that the transmission was previously rebuilt approximately 3-4 years ago with AAMCO due to an undetermined failure with an unexpected downshift into first gear. The vehicle was taken to a dealer where it was serviced for NHTSA Campaign Number: 24V444000 (Power Train). The contact was concerned that the failure would recur. The manufacturer was made aware of the failure and was referred to the NHTSA Hotline. The failure mileage was 150,000.

NHTSA ODI 11600793

Downshift CRASH of truck, oss failure, i have video, built 11/13, 2014 ford raptor with 6r80 transmission. Ford refuses to pay for lead frame replacement. Injuries and truck has over 10k in damage, another car was totalled and man injured. This OSS defect is deadly. Need help.

NHTSA ODI 11553629

2014 ford f150 raptor, built in 11/13 in Dearborn Michigan plant. Driving down wet highway in slow lane doing 55mph, speedometer goes to 0, airbag light illuminates, odometer changes to dashes, wrench light comes on, transmission downshifted locking up my wheels. My truck is totaled and i could have died. Another car is totaled as well. This is the same defect as the 09-13 recalls. Speed sensor in lead frame failure. Ford did not notify me and is not notifying other 2014 f150 owners. Please help [XXX], [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11527701

The contact owns a 2014 Ford F-150. The contact stated while driving at 80 MPH, the vehicle downshifted to first gear and decelerated to 20 MPH, causing the front seat passenger’s head to strike the dashboard. No medical attention was required. The contact pulled over to the side of the road and then drove the vehicle back to the residence. The contact stated that a certified mechanic arrived at the residence to diagnose the vehicle. The contact was informed that the output shaft sensor failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 87,000.

NHTSA ODI 11509709

while driving my vehicle it suddenly downshifts from 6th gear to 1st gear causing the rear wheels to lock up.

NHTSA ODI 11424739

while driving on the freeway my 2014 ford f150 suddenly downshifted from 6th gear to 1st gear causing my rear wheels to lock up and having the steering wheel jerk to the left. the car behind me had to swerve to avoid hitting me from behind since the trucks wheels locked up with no brake lights. this has been the 8th time this has happened. each time i take it to ford for them to check it out they tell me they can not duplicate the issue. the wrench light comes on and it throws codes and ford will do nothing to fix it.

NHTSA ODI 11421240

WHILE DRIVING DOWN THE HIGHWAY AT ROUGHLY 75MPH THE VEHICLES SPEEDOMETER SUDDENLY JUMPED TO 105MPH THEN DOWN TO 65MPH, THEN TO ROUGHLY 90MPH AND FINALLY DROPPING TO 0MPH AT WHICH TIME THE TRANSMISSION SUDDENLY SHIFTED DOWN INTO 1ST GEAR CAUSING THE REAR WHEELS TO LOCK UP WHILE GOING 75MPH ALMOST KILLING MYSELF. AFTER THIS OCCURRED AND THE VEHICLE STOPPED THE IGNITION WAS TURNED OFF. ONCE RESTARTED EVERYTHING SEEMED TO BE FUNCTIONING AS IT SHOULD. A COUPLE DAYS OF DRIVING NORMALLY WENT BY BEFORE THE VEHICLE LOCKED ITSELF IN 5TH GEAR, THE ONLY WAY THIS WAS FIXED WAS FOR THE VEHICLE TO BE CYCLED ON AND OFF. A FEW MORE DAYS OF NORMAL DRIVING WENT BY AND THE VEHICLE THEN EXHIBITED SHIFTING FROM 1ST TO 5TH ONCE SPEED REACHED ABOUT 5MPH. THIS OCCURRED UNTIL THE VEHICLE WAS CYCLED ON AND OFF. FROM MY RESEARCH ONLINE THIS IS DIRECTLY RELATED TO THE OUTPUT SHAFT SPEED SENSOR IN THE TRANSMISSION LEAD FRAME. 2012-2013 F150S WERE RECALLED DUE TO THESE SAME SYMPTOMS, HOWEVER, THERE HAS NOT BEEN A RECALL FOR 2014'S AS OF YET, EVEN THOUGH THEY USE THE SAME FAULTY TRANSMISSION LEAD FRAME.

NHTSA ODI 11163436

HAD TO REPAIR THE "LEAD MOLDED FRAME & GASKET" ! TRUCK WOULD JUMP THREW GEARS WHILE MOVING AT ANY SPEED. FINAL DRAW WAS WHEN TRUCK DROPPED TO 1ST GEAR WHILE TRAVELING 70 MPH ON I-64 EAST NEARLY CAUSING TRUCK TO FLIP OVER AFTER SCREECHING TIRES AND RUNNING OTHER CARS OFF THE ROAD! FORD DEALERSHIP MAINTENANCE DEPT. TOLD ME THERE WERE RECALLS FOR SAME PROBLEM ON F-150'S BUT NOT FOR THE YEAR 2014 AS MINE IS!.. PLEASE NOTE IF IT WERE WET/RAINING AT THE TIME THIS HAPPENED TO US, THERE WOULD HAVE BEEN A SEVERE ACCIDENT WITH POSSIBLE CASUALTIES...!!!

NHTSA ODI 11124471

TL* THE CONTACT OWNS A 2014 FORD F-150. THE CONTACT PARKED THE VEHICLE IN THE DRIVEWAY (ON AN INCLINE), SHIFTED THE GEAR TO PARK, AND REMOVED THE KEYS FROM THE IGNITION. THE CONTACT WENT INSIDE THE RESIDENCE TO RETRIEVE A WHEELCHAIR FOR THE PASSENGER. AS THE CONTACT WAS TRANSFERRING THE PASSENGER TO THE WHEELCHAIR WITH THE PASSENGER DOOR OPEN, THE VEHICLE STARTED TO ROLL AWAY IN REVERSE. AS THE VEHICLE WAS ROLLING AWAY, THE PASSENGER IN THE WHEELCHAIR WAS DRAGGED DOWN THE DRIVEWAY AND INTO THE STREET. POLICE REPORT NUMBER: 17-24021 WAS FILED. THE PASSENGER WAS TRANSPORTED TO THE NEAREST HOSPITAL WITH SCRATCHES AND SCRAPES. THE VEHICLE WAS TOWED TO THE DEALER (LEGACY FORD IN ROSENBERG TEXAS, 833-811-8141), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE CONTACT WAS INFORMED THAT THERE WERE NO FAILURES WITH THE VEHICLE AND HAD NO EXPLANATION AS TO WHY THE VEHICLE ROLLED BACKWARDS WHILE IN PARK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,477. *TT CONTACT STATES THERE IS A RECALL FOR 150 FORD TRUCK CLIP THAT LOCKS GEAR SHIFT CABLE TO TRANSMISSION. *TT

NHTSA ODI 11084279

I WENT TO TURN AROUND OFF OF A PAVED STREET. MY FRONT RIGHT TIRE FEEL INTO THE MUD. I TOLD MY WIFE WE ARE STUCK, THEN PUT MY TRUCK IN FOUR WHEEL DRIVE, OFF ROAD MODE AND SPORT TRACK MODE ON THE DASH. I PULLED FORWARD ABOUT A FOOT OR SO AND WAS STOPPED BY SOMETHING, I THEN WENT BACKWARDS. I REPEATED THIS FOR ABOUT FIVE TIMES. MY DAUGHTER WAS HYSTERICAL FOR JUST BEING STUCK, I TURNED AND TOLD HER TO CALM DOWN, WHEN I TURNED BACK AROUND I SAW FIRE IN THE DRIVER SIDE MIRROR, I TOLD MY FAMILY " IT'S ON FIRE, GET OUT". I OPENED MY DOOR TO GET OUR AND WAS ENGULFED BY FLAMES, I QUICKLY EXITED THE PASSENGER SIDE DOOR. I YELLED FOR MY DAUGHTER THREE TIMES, SHE HAD RAN A LONG WAY AWAY FROM THE TRUCK, BECAUSE SHE WAS FRIGHTENED. WHEN I HAD HER IN MY SIGHT I STARTED FILMING. SHE HAD EXITED OUT OVER THE TOP OF MY SON ON THE PASSENGER SIDE AS WELL. MY SON SAID HE HEARD A SPEWING NOISE WHILE I WAS TELLING MY 8 YEAR OLD DAUGHTER TO CALM DOWN. HE SLUNG MY DAUGHTER OUT WHEN HE SAW ME BECOME ENGULFED IN FLAMES. I WAS OFF THE ROAD LESS THAN A MINUTE BEFORE I SAW THE FLAMES, I STARTED FILMING WELL WITHIN TWO MINUTES OF BEING OFF THE ROAD AND MY 2014, RUBY RED, SPECIAL EDITION ONE OF A KIND FORD F150, SVT RAPTOR WAS COMPLETELY ENGULFED IN FLAMES IN LESS THAN FIVE MINUTES. CAUSE OF FIRE IS UNDETERMINED. *TR

NHTSA ODI 10682836

TL* THE CONTACT OWNS A 2014 FORD F-150. WHILE THE CONTACT WAS HITCHING A TRAILER TO THE VEHICLE, THE VEHICLE ROLLED IN REVERSE WHILE PARKED. THE VEHICLE ROLLED OVER THE CONTACT'S LEFT FOOT AND THE TRAILER CRASHED INTO A FENCE. THE CONTACT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.

NHTSA ODI 10639261