What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

I am un able to steer my vehicle almost got into an accident on my way to work . I lost all steering function and lights displayed for power steering assist . I feel this issue needs to be part of the recall amd include 2014 explorers seems to be a common complaint as I was reading and very unsafe.

NHTSA ODI 11478089

Cranked car and began to drive home. Noticed there was a grinding noise when turning the steering wheel at low speeds. After approx 10 miles, while driving on a straight road, the steering wheel started jerking to the left and then automatically straightening itself up and then jerking to the right. This happened two times within a 6 mile distance. The second time it happened, there were two orange notifications that popped up. One said Service AdvanceTrac and one said Steering Fault Service Now. After that, the vehicle became extremely difficult to maneuver. I almost hit other vehicles several times as I was driving on a 6 lane divided road so traffic was on either side of me and the steering wheel wouldnt stay straight. Upon arriving at my destination, the vehicle sat in the driveway for 2 days until it could be towed to the shop. Upon cranking the vehicle, an orange notification popped up that said Service AdvanceTrac, as well a red notification that said Steering Loss Stop Safely. Problem persisted, vehicle had to be manhandled to be able to steer the wheel to get it loaded so it could be taken to the shop for diagnostic. Tech duplicated issue and diag as needing a new steering rack but cleared codes and vehicle began running as designed but quickly malfunctioned again. Mileage 142885 at time of fault.

NHTSA ODI 11477783

The contact owns a 2014 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the vehicle lost motive power with the transmission warning light illuminated. The contact's wife was able to restart the vehicle; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed that the throttle body assembly needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 115,000.

NHTSA ODI 11477329

Power steering went out while driving the vehicle and steering wheel was extremely difficult to maneuver. Received error “steering assist fault service required”

NHTSA ODI 11477469

The vehicle began to overheat in traffic and forced me to stop. This is a known problem with Fords from 2011-2016. The issue has been resolved in Canada but in the US customers are being forced to pay for repairs.

NHTSA ODI 11477084

Exterior trim or molding, and weather strip on windshield, driver and passenger sides flew off vehicle while highway driving 65 MPH. The weather conditions were sunny skies during day time. Thank God no serious accidents occurred I'm aware of. After some research, I learned this is a common occurrence with Ford Explorer vehicles. I feel this is a safety concern. Hopefully Ford issues a recall or other type of compensation for owners. I contacted DACARS Ford in Lanham, MD for a repair estimates 2 weeks ago. I have not recieved a call back. I will look elsewhere for support.

NHTSA ODI 11476845

The contact owns a 2014 Ford Explorer. The contact stated while driving at various speeds, excessive force was needed to steer the vehicle. The contact stated that the "Service Advance Trak" and "Steering Assist Fault, Service Required" messages were displayed on the instrument panel. Two independent mechanics and three dealers were notified of the failure. The manufacturer was also notified about the failure and referred him to the NHTSA for assistance. The vehicle was not repaired. The failure mileage was 163,000.

NHTSA ODI 11476091

The contact owns a 2014 Ford Explorer. The contact stated while driving 50 MPH, the steering assist fault warning light illuminated, with a message to “Drive Safely’ displayed. The vehicle was towed to the local dealer who diagnosed the vehicle with a failure within the electronic steering rack. The dealer stated parts were not available. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 14V286000 (Steering). The approximate failure mileage was 104,200.

NHTSA ODI 11476108

The contact owns a 2014 Ford Explorer. The contact stated while driving 50 MPH, the vehicle lost power steering functionality. The steering assist warning light was illuminated. The contact was able to veer to the side of the road using physical strength to steer the vehicle. The vehicle was towed to an unknown dealer where it was diagnosed that the rack and pinion needed to be replaced; however, the dealer informed the contact that the parts were on a national backorder. The vehicle was then towed to an independent mechanic who informed the contact that the parts were not available. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance The failure mileage was approximately 65,000.

NHTSA ODI 11476121

The contact owns a 2014 Ford Explorer. The contact stated while entering the driver’s side front door, she noticed that the trim panel cover material had separated at the top of the window. The contact also noticed the failure on the passenger’s side front door. The vehicle was taken to an independent mechanic to be diagnosed. The mechanic linked the failure to the manufacturer’s Customer Satisfaction Program Number: 17N04. The dealer and the manufacturer were contacted and stated that the vehicle was out of warranty and also exceeded the mileage limit for coverage under Customer Satisfaction Program Number: 17N04. The failure mileage was 83,000.

NHTSA ODI 11475272

DRIVING DOWN ROAD AND LOST STEERING. WOULD NOT STEER AT ALL. THE STEERING RACK MALFUNCTIONED. HAD MECHANIC SHOP IDENTIFY ISSUE. THE POWER STEERING SERVICE LIGHT CAME ON WHEN STEERING WAS LOST AND THERE WAS NO NOTICE. HAD TO HAVE STEERING RACK REPLACED. LUCKY NOBODY GOT HURT. THIS IS A BIG SAFETY ISSUE. FORD HAS HAD PROBLEMS WITH STEERING ISSUE BEFORE. I THINK FORD SHOULD ISSUE A RECALL AND I AM LOOKING FOR REIMBURSEMENT FOR THE TOW AND REPAIRS.

NHTSA ODI 11475075

Power Steering and Terrain Managment Sysyem Fault, Left me trapped in a completely different state, Vehicle only has 55,588 Miles on it, I haven't yet gotten it checked, but will update my complaint as soon as I do

NHTSA ODI 11474743

The contact owns a 2014 Ford Explorer. The contact stated that while her daughter was driving approximately 15 MPH, the steering wheel became difficult to turn. The driver was able to steer the vehicle safely to a nearby parking lot. The contact was unaware if any warning lights were illuminated. The vehicle was towed to the local dealer and was diagnosed with the steering gear assembly failure. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 16V245000 (Suspension). The approximate failure mileage was 105,000.

NHTSA ODI 11473375

The power steering went out and made the vehicle impossible to drive.We were on vacation 112 miles from home when this happen, so I had it towed 112 miles back home and I took it in the the dealer I purchased it from. They said there was a recall on 2011-2017 Explorers but excludes the 2014 model year. This vehicle only has 24517 miles on it and the dealer said I would have to pay the whole repair bill of almost $2200. Ford knows there is an issue with these vehicles so I don't understand why they would not include the 2014 Explorer also.

NHTSA ODI 11473090

The contact owns a 2014 Ford Explorer. The contact stated while driving 60 MPH, the vehicle lost motive power with the TPMS warning light illuminated. Additionally, the vehicle was leaking coolant. The vehicle was taken to an independent mechanic who diagnosed that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.

NHTSA ODI 11472801

The contact owns a 2014 Ford Explorer. The contact stated while driving approximately 60 MPH, the power steering failed. There were no warning lights illuminated. The contact pulled safely to the side of the road for 15 minutes and restarted the vehicle. The contact drove home safely; however, the steering failure reoccurred. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 82,000.

NHTSA ODI 11472308

I was driving down the street and my steering wheel locked up and all kinds of warning lights came on. I glided in to a parking lot and I am 7 months pregnant. I took it to dealer and they said it was the steering gear which was going to cost me over $2600. I started researching and see that this was a recall on 2011-2013 and 2015=2017 Explorers but not on the 2014. This is crazy. Luckily there were no other cars around or I would have been in a bad accident. I believe this should be a covered recall on my vehicle.

NHTSA ODI 11472041

The contact owns a 2014 Ford Explorer. The contact stated while driving 30 MPH and making a left turn, the low coolant warning light was illuminated. The contact was able to park on the side of the roadway. The contact stated that her husband later added coolant to the reservoir. After starting the vehicle, the warning light was off. The contact stated that her husband saw coolant leaking from the water pump. The contact was able to drive to her residence. The contact called multiple independent mechanics and made them aware or the failure. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 160,000.

NHTSA ODI 11471586

The contact owns a 2014 Ford Explorer. The contact stated the vehicle was at the dealer for an air bag customer service repair when a leak in the water pump was discovered. The contact stated that the water pump needed to be replaced; however, the water pump was not replaced due to the cost. The contact stated that the dealer informed him that the engine could fail. The contact stated that he had not experienced a failure but was concerned that a failure could occur with no warning as the issue was not discovered until the vehicle went to the dealer for an air bag customer service program. The manufacturer was notified of the failure however, no assistance was offered as there was no recall. The contact stated that he researched the failure and found a Customer Service Program in Canada for the issue but not in the United States. The approximate failure mileage was 105,000

NHTSA ODI 11471171

The contact owns a 2014 Ford Explorer. The contact stated that while driving at various speeds, an abnormal grinding sound was coming from the steering wheel while steering in either direction. In addition, the contact also stated that the steering wheel would fail to readjust after making a turn and would stiffen while driving at various speeds without warning. The contact called the dealer where she was given an estimate for the repair and was informed that the parts to repair the steering wheel were on back order. The manufacturer was also notified of the failure and provided the same information as the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11471230

Faulty water pump went out on roadtrip, hours away from home. It left me and my children stranded for 4 hours in 100° conditions. No engine light or indicators came on to warn there was a problem. Coolant mixed in with oil and engine started misfiring. I immediately turned vehicle off until a Mechanic could diagnose the problem.

NHTSA ODI 11471026

The contact owns a 2014 Ford Explorer. The contact stated that after parking the vehicle in the driveway and shifting to park(P), the gear position indicator failed to indicate that the vehicle was in park(P). The contact turned on and turned off the vehicle several times before the vehicle operated as intended. The vehicle was not diagnosed. The dealer was contacted and the contact was informed that the VIN was not under recall for the failure. The manufacturer was contacted and informed of the failure. The contact was referred to the NHTSA to file a complaint. The approximate failure mileage was 50,000.

NHTSA ODI 11470636

The contact owns a 2014 Ford Explorer. The contact stated that upon starting the vehicle, the steering wheel was locked with the Service Advance Trac and Steering Fault - Service Now messages displayed. The contact turned off and restarted the vehicle and the vehicle regained power steering functionality. Upon taking the vehicle to an unknown dealer for an oil change, the dealer was notified of the failure. The dealer diagnosed that no issues were found; however, the contact stated that the steering felt sticky while driving. The dealer was notified of the failure and informed the contact that there was no early availability to inspect the vehicle. The contact stated while driving 45-60 MPH while taking the vehicle to an independent mechanic, the steering wheel seized inadvertently. The Service Advance Trac and Steering Fault - Service Now messages were displayed. The contact stated that he shook the steering wheel several times and the steering wheel loosened. The contact was able to continue driving. The vehicle was taken to the independent mechanic where it was diagnosed that the electric power steering assist unit had failed and needed to be replaced; however, neither the OEM parts nor aftermarket parts were available. The manufacturer was notified of the failure and informed the contact that they could not assist as there was no open recalls associated with the failure. The manufacturer referred the contact to the dealer. A case was opened. The vehicle was not repaired. The failure mileage was approximately 80,000.

NHTSA ODI 11470431

second time loss of power steering, first time almost got in accident. they said it was battery, so they replaced battery and reprogramed it at dealership. second time it happened was parked and when restarted no power steering, brought to dealership they said it was the steering rack, replaced rack, cost 2400,00 this should be covered under the recall

NHTSA ODI 11470441

Air conditioner malfunctioned 2014 and entire dual system climate required replacement. System malfunctioned again and rear lines require replacement and compressor was reported to have malfunctioned. Power steering pump and components failed and June 2014 requiring repair. Sunroof motors failed in 2020 requiring replacement.

NHTSA ODI 11470442