What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

Electric Power Steering locked up. Almost killed me my fiance. And my 2 kids.

NHTSA ODI 11484361

The power steering went out and it was discovered the steering rack and pinion need replaced. This is available for inspection upon request. It is unknown when this can be fixed so I am without a car until then. Upon research this is a common problem for this year and model of car. There was no warning messages, I just all of a sudden did not have power steering and was not able to steer my vehicle.

NHTSA ODI 11484536

Steering went completely out in a curve while my wife was driving. She had to manually steer the wheel to keep from wrecking, and it was very hard for her to turn. This isn’t the first issue I’ve had with the steering, but I’ve researched and other years of explorer with the same issue have recalls but not the 2014s. It’s VERY dangerous for my 110lb wife with our 4 children to drive a vehicle who’s steering may go out at any moment. There were never any dash lights to indicate any problems. I will be getting it serviced soon. Please put out a recall on the 2014s before the steering goes out and ends up killing someone.

NHTSA ODI 11484229

The contact owns a 2014 Ford Explorer. The contact stated while driving approximately 35 MPH and other speeds, the vehicle overheated. The contact stated no warning light was illuminated. The contact stated that when the vehicle was parked, the hood was extremely hot to the touch. There was also an odor of antifreeze and gasoline coming from under the hood. The contact had taken the vehicle to a dealer who diagnosed the vehicle and determined that the water pump needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 86,000.

NHTSA ODI 11484280

The contact owns a 2014 Ford Explorer. The contact stated while driving 40 MPH, the steering wheel seized. A message indicating a steering rack failure was displayed. The contact was unable to veer to the side of the road. The contact stated upon turning off and restarting the vehicle, the steering wheel operated as needed; however, the failure reoccurred several times while driving. The vehicle was taken to the dealer where it was diagnosed that the power steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as the vehicle was not included in a recall. The failure mileage was unknown.

NHTSA ODI 11483695

Power steering stopped working while my family and I were an hour from home. Dash warning said Power Steering Fault Stop Safely. Drove home with no power steering and parked it. Have not driven it since. Started the vehicle multiple times, inspected all fuses and breakers, all intact. All research points towards a fault in the Electric assisted power steering.

NHTSA ODI 11483166

I was driving home on the Bonne Carre Spillway Bridge from New Orleans to Baton Rouge and the warning lights came on while my car started swerving. Needless to say, I was Terrified when the warning message on my dashboard said, "Steering fault Service now" and both swervy line warning lamps under the directional panel on the dashboard came on. I had no steering power and had to drive 45 mph all the way to Baton Rouge on I-10 almost getting run over by 18 wheelers and other vehicles. I have 163,303 miles on the truck. Thank God for the Hollingsworth Ford Dealership employees (Lori) who were able to take my vehicle that same day. They had to tow it into the work bay, because the system completely froze up on them the following day. There is already a 2014 - 2017 Ford Explorer recall for Northeastern states, but Louisiana should be included also as we have a lot of flooding which can be worse than snow and ice nowadays. I have had to rent a vehicle for a month now and do not have anymore money to rent. I am over 50 years old so you can imagine how my body will be worn out if I have to take a bus to work. I know my truck was probably made in the same plant as the other 22 states vehicles who are included in the recall. I should NOT have to pay for these repairs!!! Please Help Me get Fair treatment as a 2017 Ford Explorer owner. I Appreciate your help.

NHTSA ODI 11483006

Steering started grinding and has slight resistance when turning left when trying to pull the wheel back to straight. Upon taking it to my repair shop, they have found that the electric steering rack & pinion component needs to be replaced. When they contacted Ford for this part, it's on national backorder with no ETA. There were no warnings to this happening, no lights, no other issues, this just started out of the blue. Obviously with the part being on national backorder, this is happening with more than just my vehicle and yet Ford is not issuing a recall. How long can I drive this for waiting on the recall? I don't have another vehicle to use to get to/from work.

NHTSA ODI 11482569

- Power steering failed - My safety as well as the safety of my children - Research shows that many people have had the same incident, some have been in accidents others have not. Luckily I was able to drift off to the shoulder of the road without an accident. There were no cars around me at the time. - Waiting on Ford Dealership to call me back - Once my power steering failed there was a warning light stating that it failed and I needed to pull over safely. This happened after my power steering failed not before.

NHTSA ODI 11482241

The contact owns a 2014 Ford Explorer. The contact stated while at a stop light, the vehicle lost motive power and stalled without warning. The contact restarted the vehicle and the vehicle would not properly accelerate. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the transmission was slipping. The vehicle was not repaired. The manufacturer was contacted and a case was filed. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was 96,000.

NHTSA ODI 11481971

Vehicle lost all power steering, traction control, and AdvanceTrac features due to electronic steering gear failure(ASE certified diagnosis). Very dangerous, and costly problem for a vehicle with only 100k miles.

NHTSA ODI 11481691

While driving down freeway at 65 mph, noticed on curves, steering was becoming "glitchy." Upon getting off freeway, noticed warning light for Loss of Accutrac warning came up on the message center. Turned engine off and looked under hood to see if there were any visible problems, no visible problems. I proceeded to turn ignition back on and red warning came up loss of power steering. I was able to drive vehicle to safe place, however with no power steering. 2014 ford explorer was then towed to dealership for repair/service. Contacted by dealership that the rack and pinion (electronic power steering) needed to be replaced and reprogrammed, not under warranty and cost would be $3200.00. It has been a month with no repair and part still on factory back order. Apparently 2014 is not under the recall for previous and post years (not sure why). Mileage on vehicle is 49500. My opinion is that Ford should cover this under recall, serious safety issue with vehicle.

NHTSA ODI 11481599

Rear back up camera only works intermittently.

NHTSA ODI 11481377

Steering has become stiff and unable to turn wheel. Have recall for toe link scheduled, but Ford says if steering is that tough than it’s not just the toe link causing issue.

NHTSA ODI 11480502

The contact's sister owns a 2014 Ford Explorer. The contact stated that while his sister was driving 75 MPH, the power steering assist fault warning message appeared on the instrument panel. The steering wheel became firm and his sister was unable to drive the vehicle. The vehicle was initially towed to a hotel; the next day, the contact drove to his sister's location and towed the vehicle back to her residence. The vehicle was then towed to a dealer where he was given an estimate for the repair and was informed that the part for repair was on backorder. The vehicle was then towed to an independent mechanic where it remained in their possession. The vehicle had yet to be repaired. The failure mileage was approximately 180,000.

NHTSA ODI 11480541

Electric power steering failing while driving. Loss of power steering assist cause vehicle to become hard to steer at speed, no warning lights. Took to mechanic who reproduced the problem but said they could not do anything and it had to go to the dealer for repair.

NHTSA ODI 11480380

Lug nuts need to be replaced due to swelling per Ford dealership

NHTSA ODI 11480394

I was on my back from NJ and all of a sudden my vehicle had a power steering fault and Terrain managment fault, I had just decided to resolve the issue by turning the vehicle on/off again, and it worked, it got me safely home but the terrain managment fault persisted, I was confused and unsure whether to keep on driving, forward from that, it felt harder to steer and slow my vehicle down, while i was going at the speed limit at one point I had attempted to stop before a red light and my vehicle even though brakes were pushed, stopped after the red light. I managed to have parked my vehicle at home, and all the faults came through "Power Steering Fault", "Terrain Managment Fault", the car steering wheel refused to turn, and my vehicle has now been in the dealership for a week, due to the amount of ford explorers that have the same issue, I have not yet gotten by car issues diagnosed from them. If it were to have happened sooner it may have lead to a vehicle accident involving 5 people. This issue is persistent and has to be looked at and resolved

NHTSA ODI 11480361

While turning into a parking lot the steering wheel locks up and almost impossible to control the steering. This will cause me to have a wreck. It will reset when the vehicle is cut off and back on. Ford had a recall on the 2013 models for this reason because it locks up the steering wheel it is a dangerous thing. I need help I read there is alot of people with this issue with their 2014 explorers around the same millage. There needs to be a recall on this

NHTSA ODI 11480376

The transmission failed without warning while traveling down the highway. The vehicle is currently being diagnosed but cost of repair is unknown at this time.

NHTSA ODI 11480182

The contact owns a 2014 Ford Explorer. The contact stated while exiting a parking spot, the steering wheel became difficult to turn. The contact stated that the power steering failure warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to the local dealer where it was diagnosed with needing the rack and pinion to be replaced. The vehicle was repaired but experience the same failure after the repair on two separate occasions. The vehicle has not been repaired. The manufacturer had been informed of the failure. The failure mileage was 18,712.

NHTSA ODI 11480035

The contact owns a 2014 Ford Explorer. The contact stated there was a leak coming from the sunroof. The contact took the vehicle to a collision center and diagnosed that there was tubing that needed to be repaired. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 105,000.

NHTSA ODI 11479747

The contact owns a 2014 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist with the power steering assist warning light illuminated. The vehicle was towed to an independent mechanic who diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,044.

NHTSA ODI 11479795

The contact owns a 2014 Ford Explorer. The contact stated while driving at 10 MPH and making a turn, the steering wheel locked. The message "Power Steering Assist Fault" and "All Terrain Maintenance" were displayed. The contact turned on her hazard lights. The contact stated as she turned off the vehicle and restarted it, the steering wheel regained power steering. The contact stated that the failure had been reoccurring while driving. The vehicle was taken to an independent mechanic at two different occasions. The independent mechanic diagnosed that the rack and pinion needed to be replaced. The contact stated that the rack and pinion was replaced twice. However, the failure persisted. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 110,000.

NHTSA ODI 11479538

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. Additionally, the steering wheel seized. The contact associated the failure with NHTSA Campaign Number: 14V286000 (Steering); however, the VIN was not included. The dealer and the manufacturer were not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 113,000.

NHTSA ODI 11478996